2005 Lexus ES330
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Lexus › ES330 › 2005
These records cover every 2005 Lexus ES330. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2005 Lexus ES330. Newest first.
Toyota IS recalling certain model year 2004 avalon vehicles; 2004 and 2005 camry, camry solara, highlander, and sienna vehicles, 2006 highlander hybrid; 2004 and 2005 lexus es330 and rx330; and 2006 lexus rx400h vehicles manufactured from june 1, 2004 through march 31, 2005, equipped with the 1mz-fe or 3mz-fe engine. the amount of adhesive agent applied…
Risk and remedy
Risk
In some cases, the belt for the power steering pump may become detached from the pulley which could result in a loss of power steering and a sudden increase in steering effort, increasing the risk of a crash.
Remedy
Toyota will notify owners, and dealers will check the crankshaft pulley to identify whether it was produced by the u.s. Supplier. if so, the dealer will replace the pulley with a new one at no charge. the safety recall IS expected to begin during early january 2012. owners may contact toyota at 1-800-331-4331.
On certain passenger vehicles equipped with a front passenger power seat, when installing certain rear-facing infant child seat bases onto the seat with an excessively high seatbelt tension, it may be possible to unseat a component called the buckle status switch from the seat belt buckle.
Risk and remedy
Risk
If the switch becomes unseated, the front passenger occupant classification system may mistake the rear-facing child restraint for an unbelted adult occupant, and may not suppress the deployment of the front passenger airbag.
Remedy
Dealers will replace the front passenger seatbelt buckle status switch. this safety improvement campaign (ssc 40M) began on december 20, 2004. owners should contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987..
Owner complaints
141 complaints34 involved a crash2 involved a fire18 injuries
What owners report most
Latest complaints
- Air bags · Air bags › Sensor › Occupant classification · Seats
Passenger seat airbag sensor light on when seated
- Air bags
This IS similar to the complain another car owner has filed. my car was purchased new from the lexus of pleasonton,ca dealership. I have had no major accident or no airbag deployment. Car has been lightly used with 80K miles on the odometer currently. the airbag container on the passenger…
This IS similar to the complain another car owner has filed. my car was purchased new from the lexus of pleasonton,ca dealership. I have had no major accident or no airbag deployment. Car has been lightly used with 80K miles on the odometer currently. the airbag container on the passenger dash has progressively cracked at the topical seams over time. I have been told an airbag should not look like this. I am concerned about an untimely deployment and if the container will get worse. at no time has the airbag been manipulated, repaired, etc since my ownership.
- Air bags
This car was purchased from the lexus of memphis dealership as used in 2010. I have had no accidents or airbag deployment. I am.not aware of any a evident history from the previous owner. the airbag container on the passenger dash has progressively cracked at the topical seams over time. I have…
This car was purchased from the lexus of memphis dealership as used in 2010. I have had no accidents or airbag deployment. I am.not aware of any a evident history from the previous owner. the airbag container on the passenger dash has progressively cracked at the topical seams over time. I have been told an airbag should not look like this. I am concerned about an untimely deployment and if the container will get worse. at no time has the airbag been manipulated, repaired, etc since my ownership.
- Electronic stability control (esc) · Engine · Steering
My check engine light IS on and when the diganoised code check IS performed "no codes appear," but I do have a power steering leakage and I hear the power steering noise when I am turning and from the recall 11v53900 11/09/2011 engine and engine cooling its a huge problem. I call customer service…
My check engine light IS on and when the diganoised code check IS performed "no codes appear," but I do have a power steering leakage and I hear the power steering noise when I am turning and from the recall 11v53900 11/09/2011 engine and engine cooling its a huge problem. I call customer service and they where no help! I called for servicing and they stated on my vin there IS no recall but on the nhtsa there pops up this recall so no cool. I am going to wait until something happens and sue the hell out of lexus for refusing to service my vehicle and neglecting the issues when I called and all the calls are recorded. Trouble & horrible service I am not a satisfied customer. I guess you need to be in certain financial bracket to receive exceptional service.
- Air bags
Passenger airbag on the dashboard IS opening, and my car has never been involved in an impact.
- Air bags · Service brakes
Tamara recall on my airbags,never repaired. I got into an accident and airbags didn't come out. Have to replace brakes every few months on this car also
- Air bags
Front passenger airbag cover appears to be separated along the seam near windshield on dashboard and there IS a wider gap on that side vs the side closest passenger. I've not seen this before in any of my other lexus vehicles and it's cause for concern of safety as a result.
- Air bags
TL* the contact owns a 2005 lexus es330. The contact noticed that the front passenger air bag cover was bulging and had separated along the seam nearest the windshield on the dashboard. The passenger air bag and check engine warning indicators illuminated. The vehicle was taken to butler lexus of…
TL* the contact owns a 2005 lexus es330. The contact noticed that the front passenger air bag cover was bulging and had separated along the seam nearest the windshield on the dashboard. The passenger air bag and check engine warning indicators illuminated. The vehicle was taken to butler lexus of south atlanta (located at 4025 jonesboro rd, union city, ga 30291, (678) 783-2703) where it was diagnosed that the passenger air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 212,000. *Tt *tr
- Electrical system · Steering
TL* the contact owns a 2005 lexus es330. While driving 35 mph, the vehicle stalled without warning. The vehicle was able to restart on the first attempt and was driven home. The vehicle was towed to an independent mechanic who diagnosed that the steering pump and alternator failed and needed to be…
TL* the contact owns a 2005 lexus es330. While driving 35 mph, the vehicle stalled without warning. The vehicle was able to restart on the first attempt and was driven home. The vehicle was towed to an independent mechanic who diagnosed that the steering pump and alternator failed and needed to be replaced. In addition, the contact needed to replace her key with another key chip. The manufacturer was not made aware of the failure. The failure mileage and vin were unknown.
- Electrical system
My complaint IS in regard to the ignition switch for my 2005 lexus es-330. While trying to start my vehicle the case that houses the key broke apart. The key was still in the ignition, the car running, but the other half of the case was dangling from the key itself.after I was able to stop the…
My complaint IS in regard to the ignition switch for my 2005 lexus es-330. While trying to start my vehicle the case that houses the key broke apart. The key was still in the ignition, the car running, but the other half of the case was dangling from the key itself.after I was able to stop the engine by turning it off with the key itself and gathering up all the parts of the ignition switch, upon observation I found a very small screw that supposedly was used to secure the switch case together had become loose and therefore allowed the switch case to break open from the pressure needed to start the engine. With a little bit of glue and transparent tape I was able to start the car and drive it to the local lexus dealer on atlantic blvd.in jacksonville, fl.the service manager seemed unconcerned about my problem, and spoke mostly about the redesigned switch presently available, and was totally unconcerned about my problem. I asked about others with the same type key case as mine and if a remedy had been taken to the securing of the small screw that holds the case together, he said not his knowledge. I guess my question IS simply why not? The service manager IS [xxx], I was told by him my only solution was to purchase another key as if the problem was mine instead of the dealers.could there be a safety concern here? I am [xxx] . information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *tr
- Unknown or other
Shrinking dashboard airbag cover - this IS a common problem for lexus owners - - lexus says this IS not a safety hazard and does not warrant repair - only cosmetic. They are repairing some dashboards for cracks on other models. I noticed the problem approximately january 2013.
- Engine and engine cooling
TL* the contact owns a 2005 lexus es330. The contact stated that the battery discharge warning light was illuminated. The contact stated that the vehicle was previously repaired under nhtsa campaign number: 11v539000 (engine and engine cooling), however the failure recurred. The vehicle was not…
TL* the contact owns a 2005 lexus es330. The contact stated that the battery discharge warning light was illuminated. The contact stated that the vehicle was previously repaired under nhtsa campaign number: 11v539000 (engine and engine cooling), however the failure recurred. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 66,108. *consumer request to withdraw complaint. Updated 10/21/16*lj the consumer requested to withdraw the complaint. The issue was fixed. Updated 10/26/16.*jb
- Engine · Power train · Vehicle speed control
The automobile seems accellerate just a little bit.when you are stepping on the gas it, kind of jumps forward some, without putting more pressure to the pedal.in motion at any speed.
- Vehicle speed control
TL* the contact owned a 2005 lexus es330. While reversing into a parking space at a low rate of speed, the vehicle surged backwards at a high rate of speed, drove over a curb, and then accelerated. The vehicle crashed into a restaurant and three parked vehicles. The air bags did not deploy. The…
TL* the contact owned a 2005 lexus es330. While reversing into a parking space at a low rate of speed, the vehicle surged backwards at a high rate of speed, drove over a curb, and then accelerated. The vehicle crashed into a restaurant and three parked vehicles. The air bags did not deploy. The vehicle was destroyed and towed to a tow yard. A police report was filed and there were no injuries. The manufacturer was notified of the failure. The failure mileage was unknown.
- Air bags
TL* the contact owns a 2005 lexus es330. The contact stated that while at a stop light, another vehicle crashed into the rear of the of his vehicle, causing the him to crash into the preceding vehicle. The air bags did not deploy. The contact sustained unknown injuries that required medical…
TL* the contact owns a 2005 lexus es330. The contact stated that while at a stop light, another vehicle crashed into the rear of the of his vehicle, causing the him to crash into the preceding vehicle. The air bags did not deploy. The contact sustained unknown injuries that required medical attention. A police report was filed. The vehicle was towed to an unknown location. The body damages were repaired but the air bag failure was not determined. The manufacturer was not made aware of the failure. The failure mileage was 65,000....updated 09/08/16 *bf updated 09/26/16.*jb
- Engine · Fuel/propulsion system · Unknown or other
Engine caught on fire. was driving on a city street when I noticed flames shooting out under the hood.
- Air bags · Seat belts · Service brakes · Vehicle speed control
As car in front of me slammed on brakes to avoid two teenagers running across in front of her, I slammed on my brakes and the car accelerated from 20-30. The air bag did not deploy nor did the seat belt engage and lock to prevent me from slamming into the steering wheel. The ABS brakes were slammed…
As car in front of me slammed on brakes to avoid two teenagers running across in front of her, I slammed on my brakes and the car accelerated from 20-30. The air bag did not deploy nor did the seat belt engage and lock to prevent me from slamming into the steering wheel. The ABS brakes were slammed and it felt like the brakes did not work like there was an air bubble in the system. I crashed into the hyundai. totaled my car and the front of the car frame was bent. Called the police, but did not take a report since no one was taken by ambulance. Went do my doctor and reported this to lexus-incident number 150922-00272 on 9/22/15. Lexus will inspect the car on 10/9/15...updated 10/15/15 *bf ...updated 12/03/15 *bf, updated 4/9/18*jb *tr
- Unknown or other
Passenger airbag deterioration (separated) on dashboard.
- Power train
Did not have a car accident, or experience any injuries or car damage, but this car, like numerous other cars of the same make, model, and year has some serious transmission/computer software issues at times. It hesitates and lurches often. I drove on the highway yesterday and the car acted up in…
Did not have a car accident, or experience any injuries or car damage, but this car, like numerous other cars of the same make, model, and year has some serious transmission/computer software issues at times. It hesitates and lurches often. I drove on the highway yesterday and the car acted up in the worst way ever.but it seems to me that with information on these same transmission issues plastered all over the internet, your organization would make toyota engineer a permanent fix for this problem, and recall and fix these cars.
- Air bags
We were going on a two way street, (old annapolis road, ellicott city, md-21042) another car crossed the two yellow lanes (median) and hit our car head- on. the front portion of our car and that car hit us was completely damaged. the car behind us could not stop and hit our car from the rear.…
We were going on a two way street, (old annapolis road, ellicott city, md-21042) another car crossed the two yellow lanes (median) and hit our car head- on. the front portion of our car and that car hit us was completely damaged. the car behind us could not stop and hit our car from the rear. we noted that both the driver side and passenger side air bags in our 2005 lexus 330 did not deploy. we were going about 30 miles and the person came in to our lane may be 35 to 40 miles. I tried to apply the horn and stop my vehicle but could not come to a complete stop. The other driver probably dozed out, but the air bags in his car deployed. why the air bags in our car did not deploy? .. Updated 03/31/15 *bf
- Air bags · Structure
The dashboard IS cracking and looks to be expanding. this IS happening on the passenger side airbag seam and it started about 3 years ago. I am very concern this may compromise the airbag and safety. I called my local lexus dealership and corporate headquarters after hearing about many other…
The dashboard IS cracking and looks to be expanding. this IS happening on the passenger side airbag seam and it started about 3 years ago. I am very concern this may compromise the airbag and safety. I called my local lexus dealership and corporate headquarters after hearing about many other models being replaced but my model IS not on the list. On clublexus.com, many users are experiencing the same thing but I am not sure if they have file a vehicle complaint yet. Here IS the link: http://www.clublexus.com/forums/es300-and-es330/657687-es330-shrinking-dash-airbag-cover.html. *tr
- Air bags
Passenger side air bag IS protruding. the vehicle has never been in an accident but I am now concerned that if one were to ocut, the airbag would not work. *tr
- Service brakes
Tl*the contact owns a 2005 lexus es330. The contact stated that while driving at approximately 25 mph, and approaching a stop sign, the brake pedal was depressed but the vehicle failed to stop. The failure recurred multiple times. The vehicle was taken to a dealer where it was diagnosed that the…
Tl*the contact owns a 2005 lexus es330. The contact stated that while driving at approximately 25 mph, and approaching a stop sign, the brake pedal was depressed but the vehicle failed to stop. The failure recurred multiple times. The vehicle was taken to a dealer where it was diagnosed that the rear brakes needed to be realigned. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown. updated 04/03/15*lj updated 9?19/2017*cn
- Service brakes
TL* the contact owns a 2005 lexus es330. While driving between 15 to 20 mph in inclement weather, the brakes were depressed and the vehicle failed to respond. The contact mentioned that the vehicle swerved into a different lane and the contact had to apply extreme force on the brake pedal in order…
TL* the contact owns a 2005 lexus es330. While driving between 15 to 20 mph in inclement weather, the brakes were depressed and the vehicle failed to respond. The contact mentioned that the vehicle swerved into a different lane and the contact had to apply extreme force on the brake pedal in order to stop the vehicle. The failure recurred on numerous occasions. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. updated 1/7/15*cn updated 9/7/2017*cn
- Exterior lighting · Power train
1. Headlights: before purchasing the vehicle, I noticed the blinking caution light on the dashboard. service manager said the automatic headlight adjustment was working fine and to ignore the blinking caution light. nothing could be done. I later researched and found there are lots of complaints…
1. Headlights: before purchasing the vehicle, I noticed the blinking caution light on the dashboard. service manager said the automatic headlight adjustment was working fine and to ignore the blinking caution light. nothing could be done. I later researched and found there are lots of complaints about this. 2. Transmission lags at low speeds. this IS incredibly dangerous especially when driving through traffic circles and going through busy intersections. service manager said this IS normal operating and to use a higher octane gas. I am returning vehicle to lexus. *tr
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Vehicle speed control
In a letter dated july 8, 2005, and after experiencing two incidents (and one crash) where he alleges his model year (my) 2002 camry accelerated without driver input, mr. Jordan ziprin petitioned the national highway traffic safety administration?s (nhtsa) office of defects investigation (odi) to commence a proceeding…
In a letter dated july 8, 2005, and after experiencing two incidents (and one crash) where he alleges his model year (my) 2002 camry accelerated without driver input, mr. Jordan ziprin petitioned the national highway traffic safety administration?s (nhtsa) office of defects investigation (odi) to commence a proceeding to determine the existence of a defect within the etc system in my 2002 to 2005 toyota and lexus vehicles, or to reopen a prior investigation preliminary evaluation (pe) 04-021.in a letter dated august 18, 2005, mr. Ziprin amended his petition to include allegations of interrelated brake and acceleration problems that allegedly result in inappropriate and uncontrollable vehicle accelerations.the 1172 vehicle owner questionnaire reports cited by the petitioner involve 4 lexus and 15 toyota models defining a population of 7 million vehicles.the reports typically alleged a defect in the brake system, the throttle control system, or a combination of both systems.in its review of the reports, odi a) failed to find evidence to support the existence of a brake related defect in the cited models, and b) determined that many cited products were not equipped with etc.accordingly, odi restricted its analysis to the 432 petitioner reports involving my 2002 to 2005 camry, solara, and ES models (all equipped with etc) that alleged an abnormal throttle control event (see the january 3, 2006 federal register notice for further details).about 40% of the 432 reports involve a driveability concern where the operator intentionally applies the throttle pedal, in expectation that the vehicle will accelerate, and then experiences a delay or hesitation in vehicle response.these reports involve vehicle response to intentional driver commands which odi considers unrelated to the allegations raised by the petitioner.therefore, the reports do not provide support for the investigation requested.about 20% of the reports involve incidents where operators allege vehicle acceleration without driver input and an inability of the brake system to control the vehicle when applied.neither the reports, nor the interviews conducted by odi, identified any vehicle-based cause to explain the incidents or disclosed evidence to support that a failure of the brake or throttle control system had occurred.because these reports do not indicate a distinct safety defect for investigation, the reports do not provide support for the investigation requested by the petitionerthe remaining reports (~ 40%, similar to the petitioner?s and those of pe04-021) typically describe incidents where a vehicle IS being maneuvered at slow speed in a close quarter situation at which point the operator alleges that the vehicle accelerates without driver input and crashes.in the aftermath, operators are unsure of whether the brakes were applied or not, sometimes stating there was insufficient time to use the brake; a crash occurred and the operator believes an uncommanded acceleration caused it.in spite of the effort expended during pe04-021 and during this analysis, odi has not identified any vehicle-based cause to explain the reports, or uncovered any evidence to indicate that a throttle control system failure occurred.therefore, the reports have ambiguous significance and do not constitute a basis on which any further investigative action IS warranted.based on the analysis conducted, it IS unlikely that the nhtsa would issue an order for the notification and remedy of a safety related defect at the conclusion of the investigation requested in the petition.consequently, in view of the need to allocate and prioritize nhtsa?s limited resources t
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10214355Lexus Safety Recall and Service Campaign - Technician Certification Requirements 4.13.2022
- 10209023TSB: Some 2005 ? 2022 model year Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this service bulletin is to provide general guidelines and procedures for odor remediation. This service bulletin provides a guide on how to prepare the interior of the vehicle prior to an odor remediation being performed, as well as contact information for an approved vendor who will arrange the remediation, and instructions on how to prepare the interior of the vehicle for reassembly once the remediation has been completed. Refer to all model and model year specific Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This service bulletin is to provide a general overview and direction for the odor remediation process.
- 10207945POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Lexus. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Lexus.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center in Dealer Daily as well.
- 10205383Spots in Window Glass - vehicle exterior
- 10205357Fuel Delivery Pipe Replacement
- 10205352Windshield Wiper Blade Maintenance and cleaning
- 10205346Auto matic Transmission Replacement kPrecautions
- 10205331Immobilizer and Smart Key Reset
- 10205330Immobilizer and Smart Key Reset
- 10205329Immobilizer and Smart Key Reset.
- 10205327Techstream ECU Flash Reprogramming Procedure.
- 10205319Brake Pedal Force Gauge SST for Parking Brake Inspection.
- 10179697TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should be repaired accordingly and will be covered under warranty if applicable. Cases that are determined to be a ?seep? should be documented on the repair order and inspected at the next service interval. Follow the Repair Information in this bulletin to determine if the concern in question is a fluid leak or fluid seep and review the Repair Procedure section to address this condition.
- 10179601TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should be repaired accordingly and will be covered under warranty if applicable. Cases that are determined to be a ?seep? should be documented on the repair order and inspected at the next service interval. Follow the Repair Information in this bulletin to determine if the concern in question is a fluid leak or fluid seep and review the Repair Procedure section to address this condition.
- 10177783TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see L-SB-0023-20.
- 10177780TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST004-01, SU001-08, and L-SB-0174-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding. This Service Bulletin provides best practice procedures for vehicle pulling complaint, diagnosis, and repair for 2002 ? 2021 model year Lexus vehicles. This information supplements Repair Manual procedures when the symptoms are: ?Vehicle Pulling: The vehicle moves to the right or left when the driver holds the steering wheel while driving straight ahead without exerting steering effort. ?Steering Wheel Off Center: The vehicle travels straight, but the steering wheel is not pointed straight ahead. The vehicle is not pulling. Before repairing a vehicle pulling to one side, it is necessary to clearly identify the cause of the pulling condition. Frequently, pulling to one side is diagnosed as a wheel alignment concern. However, the actual cause may be related to the lateral force generated by the tires, vehicle damage, road crown or worn components. Performing a wheel alignment when tire force is the cause could result in the wheel alignment being set at a value outside of specifications. This could then cause other problems such as uneven tire wear, etc. A customer may notice a pull to the left when in the left lanes of travel and notice a pull to the right or no pull when traveling in the right lanes of travel on the very same section of roadway. This road crown effect is environmental and cannot be corrected with suspension adjustments or any other wheel or tire modification discussed in this bulletin.
- 10176283Safety Recall and Service Campaign - Technician Certification Requirements
- 10174889TSB: OBSOLETE NOTICE April 06, 2020: This bulletin is now obsolete. Please see L-SB-0008-20. Replacement Certification Labels and VIN Plates
- 10174888TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003-93, PG002-90, L-SB-0048-08, PG007-07, PG016-01, PG015-01, PG004-97, PG003-97, PG003 93, and PG002-90. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1990 ? 2020 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin.
- 10133926In the recent Bi-annual Floor Mat reminder letter distributed November, 2012, Lexus indicated that we were developing support materials that will help remind dealership customers and associates of the importance of proper floor mat usage.
- 10133923Lexus vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devices did not per
- 10133914Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprograming process and outlines use of the TIS and the CUW.
- 10133910When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or other compounds that may contaminate electrical contacts, and therefore increase electrical resistance and decrease switch performance. The use of any cleaners or fluids may increase the risk of further damage to electrical components.
- 10133866Navigation/ Multi Info Display Day Mode Operation
- 10133849A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the Brake Pedal Force Gauge. Refer to the appropriate Repair Manual for parking brake pedal travel inspection and adjustment specification.
- 10132778TSB: OBSOLETE NOTICE-June 12, 2014: This bulletin is now obsolete.
- 10132777TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
- 10132734TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
- 10132726TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
- 10132625TSB: Revision Notice: Applicability section has been updated to include 2016-2017 applicable model year Lexus vehicles. The Repair Procedure section, Required Tools & Equipment section, and the Repair Procedure section has been updated. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
- 10132302If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, the source of the noise may be the two windshield stoppers bonded to the top of the windshield or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield area.
- 10132276Certain service publications, Technical Service Bulletins, Service Campaign Technical Instructions and Service & Parts Operation Communication Bulletins may reference specifically required adhesives and sealants
- 10132273Prior to tire rotation use the quick reference chart below to verify the size of the lug nut and the lug nut torque specifications. The quick reference chart is applicable to current generation vehicles only.
- 10132146If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved.
- 10132108This bulletin is now obsolete. Please see L-SB-0082-14.
- 10132083Adhesive & sealant cross reference Information
- 10132074Beginning in 1998, Lexus introduced side airbags as optional equipment. Lexus does NOT recommend replacement of original seat covers with non-Lexus leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Lexus may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Lexus leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury. Lexus strongly discourages modifying original equipment seats that have optional side airbags. Additionally, Lexus strongly advises against the installation or use of aftermarket seat covers, which could impair the performance of the side airbags in the event of an accident.
- 10132006This bulletin is now obsolete. Please see L-SB-0092-13.
- 10132004The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
- 10131964Lexus vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
Every Lexus ES330 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.