2005 Mitsubishi Endeavor
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Mitsubishi › Endeavor › 2005
These records cover every 2005 Mitsubishi Endeavor. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2005 Mitsubishi Endeavor. Newest first.
Mitsubishi IS recalling certain model year 2004-2010 endeavor vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virginia…
Risk and remedy
Risk
Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Dealers will replace the fuel filler pipe with a new improved part free of charge. the safety recall IS expected to begin on or before july 5, 2010. owners may contact mitsubishi at 1-800-222-0037.
Mitsubishi IS recalling 45,988 my 2005-2007 endeavor, galant, eclipse coupe, and my 2007 eclipse spyder vehicles. the bracket that IS the attachment point for the left rear fuel tank mounting strap may have been improperly formed during a metal stamping process. the process may have caused the metal to have a split in the area where the bolt that holds…
Risk and remedy
Risk
Fuel leakage in the presence of an ignition source could result in a fire.
Remedy
Dealers will inspect to see if the left rear fuel tank strap mounting bracket has splitting beyond a specific limit. vehicles with moderate to severe splitting will be repaired using a reinforcement cap, a special structural adhesive, and a rivet to reinforce the fuel tank mounting bracket. The recall began on september 20, 2008. owners may contact mitsubishi at 1-800-222-0037.
Mitsubishi IS recalling 120,000 my 2004-2006 endeavor passenger vehicles. during vehicle use, the ignition key interlock cable (which IS a component of the interlock system) may allow the interlocking cam to fall forward and allow the ignition key to be removed from the ignition switch when the gearshift mechanism IS not in the park position.
Risk and remedy
Risk
If the driver does not shift to park before removing the key and fails to engage the parking brake, the vehicle could roll and a crash could occur.
Remedy
Dealers will inspect and correct these vehicles for the reported condition. the recall will begin on july 7, 2008. owners may contact mitsubishi at 1-888-648-7820.
On certain sport utility vehicles, the material used to manufacture the front disc brake calipers may be brittle due to improper metallurgy.
Risk and remedy
Risk
This could cause fracture of the brake caliper and subsequent unexpected partial loss of braking force, which could result in a vehicle crash.
Remedy
Dealers will inspect and replace the front brake caliper if necessary free of charge. the recall began on april 10, 2006. owners may contact mitsubishi at 1-800-222-0037.
On certain passenger vehicles equipped with anti-lock brakes, the brake master cylinder, which controls the fluid pressure to the vehicle's brakes, may allow brake fluid to bypass internally during stopping.
Risk and remedy
Risk
This may result in a partial loss of braking, increased stopping distances, and could lead to a vehicle crash.
Remedy
Dealers will replace the brake master cylinder. the recall began on october 3, 2005. owners may contact mitsubishi at 1-800-222-0037.
On certain sport utility vehicles, the parking brake pedal cable lock nut may not have been tightened to the proper torque specification. the lock nut may loosen and come off, which will reduce the effectiveness of the parking brake.
Risk and remedy
Risk
This condition could allow the vehicle to roll if the transmission IS not placed into the "park" position and the vehicle IS parked on a slope, thus raising the possibility of a crash.
Remedy
Dealers will inspect and tighten the parking brake cable lock nut, if necessary free of charge. the recall began february 24, 2005. owners may contact mitsubishi at 1-800-222-5500.
Owner complaints
40 complaints6 involved a crash2 involved a fire3 injuries
What owners report most
Latest complaints
- Fuel system, gasoline
The contact owns a 2005 Mitsubishi Endeavor. The contact stated that while refueling the vehicle on two occasions, gasoline was leaking under the driver’s rear, underneath the fuel door, onto the ground. The contact stated that after refueling the vehicle, the fuel leak ceased. The vehicle was…
The contact owns a 2005 Mitsubishi Endeavor. The contact stated that while refueling the vehicle on two occasions, gasoline was leaking under the driver’s rear, underneath the fuel door, onto the ground. The contact stated that after refueling the vehicle, the fuel leak ceased. The vehicle was taken to the residence. The contact stated that on the second occasion, while refueling the vehicle, an oil pan was placed underneath. After refueling the vehicle, there was an eighth of a cup of fuel inside the oil pan. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Campaign Number: 10V065000 (Fuel System, Gasoline). The manufacturer was not notified of the failure. The failure mileage approximately 160,000.
- Power train
I was using an exit to merge into the highway and when I merged, the vehicle completely lost power. I could hear the engine working but no power to the vehicle. A semi almost totaled me but thank god it merged thanks to another driver. The rolled barely making it to the side of highway and found…
I was using an exit to merge into the highway and when I merged, the vehicle completely lost power. I could hear the engine working but no power to the vehicle. A semi almost totaled me but thank god it merged thanks to another driver. The rolled barely making it to the side of highway and found out the transmission blew out. I want to make this perfectly clear: I do routine maintenance conducted at professional shops for all oil changes and or other issues religiously and the miles on vehicle aren't high. In other words, I almost lost my life because of this with no working vehicle to add. This incident happened in a busy highway. No acceleration, reverses or anything else other than park. The mechanics told me that this model comes with a cheap filter that allows anomalies such as poorly made material from the SUV or others to slowly get in the transmission. As stated before, I regularly keep up maintenance to this vehicle. I don't know how this happened but a good transmission all of a sudden died and I too almost lost my life from a semi doing 75 on a highway.
- Structure › Body
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that extensive mold developed due to a leak in the vehicle. Due to the placement of the air conditioning drain plug, water leaked onto the floorboard. The contact stated that the carpet in the vehicle was soaked. While driving and…
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that extensive mold developed due to a leak in the vehicle. Due to the placement of the air conditioning drain plug, water leaked onto the floorboard. The contact stated that the carpet in the vehicle was soaked. While driving and attempting to depress the brake pedal, the contact's foot slipped off of the brake pedal due to the bottom of her shoe being wet from the leak. The vehicle was taken to several independent mechanics who confirmed that the water leaked from the drain plug. The vehicle was not repaired. A dealer and the manufacturer were not contacted. The approximate failure mileage was 112,000.
- Electrical system
My vehicle has the same problem as 2006-2008 model years of the same car. That IS, the heater controller signal to the hvac system codes as U111, and consequently the a/c will not turn on at all, but indicator light shows it to be on. The compressor IS not receiving the signal from the controller. The dealer says this recall (number 10v514000) does not cover 2005 cars.
- Exterior lighting · Structure › Body
As I was driving on the highway and and as I sped up the vehicle kept fish tailing it felt like it was the front of the vehicle . so I went straight to my mechanic and he showed me the rust of the rear subframe of the car and it was detached and broken. he suggested I not drive the vehicle because I amy lose co trol of the vehicle.
- Unknown or other
The vehicle has a very bad vibration and severe wining sound, not sure what it IS but we dont feel safe driving it. New tires , rotors, and breaks were installed and still the same problem. It usually starts vibration at about 25 mph and IS hard to maintain a speed.
- Unknown or other
Air conditioning drain plug doesn't drain and driver side floor gets very wet causing damaged floor and moldy smell after a while
- Fuel/propulsion system · Service brakes
Wet floor board on drivers side due to a leaking hvac. May cause slippery feet while operating vehicle. Also causing mildew and or rust. Seen lots and lots of discussion on net about this known problem. And they even have a bulletin on there website for the problem. but no recall?
- Engine · Power train · Service brakes
I was pulling into an apartment parking lot at 3 miles per hour or less applied brake and car surged forward. I applied more pressure to brake and the car surged again and would not stop. This caused me to crash into a unoccupied parked car which banged another unoccupied car parked next to it.…
I was pulling into an apartment parking lot at 3 miles per hour or less applied brake and car surged forward. I applied more pressure to brake and the car surged again and would not stop. This caused me to crash into a unoccupied parked car which banged another unoccupied car parked next to it. All 3 cars were damage. My car and the car I hit sustained front end damage. The third car was scraped along the driver side door and rear panel. There was a witness to this accident that told the responding california chp officer that he saw my car experience two surges as I slowly entered the parking. He also informed the office that he saw my break lights on before the first surge happened. updated 02/24/16*lj updated 12/12/2017*cn
- Electrical system · Equipment › Appliance › Air conditioner · Structure › Body
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that extensive mold was developing inside of the vehicle due to leak in the interior of the vehicle. The vehicle was taken to an authorized dealer where it was diagnosed that the air conditioning box and tube needed to be cleaned…
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that extensive mold was developing inside of the vehicle due to leak in the interior of the vehicle. The vehicle was taken to an authorized dealer where it was diagnosed that the air conditioning box and tube needed to be cleaned and replaced. The contact was included in nhtsa campaign number: 08v139000 (electrical system). The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 160,000.
- Seat belts
Drivers seat belt latch sticks. It takes several times of pressing release button to unlatch the belt. *Tr
- Engine and engine cooling
My air conditioner keeps going out every year. I have own the vehicle 2 1/2 years. I am having to have the air conditioner fixed again ( that IS the summer of 2013, & 2014). I have talked to other owners who are having the same problem. This IS costing me around $400.00 every year. I would like…
My air conditioner keeps going out every year. I have own the vehicle 2 1/2 years. I am having to have the air conditioner fixed again ( that IS the summer of 2013, & 2014). I have talked to other owners who are having the same problem. This IS costing me around $400.00 every year. I would like someone to investigate and fix this problem. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *tr
- Service brakes
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that the brake warning lamp illuminated. The contact mentioned that the vehicle was consuming excessive brake fluid. The vehicle was taken to the dealer where the technician diagnosed that the brake booster, master cylinder, and…
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that the brake warning lamp illuminated. The contact mentioned that the vehicle was consuming excessive brake fluid. The vehicle was taken to the dealer where the technician diagnosed that the brake booster, master cylinder, and wheel cylinders needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage was 40,000.
- Electrical system
I was driving along the highway, I smelled what seems to be burning plastic, I saw smoke from under my glove compartment, suddenly my a/c stop working. Upon inspection I notice that the electrical plug to the fan motor looked charred/burnt. I removed it for safety reasons. I read over the internet that IS a common problem with these vehicles, the item should be recalled. *tr
- Service brakes
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that while driving 50 mph, he depressed the brake pedal and heard an abnormal grinding noise. The contact exited the vehicle and noticed that the front passenger's side rotor was corroded and had become fractured. The vehicle was…
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that while driving 50 mph, he depressed the brake pedal and heard an abnormal grinding noise. The contact exited the vehicle and noticed that the front passenger's side rotor was corroded and had become fractured. The vehicle was not taken to the dealer for inspection or repairs. The manufacturer was notified of the failure. The failure mileage was 100,000.
- Structure › Body
Drivers side floor soaked, after checking forums sounds like a a/c drain issue. *tr
- Electrical system
I was driving the vehicle home from work when I smelled electrical wire burning through out the car. It was coming from under the glove compartment. I pulled off the road to investigate. The connector to the a/c & heater motor was charred. During internet research I discovered that this IS very…
I was driving the vehicle home from work when I smelled electrical wire burning through out the car. It was coming from under the glove compartment. I pulled off the road to investigate. The connector to the a/c & heater motor was charred. During internet research I discovered that this IS very common occurrence. What people have said on-line was that it was a poor design, thus the connecting pins are too close which causes them to heat up and char the connector. if I would have had a new paper or backpack in that area, it could cause a fire while driving resulting in a fatal accident. I tried reconnecting, that part I used was charred a second time. I believe it should be recalled by the manufacturer. *tr
- Latches/locks/linkages · Structure
The rear trunk latch fails to unlock. I cannot open either the glass or the trunk. Have to use the manual release from inside to open. *tr
- Electrical system · Engine and engine cooling › Cooling system
Air conditioning water drains into the vehicle causing clogging and flooding of the drivers side floor the mileage IS only115k. This causes bad odor,growth of microorganisms and could lead to accidents because the floor on the drivers side becomes slippery. Took it to the dealer but they said they…
Air conditioning water drains into the vehicle causing clogging and flooding of the drivers side floor the mileage IS only115k. This causes bad odor,growth of microorganisms and could lead to accidents because the floor on the drivers side becomes slippery. Took it to the dealer but they said they have been receiving same complaints. They inspected it for 30 minutes and said looks like the problem has been fixed. Next day after using the air condition for about an hour the floor was flooded again. *tt
- Structure › Body
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that the exterior door handles fractured from all four doors, as well as the rear hatchback door. the contact spoke with the manufacturer and was told there was no warranty for the door handles. The contact stated that he had to…
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that the exterior door handles fractured from all four doors, as well as the rear hatchback door. the contact spoke with the manufacturer and was told there was no warranty for the door handles. The contact stated that he had to enter the vehicle through the hatch as a result of the failure. The vehicle was not repaired. The failure mileage was unknown and the current mileage was 80,000.
- Structure › Body · Visibility
TL* the contact owns a 2005 mitsubishi endeavor. The contact stated that the driver side door window dropped and shattered from the interior of the vehicle. The contact mentioned that the door knob was fractured in half. The vehicle was not taken to the dealer and the manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and current mileage was 130,000.
- Service brakes, hydraulic
TL* the contact owns a 2005 mitsubishi endeavor. The contact was driving 10 mph when the brakes were depressed but the vehicle failed to stop. the emergency brake was deployed in order to stop the vehicle. The contact also mentioned the vehicle caliper was detached under the vehicle. The vehicle…
TL* the contact owns a 2005 mitsubishi endeavor. The contact was driving 10 mph when the brakes were depressed but the vehicle failed to stop. the emergency brake was deployed in order to stop the vehicle. The contact also mentioned the vehicle caliper was detached under the vehicle. The vehicle was taken to a private mechanic where the mechanic confirmed that the caliper and front brakes needed to be replaced. The manufacturer was contacted and they confirmed that the vin did not qualify for repairs under nhtsa campaign ID number: 06v068000 (service brakes, hydraulic: foundation components:disc:caliper). The vehicle was repaired. The failure mileage was 80,000 and the current mileage was 82,000.
- Electrical system · Service brakes, hydraulic · Unknown or other
While air conditioner IS running and vehicle IS in motion, blower stops blowing cold air, water drips inside vehicle on passenger side floor gets soaked with water and moldy smell inside vehicle. When making turns, you can hear water sloshing around inside the dashboard, and what sounds like static…
While air conditioner IS running and vehicle IS in motion, blower stops blowing cold air, water drips inside vehicle on passenger side floor gets soaked with water and moldy smell inside vehicle. When making turns, you can hear water sloshing around inside the dashboard, and what sounds like static or sparks behind the dash. Water sometimes run over onto the gas and brake pedals, casing a dangerous situation. Blower motor has since stopped working as a result of water constantly running down on it.
- Service brakes, hydraulic
TL* the contact owns a 2005 mitsubishi endeavor. The contact was driving 35 mph when the front brake calibers detached forcing an emergency stop. the vehicle was unable to be driven and was towed. The vehicle was serviced by a private mechanic who confirmed the failure. the vehicle was repaired…
TL* the contact owns a 2005 mitsubishi endeavor. The contact was driving 35 mph when the front brake calibers detached forcing an emergency stop. the vehicle was unable to be driven and was towed. The vehicle was serviced by a private mechanic who confirmed the failure. the vehicle was repaired by replacing the calibers and installing new brakes. The manufacturer was contacted who advised that the vin did not qualify for repairs under nhtsa campaign ID number: 06v068000 (service brakes, hydraulic:foundation components:disc:caliper). the failure mileage was 130,000 and the current mileage was 131,000.
- Engine and engine cooling › Cooling system
Air conditioning water recipient clogs causing flooding of the drivers side floor. It IS the third time it happens to my mitsubishi endeavor 2005 SUV., whose mileage IS 55K. This causes bad odor,growth of microorganisms and could lead to accidents because of wet shoes. Additionally, unclogging the water recipient IS expensive. *tr
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Ignition-park interlock system
The subject vehicle ignition-park interlock and shift lock (brake-shift interlock) systems are mechanically actuated.the systems utilize two cable assemblies that connect to a plastic housing mounted to the shift lever mechanism.within the housing IS a lever (interlock lever) that the ignition-park interlock cable…
The subject vehicle ignition-park interlock and shift lock (brake-shift interlock) systems are mechanically actuated.the systems utilize two cable assemblies that connect to a plastic housing mounted to the shift lever mechanism.within the housing IS a lever (interlock lever) that the ignition-park interlock cable connects to.when the interlock lever IS positioned in its rearward travel range, the ignition key removal IS prevented; when the lever IS positioned in its forward position, key removal IS allowed.according to mitsubishi, the ignition key interlock cable may allow the interlock lever to fall forward during vehicle use.in this state the ignition key can be removed from the ignition switch when the gearshift mechanism IS not in the park position.if the driver does not shift to park before removing the key and fails to engage the parking brake, the vehicle could roll and a crash could occur.most of the reported crash incidents were minor in nature involving unoccupied vehicles rolling from a parked condition and striking other vehicles or objects.the single injury incident occurred when the operator parked the vehicle, exited, and was subsequently struck by the vehicle as it rolled away.the type and severity of the injuries were not described.in a letter dated march 21, 2008, mitsubishi advised nhtsa that it will conduct a safety recall to address this condition (see www.safercar.gov, recall action 08v-139 for further details); remedy details and timing are to be determined.accordingly the investigation IS closed.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10240443This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.
- 10235609This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.
- 10235608This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.
- 10235606This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.
- 10211530This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.
- 10170852This Technical Service Bulletin updates the door adjustment procedure in the Body Section of the applicable service manuals.
- 10170102This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170100This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170099This is an index of Tech Talk newsletter articles released in 2012.
- 10170097This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170096This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170087This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170086This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170074This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170071This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170070This TSB contains troubleshooting steps for diagnosis of various customer complaints relating to the audio system speakers in Mitsubishi vehicles equipped with original equipment audio components.
- 10169006This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10163703This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
- 10152965This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Cover.
- 10130469This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10130468This is a message sent to dealers, to inform them that an update for MEDIC will be available.
- 10046519Mitsubishi: on some vehicles, an active stability control (asc) steering wheel sensor has been installed, replacing original sensor. New sensor not to be rotated before installation. Models 2007-12 outlander, 2008-11 lancer evolution, 2010-12 lancer/lancer sportback & galant, 2008-12 eclipse/eclipse spyder, 2004-11 endeavor.
- 10030329Mitsubishi: liftgate gas spring bolt torque service manual revision. The tightening torque for the liftgate gas spring bolts IS incorrectly printed in he affected service manual pages. This bulletin contains the correct torque specification for the liftgate gas spring bolts.
- 10021743Reprogramming the pcm drivability or sensitivity issues can be corrected.
- 10020105Seat belt stopper button replacement.
- 10019921Freeze-frame data for misfire conditions.
- 10019649Tire pressure monitoring system.
- 10018782Rear suspension bushing replacement - service manual revision. Various models including the 2006 endeavor.
- 10018382Wind noise from delta glass area. Mitsubishi. Tech talk.
- 10018378Buzz or rattle in rear speaker area. Mitsubishi. Tech talk.
- 10018375Time interval adjustments for lights and wipers. All mitsubishi models with adjustable time interval function for wiper and lights. Tech talk.
- 10018367Water leaks. Refer to 03-42b-003. Mitsubishi. Tech talk.
- 10018364High-pitched whine that varies with slight acceleration, sometimes on deceleration. Mitsubishi tech talk.
- 10018360Replacement engine gasket service parts now available.
- 100167542-3 shift flare.
- 10016133Alternator fr terminal voltage - service manual revision.
- 10016006Ignition key ring antenna inspection-service manual revision.
- 10015842Immobilizer system information update
- 10015720Seat side seam tearing. Mitsubishi tech talk.
- 10015717Transaxle gear whine. Mitsubishi tech talk.
Every Mitsubishi Endeavor model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.