2005 Mitsubishi Galant
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Mitsubishi › Galant › 2005
These records cover every 2005 Mitsubishi Galant. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 2005 Mitsubishi Galant. Newest first.
Mitsubishi IS recalling 45,988 my 2005-2007 endeavor, galant, eclipse coupe, and my 2007 eclipse spyder vehicles. the bracket that IS the attachment point for the left rear fuel tank mounting strap may have been improperly formed during a metal stamping process. the process may have caused the metal to have a split in the area where the bolt that holds…
Risk and remedy
Risk
Fuel leakage in the presence of an ignition source could result in a fire.
Remedy
Dealers will inspect to see if the left rear fuel tank strap mounting bracket has splitting beyond a specific limit. vehicles with moderate to severe splitting will be repaired using a reinforcement cap, a special structural adhesive, and a rivet to reinforce the fuel tank mounting bracket. The recall began on september 20, 2008. owners may contact mitsubishi at 1-800-222-0037.
Mitsubishi IS recalling 73,000 my 2004-2006 gallant passenger vehicles. during vehicle use, the ignition key interlock cable (which IS a component of the interlock system) may allow the interlocking cam to fall forward and allow the ignition key to be removed from the ignition switch when the gearshift mechanism IS not in the park position.
Risk and remedy
Risk
If the driver does not shift to park before removing the key and fails to engage the parking brake, the vehicle could roll and a crash could occur.
Remedy
Dealers will inspect and correct these vehicles for the reported condition. the recall began on september 2, 2008. owners may contact mitsubishi at 1-888-648-7820.
On certain passenger vehicles equipped with anti-lock brakes, the brake master cylinder, which controls the fluid pressure to the vehicle's brakes, may allow brake fluid to bypass internally during stopping.
Risk and remedy
Risk
This may result in a partial loss of braking, increased stopping distances, and could lead to a vehicle crash.
Remedy
Dealers will replace the brake master cylinder. the recall began on october 3, 2005. owners may contact mitsubishi at 1-800-222-0037.
Owner complaints
26 complaints1 involved a crash1 involved a fire1 injuries
What owners report most
Latest complaints
- Suspension · Unknown or other
Seems struts, shocks, cadallytic converter are bad
- Fuel/propulsion system
TL* the contact owns a 2005 mitsubishi galant. While driving 50 mph, an odor of fuel was detected inside the vehicle. Upon inspecting the vehicle, a leak was detected under the rear driver's side bracket under the fuel tank. Springfield mitsubishi (313 baltimore pike, springfield, pa 19064, (484)…
TL* the contact owns a 2005 mitsubishi galant. While driving 50 mph, an odor of fuel was detected inside the vehicle. Upon inspecting the vehicle, a leak was detected under the rear driver's side bracket under the fuel tank. Springfield mitsubishi (313 baltimore pike, springfield, pa 19064, (484) 574-8434) was contacted and stated that the vehicle was not included in nhtsa campaign number: 08v454000 (fuel system, gasoline). The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 115,000.
- Tires
Last week fri mar. 16, 2018, I drove my 2005 mitsubishi gallant ES car into work. on my way, I heard a pop sound from the car. then a very loud car noise and felt rattling, and the car drive was not a smooth one. I figured it was a flat tire. I was entering the I75 highway. once on the…
Last week fri mar. 16, 2018, I drove my 2005 mitsubishi gallant ES car into work. on my way, I heard a pop sound from the car. then a very loud car noise and felt rattling, and the car drive was not a smooth one. I figured it was a flat tire. I was entering the I75 highway. once on the highway, I pulled across 3 lanes to the right shoulder of the highway. this was 7 am and dark, and also during rush hour traffic so lucky to be able to pull over safely. I drove about a few seconds on the shoulder, stopped the car, and parked there. I could smell burning metal. I then called aaa and the service driver came and changed the flat tire. this was not a simple punctured car tire. the michelin car tire had exploded - the car tire had come off the rim. after this exploding car tire incident, I am emotionally shaken and scared. to think that I could have been killed, and not be here today because of a possible defective tire. or I could have suffered serious injuries, or caused a major accident on the highway. note: 1.I purchased the 4 sets of tires from costco on dec. 20, 2016, and the odometer reading was 125,597 km; and right now, the odometer reading IS about 151,350 km, therefore these 4 sets of tires had only been driven 25,753 km or 25,753 km / 1.60934 km/mile = 16,002 miles over in about 15 months. 2.THE vehicle was originally from canada, therefore it reads in km instead of mile. 3.I have taken photos of the exploded tire which completely separated from the rim. I can send those photos to you anytime. 4.I will be going to costco to replace the tire this week, I think costco will want to keep the exploded tire, should I give it to costco?
- Air bags
TL* the contact owned a 2005 mitsubishi galant. While driving approximately 40 mph, the contact's vehicle crashed into the rear of another vehicle. The air bags failed to deploy. A police report was filed. The contact sustained injuries to the chest, back, and neck. Medical attention was required. The vehicle was destroyed and towed to an independent towing facility. The vin and failure mileage were unknown.
- Structure › Body
About 1YR. Ago paint started fading dealer did not help me, what can I do. *tr
- Air bags
Good morning, I purchased my 2005 mitsubishi galant ES in june or july of 2005 with approximately 1,400 miles and for the pasted few weeks I've notice the passenger air bag IS rising/separating more and more of the dashboard exactly above the glove compartment silver trimming. I contact the…
Good morning, I purchased my 2005 mitsubishi galant ES in june or july of 2005 with approximately 1,400 miles and for the pasted few weeks I've notice the passenger air bag IS rising/separating more and more of the dashboard exactly above the glove compartment silver trimming. I contact the mitsubishi dealer (866-346-0796) on sept. 10, 2013 where I my purchased the vehicle and explained to them in detail the problem with the passenger air bag. The service writer asked for the last eight digit of the vehicle vin # which I provided. The service writer pulled up the history in his computer and advised me that the car was out of warranty and there IS nothing they can do about. I was very surprised by his answer and told him I will contact mitsubishi corp. Office to find a resolution to this problem before it get worst. and for the record I've previously owned two montero mitsubishi SUV. *tr
- Structure › Body
Paint IS coming off even though it IS properly cared for, garaged etc. this IS a known paint issue and I'm wanting it fixed.. No one will buy this vehicle in this condition. owned since new in 2005. *tr
- Steering
TL* the contact owns a 2005 mitsubishi galant. The contact stated that the vehicle pulled to the right when being driven. The contact took the vehicle to the dealer and had it test driven. The dealer advised the contact that the vehicle was performing as designed. the contact believed that the…
TL* the contact owns a 2005 mitsubishi galant. The contact stated that the vehicle pulled to the right when being driven. The contact took the vehicle to the dealer and had it test driven. The dealer advised the contact that the vehicle was performing as designed. the contact believed that the torque on the front passenger side axle was too tight and causing the failure. The failure mileage was unknown and the current mileage was 15,000.
- Structure
I have a 2006 mitsubishi galant that IS out of warranty and only has 65K miles on the odometer. It a black galant and the paint IS fading in spots, it looks like oxydation IS setting in, I've tried over the counter polishes to correct the problem to no avail. This imho, IS a paint defect and I feel…
I have a 2006 mitsubishi galant that IS out of warranty and only has 65K miles on the odometer. It a black galant and the paint IS fading in spots, it looks like oxydation IS setting in, I've tried over the counter polishes to correct the problem to no avail. This imho, IS a paint defect and I feel that mitsubishi should correct the problem. The car looks like like crap now and I am not likely to purchase another galant if this IS not remedied. *tr
- Structure
I have a black 2005 mitsubishi galant. Within the past year the paint has been fading by turning a off white in some areas and it IS spreading like cancer. I even have a spot that IS getting rusted. I am not sure what to do but there needs to be a paint recall. I need my paint fixed please before it spreads everywhere. I have three children and am not able to purchase a new car at this time. *Tr
- Structure › Body
Black paint on car IS coming off despite proper care and garage. *Tr
- Tires
Tl*the contact owns a 2005 mitsubishi galant. the vehicle has mastercraft a/s IV steel belted radial tires, size p225/70r15. while driving approximately 60 mph, the contact felt the rear passenger side of the vehicle drop down. he maneuvered onto the side of the road and discovered that the tread had separated from the tire all the way around. the current mileage was 78,000 and failure mileage was 76,000.
- Engine and engine cooling · Service brakes, hydraulic
My 2005 galant has been experiencing brake problems I reported it to mitsubishi dealer before my warranty expired and they told me there was nothing wrong just a glaze. I finally took it somewhere else to get the brakes done they replaced the pads 2 weeks later the brakes started making noise…
My 2005 galant has been experiencing brake problems I reported it to mitsubishi dealer before my warranty expired and they told me there was nothing wrong just a glaze. I finally took it somewhere else to get the brakes done they replaced the pads 2 weeks later the brakes started making noise since then I have taken them back for the same problem over and over again all they tell me, its a glaze but the noise gets louder. The engine also makes a clicking noise that doesn't sound right. *tr
- Service brakes, hydraulic
There IS a recall on certain 2005 galants but I was told not mine. I am having the same problems with my brakes as the recall states. I have had it to the dealer and told the first time that there was nothing wrong. the second time they ordered a timing part but I feel that IS not the problem.…
There IS a recall on certain 2005 galants but I was told not mine. I am having the same problems with my brakes as the recall states. I have had it to the dealer and told the first time that there was nothing wrong. the second time they ordered a timing part but I feel that IS not the problem. I go tomorrow to have the part put on. I fear for my safety with these malfunctioning brakes. they make a terrible grinding noise and my car lurches forward about 4 inches and IS only getting worse. I asked just because my car isn't in the recall it doesn't mean I am not having the same problem. how long do I need to ride around in a car with damaged brakes before the problem IS corrected. I have not had an accident yet and would like to get this problem fixed so I don't end up in one. *tr
- Engine and engine cooling › Cooling system › Fan · Equipment › Appliance › Air conditioner · Exterior lighting › Fog lights › Switch · Exterior lighting › Headlights · Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Brake failure when you stop the brakes scrub I have receipts showing that the I have to continue to have the brake inspected and also have to slam very hard when trying to stop the car. The noise when you are stopping the car IS very loud and contact the manufacturer and was told nothing they can…
Brake failure when you stop the brakes scrub I have receipts showing that the I have to continue to have the brake inspected and also have to slam very hard when trying to stop the car. The noise when you are stopping the car IS very loud and contact the manufacturer and was told nothing they can do due to no warranty. Also, there IS no signal indicating when the car needs oil, no check engine comes on, front lights blew a week after buying the car and replace it several times and continue to blow, the same brake light blew again and contact mitsubishi and ask them about it and they told they will charge me to fix it. When pulling up the brake in the car no light indicating that the brake light IS on. My fan for the ac stop working and now when I drive I can hear the ac sounds like it IS going to blow when you turn it on. *tr
- Exterior lighting › Headlights
Tl*the contact owns a 2005 mitsubishi galant. the driver side headlights have failed three times within the past 12 months. the first failure occurred while driving 15 mph. the contact has taken the vehicle to the dealer everytime the failure occurs, but they could not determine the cause of the failure. the failure mileage was 31,000 and current mileage was 51,000. Updated 04/14/08. *lj updated 04/11/08 *tr
- Electrical system › Wiring › Front underhood
My car would not start at all. After it being towed to a garage, they diagnosed the problem to be the electrical wiring harness. It was chafing against the engine and causing a short. When they replaced all the fuses the car sparked and smelled of smoke with small flames by the fuse box. The…
My car would not start at all. After it being towed to a garage, they diagnosed the problem to be the electrical wiring harness. It was chafing against the engine and causing a short. When they replaced all the fuses the car sparked and smelled of smoke with small flames by the fuse box. The mechanic ended having to replace the harness. But said that this maybe a universal problem as my car IS only a 2005 mitsubishi galant. Of course it has 72,000 miles so it IS out of warranty. *tr
- Service brakes, hydraulic › Foundation components › Disc › Rotor
The vehicle has a consant squeaking noise and a slight vibration when braking. I have contacted the local mitsubitsi service department 4 times about this concern. I know that it IS not the brake pads because I have changed them 4 times and the vehicle only has 27000 miles. I was told at…
The vehicle has a consant squeaking noise and a slight vibration when braking. I have contacted the local mitsubitsi service department 4 times about this concern. I know that it IS not the brake pads because I have changed them 4 times and the vehicle only has 27000 miles. I was told at my last visit that I should have reproted this problem before the vehicle had 10000 miles. however, when I told the service clerk that I had, he advised me that they had no record of it, only that I had taken the car in for oil changes. I feel that my vehicle IS unsafe. it IS not normal for a vehicle do the above described when braking.*ak
- Fuel system, gasoline
Car stopped while driving. I took the car to the dealership and 8 hours later they said that the car was overfilled causing the filter and canister to be saturated with fuel making the vehicle stop. (although I know I did not overfill my vehicle) there IS nothing in the owners manual or warranty warning not to overfill the gas tanks and that it will cause car failure while driving. *jb
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
I feel there IS a dangerous defect in anti-skid brakes. I have contacted mitsubishi and feel their response IS inadequate. anti-skid function failed during two emergency stops and almost resulted in rear-end collisions. anti-skid function also actuates when there IS no braking condition that warrants it to activate. *jb
- Electrical system · Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module · Structure › Body › Door › Hinge and attachments
Dt*: the contact stated, on two separate occasions there have been multiple times the abs/tcl (traction control) has disengaged without warning. Each occurrence was at different speeds. The dealer's service technicians have inspected the vehicle on several occasions. updated 8/9/2006 - the…
Dt*: the contact stated, on two separate occasions there have been multiple times the abs/tcl (traction control) has disengaged without warning. Each occurrence was at different speeds. The dealer's service technicians have inspected the vehicle on several occasions. updated 8/9/2006 - the traction control light disengages while at speed with or without cruise control on, the consumer feels that the ABS system IS also at question. the dealer inspected the vehicle and did a diagnostic check. there were no signs of corrosion, dtc's and all pcm's were ok. the passenger rear door makes noise when opening.*nm
- Seat belts
My son became trapped in the rear passenger seat belt of my 05 galant while driving. I pulled over to release the seat belt and it refused to unlock. every attempt to remove my son from the seat belt caused his breathing to be further cut off, at which time we had no choice but to cut him out of the seat belt. *Jb
- Steering › Hydraulic power assist system
Nothing extraordinary leading up to this failure but on the morning of oct 4TH I was driving my 2005 mitsubishi galant LS at 55 mph and experienced a total power steering failure. fortunately I was able to slow the vehicle down and pull off to the side of the road. I then opened the hood and…
Nothing extraordinary leading up to this failure but on the morning of oct 4TH I was driving my 2005 mitsubishi galant LS at 55 mph and experienced a total power steering failure. fortunately I was able to slow the vehicle down and pull off to the side of the road. I then opened the hood and there was a fluid covering the underside of the hood. I called roadside assistance and a tow truck was dispatched to pickup the vehicle and deliver it to a mitsubishi dealership, which happened to be metro mitsubishi in bloomington minnesota. not that a statement by a tow truck driver IS law but he mentioned that this IS not the first time he has seen this issue and that it was his belief that there should be a recall on this vehicle as a result of this issue. metro mitsubishi called me a few hours later to notify me that it was indeed a steering pump failure and they would not be able to get replacement parts until the next day which meant that I was now without a vehicle because this vehicle that I'm leasing IS my only means of transportation. the pump was replaced but a steering failure at any time and at any speed IS a very serious safety issue and needs to be investigated. I look forward to you response to this issue. thank you douglas niznick. *nm
- Vehicle speed control › Cables
Vehicle has been repaired twice at two different dealerships for same problem. vehicle has been in two separate dealerships for repair for approx. 40 days total. Selling dealership, palm springs mitsubishi, has refused to replace vehicle as requested. *nm
- Suspension
Bought a new mitsubishi galant 2005. At about 150 miles during the break in period I started to notice a vibration in the front. After the break in period when I could take it to a higher speed I also noticed a distinct shimmy in the steering wheel. The vibration IS very pronounced between 70 and…
Bought a new mitsubishi galant 2005. At about 150 miles during the break in period I started to notice a vibration in the front. After the break in period when I could take it to a higher speed I also noticed a distinct shimmy in the steering wheel. The vibration IS very pronounced between 70 and 80 mph. At this speed the vibration IS noticeable on just about any road surface. The vibration IS felt in the steering wheel shimmy and in the seat of the pants vibration emanating from the front. The complaint was initially addressed by the mitsubishi dealer by noting that two tires were out of balance and re-balancing. This did not work. Then the vehicle was sent to a tire specialist where a road balance was done and one tire wheel combination that could not be balanced the tire was replaced under warranty through yokohama. The problem did not go away. Mitsubishi was contacted and the regional manager for mitsubishi ordered to replace the yokohama tires with michelin. I allowed a break in period for the tires and this has not solved the problem. The tire specialist noted that it could be a bad front axel or transmission engine mounts. At this point I feel it IS a defect since the work done while consistent with bad tires or unbalanced tires has not solved the problem even though there has been several re-balancings and a new set of tires by michelin. The problem of front vibration and the shimmy in the steering wheel continues. *nm
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10240443This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 3rd quarterly technician quiz for 2023.
- 10235609This Technical Service Bulletin provides instructions and material safety data sheets for removal of rap-film adhesive residue.
- 10235608This Technical Service Bulletin reviews the regulations that require a label showing the reduction in load carrying capacity be affixed to vehicles when the total net weight of accessories is more than 1.5 percent of the vehicle's gross vehicle weight rating (GVWR) or 100 lbs.
- 10235606This is a Dealer Letter sent to dealers informing that Mitsubishi Technical Training has launched the 2nd quarterly technician quiz for 2023.
- 10211530This Technical Service Bulletin was sent to dealers to explain the difference between normal dew condensation, which is a natural phenomenon, and water penetration caused by improper sealing or a defective/broken part.
- 10170853Caution statements regarding the disposal of certain SRS components have been incorrect in the service manuals of affected vehicles. This TSB provides updated caution statements.
- 10170852This Technical Service Bulletin updates the door adjustment procedure in the Body Section of the applicable service manuals.
- 10170102This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170100This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170099This is an index of Tech Talk newsletter articles released in 2012.
- 10170097This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170096This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170087This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170086This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170074This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170071This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10170070This TSB contains troubleshooting steps for diagnosis of various customer complaints relating to the audio system speakers in Mitsubishi vehicles equipped with original equipment audio components.
- 10169006This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10163703This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
- 10152965This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Cover.
- 10130469This is a service newsletter (Tech Talk) that was sent out to dealers.
- 10130468This is a message sent to dealers, to inform them that an update for MEDIC will be available.
- 10030267Mitsubishi: in certain model/model years vehicles, the coils have been found to overheat and possibly melt; check ground point #12 for signs of corrosion, especially if the battery has recently been replaced. High resistance at the ground can cause coils to overheat.
- 10021743Reprogramming the pcm drivability or sensitivity issues can be corrected.
- 10021705Extended warranty for partial zero emissions.
- 10020105Seat belt stopper button replacement.
- 10019921Freeze-frame data for misfire conditions.
- 10018782Rear suspension bushing replacement - service manual revision. Various models including the 2006 endeavor.
- 10018375Time interval adjustments for lights and wipers. All mitsubishi models with adjustable time interval function for wiper and lights. Tech talk.
- 10018370Trunk lid opening & closing effort. Mitsubishi. Tech talk.
- 10018369Glove box gap at dash. Refer to 04-52a-001rev. Mitsubishi. Tech talk.
- 100167542-3 shift flare.
- 10016133Alternator fr terminal voltage - service manual revision.
- 10016006Ignition key ring antenna inspection-service manual revision.
- 10015842Immobilizer system information update
- 10015723Rear door lock actuator failure. Mitsubishi tech talk.
- 10015721Headliner sagging update.
- 10015715Diagnostic trouble code (dtc) p0421 / dtc p0431. Mitsubishi tech talk.
- 10015712Diagnostic trouble code (dtc) p2100. Mitsubishi tech talk.
- 10015636Rear door lock actuator failure. Mitsubishi tech talk.
Every Mitsubishi Galant model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.