2014 Thor Motor Coach Palazzo
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Thor Motor Coach › Palazzo › 2014
These records cover every 2014 Thor Motor Coach Palazzo. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2014 Thor Motor Coach Palazzo. Newest first.
Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as…
Risk and remedy
Risk
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy
Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.
Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.
Risk and remedy
Risk
If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.
Remedy
TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.
Thor Motor Coach (TMC) is recalling certain 2014-2015 Tuscany, Tuscany XTE and Palazzo motorhomes. The windshield wiper systems on these vehicles may have been improperly installed or secured, causing the wipers to fail during operation.
Risk and remedy
Risk
If the windshield wipers fail, the driver would have decreased visibility, increasing the risk of a crash.
Remedy
TMC will notify owners, and dealers will inspect the wiper system, tightening the wiper nuts to the proper specifications, as necessary, free of charge. The recall began on April 12, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000128.
Thor Motor Coach (Thor) is recalling certain model year 2013-2014 Challenger and Tuscany recreational vehicles, and 2014 Tuscany XTE and Palazzo recreational vehicles manufactured March 8, 2013, through August 8, 2013, and equipped with certain Frigidaire KG-series microwave models CFMV152CLB and CFMV154CLS manufactured January 27, 2013, through April 10…
Risk and remedy
Risk
If the microwave starts on its own and there are contents inside, a fire could result.
Remedy
Thor will notify owners, and dealers will repair the membrane/keypad component, free of charge. The recall began on May 12, 2014. Owners may contact Thor Motor Coach at 1-877-500-1020. Thor's number for this recall is RC000088. Note: Until the microwave has been repaired, owners should not store anything in the microwave while it is unattended.
Owner complaints
7 complaints
What owners report most
Latest complaints
- Visibility/wiper
The passenger side front window is a 2 pane window and the seal between the 2 panes has failed and the window is fogging up which makes it difficult to see the side mirror on the passenger side of the motorhome. This makes driving difficult with the fogged window.
- Visibility/wiper
Many of the side windows are foggy and cant see out of them especially during hot sunny days. It is hard to see through them and view the mirrors on the drivers and passenger sides. 1 of the dual pane window assemblies is separating from the other window
- Structure › Body
We have hehr windows on our class a rv that the frameless window adhesive has failed on three windows and possibly 3 others. One window the latch has failed also. The windows won't properly close and flap going down the road. We are worried about them flying/falling off as we are driving.*dt*jb*ln *tr
- Unknown or other
My grandson was locked in our motorhome because the only door in our coach broke in half inside our door. We had to break a window on our slide out to get him out. Replaced the lock and window at our expense not to mention I heard this IS an ongoing problem and safety hazzard
- Visibility/wiper
The driver's side window IS a double pane gas sealed type. The double pane seal has failed and the window has become opaque. It has become very difficult to see through this window. From a safety stand point this failure IS causing an inability to view the side view mirror on the drivers side. In direct sunlight the side view mirror becomes almost invisible.
- Visibility/wiper
While driving the wipers stalled in the pouring rain. luckily I was able to pull over without incident. I waited until the rain slowed and when I started out the wipers started working again. a few minutes later the stalled again and was able to pull into a rest stop. I was doing about 60 mph and believe my wife and I were fortunate that nothing terrible happened.
- Latches/locks/linkages › Doors › Latch · Structure › Body
A part of the locking mechanism on the only door on the rv broke, effectively trapping us inside the vehicle. The manufacturer (trimark) IS aware of this issue and now manufactures the part out of steel instead of the cast part that failed. We were at a fuel station and parked. We had to climb out a window with tools to force the door open.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Trimark 060-1650 Door Latch Failures
On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Owner’s Questionnaires (VOQs) describing…
On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Owner’s Questionnaires (VOQs) describing consumers being locked in or out of their vehicles.The door latch, containing a die-cast zinc plunger, was produced by Equality during calendar years 2014-2016. The die-cast may become porous and brittle over time and can break without warning, causing the vehicle owner to be unable to open the recreational vehicle door equipped with the latch.If the motorhome does not have any other doors such as some Class A models, occupants could be trapped inside, needing to climb out using the emergency exits. If locked out, owners would be unable to easily get in and retrieve children and pets. ODI analyzed the data provided by Trimark in response to its January 27, 2021 information request letter.Although an elevated failure rate was evident on a specific combination of plunger bolt, door lock/latch assembly and door, the data showed that most failures occurred within the first two years of service on the affected 2015-2017 vehicles.This data suggests that component failures generally would have already occurred.Further, ODI data reflects a downward trend in complaints after calendar year 2018 and for post- MY 2016 vehicles.This downward trend may be attributed Trimark's actions in 2016 such as changes in the manufacturing process of its zinc plunger component for the relevant population and its 2016 decision to switch to a steel plunger. In view of the nature of early-life failure, and failure rate trending downward for model years 2017 and newer, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10169044This letter stated that there were no Service Bulletins or Technical Service Bulletins issued for the month of November, 2019.
- 10124236This letter stated that there was one (1) Service Notification issued for the month of October, 2017.
Every Thor Motor Coach Palazzo model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.