2006 Volkswagen Touareg
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volkswagen › Touareg › 2006
These records cover every 2006 Volkswagen Touareg. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2006 Volkswagen Touareg. Newest first.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
Owner complaints
37 complaints1 involved a fire
What owners report most
Latest complaints
- Fuel/propulsion system
I get dizzy every time I drive my 2006 Volkswagen Touareg. There is a fuel smell inside the cabin and outside of the driver's rear wheel well. I noticed this during the short time I park in my garage. Since, the noticeable smell, I have been parking outside and have since minimized by use of the…
I get dizzy every time I drive my 2006 Volkswagen Touareg. There is a fuel smell inside the cabin and outside of the driver's rear wheel well. I noticed this during the short time I park in my garage. Since, the noticeable smell, I have been parking outside and have since minimized by use of the vehicle. I love the vehicle, but I am getting headaches and dizziness while driving it. Upon looking up more information on the fuel smell, I came across Volkswagen Manufacture Safety recall 20Ai and 20Z4. Since I last spoke of Community Volkswagen of Santa Maria, they said that the recall has been repaired. However, after further research, this is an Open Recall and is still eligible to be repaired. Please advise me on my next steps so as to not be in a dangerous situation while driving this vehicle. Thank you.
- Air bags
The contact owns a 2006 Volkswagen Touareg. The contact stated while driving at approximately 40 MPH, the passenger’s side front side air bag and the passenger’s side rear side air bag independently deployed. The contact stated that there was no warning light illuminated. The contact stated that…
The contact owns a 2006 Volkswagen Touareg. The contact stated while driving at approximately 40 MPH, the passenger’s side front side air bag and the passenger’s side rear side air bag independently deployed. The contact stated that there was no warning light illuminated. The contact stated that the vehicle had stalled after the air bags had deployed. The contact was unable to restart the vehicle. The contact stated that after several attempts, the vehicle was towed to the residence. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 173,000.
- Vehicle speed control
While driving the vehicle it will slow down and will not accelerate even while pressing the gas. It may even cut off. I have to keep pushing the pedal maybe 3 to 5 times before it will accelerate. This happens even on the freeway. I don't drive it anymore because of fear I might have an accident.
- Electrical system · Exterior lighting · Visibility/wiper
Insulation on wiring inside headlight housing deteriorated leaving exposed wire. short circuit occurred causing complete loss of headlights while driving.
- Fuel/propulsion system
TL* the contact owns a 2006 volkswagen touareg. The contact received a recall notice for nhtsa campaign number: 17v583000 (fuel system, gasoline), but did not have the vehicle immediately serviced. While driving 30 mph, the vehicle shut off without warning. The contact was able to restart the…
TL* the contact owns a 2006 volkswagen touareg. The contact received a recall notice for nhtsa campaign number: 17v583000 (fuel system, gasoline), but did not have the vehicle immediately serviced. While driving 30 mph, the vehicle shut off without warning. The contact was able to restart the vehicle enough times for him to drive home. The contact took the vehicle to volkswagen of huntington (838 e jericho turnpike, huntington station, ny 11746, (631) 533-5222) and was informed that the two fuel pumps failed and needed to be replaced at his expense. The contact was informed that the fuel pumps were not covered under the recall. The manufacturer was notified and provided the same information as the dealer. The vehicle was not repaired. The failure mileage was 160,000.
- Fuel/propulsion system
I got my car repaired for this issue after smelling gas leakage before VW released the relevant recall campaign. I sent VW all receipt for repair paid by my pocket money, but VW refused to reimburse for my expense because I got it repaired too early. I did on 09/17/2014 but VW states that only the…
I got my car repaired for this issue after smelling gas leakage before VW released the relevant recall campaign. I sent VW all receipt for repair paid by my pocket money, but VW refused to reimburse for my expense because I got it repaired too early. I did on 09/17/2014 but VW states that only the repair was done between 09/20/2016 and 03/19/2018. This IS ridiculous answer. I am here attaching all the receipt and the letter from VW . Car IS currently in motion after repair.
- Fuel/propulsion system
I have a VW touareg V8 2006. On saturday 12/01/18 I took the car to VW david maus dealer @lee rd, orlando, fl for the safety recall -fuel pump flange replacement'- after they performed the job, my car stated to misfires, decrease in power and acceleration and it shut off while driving. they…
I have a VW touareg V8 2006. On saturday 12/01/18 I took the car to VW david maus dealer @lee rd, orlando, fl for the safety recall -fuel pump flange replacement'- after they performed the job, my car stated to misfires, decrease in power and acceleration and it shut off while driving. they want me to authorize them to perform a diagnostic test , that will cost me $155. on 12 /3/18 I spoke to the service manager , she said she was told the problem IS the fuel pump. , so I don't know why they insist on the diagnostic test if they know what IS the problem. they broke the fuel pump and now they want me to be responsible for that expense and the repairs. I refuse to paid for the diagnostic and repairs, , because my car was fine. They broke the parts so they should be responsible for it. VW company gave me a case number and says that if the dealer says the issues IS related due to the work they did ' I should not be responsible. But if the dealer says it IS not related, then I am responsible for the expenses. I keep saying my car was fine before they put their hands on my car, so what ever they did they broke my car and I should not be charge.
- Fuel system, gasoline
2006 volkswagen touareg. Consumer writes seeking reimbursement for vehicle repairs related to a safety recall. *Ld the consumer stated the manufacturer refused to provide a full reimbursement for the recall , due to the vehicle being repaired by an independent mechanic. *js the consumer…
2006 volkswagen touareg. Consumer writes seeking reimbursement for vehicle repairs related to a safety recall. *Ld the consumer stated the manufacturer refused to provide a full reimbursement for the recall , due to the vehicle being repaired by an independent mechanic. *js the consumer stated the manufacturer reimbursed only a portion of the repair expenses. The manufacturer stated that they normally would not provide a reimbursement for vehicles repaired by an independent mechanic. *Js
- Engine · Fuel/propulsion system
TL* the contact owns a 2006 volkswagen touareg. While driving various speeds, the check engine warning indicator remained illuminated. The contact received notification of nhtsa campaign number: 17v583000 (fuel system, gasoline); however, the part needed for the repair was not available. The…
TL* the contact owns a 2006 volkswagen touareg. While driving various speeds, the check engine warning indicator remained illuminated. The contact received notification of nhtsa campaign number: 17v583000 (fuel system, gasoline); however, the part needed for the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The vehicle was taken to autonation volkswagen of las vegas (6375 w sahara ave, las vegas, NV 89146, (702) 605-5802), but the part for the repair was not available. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 91,287. Vin tool confirms parts not available.
- Fuel system, gasoline
Fuel smell on the rear passenger side coming from the fuel filter tank area. Fuel tank IS located at the bottom the rear seats. The fuel fumes are very strong we are afraid the car might catch fire. The fumes smell like fresh fuel. The fuel fumes are very strong especially after using the car after a 3 mile round trip grocery errands. *tr
- Electrical system · Electronic stability control (esc) · Exterior lighting
Headlight wiring insulation has melted creating several shorts and causing the headlights to stop working completely. It appears to be all of the wiring heading to and including the headlight. It has caused false codes to appear as well.
- Fuel/propulsion system
I have taken this vehicle to the volkswagen dealer because of a fuel smell and a sudden jolt that I get undercarriage when driving. they have told me that they are not sure where the jolt IS coming from they don't know if it IS the transmission or a fuel leak. I'm very afraid to continue driving…
I have taken this vehicle to the volkswagen dealer because of a fuel smell and a sudden jolt that I get undercarriage when driving. they have told me that they are not sure where the jolt IS coming from they don't know if it IS the transmission or a fuel leak. I'm very afraid to continue driving this vehicle. I have a small child and I would like for volkswagen to buy the vehicle back from me. please see enclosed letter from VW. thank you!
- Fuel/propulsion system
Vehicle was smelling like gas - thought it was due to running over debris but no damage to tank found in inspection. mechanic removed tank shields and straps and found that the fuel pump flange was leaking due to a crack and needed to be replaced along with connector seal. car owner has the part…
Vehicle was smelling like gas - thought it was due to running over debris but no damage to tank found in inspection. mechanic removed tank shields and straps and found that the fuel pump flange was leaking due to a crack and needed to be replaced along with connector seal. car owner has the part if it needs to be sent in for review. did research and noticed that 2007-2010 VW touareg's were recalled for this exact issue (https://www.nhtsa.gov/vehicle/2007/volkswagen/touareg/4%252520dr/awd#recalls). want to ensure that this recall should not be widened as research on several VW owner sites have noted this same issue with more years. owner called VW to put in complaint but was told the car IS not under recall and that there IS nothing they could do. mechanic bill attached - part IS in owner's possession for review if needed.
- Unknown or other
The door locks on both of the back doors have stopped working. can not open either of the rear doors. this problem was not caused by any specific event that we know of. first one door stopped working and about a week later the other door stopped working. I would not be surprised if the other doors failed soon.
- Exterior lighting
I had my touareg in puerto rico for over 10 years in storage. Since car had not used for normally business days. The headlight cables and lights are got bad. All cables got dry and broke in the outside cause the heat of the island. The control unit got bad. All front light sistem doesnot work correctly. The vehicle only have 86000 miles.
- Fuel/propulsion system
While having vehicle looked at oil change place I complained to attendant about strong fuel odor. He looked under vehicle and saw a gas drip near exhaust system. He looked under seat and removed compartment for pump. He said looked like a defective piece on top that was seeping gas through membrane. Have stopped driving vehicle for fear of explosion or fire. *tr
- Air bags · Electrical system
My airbag fault light has been on for a few months now and I'm getting concerned. Was there a recall or what IS the best way to fix this problem?
- Fuel system, gasoline
TL* the contact owns a 2006 volkswagen touareg. The contact stated that there was an odor of fuel present inside the vehicle and there was fuel leaking from the vehicle which was present on the garage floor. The vehicle was taken to the dealer, who diagnosed that the fuel was leaking from the fuel…
TL* the contact owns a 2006 volkswagen touareg. The contact stated that there was an odor of fuel present inside the vehicle and there was fuel leaking from the vehicle which was present on the garage floor. The vehicle was taken to the dealer, who diagnosed that the fuel was leaking from the fuel system and no other information was available. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 95,000.
- Exterior lighting
All headlamps flickered with no notice and then went dark. used bright headlamps but they would not stay on permanently. had to drive holding brights in manual mode. immediately phoned VW to explain and they advised I needed new headlamp bulbs. hard to believe all of my bulbs went out at the…
All headlamps flickered with no notice and then went dark. used bright headlamps but they would not stay on permanently. had to drive holding brights in manual mode. immediately phoned VW to explain and they advised I needed new headlamp bulbs. hard to believe all of my bulbs went out at the same time. I've googled to learn that VW has headlamp problems reported but the consumer IS still responsible for the cost to repair/replace. *tr
- Fuel system, gasoline
The outside rear of the car smelled like gas. after looking under the car we noticed a puddle of gas collecting after stopping the vehicle. the dealer told us the driver side fuel pump has a crack leaking fuel. this IS a serious problem and has to be addressed before somene dies. it IS a hazard…
The outside rear of the car smelled like gas. after looking under the car we noticed a puddle of gas collecting after stopping the vehicle. the dealer told us the driver side fuel pump has a crack leaking fuel. this IS a serious problem and has to be addressed before somene dies. it IS a hazard to my family and the public as a whole. apparently VW has done a recall for this for later model year touareg, but not the 2006. they refuse to fix it due to age?! in all the years I've been driving, I've never had a fuel pump that cracks and spews gas all over the road. in order to even find the problem, they had to take out all of the rear seats, cut through the carpet of the vehicle, and open up two vents through the floor of the SUV. this IS a serious hazard. so if I hadn't smelled the gas and someone threw a cigarette, my family would be in hazard for their life?! even though there are many other examples of this on the internet VW has refused to acknowledge this IS an issue. *tr
- Electrical system › Wiring · Engine and engine cooling · Engine and engine cooling › Exhaust system › Emission control · Equipment › Electrical › Navigational system(global positioning system) · Power train · Service brakes, hydraulic
2006 volkswagen touareg. consumer writes in regards to unsatisfactory customer service at dealership concerning several vehicle repairs. *smd the consumer stated from the beginning, the vehicle had problems. The navigation system malfunctioned. The unit was removed and installed again. The front…
2006 volkswagen touareg. consumer writes in regards to unsatisfactory customer service at dealership concerning several vehicle repairs. *smd the consumer stated from the beginning, the vehicle had problems. The navigation system malfunctioned. The unit was removed and installed again. The front and rear brakes were replaced, the evap purge valve was replaced, the ignition coils were replaced, corrosion built up in the sensor and wiring of the headlight, and the wiring and headlight were replaced. The check engine light illuminated, due to a faulty purge valve, for the third time. While driving on the freeway, the consumer felt vibrations and heard loud noises under the center arm rest. It was discovered the propeller shaft was broken. Also, the front brake pads material, was metal on metal. The brakes only lasted 24,600 miles. the consumer was also informed the water pump and oil pan were leaking.
- Power train
While traveling at highway speed, began to hear a thunking noise consistent with a flat tire. After further inspection determined the noise was originating from the underside of the vehicle in the center. Dealer was able to diagnose as a failed carrier bearing over the phone as it IS a "recurring…
While traveling at highway speed, began to hear a thunking noise consistent with a flat tire. After further inspection determined the noise was originating from the underside of the vehicle in the center. Dealer was able to diagnose as a failed carrier bearing over the phone as it IS a "recurring issue" (dealer's words). Since this was only a "recurring issue and not a problem", volkswagen stuck me with a $1483 repair bill and a week without a car or loaner vehicle. *Tr
- Engine
Upon driving the vehicle on the night in question, out of nowhere, a light came on and said coolant overheated. I was driving on the dallas tollway, and pulled over immediately, and the vehicle shut down completely. I called a tow truck, and had the vehicle towed, and was told maybe the battery…
Upon driving the vehicle on the night in question, out of nowhere, a light came on and said coolant overheated. I was driving on the dallas tollway, and pulled over immediately, and the vehicle shut down completely. I called a tow truck, and had the vehicle towed, and was told maybe the battery was bad. I purchased a new battery the next day, but the vehicle still would not start. I then had it towed to the dealer, and was told that I needed a new engine. I couldn't understand how an engine could go out at less than 60,000 miles. I've been fighting with VW to have the problem resolved, but they have refused to do so. They've had my vehicle for 2 months now, and the problem still hasn't been resolved. I plan to pursue litigation. *tr
- Fuel/propulsion system
After smelling gasoline on several occasions, we determined there was a crack in the fuel filter housing assembly. the crack allowed gasoline to pump out filling the indention on the top of the fuel tank then overflowing down the sides of the tank. *tr
- Air bags · Seats
In order to flip backseats down to give rear more cargo space the front seats must be moved forward. However when front seats are slid forward more then a few inches the wires for the airbag sensors under the seats are torn and ripped out of place since the harness IS to short. This in turn…
In order to flip backseats down to give rear more cargo space the front seats must be moved forward. However when front seats are slid forward more then a few inches the wires for the airbag sensors under the seats are torn and ripped out of place since the harness IS to short. This in turn disables the airbags. VW IS aware of this issue and makes customers buy a new wiring harness that IS long enough to move seats forward with out tearing to repair the issue. *Tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10253215Exterior Lights, Moisture Accumulation
- 10253214Exterior Lights, Moisture Accumulation
- 10253213Exterior Lights, Moisture Accumulation
- 10253204Customer States Windshield Wipers Streak or Smear
- 10253180Antenna Diagnosis Overview
- 10252942Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
- 10252220All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
- 10243066VW Elsa Newsletter
- 10243065VW Elsa Newsletter
- 10243059VW Elsa Newsletter
- 10243034VW Elsa Newsletter
- 10243008VW Elsa Newsletter
- 10243001VW Elsa Newsletter
- 10242996VW Elsa Newsletter
- 10242682ODIS Service Update
- 10242404VW Elsa Newsletter
- 10242400VW Elsa Newsletter
- 10242399VW Elsa Newsletter
- 10242397VW Elsa Newsletter
- 10242390VW Elsa Newsletter
- 10242381VW Elsa Newsletter
- 10242375VW Elsa Newsletter
- 10242372VW Elsa Newsletter
- 10242358VW Elsa Newsletter
- 10241721Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
- 10241720Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
- 10241345Electric Coolant Fans Continue to Run after Ignition is Switched OFF
- 10241344Electric Coolant Fans Continue to Run after Ignition is OFF
- 10241342Electric Coolant Fans Continue to Run after Ignition is OFF
- 10241340Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
- 10241339Oil Consumption Measurement
- 10241335Oil Consumption Measurement
- 10241333Oil Consumption Measurement
- 10241311Gasoline Quality
- 10241310Software Version Management
- 10241274Fuel Additive to Help Prevent Sporadic Misfire Faults
- 10241266Squeaks, Rattles, Noise, Repair Materials
- 10241265Fuel Additive to Help Prevent Sporadic Misfire Faults
- 10241264Fuel Additive to Help Prevent Sporadic Misfire Faults
- 10241263Fuel Additive to Help Prevent Sporadic Misfire Faults
Every Volkswagen Touareg model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.