2025 Volvo Vah
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2025 Volvo Vah. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2025 Volvo Vah. Newest first.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2026 VAH trucks. The passenger seat belt anchor may fail due to inadequate floor reinforcement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk and remedy
Risk
A seat belt anchor that fails will not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy
Dealers will install a new weld nut and washer, free of charge. Owner notification letters were mailed December 16, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2510. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 10, 2025.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.
Risk and remedy
Risk
Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.
Remedy
Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX2409.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010811Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping. These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
- 1101080711L Engine Block Compatibility and Backward Conversion Parts Requirements
- 11010806This CBR solution provides a step-by-step procedure to replace the hood tilt switch on Volvo Autohauler (VAH) and Volvo Heavy Duty (VHD) models, specifically for units equipped with bodybuilder applications that enable remote start/stop functionality outside the cab when the PTO (Power Take-Off) is engaged. The hood tilt switch is a critical safety component that disables remote start when the hood is opened or tilted.
- 11010803CBR- 13L Engine - Rear Main Oil Seal Leak - Model Year 2025
- 11009762CBR - Volvo Chassis - Timing Gear Plate Repair
- 11009746CBR - One-Box SCR Weld Leaks
- 11009744CBR - 13L Engine - Rear Main Oil Seal Leak - Model Year 2025
- 11008306CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
- 11008305CBR - Volvo Chassis - HVAC Fresh Air Door Binding
- 11008302CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
- 11008301CBR - Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life (VCS2).
- 11006957CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
- 11006951CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
- 11006950CBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)
- 11006949CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
- 11006944Service Campaign: Volvo Trucks has determined that certain VN and VHD model vehicles could have un-torqued wheel nuts on the left side of the vehicle. Left side wheel nuts on effected vehicles will need to be inspected and torqued to specification.
- 11005405CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
- 11005403CBR: Telematics Gateway (TGW) Connect Ability Issues
- 11002821CBR - Accelerator Pedal: Inspection/Instructions
- 11002820CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
- 11002819CBR - Drivers Information Display (DID) Inoperative After Cluster Replacement And Programming
- 11000890CBR - Volvo Chassis - Enable Air Suspension Gauge Function - US17 And Newer Chassis ONLY
- 11000873CBR - 11 Liter Engines - Fuel In Oil.
- 11000870CBR - Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure warning ( LDWS ) .
- 10253829CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
- 10252321CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as designed.
- 10252317CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
- 10252316CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
Every Volvo Vah model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.