2012 Volvo VT
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2012 Volvo VT. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2012 Volvo VT. Newest first.
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
Risk and remedy
Risk
Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
Remedy
Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Owner complaints
1 complaints
Latest complaints
- Fuel/propulsion system
TL* the contact operatated a 2012 volvo tractor for jordan carriers. the contact stated while driving approximately 55 mph, the fuel injector caused the truck to shake vigorously. the shaking would stop when vehicle was traveling at a speed of 35 mph or below. this failure continuously…
TL* the contact operatated a 2012 volvo tractor for jordan carriers. the contact stated while driving approximately 55 mph, the fuel injector caused the truck to shake vigorously. the shaking would stop when vehicle was traveling at a speed of 35 mph or below. this failure continuously occurred. the vehicle had not been taken to a dealer. the manufacturer had not been notified. The vin was not available. The approximated failure mileage was 187,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Discrepancies in Required CFR Reporting
On October 22, 2018, an Audit Query (AQ18-005) was opened to assess the completeness and timeliness of Volvo Group's early warning reporting, safety recalls, and communications submissions to the agency.NHTSA's investigation determined that Volvo Group failed to recall vehicles in a timely fashion and to comply with…
On October 22, 2018, an Audit Query (AQ18-005) was opened to assess the completeness and timeliness of Volvo Group's early warning reporting, safety recalls, and communications submissions to the agency.NHTSA's investigation determined that Volvo Group failed to recall vehicles in a timely fashion and to comply with other recall and reporting requirements, including notifying owners of recalls and reporting death and injury incidents.NHTSA and Volvo Group entered into a Consent Order on January 27, 2023 to resolve AQ18-005.As part of the Consent Order, Volvo Group agreed to a total civil penalty of one-hundred and thirty million dollars ($130,000,000), of which, sixty-five million dollars ($65,000,000) was paid on February 21, 2023.Also, of that total civil penalty, Volvo Group agreed to spend twenty million dollars ($20,000,000) on the specific performance obligation to create a safety data analytics infrastructure to detect and study emerging safety-related defect trends on its vehicles. The Consent Order also holds forty-five million dollars ($45,000,000) of the civil penalty in abeyance pending Volvo Group's satisfactory completion of the requirements of this Consent Order, and its compliance with the Safety Act, and regulations thereunder.The Consent Order is for a three-year term and may be extended by up to two years if NHTSA reasonably finds that an extension is warranted.In the Consent Order, Volvo Group agreed to several performance obligations, including enhanced oversight of its compliance with the Safety Act and the terms of the Consent Order through a third-party auditor and regular meetings with NHTSA.The third-party auditor will recommend and oversee implementation of process improvements to enhance Volvo Group's safety compliance processes and oversee the company's review of past recalls and submissions to NHTSA for accuracy and completeness.Also, via the Consent Order, Volvo Group agreed to create updated written policies, procedures, and training to ensure that its employees understand the requirements of the Safety Act, the regulations thereunder, and this Consent Order.Volvo Group further agreed to launch a user interface on its websites to allow users to search vehicle identification numbers (VINs) for open recalls and implement a system to support NHTSA's VIN lookup tool.Based on the Consent Order, this audit query investigation, AQ18-005, is closed.Closure of this AQ has no bearing on the terms of the Consent Order, including Volvo Group's ongoing performance obligations or legal obligations, and does not represent a determination by NHTSA as to Volvo Group's performance under the Consent Order to date.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10251325CBR - Telematics Gateway (TGW) Connect Ability Issues.
- 10251323CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
- 10251319CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
- 10249569CBR: TGW Will Not Connect After SIM Card Replacement
- 10225704Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
- 10224584Expendable Items Parts List.
- 10222270TSB-Charge Air Cooler t-clamp install.
- 10219421Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
- 10219302Part information for AMT input shaft repair kits and the shim kit that is required for repair.
- 10215308Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
- 10215306Volvo Chassis - Drag Link Inspection And Replacement Criteria
- 10215292Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer.
- 10215283AMT Control Housing Bench Testing - False Failures
- 10215282DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
- 10215281Programming Failure - Chassis With Cummins Engine And An Allison Transmission
- 10215279NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
- 10215277DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
- 10215276(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
- 10215271DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
- 10215270Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
- 10215265Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
- 10215263Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
- 10213668Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
- 10213666Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
- 10213631DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
- 10213604Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- 10213526The Diagnostic Process
- 10213524Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
- 10213510Volvo Chassis Ghost Codes Due To Poor Grounding
- 10213484Volvo Chassis - Fuel Level Sending Unit Specification Information
- 10213483(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
- 10212892Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- 10212891VIDA QR Scanner Mobile App
- 10209841Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical Service Bulletin V-216-001 Twin Mass Flywheel Conversion
- 10209840Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
- 10209834Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
- 10209832(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
- 10209817Volvo Chassis - FSB 392 - 004 - Radio, Replacement
- 10208542Volvo Monthly Bulletin Release Letter - Feb 2022
- 10208517Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
Every Volvo VT model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.