2020 BMW X7
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2020 BMW X7. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
12 recalls name the 2020 BMW X7. Newest first.
BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.
Risk and remedy
Risk
An overheated starter motor can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy
Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.
BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the…
Risk and remedy
Risk
A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy
Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2019-2022 BMW X7 xDrive40i, X7 Drive50i, X7 M50i vehicles with third-row seats. One or more of the compression springs that lock the backrest may not have been installed properly, and could dislodge or detach.
Risk and remedy
Risk
In a crash, the seat backrest may not fully lock, increasing the risk of injury.
Remedy
Dealers will inspect the third-row seat and, if necessary, remove and reinstall improperly installed compression springs, and reinstall any missing springs, free of charge. Owner notification letters were mailed November 4, 2022. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles.…
Risk and remedy
Risk
A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.
Remedy
Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i…
Risk and remedy
Risk
If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy
BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7…
Risk and remedy
Risk
A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.
Risk and remedy
Risk
If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108…
Risk and remedy
Risk
Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.
Remedy
BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.
Risk and remedy
Risk
An engine stall increases the risk of a crash.
Remedy
BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020 X7 xDrive40i and X7 xDrive50i vehicles. The rear reflex reflectors may not reflect an adequate amount of light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk and remedy
Risk
An inadequate amount of reflected light will decrease the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace both rear reflex reflectors, free of charge. The recall began March 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5…
Risk and remedy
Risk
The lack of an image in the back-up camera display increases the risk of a crash.
Remedy
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, X5 xDrive40i, X5 M50i, X7 xDrive40i and X7 M50i vehicles. The steering rack pinion teeth may break under load, resulting in a loss of steering control.
Risk and remedy
Risk
A loss of steering control increases risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the steering rack, free of charge. The recall began August 21, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Owner complaints
56 complaints2 involved a crash3 involved a fire3 injuries
What owners report most
Latest complaints
- Power train
Front differential failed at ~79,000 miles. Regular service intervals and BMW specific oil were followed throughout the life of the vehicle. The pinion bearing began to wear prematurely which resulted in gear damage on a ring/pinion from metallic fragment introduction into the compartment.
- Unknown or other · Visibility/wiper
The vehicle suffered a complete premature failure of the factory aluminum A/C evaporator core due to internal corrosion. This is a known, widespread issue on BMW G-chassis vehicles. The failure causes pressurized R-1234yf chemical refrigerant and atomized PAG compressor oil to leak directly into…
The vehicle suffered a complete premature failure of the factory aluminum A/C evaporator core due to internal corrosion. This is a known, widespread issue on BMW G-chassis vehicles. The failure causes pressurized R-1234yf chemical refrigerant and atomized PAG compressor oil to leak directly into the passenger cabin ventilation stream, creating a health hazard from chemical fumes. Additionally, the complete loss of climate control dehumidification causes immediate, severe windshield fogging during inclement weather, creating a sudden and significant visibility hazard while driving. A formal diagnostic by a BMW dealership confirmed the leak and estimated the repair cost at $7,600.
- Service brakes · Steering · Suspension
2020 bmw x7 with 34k miles 1 driver, front suspension control arm leaking causing clunk and un even steering / braking feel due to premature leaking of the hydraulic fluid do to a design flaw. As a 40 Honda master tech and 30yr dealer principal I cant believe bmw will not warranty this defect or up…
2020 bmw x7 with 34k miles 1 driver, front suspension control arm leaking causing clunk and un even steering / braking feel due to premature leaking of the hydraulic fluid do to a design flaw. As a 40 Honda master tech and 30yr dealer principal I cant believe bmw will not warranty this defect or up grade the part as it seems its still used today and thousands have complained about the issue not even to mention the car is 95k new totally unexceptable. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system · Power train · Unknown or other
Approximately 67,000 miles, my 2020 BMW X7 XDrive 40i began falsely indicating that the driver's door was open even though the door was securely closed. While the vehicle was in drive and moving, the false door open signal caused the vehicle to automatically shift into park and abruptly react. This…
Approximately 67,000 miles, my 2020 BMW X7 XDrive 40i began falsely indicating that the driver's door was open even though the door was securely closed. While the vehicle was in drive and moving, the false door open signal caused the vehicle to automatically shift into park and abruptly react. This caused a serious risk of an unexpected stop and loss of vehicle control. BMW Fairfax inspected the vehicle and verified that it indicated the driver's door was open and shifted or attempted to shift into park while driving and moving. BMW found fault code 804168 relating to the driver door contact circuit and reported that the fault had occurred more than 53 times. BMW also found multiple invalid signal faults and loss of communication with the body domain controller. At approximately the same time, the vehicle displayed chassis malfunction and parking assistant malfunction warnings. The vehicle also has an ongoing water intrusion problem involving the panoramic roof, including water entering the passenger compartment. It's not yet known whether the water intrusion contributed to the electrical and communication faults. Additionally, there have been multiple issues with the rear sunroof not working properly and noises happening when the front sunroof is opened. BMW is recommending replacing the driver door actuator and attempting to program the body domain controller with a possible BDC replacement if programming is unsuccessful. The safety condition has not yet been repaired or conclusively resolved. There was no crash or injury. I'm reporting this because an erroneous door open signal that causes a moving vehicle to shift or attempt to shift and depart could result in sudden deceleration, loss of control, or collision.
- Electrical system · Unknown or other
We came from [XXX] to [XXX] at night. It was rainy in [XXX]. We parked the vehicle in the front of the garage door of the house and went to sleep. Around 8:00-9:00AM two police cars from [XXX] PD came to our house. The officer said that the vehicle calls to BMW or 911 as an emergency and they…
We came from [XXX] to [XXX] at night. It was rainy in [XXX]. We parked the vehicle in the front of the garage door of the house and went to sleep. Around 8:00-9:00AM two police cars from [XXX] PD came to our house. The officer said that the vehicle calls to BMW or 911 as an emergency and they forwarder that call to FPD. The officers checked the vehicle and they figured that the vehicle did the emergency call when was parked. Now, the emergency call system is not working, because of the bad factory sealant in the top of the roof and the water leaks exactly to the Telecomunication module (TCM). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine
Low oil sensor continues to light up and says i am low on oil. Found out that my oil pump was the main cause of the issue. At this time I have to have the oil pump replaced. It was also determined there have been numerous reports regarding oil pump failure in the 2020 BMW x7 due to an internal plastic part.
- Suspension
The front thrust arm bushing was previously replaced on December 19, 2023, at 34,750 miles (after three years of ownership). It has now failed again at 57,203 miles, lasting only about 22,500 miles. This repeat failure within a relatively short timeframe and mileage interval suggests an underlying issue or defective part. The dealer wants me to replace both Front Thrust Arm bushings again.
- Power train
My X7’s front differential went bad at 50k miles. I paid over 100k for a vehicle of this caliber to have something like this fail and have to pay 8k with no help from BMWNA. I’ve been a loyal customer with bmw having owned over 5 bmw vehicles in the past. And for me to get treated like this is unacceptable. I hope we can have a law suit against bmw for this.
- Engine
While driving the vehicle sensor lights began to come on. I assumed it was a dirty outside sensor. Not long after the ABS system lit up and my car said traction even though I was just pulling into my driveway. I quickly turned around and drove to my mechanic. Showed him all the lights and he…
While driving the vehicle sensor lights began to come on. I assumed it was a dirty outside sensor. Not long after the ABS system lit up and my car said traction even though I was just pulling into my driveway. I quickly turned around and drove to my mechanic. Showed him all the lights and he connected the computer to read the error codes. Found out that my oil pump was the main cause of the issue. Double checked to make sure it wasn't a battery failure causing incorrect error codes and the battery was in good condition. At this time I have to have the oil pump replaced. It was also determined there have been numerous reports regarding oil pump failure in the 2020 BMW x7 due to an internal plastic part.
- Engine
I am writing to formally report a potential safety-related defect involving BMW vehicles equipped with the B58TU engine, primarily affecting model years 2019 through 2021. My vehicle experienced a sudden loss of engine oil pressure that resulted in catastrophic engine failure. This condition…
I am writing to formally report a potential safety-related defect involving BMW vehicles equipped with the B58TU engine, primarily affecting model years 2019 through 2021. My vehicle experienced a sudden loss of engine oil pressure that resulted in catastrophic engine failure. This condition occurred with little to no warning and led to immediate vehicle disablement. The failure created a hazardous situation, as the vehicle was no longer able to maintain propulsion and could have placed occupants at risk because it occurred in active traffic or unsafe conditions. Based on my experience and additional research, the issue appears to originate from the engine’s oil pump design. Specifically, the oil pump contains an internal pressure-regulating component originally manufactured from plastic. This component is prone to fracturing, particularly during cold starts or low ambient temperatures. When this failure occurs, oil pressure becomes erratic or is lost entirely, often without sufficient warning to prevent engine damage or vehicle shutdown. My vehicle had this occur on January 20th 2026, as it was 5 Degrees outside. I suddenly lost oil pressure and had my vehicle’s engine catastrophically fail on a highway with my two small children ages (3) and (7 months) in the vehicle. In some cases, drivers may observe warning signs such as inability to measure oil level electronically, abnormal oil pressure readings, or drivetrain malfunction warnings. However, these indicators are inconsistent and often appear only moments before complete failure, leaving insufficient time for corrective action. This issue represents a significant safety concern for the following reasons: * Sudden loss of oil pressure can result in immediate engine shutdown or loss of propulsion while driving * Failures frequently occur under predictable conditions (cold starts in low temperatures), indicating a repeatable defect * Drivers are not provided with adequate warning to safely respond before damage.
- Electrical system · Service brakes · Unknown or other
NHTSA COMPLAINT (VERY IMPORTANT – SAFETY FOCUSED) Subject: Safety Complaint – BMW X7 Electrical Defect and Fire Risk (VIN: [XXX] ) To the National Highway Traffic Safety Administration, I am submitting a formal safety complaint regarding a 2020 BMW X7 xDrive40i affected by Recall No. 24V-576…
NHTSA COMPLAINT (VERY IMPORTANT – SAFETY FOCUSED) Subject: Safety Complaint – BMW X7 Electrical Defect and Fire Risk (VIN: [XXX] ) To the National Highway Traffic Safety Administration, I am submitting a formal safety complaint regarding a 2020 BMW X7 xDrive40i affected by Recall No. 24V-576 (Engine Starter Defect). My vehicle has experienced: •Sudden battery failure •Electrical system malfunction •Starter-related issues consistent with recall description BMW’s recall states that the defect can cause: •Electrical overload •Starter overheating •Increased risk of engine compartment fire This is not a theoretical issue—I have already experienced a complete system failure requiring towing and major repair, placing my family and me at risk. Serious Concerns •The defect appears systemic and dangerous •The remedy (software update) does not appear sufficient •The failure occurred without adequate warning Request for Investigation I urge NHTSA to: 1.Investigate the effectiveness of BMW’s recall remedy 2.Determine whether additional defects exist in the electrical system 3.Ensure BMW provides a permanent and safe solution This issue poses a serious public safety risk, and stronger regulatory action may be necessary. Sincerely, DLAA REAL ESTATE INVESTMENT, LLC, [XXX] and [XXX] ), regarding the defective BMW, YEAR 2020, MODEL: X7 xDrive40i | COLOR: OC27 ARCTIC GREY METALLIC VIN: [XXX] | CELL: [XXX] | FAX: [XXX] [XXX] | [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine
I'm reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure…
I'm reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drivetrain malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.
- Power train
The transfer case on my 2020 BMW X7 failed and had to be replaced. Turning the vehicle became unstable as the vehicle shuttered badly. BMW confirmed the shuttering and first changed the transfer case fluid. However, it only slightly helped at first but the shuttering came fully back shortly…
The transfer case on my 2020 BMW X7 failed and had to be replaced. Turning the vehicle became unstable as the vehicle shuttered badly. BMW confirmed the shuttering and first changed the transfer case fluid. However, it only slightly helped at first but the shuttering came fully back shortly thereafter. The vehicle was inspected by BMW twice. I don’t remember any warning lights on the dash. The shuttering first occurred in 2024.
- Engine
Oil pum with plastic internals. Repeat hot and cold cycles cause premature failure of the plastic components and cause loss of oil pressure along with the pump grenading itself.
- Power train
Transfer case broke and struck the engine while driving.
- Electrical system · Engine
My vehicle is included in BMW Recall Campaign No. 25V 644 – Engine Starter. It has repeatedly failed to start, and on two separate occasions the engine completely stalled while I was stopped at a traffic light. Each time, it took multiple attempts before the car would restart. I have also been…
My vehicle is included in BMW Recall Campaign No. 25V 644 – Engine Starter. It has repeatedly failed to start, and on two separate occasions the engine completely stalled while I was stopped at a traffic light. Each time, it took multiple attempts before the car would restart. I have also been stranded in numerous parking lots—during both extreme heat and freezing temperatures—with my children because the vehicle would not start. These incidents were unexpected, unsafe, and entirely consistent with the symptoms described in the recall. We have experienced these problems since purchasing the vehicle, but at the time we had no reason to believe we needed to document every occurrence. Now that BMW has acknowledged a fire risk defect and still has no available remedy, I do not feel safe continuing to operate this car. BMW has even advised owners not to park in a garage due to the potential fire hazard. The first recall was issued in 2024 and did not resolve the issue. The subsequent recall in August 2025 still has no fix. This ongoing situation presents a serious safety risk, and it is unacceptable that it remains unresolved. BMW should be buying these vehicles back and compensating owners for the significant inconvenience and danger this defect has caused.
- Electrical system · Engine
The check engine light on my 2020 BMW X7 intermittently illuminates and then clears without warning. A BMW technician diagnosed the cause as a malfunctioning active grille shutter assembly at the front of the vehicle. Research shows this is a widespread issue among BMW X5 and X7 models of similar…
The check engine light on my 2020 BMW X7 intermittently illuminates and then clears without warning. A BMW technician diagnosed the cause as a malfunctioning active grille shutter assembly at the front of the vehicle. Research shows this is a widespread issue among BMW X5 and X7 models of similar years, with many owners reporting the same failure and expensive repairs. This appears to be a systemic defect, not an isolated incident. Because the grille shutter directly affects engine airflow and cooling, this issue raises reliability and potential safety concerns and should be reviewed for a possible recall.
- Engine
Low oil pressure warning. Oil pump replacement
- Electrical system
The contact owns a 2020 BMW X7. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System). The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled in the middle of traffic. The contact immediately depressed the brake…
The contact owns a 2020 BMW X7. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System). The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled in the middle of traffic. The contact immediately depressed the brake and attempted to shift into park(P), but the transmission failed to respond as needed. The contact remained in the vehicle with the brake pedal depressed until Roadside Assistance arrived. The contact stated that the Roadside Assistance team held the start button down and the gear selector was shifted into neutral(N) for a second and continued to inadvertently shift back to park(P). The vehicle was towed to an independent mechanic who was unable to properly diagnose the vehicle and referred the contact to the dealer. The vehicle was then towed to the dealer, where it was diagnosed and determined that the starter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 85,600.
- Seats · Seats › Mid/rear assembly › Recliner
• Third-row seat in my 2020 BMW X7 failed during normal operation and trapped my [XXX] daughter between the seatbacks. • She sustained injuries to her legs (documented in photos). I injured my arm while trying to free her. • Approximately 10 people witnessed the incident. • Seat would not move or…
• Third-row seat in my 2020 BMW X7 failed during normal operation and trapped my [XXX] daughter between the seatbacks. • She sustained injuries to her legs (documented in photos). I injured my arm while trying to free her. • Approximately 10 people witnessed the incident. • Seat would not move or release electronically or manually—no functional emergency release. • Multiple BMW system warnings occurred before the incident, including: – “Third row seat risk of injury” – “Right/left rear seat unlocked” – “Right/left rear seat back unlocked” • BMW’s inspection found the passenger-side third-row seat motor housing broken. • There was no misuse and the failure occurred during normal operation • BMW refuses to repair the defect under warranty and attempted to return the vehicle unrepaired. • BMW suggested an “outside influence,” but evidence does not support this. • This defect creates a serious entrapment and injury hazard with no reliable manual release. • Requesting NHTSA investigation into BMW X7 third-row seat motors, locking mechanisms, and lack of emergency release due to risk of occupant injury or inability to evacuate a trapped passenger. There is an open and unresolved case with the manufacturer. Please help us and others that may be in danger. We still don’t have our vehicle back after 6 weeks and they state they will not fix it and return it to us broken, unsafe, and not usable. Here is the contact at BMW Gabrielle Dorcean Executive Customer Care, Customer Relations and Services BMW of North America, LLC Phone: [XXX] [XXX] Email: gabrielle.dorcean@bmwgroup.com INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Seats
I am filing this complaint because the third-row passenger seat in my 2020 BMW X7 has a serious defect that poses an immediate safety risk to children and passengers. The third-row seat malfunctioned while my child was exiting the vehicle. The powered seat began moving unexpectedly and trapped my…
I am filing this complaint because the third-row passenger seat in my 2020 BMW X7 has a serious defect that poses an immediate safety risk to children and passengers. The third-row seat malfunctioned while my child was exiting the vehicle. The powered seat began moving unexpectedly and trapped my child’s leg, and we had extreme difficulty getting the seat to release. This is an extremely dangerous failure for any powered seat, especially one that is frequently used by children. This is not normal wear and tear — this is a mechanical and electrical failure of a safety-critical seat system. BMW Fresno has had the vehicle for more than six weeks and cannot fix the problem. BMW North America reviewed the case but denied responsibility and closed it, even though the defect affects a powered safety-critical seat. We still have no repair, no explanation, and no assurance that the seat is safe. I am filing this because the powered seat poses a clear risk of injury, and BMW has not resolved or acknowledged the safety defect. I request that NHTSA investigate the 2020 BMW X7 third-row seat system for potential entrapment hazards. Actions Taken •BMW Fresno inspected the vehicle and kept it for 6+ weeks. •BMW NA conducted a review but has refused to cover cost of repair or acknowledge a defect. •I am seeking NHTSA’s involvement because this is a clear safety problem that BMW has not corrected.
- Power train · Steering · Suspension
Hello , I would like to report a failed front differential on my vehicle. This issue was diagnosed by an independent BMW shop and is currently being repaired. Mine made it to 69k miles but many others have had theirs failed before 50k miles. My main goal is to bring light to this issue since it…
Hello , I would like to report a failed front differential on my vehicle. This issue was diagnosed by an independent BMW shop and is currently being repaired. Mine made it to 69k miles but many others have had theirs failed before 50k miles. My main goal is to bring light to this issue since it seems to be a design flaw. There's also numerous reports for failed transfer cases since they aren't normally serviced by BMW dealers. I've attached both repair invoices.
- Power train
My front differential has failed and my vehicle has 62,000 miles. There is no recommended service and maintenance schedule for replacing fluids for the front differential so I thinking that this failure is due to an engineering design flaw including no recommended schedule to service the unit. It…
My front differential has failed and my vehicle has 62,000 miles. There is no recommended service and maintenance schedule for replacing fluids for the front differential so I thinking that this failure is due to an engineering design flaw including no recommended schedule to service the unit. It also seems this component may be too small/weak for the engine output. I has seem this failure reported on many blobs and users groups and seems to be recurring issue that BMW turns a blind side to. They ask why an extended warranty was not purchased and seeing that this is a recurring problem I am asking for a possible recall to force BMW to pay or reimburse others for repairs.
- Suspension
The contact owns a 2020 BMW X7. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the wheels while turning to the right or the left. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that both front…
The contact owns a 2020 BMW X7. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the wheels while turning to the right or the left. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that both front control arms needed to be replaced; however, the vehicle was not repaired due to the cost. Upon investigation, the contact related the failure to NHTSA Campaign Number: 20V678000 (SUSPENSION); however, the VIN was not included. The vehicle was previously serviced under NHTSA Campaign Number: 25V644000 (ELECTRICAL SYSTEM). The manufacturer was not made aware of the failure. The failure mileage was approximately 42,000.
- Engine · Power train
The contact works for a company that owns a 2020 BMW X7. The contact stated that while his boss was driving at an undisclosed speed, the vehicle stalled. The driver was able to veer to the side of the road. The vehicle was towed to a station. The vehicle was then towed to the dealer, where it was…
The contact works for a company that owns a 2020 BMW X7. The contact stated that while his boss was driving at an undisclosed speed, the vehicle stalled. The driver was able to veer to the side of the road. The vehicle was towed to a station. The vehicle was then towed to the dealer, where it was diagnosed and determined that the front trans-axle had disintegrated, causing the shaft to pinch and to create an 8-inch hole at the bottom of the oil pan. The contact stated that a significant amount of oil had leaked from the vehicle. The dealer determined that the transmission and engine had failed and needed to be replaced. The dealer informed the contact that it was a known failure, but the vehicle failure was the most dangerous reported failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that no assistance could be provided because the VIN was not included in a related recall. The failure mileage was approximately 140,218.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11012089Head restraint and/or backrest of 3RD row seats cannot be folded down
- 11012075the NVLD modules limited warranty for defects in materials and/or workmanship has been extended to 15 years / 150,000 miles as determined from the vehicles original in-service / first delivery date.
- 11010768For this vehicle, the engine coolant thermostat limited warranty for defects in materials or workmanship has been extended to 15 years/150,000 miles, as determined from the original in-service date.
- 10252280The connection between the LED module and the light tube inside the upper/top headlamp housing is damaged.
- 10252279The seat leather upholstery detaches from the front of the thigh support (aka knee bolster) of either front seat.
- 10252135After performing a BMW Remote Software Upgrade (RSU), the functionality of the Comfort Access andPassive Go/Exit features may be reduced. Also, one or more of the following error memory entries below may be stored in the Basic Central Platform(BCP) module. 80424A Remote control receiver at the front (FBD5 VM): Programming defective 80424B Remote control receiver at the rear (FBD5 HM): Programming defective 80424C Remote control receiver at the front left (FBD5s VL): Programming defective 80424D Remote control receiver at the front right (FBD5s VR): Programming defective 80424E Remote control receiver at the rear right (FBD5s HR): Programming defective 80424F Remote control receiver at the rear left (FBD5s HL): Programming defective
- 10252038Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt betweenCombustion engine and starter generator torn And/or one or more of the following other issues are also occurring: Noise in the area of the belt drive. Odor from the engine compartment. Smoke formation in the area of the belt drive. Drive belt damaged or prematurely worn. Torn drive belt.
- 10252033During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/o router CV boots.
- 10252031One or more of the LED daytime running lights are dim or discolored.
- 10252023The original Conditioned Based Service (CBS) Key data point closed with 23-07 soft ware, all CBS systems are now collectively under analysis.
- 10252016Deactivated: Currently investigating other components that maybe playing a factors besides what is mentioned in the SIB. Topic is under investigation.
- 10250893SITUATION BMW AG is conducting a Voluntary Emissions Recall (effective April 23, 2021) on a certain Model Year 2020 - 2021 BMW vehicles that were produced between August 13, 2019 and December 11, 2020. Do not deliver to a customer, a New, Certified Pre-Owned or Used vehicle subject to an emissions recall, until the vehicle is repaired. Do not use or sell replacement equipment/parts subject to an emissions recall. The 12 V batterys dual storage system (DSS) may contain a software error which intermittently causes a continuous resetting of the microcontroller and communication failure. The error is displayed by a red Check Control message.
- 10249437The basic conditions for initializing the power windows are not met.
- 10249425The Check Control message below appears even though the coolant level is not below minimum when theengine is cold. Check Control message (ID 166): Top up coolant.
- 10249032The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 HU-H: Reset will be stored in the HU-H3.
- 10249031Check Engine light is on IHKA has stored fault 80131C IHKA: 12V voltage sensor plausibility
- 10249027The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.
- 10249025The roller sunshade (aka sun protection or sunblind) of the front panoramic sunroof is bunching up during operation or may hang down and appear loose.
- 10249024This bulletin outlines known areas of possible water entry, operational noise, or wind noise for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting complaints from the roof area. This bulletin and the associated attachments are designed to provide one single diagnostic resource for troubleshooting all known issues related to the panoramic sunroof of BMW Sports Activity Vehicles which have quality improvement measures already in place.
- 10249018At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking, maneuvering)with a large steering angle, the front end can be slightly axially misaligned. This can be felt (jerking)/ heard via an acoustic acknowledgement (clunk) as seen at the 11 second mark of the video. See attached video V36 01 21.
- 10249017SITUATION Unusual noises occur only when operating the steering column in the axial direction. 1. A one-time thump sound at the start of movement Shortly after the steering column starts moving, retracting, or extending, a one-time thump noise is heard. See attached video V32 03 23 2. Humming noise while steering column extends in the axial direction. The sound is only heard when the steering column is extended, not when the steering column is retracted. When the steering column starts to move in the extended direction, the humming noise can be heard. See attached video V32 04 23
- 10249015A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a large leak, after confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
- 10247578When using the Key Reader to retrieve CBS information from the customer key, no current vehicle data is available, or the data does not match the maintenance schedule.
- 10247567Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
- 10246302Two areas of the third-row seat backrest that may cause a noise concern have been added.
- 10245422Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicles equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
- 10245420Emergency Stop Assistant is activated. Thisicon will appear in the CID when this function is activated.
- 10245377When using the Key Reader to retrieve CBS information from the customer key, no current vehicle data is available, or the data does not match the maintenance schedule.
- 10245367Check Control message (CCM) indicates: (ID 213): Stop, exercising due care. Voltage supply The Service Engine Soon light is on with the following DME Fault Code: 21B209 - Starter alternator / belt for 48V system (OSA_RIEMEN_RISS): Belt betweenCombustion engine and starter generator torn And/or one or more of the following other issues are also occurring: Noise in the area of the belt drive. Odor from the engine compartment. Smoke formation in the area of the belt drive. Drive belt damaged or prematurely worn. Torn drive belt.
- 10244528BMW of North America, LLC (BMW NA) has a nationwide settlement with the plaintiffs in the following class action: Brightk Consulting, Inc. v. BMW of North America, LLC. The Court has granted final approval of the settlement. Note: This updated bulletin (10/2023) is a notice that the Class Action Settlement was finalized on September 22, 2023. This is NOT a notice of a Recall or Service Action. Class Allegations The plaintiff in the lawsuit alleges that the front cupholders in certain model year 2019 through 2022 BMW X5, X5 M, X6, X6 M, or X7 vehicles are permeable to spilled liquids that may seep through the cupholders onto components, which in turn, may result in the illumination of the Supplemental Restraint System (SRS) warning light along with displaying a corresponding Check Control Message (CCM). BMW NA expressly denies any wrongdoing alleged in the complaint and does not admit or concede any actual or potential fault, wrongdoing, or liability.
- 10244258Second seat row blocking access to third seat row, program seat modules. Visible stitching on first row sport seat. Third seat row backrest Bowden cable routing and length change.
- 10244257Various concerns about the third row of seats: 1. Head restraint (aka headrest), on one or both sides, cannot be folded down. 2. Third-row seating, on one or both sides, cannot be folded down.
- 10244242Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
- 10244239This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
- 10242887Due to an assembly ase ventilation line connections may not be securely locked.
- 10242886Due to an assembly ase ventilation line connections may not be securely locked.
- 10242878Moisture is visible in one or both of the Daytime Running Light (DRL) headlights.
- 10242874Customers may be experiencing one or more of these following issues with Bluetooth operation: Bluetooth cannot be switched on or off in the head unit (HU-H4) Paired mobile devices cannot be deleted Customer is unable to make phone calls or stream music with mobile device Customer is unable to connect a new mobile device via Bluetooth Mobile device does not automatically reconnect via Bluetooth in the next drive cycle (after short sleep cycle)
- 10242696?Water leaking into the vehicle from the headliner/microphone area.
- 10242695?Various concerns about the third row of seats.
Every BMW X7 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.