2004 Ford E-Series
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › E-Series › 2004
These records cover every 2004 Ford E-Series. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Owner complaints
2 complaints
What owners report most
Latest complaints
- Equipment › Appliance › Air conditioner · Latches/locks/linkages · Power train › Manual transmission · Seats › Front assembly › Seat heater/cooler · Steering · Structure · Tires · Visibility
I have had this 2004 van in the ford garage in fremont mi at least 10 times. Even had to have the subframe replaced and that wore out all the tires all doors ,air conditioner,brakes,transmission replaced. Locks replaced, heated seat twice,swaybar replaced. I feel I am in a time bomb, we owe more on…
I have had this 2004 van in the ford garage in fremont mi at least 10 times. Even had to have the subframe replaced and that wore out all the tires all doors ,air conditioner,brakes,transmission replaced. Locks replaced, heated seat twice,swaybar replaced. I feel I am in a time bomb, we owe more on it then it IS worth. Last one we buy! We are luckily to be alive in this piece of junk,to many dates of repair to give you. *Tr
- Electrical system · Latches/locks/linkages · Power train › Automatic transmission · Service brakes, air
We own a 2004 ford freestar with approximately 80,000miles. on july 18TH we experienced difficulty with the air conditioner working properly. on july 19TH the car struggled to go up hill. on july 20TH we took the vehicle to bob davidson ford dealership 1845 joppa rd in baltimore, maryland 21234…
We own a 2004 ford freestar with approximately 80,000miles. on july 18TH we experienced difficulty with the air conditioner working properly. on july 19TH the car struggled to go up hill. on july 20TH we took the vehicle to bob davidson ford dealership 1845 joppa rd in baltimore, maryland 21234 888-211-0807 on july 21ST we were informed that our transmission needed to be replaced at a cost of over $3,000 in addition to repair for the air conditioning at a cost over $1,000 with a more recent response from the dealership that the total repair was now listed at approximately $5,400.00 or more. we are shocked to say the least that our freestar that IS barely 4years old and even have purchased the extended warranty up to 60,000miles or five years "whichever came first" as I was reminded by the repairshop representative, that this vehicle should need this type of repair at such an early stage in the vehicle's ownership. the cost made us suspect and we searched on line through consumer reports and found numerous complaints with similar stories like our own. at this time when energy costs are at an all time high and we have a son about to attend college this additional outlay of considerable monetary funds seems completely above what IS reasonable. we are still awaiting a final cost report from the ford dealership, but wanted to make sure that we registered a formal complaint as we are confident that the 2004 ford freestar will be recalled. in addition to this current problem we have already had to replace the breaks and encountered electrical problems with the sliding door locks. any information you have regarding this complaint would be most appreciative. *tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10109070The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
- 10042864Ford: the blower motor on some vehicles are operating either incorrectly or not operating or just functioning on one speed.
- 10030839Ford: certain vehicles with ambulance prep package ambulance class action settlement; pcm part number inspection. Awareness communication dated 4/20/09.
- 10030838Ford: certain vehicles, e series and f super duty, with ambulance prep package ambulance class action settlement-6.0l diesel engine replacement warranty extension. Awareness communication dated 4/20/09.
- 10030837Ford: certain vehicles with ambulance prep package ambulance class action settlement; specific component warranty extension. Awareness communication, dated 4/20/09.
- 10030836Ford: multiple vehicles with a torq shift transmission intermittent clunk when shifting between drive, reverse and park and/or during 2-3 upshift. Models f super duty; e series; excursion; F53 motorhome chassis and low cab forward.
- 10028125Ford: vehicles may exhibit fuel in the engine coolant, due to leaks in the cylinder head fuel injector area. Symptoms may include fuel in engine coolant and coolant expulsion from the degas bottle. Updated 3/20/09.
- 10023943Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. This includes F-53 motorhome chassis. Updated 2/23/10.
Every Ford E-Series model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.