2018 Grand Design Reflection
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Grand Design › Reflection › 2018
These records cover every 2018 Grand Design Reflection. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2018 Grand Design Reflection. Newest first.
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Risk and remedy
Risk
An electrical arc increases the risk of a fire.
Remedy
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2018 Reflection trailers. A wiring connector in the vehicle underbody may not be properly secured, allowing water intrusion into the wiring connector, possibly resulting in an electrical short circuit.
Risk and remedy
Risk
If water enters the wiring connector, it can cause a short circuit, increasing the risk of a fire.
Remedy
Grand Design will notify owners, and dealers will inspect and secure the wiring connectors up to prevent water intrusion, free of charge. This recall began June 29, 2020. Owners may contact Grand Design's customer service at 1-574-825-9679. Grand Design's number for this recall is 910020.
Grand Design RV, LLC is recalling certain 2018-2019 Reflection fifth wheel trailers, models 28BH and 29RS. The circuit for the power converter does not have over-current protection.
Risk and remedy
Risk
An electrical short circuit in the unprotected circuit can increase the risk of a fire.
Remedy
Grand Design RV will notify owners, and dealers will inspect the trailers to determine if the 50-amp mini breaker at the bus bar is installed correctly and that the circuit is wired correctly, correcting it as necessary, free of charge. The recall began November 19, 2018. Owners may contact Grand Design RV customer service at 1-574-825-9679. Grand Design RV's number for this recall is 910017.
Grand Design RV, LLC (Grand Design) is recalling certain 2017-2018 Reflection and Imagine travel trailers equipped with a Smart-Jack model power tongue jack. The laminated plastic touch pad on the jack may crack or separate allowing water to enter, potentially causing the jack to operate unintentionally.
Risk and remedy
Risk
If the tongue jack retracts or extends unexpectedly, there could be an increased risk of a crash or injury.
Remedy
Grand Design will notify owners, and dealers will replace the power tongue jack, free of charge. The recall began on December 29, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 900012.
Grand Design RV, LLC (Grand Design) is recalling certain 2018 Reflection travel trailers, model 297RSTS. These vehicles may have insufficient clearance between the tire and the ram that moves the slide out room. The tire can contact the ram for the slide out room while the trailer is being towed, causing tire damage or a possible tire blowout.
Risk and remedy
Risk
Tire failure can increase the risk of a crash.
Remedy
Grand Design will notify owners, and dealers will install a lift kit at each of the axle hangers, giving two additional inches of clearance. Tires that show evidence of damage will be replaced. These repairs will be performed free of charge. The recall began on December 14, 2017. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910011.
Owner complaints
11 complaints1 involved a fire1 injuries
What owners report most
Latest complaints
- Structure
The contact owns a 2018 Grand Design Recreational Reflection RV. The contact stated that there were structural cracks and frame separation on the RV, causing the rear interior walls to separate from the floor of the RV. The cause of the failure was not yet determined. The contact was informed of a…
The contact owns a 2018 Grand Design Recreational Reflection RV. The contact stated that there were structural cracks and frame separation on the RV, causing the rear interior walls to separate from the floor of the RV. The cause of the failure was not yet determined. The contact was informed of a Customer Satisfaction Campaign related to the failure. The vehicle was not yet repaired. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was unknown.
- Service brakes
A thin rubber grommet is used to protect the electric brake wires passing through the axel tube. These grommets wear through during normal towing. This, in turn, causes the wire to short to ground leading to total failure of the trailer brakes. I did not experience an accident but came very…
A thin rubber grommet is used to protect the electric brake wires passing through the axel tube. These grommets wear through during normal towing. This, in turn, causes the wire to short to ground leading to total failure of the trailer brakes. I did not experience an accident but came very close as I was approaching a stopped vehicle and realized I needed MUCH more braking force on my truck brakes to stop my forward movement. All 4 grommets on the 2 axels on my trailer have failed as shown in the attached pictures but only one has resulted in the wire being rubbed through causing the brake failure. A picture of the axel ID is also included. This appears to be a serious design flaw that should be corrected. A quick Internet or YouTube search will show there are many occurences of this!
- Equipment
The contact owns a 2018 Grand Design Reflection RV. The contact stated stated after starting the RV, he noticed that there was fire coming out of the refrigerator compartment. The contact was able to extinguish the fire with 3 fire extinguishers, fire hoses, and with the assistance of the fire…
The contact owns a 2018 Grand Design Reflection RV. The contact stated stated after starting the RV, he noticed that there was fire coming out of the refrigerator compartment. The contact was able to extinguish the fire with 3 fire extinguishers, fire hoses, and with the assistance of the fire department. A fire department report was filed. A police report was filed, but the police report information was not available. The contact sustained a scraped left knee while exiting the RV, but did not seek medical assistance. The RV was towed to the contact's residence. The manufacturer was notified of the failure and informed that the VIN was included in NHTSA Campaign Number: 22V038000 (Equipment). Additionally, the manufacturer sent a field technician to the contact's residence, where the RV was inspected but the cause of the failure could not be determined. The dealer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 10,000.
- Suspension
Own 2018 Grand Design (GD) RV with a broken Lippert (LCI) spring hanger that holds the axle in place, not discovered until maintenance. Photos available. Research reveals longevity, LCI knowledge, fix, number of & lack of notification. Contacted dealer, GD & LCI about safety defect told “Out Of…
Own 2018 Grand Design (GD) RV with a broken Lippert (LCI) spring hanger that holds the axle in place, not discovered until maintenance. Photos available. Research reveals longevity, LCI knowledge, fix, number of & lack of notification. Contacted dealer, GD & LCI about safety defect told “Out Of warranty.” Not warranty, safety. The GD RV requirement or LCI frame equipment component issue is the spring/axle hanger. Other RV manufactures utilize Lippert frames with the same component/condition. LCI RV frames experience a higher rate of spring/axle hanger failures than RV manufactures Northwoods or Outdoor RV that design and construct their own RV frames. Info GD Forum. Attached #1, 2, 3, 4. There are more. 7/2014 NHTSA Recall # 14V-288 Starcraft. #5 10/7/2016 Keystone Rv RECALL: 14V-146 Safety Advisory: 14-205. #6 4/ 23/2021 LGS Industries Inc, #7 Recalls based on quality. Current cause unknown, “may fail during travel leading to an increased risk of loss of control and vehicle crash” remains the same. March 6, 2022, post describes in detail the broken spring hanger issue, includes a mechanical drawing dated 2003 of Lippert designed V modification fix. #8 LCI Publication LIP-0135 revA, AXLE RETRO PROCEDURE developed for 2009 Open Range RV. Page 2, information/drawings how to modify spring hanger, with V mod. #9 On 12/2020, a post “This is what the spring hanger looks like with the V reinforcements factory installed on my ’21 31G.” Is Lippert now installing the V mod on new frames? #10 Educating RV owners, the importance of inspection & available V mod of potential hanger failure, would result in safer roads for owners & public. GD & LCI’s current absence of responsibility & involvement is unfair.
- Structure › Body
The contact owns a 2018 Grand Design Reflection. The contact stated that as he retracted the RV's main slide out, the actuator used to retract the slide out snapped. Due to the failure, the slide out remained loose and was no longer secured to the RV. A technician was called to inspect the RV but…
The contact owns a 2018 Grand Design Reflection. The contact stated that as he retracted the RV's main slide out, the actuator used to retract the slide out snapped. Due to the failure, the slide out remained loose and was no longer secured to the RV. A technician was called to inspect the RV but informed the contact that there was too much damage and that extensive repairs would be needed. The manufacturer was notified of the failure and informed the contact that the RV was no longer under warranty. The RV was not repaired. The failure mileage was unknown.
- Suspension
The contact owns a 2018 Grand Design Reflection. The contact stated that during maintenance of the vehicle, he noticed that the driver’s side rear upper shackle pin on the Dexter trailer axle was not drilled to allow lubricant grease to enter, causing the pin and spring to dry out. The vehicle was…
The contact owns a 2018 Grand Design Reflection. The contact stated that during maintenance of the vehicle, he noticed that the driver’s side rear upper shackle pin on the Dexter trailer axle was not drilled to allow lubricant grease to enter, causing the pin and spring to dry out. The vehicle was not taken to a dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 9,000. Consumer contacted the RV manufacturer, Grand Design, who suggested he follow up with axle manufacturer, Dexter.
- Suspension
While towing my rv, the weld that secures the rear axle springs broke. This weld was located on the right rear side of the frame and it snapped completely off the Lippert frame. It allowed the rear axle to move forward and the two tires on the right side contacted each other and the tires started…
While towing my rv, the weld that secures the rear axle springs broke. This weld was located on the right rear side of the frame and it snapped completely off the Lippert frame. It allowed the rear axle to move forward and the two tires on the right side contacted each other and the tires started to disintegrate. A tire on the left side was forced out of alignment and the tire shaved rubber until the steel belts were visible. These tires were high grade tires with less than 5000 miles on them. I stopped for fuel and noticed the damage. If I had continued the tires would surely have had a catastrophic failure shortly. This would have certainly resulted in a loss of control and a probable crash at highway speed. Since the tires were rubbing it is also likely a fire could have resulted. I was unable to have the vehicle moved to a repair location and no mobile rv techs would respond since I was in a remote location. I had to hire a local welder to reattach the weld and reinforce the frame on both sides. In speaking with my insurance company it was determined that this is not an unusual problem with welds breaking. The vehicle was not inspected by police as no other individuals or property was involved. Photos of the damage and broken weld were sent to Grand Design and Lippert, the manufacturer of the frame. Photos taken of the repairs performed by the welder were also sent to them. In addition to repairing the broken weld, I had the welder reinforce the left side of the frame holding the axle springs in place so that it would not fail. The unit is now much safer than it was before the repair. There were no warning lights or symptoms for this problem. I stopped purely by chance for fuel and noticed the steel belts protruding through my tires and this is the only thing that stopped a catastrophic failure and probable crash. The trailer has never been overloaded, and was never driven faster than 65. It has never been in an accident.
- Suspension
The suspension hanger, the piece that holds leaf spring and IS attached to the frame of the trailer, broke clean through on inboard rear passenger side of the vehicle. the suspension failure was discovered while parked and during routine lubrication of the suspension wet bolts. the component IS…
The suspension hanger, the piece that holds leaf spring and IS attached to the frame of the trailer, broke clean through on inboard rear passenger side of the vehicle. the suspension failure was discovered while parked and during routine lubrication of the suspension wet bolts. the component IS an inverted u bracket, the top of which attaches to the trailer frame, the arms of which, in conjunction with a wet bolt provide the mounting location for the rear eye of the leaf spring. one leg of this u bracket, and consequently one end of the bolt attaching the leaf spring to the body completely failed, breaking clean away from the frame. upon further inspection the rear driver side leaf spring bracket has developed a crack, but has not propagated through the entire arm of the bracket. fortunately this suspension failure was discovered while this 10,000lb vehicle was parked and fairly early as the arm of the suspension had not yet hung to a hanging position. with the other hanger beginning to fail, this vehicle would pose a significant hazard to persons and property while traveling at highway speeds. the vehicle IS less than 2 years old, it has been trailered less than 3000 miles, has been loaded within gvwr limits, has never been in an accident, has sustained no body damage. *Dt consumer contacted manufacturer of the frame and suspension components. carfax cannot process this request. *Jb
- Power train · Power train › Axle hubs · Suspension
Grand design reflection options assembled at manufacturer or dealer are not included are not included in 9556# uvw or subtracted from ccc label of 1379# as required by amended federal motor vehicle safety standard (fmvss) nos. 110 and 120 to address the problem of motor home and recreation vehicle…
Grand design reflection options assembled at manufacturer or dealer are not included are not included in 9556# uvw or subtracted from ccc label of 1379# as required by amended federal motor vehicle safety standard (fmvss) nos. 110 and 120 to address the problem of motor home and recreation vehicle trailer overloading. The final rule took effect on june 2, 2008. if options installed by manufacturer or dealer at time of sale when options exceed 165# which IS 1.5% of 10,995 lbs gvwr the ccc tag needs to be modified or replaced. manufacturer shipped options dinette with 4 chairs, 2ND a/c, 2ND awning. dealer added 2 slide toppers, automatic lift system the sum of each item exceeds 165# threshold, thus placing owner at risk of exceeding 10,995# thus overloading axle and springs. grand design requires owner to weigh trailer before warrantying bent axles or springs and deny's claim if in excess of 10,995# blaming customer for exceeding the cargo weight. in our case our trailer was over by 280# which resulted in inside tire wear, 2 bent axles and springs after approximately 11,500 trailer miles across us and alaska between 12/27/2017 through 8/20/2018. purchase 2018 grand design 315rlts on 12/27/2017 thus under 1 year warranty. grand design claims roads in alaska are damaging to rv with excessive weight due to permafrost thus denying the claim. challenging the amended standard was not followed and weight are not provided anywhere on grand design website or documentation customers are unaware to subtract options from cargo weight at time of purchase. Grand design offered heavier springs, but I was responsible for labor and axles. grand design has not provided weight of options or original weight certification to understand what IS included in original certification. repaired on 8/20/2018 at owners expense. tire manufacturer did accept warrenty
- Service brakes
Found several problems online indicating that grease leaks past the axle seals and contaminates the brakes. my wheels are showing signs of grease and it IS only a matter of time before the brakes lose effectiveness. problem IS that the condition will get progressively worst and the user may not notice the loss of brake effectiveness until it IS too late.
- Service brakes
Grease leaking from axle seal onto brake drums on all four wheels causing ineffective brakes. lippert axles
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10188517The #10 screws used to fasten the vertical column of the Schwintek In Wall system to the may have been over torqued, causing a loss of hold, resulting in loose and/or broken screwheads. As a result, columns may pull away from the sidewall.
- 10172587Customer Satisfaction Program released to have a protective heat shield installed behind convection microwave on units identified below to address concerns with excessive heat buildup.
Every Grand Design Reflection model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.