2020 Honda Insight
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Honda › Insight › 2020
These records cover every 2020 Honda Insight. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2020 Honda Insight. Newest first.
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic…
Risk and remedy
Risk
Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy
Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX…
Risk and remedy
Risk
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy
Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump…
Risk and remedy
Risk
Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy
Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Honda (American Honda Motor Co.) is recalling certain 2020 CR-V Hybrid, Accord Hybrid, and 2020-2021 Insight vehicles. The DC-DC converter may shut down and prevent the 12-volt battery from recharging, possibly resulting in a loss of drive power.
Risk and remedy
Risk
A loss of drive power can increase the risk of a crash.
Remedy
Honda will notify owners, and dealers will update the power converter unit (PCU) software, free of charge. The recall began February 12, 2021. Owners can contact Honda customer service at 1-888-234-2138. Honda's number for this recall is K9E.
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Accord Sedan, Accord Hybrid, and 2019-2020 Insight vehicles. A software error may cause intermittent or continuous disruptions in communication between the Body Control Module (BCM) and other components. This may result in malfunctions of various systems such as the windshield wipers and…
Risk and remedy
Risk
Various system malfunctions such as inoperative windshield wipers, defroster, rearview camera, or exterior lighting can increase the risk of a crash.
Remedy
Honda will notify owners, and dealers will update the BCM software, free of charge. The recall is expected to begin February 22, 2021. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is X95.
Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura NSX, 2019 Acura RDX, RLX and RLX Sport Hybrid, 2018-2019 Honda Accord, Civic Hatchback, Civic Type R and HR-V, 2019-2020 Insight and 2019 Fit vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Risk and remedy
Risk
If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy
Honda will notify owners and dealers will replace the fuel pump assembly, free of charge. The recall began July 22, 2020. Owners may contact Honda customer service at 1-888-234-2138.
Owner complaints
31 complaints3 involved a crash2 injuries
What owners report most
Latest complaints
- Forward collision avoidance › Automatic emergency braking
I was driving to Pilates class and everything was normal but as I reached a railroad crossing the car suddenly and for no reason stopped dead on the tracks. Luckily for me there were no vehicles in front or behind me and there were no trains coming. I was terrified and wasn’t sure what to do but I pushed the Drive button and the vehicle went ahead as if nothing happened.
- Forward collision avoidance › Warnings · Unknown or other
The vehicle unintentionally accelerated while pulling into a parking space. I was depressing the brake to slow down while making the right turn into the space. The engine suddenly revved up (as though you were depressing the gas and brake at the same time) and it accelerated forward (a though you…
The vehicle unintentionally accelerated while pulling into a parking space. I was depressing the brake to slow down while making the right turn into the space. The engine suddenly revved up (as though you were depressing the gas and brake at the same time) and it accelerated forward (a though you suddenly released the brake while depressing the gas pedal) and the car lept forward, jumping a 3 foot long curb, striking the vehicle parked in front of me. The tires kept spinning as though the gas pedal was being depressed, even though the vehicle could no longer make any forward progress since it had run into the front of the vehicle parked in front of me. We’re it not for the vehicle in front, I feel that the car would have continued accelerating forward and could have caused injury or death to customers in the shopping center and/or damage to other vehicles or structures. The vehicle was towed and is currently in the body shop for repairs, but I don’t think this addresses my concern for the sudden acceleration. I don’t want to drive it in case the problem reoccurs and could cause further damage. I’ve reached out to Honda to see if I can tow the vehicle to their service repair center to try to diagnose the problem by reading data from the car’s computer, but they have not responded. I checked the floor mats and they were flat and properly installed. If I had mistakenly depressed the gas pedal (not likely as I was already braking as I approached the parking space), I would have thought that the collision avoidance system would have braked the vehicle. Airbags also did not deploy in either vehicle.
- Steering
At approximately 148,000 miles the steering would have an intermittent notchy, or sticky, feeling while driving straight. While driving straight at cruising speed, I noticed that the resistance on the left side of the steering wheel was greater than the right side, then the resistance would…
At approximately 148,000 miles the steering would have an intermittent notchy, or sticky, feeling while driving straight. While driving straight at cruising speed, I noticed that the resistance on the left side of the steering wheel was greater than the right side, then the resistance would decrease suddenly (release), and the steering wheel would rotate slightly to the right, but less than 1 degree, so it would be hardly noticeable on video. The issue seems to only present itself after the vehicle is driven 20-40 minutes and when the temperature is 47 degrees or higher. I have noticed it at low speed (15-20mph) and at highway speeds. If I recall correctly, the issue first presented itself when we had our first 60 degree day and I was driving on the highway with the wheel straight. Then as I accumulated miles throughout the weeks, I would notice that it didn't happen on colder days but then happened more often on warmer days. Now that the vehicle has ~148,800 miles on it, and the air temperature is 67 degrees, the issue presented itself this morning (4/1/2026) after 3 minutes of driving and during the first sweeping left turn on my commute and at approximately 40 mph. Then the issue continued to happen throughout the drive, eventually becoming nearly constant by the end of the 45-minute commute. I do have an appointment with the Honda dealer for diagnosis, but the service advisor and I suspect that the steering rack is failing.
- Electrical system
Battery keeps draining. On my 3rd battery and believe there’s a defect in the DC/DC converter (earlier recall - K9E). This has caused issues being stranded in the cold.
- Forward collision avoidance › Automatic emergency braking · Service brakes
This 2020 Honda Insight performed “phantom braking” of the automated braking system when I was about to enter a clear intersection with no vehicles or obstacles in front of me. It activated the automated braking system and endangered my life and the lives of others over no real threat. This occurred 08/23/2025. The car is well maintained and does not have any service issues. This was completely random.
- Electrical system · Forward collision avoidance · Service brakes, hydraulic
The contact owns a 2020 Honda Insight. The contact stated that after starting the vehicle, several unknown warning lights illuminated. During the failure, the brakes failed to function as intended, and the Lane Departure, Cruise Control, and Forward Collision Avoidance features failed to function…
The contact owns a 2020 Honda Insight. The contact stated that after starting the vehicle, several unknown warning lights illuminated. During the failure, the brakes failed to function as intended, and the Lane Departure, Cruise Control, and Forward Collision Avoidance features failed to function as intended. The failure was intermittent. During the first failure, the vehicle was turned off and restarted after several minutes and the vehicle operated as intended. The vehicle was taken to the dealer and diagnosed with battery failure. The dealer also determined that the brake pedal simulator had failed. The vehicle was not repaired. The manufacturer was not notified of the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 18,000.
- Structure › Frame and members › Underbody shields
I was driving home from vacation when my engine splash plate came loose from my car on the interstate. The splash plate fell down and dragged on highway creating friction under my car. The metal had fallen down and was chipping away creating dangerous debris to my car and other cars on the highway.…
I was driving home from vacation when my engine splash plate came loose from my car on the interstate. The splash plate fell down and dragged on highway creating friction under my car. The metal had fallen down and was chipping away creating dangerous debris to my car and other cars on the highway. Roadside service was no help, per usual. I was traveling alone. The splash plate had to be removed entirely to prevent a fire and more damage to my car. I couldn’t remove the splash plate on the side of the interstate. I drove 30-40 mph to get help to prevent further damage or loss of property and my life.
- Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings · Service brakes
I was driving down the highway, with no one in front of me, and my car alerted BRAKE and brought my car from 70 to an almost complete stop. This jerked myself and my passenger and caused a heat mark from the seat belt on my collar bone. It has done it multiple times since then. I'm terrified to be…
I was driving down the highway, with no one in front of me, and my car alerted BRAKE and brought my car from 70 to an almost complete stop. This jerked myself and my passenger and caused a heat mark from the seat belt on my collar bone. It has done it multiple times since then. I'm terrified to be in traffic and for it to do this. This is most definitely putting my safety at risk, and the safety of others. I have not taken it to the dealership yet.
- Forward collision avoidance › Automatic emergency braking
I was driving on a two lane road driving over a small paved bridge going about 40mph with a car next to me and a car behind me nothing in front of me when my car did a hard phantom brake. No pre warning, the display did show BRAKE and it did beep. But everything was sudden. Luckily the car behind…
I was driving on a two lane road driving over a small paved bridge going about 40mph with a car next to me and a car behind me nothing in front of me when my car did a hard phantom brake. No pre warning, the display did show BRAKE and it did beep. But everything was sudden. Luckily the car behind was able to slam on brakes. The car behind me continued to follow but was at least 4 car lengths away. I assume bc they didn't know why I braked.
- Fuel system, gasoline
The contact owns a 2020 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated the vehicle had stalled on several occasions. Additionally, the vehicle…
The contact owns a 2020 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated the vehicle had stalled on several occasions. Additionally, the vehicle occasionally failed to start-up. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000. Parts distribution disconnect.
- Structure › Body
The whole hood vibrates while driving or when is windy, very noticeable at times. It was replaced once, almost a year ago but now it needs to be replaced again. same problem eventually the latches will be damaged creating a very hazardous situation. This vehicle has not been on an accident
- Power train · Suspension · Wheels
I believe the tire, wheel or suspension system failed while driving on the highway, causing me to hit my head on the driver's window and lose cosciousness. I skidded into a concrete barrier on the right side of the highway and was found unconscious at the scene. The damage to the passenger side…
I believe the tire, wheel or suspension system failed while driving on the highway, causing me to hit my head on the driver's window and lose cosciousness. I skidded into a concrete barrier on the right side of the highway and was found unconscious at the scene. The damage to the passenger side body of the vehicle is minor and does not match the catastrophic failure of the wheel, leading me to believe the wheel failed and caused the crash, not that the crash resulted in the damage to the wheel. The vehicle is currently at a tow lot and available for inspection. Luckily, no other vehicles were involved, but I was injured and could have easily been killed, or injured and killed others as it is a busy highway, especially during rush hour when this occurred. Inspection by the insurance company is pending. The police did not investigate as a safety incident because they immediately said on site that almost all single vehicle accidents are drug/alcohol related and treated it like a DUI stop. I passed field sobriety tests and a breathalyzer on scene and blood work at the hospital showed no drugs or alcohol in my system. I am missing time and memories starting about 5 minutes before the crash and for about 30 minutes after as a result of my concussion, I do not remember much besides a feeling that my car was falling, then I remember being woken up by the cop asking if I was under the influence.
- Air bags
On September 16, 2022, I was in an accident where a driver hit me on the rear passenger side. I went a through a green light of an intersection on the Mopac N feeder Road and Duvall. Either both our lights were green or the other driver was dishonest and his was red. Every airbag deployed. Based on…
On September 16, 2022, I was in an accident where a driver hit me on the rear passenger side. I went a through a green light of an intersection on the Mopac N feeder Road and Duvall. Either both our lights were green or the other driver was dishonest and his was red. Every airbag deployed. Based on the impact, it would be highly unlikely to sustain a cracked sternum. The impact was to the right and slightly behind me. I have requested information from Honda America on the airbags and they refuse. They further insulted me by telling to go to a dealership. After this, Honda is the last car I would purchase or lease. Having worked at dealerships for many years, I am certain Honda knows, as well as I do, that the dealer cannot or will not give me compete information on the airbags. My car was maintained and in amazing condition. The last time I was at First Texas Honda for service, the advisor brought it around because they were very busy. He said he was stunned it had 125,000 miles on it. It drove like it was brand new. Please see photos and reports. If you need any further information, please let me know.
- Electrical system · Engine · Power train
Driving down highway at highway speed and car shot 52 failure codes. Car lost power and crawled to side of road. Nearly got rear ended multiple times trying to remove vehicle from roadway. Engine permanent codes U0111 U012D U0110 U12A5 U1206 U1205 Anti lock brakes permanent codes U040168 CAN…
Driving down highway at highway speed and car shot 52 failure codes. Car lost power and crawled to side of road. Nearly got rear ended multiple times trying to remove vehicle from roadway. Engine permanent codes U0111 U012D U0110 U12A5 U1206 U1205 Anti lock brakes permanent codes U040168 CAN Gateway Permanent codes U0029-00 Electric power train traction motor control module permanent code U1204 U12A5 U1205 U0100 U012D U1206 U0111 Electric power steering permanent codes U0416-68 Electric servo brake - permanent codes U0029-00 U0401-68 Integrated driver support system - permanent codes U0418-92 C0023-F0 U0100-F1 U0122-F1 U0100-00 C0031-62 C0034-62 C003A-62 U0416-68 Tire Pressure monitoring permanent codes U040168 OBDII Codes U1204 U12A5 U1205 U0100 U012D U1206 U0111 OBDII Permanent codes U1206 U12A5 U1205 U0111 U012D U0110 Over 41 codes documented and Honda says there is nothing wrong with the vehicle.
- Electrical system · Engine
I was driving at 65-70 mph on a freeway, and all of a sudden the car speed dropped even my foot IS on the gas pedal, the car slow down to 40mph when decided to pull over to the shoulder, barely enough time to get out of danger. The car engine shot down by its self, I could not move the vehicle to…
I was driving at 65-70 mph on a freeway, and all of a sudden the car speed dropped even my foot IS on the gas pedal, the car slow down to 40mph when decided to pull over to the shoulder, barely enough time to get out of danger. The car engine shot down by its self, I could not move the vehicle to the far right ass I wanted too. The warning light on dash board indicated in red " power system " bottom of it in white light " power system problem do not drive" then a minute later, the warning light changed to a red logo of a battery 12 volt battery charging system problem do not drive.
- Fuel/propulsion system
On July 22, 2022 I was driving my Honda Insight 2020. I was on the highway, current mileage on vehicle 50,796 miles, my speed was normal at 65 MPH when the car lost the ability to accelerate and it stalled. I was forced to make an emergency stop on the side of the interstate. Vehicle displayed on…
On July 22, 2022 I was driving my Honda Insight 2020. I was on the highway, current mileage on vehicle 50,796 miles, my speed was normal at 65 MPH when the car lost the ability to accelerate and it stalled. I was forced to make an emergency stop on the side of the interstate. Vehicle displayed on the dashboard "Critical Failure Detected. Stop Driving When Safe" The acceleration on the car kept decreasing and when stop it displayed "Power System Problem. Do Not Drive." Pulling to the side of the interstate was very scary because trucks were flying at about 80mph. I requested for tow company to pick me up but after hour wait, I gave up waiting on the tow truck. I restarted the vehicle and I was able to take off again. The fuel gas showed half of tank so I continue to drive. Forty miles later down the road, the same issue occurred again. I waited 30 minutes and since I was near a gas station I filled up the gas tank to full capacity. I drove another 100 miles (very skeptical) until I reached my final destination. During my drive I felt like the car had difficulties going into gear above 65MPH. The following day I took the vehicle to the Honda dealer, they said they couldn't pin point exactly what it is. Test show no issues on their diagnostic computer. However, the computer show a record of time and issue happening. They believe it is a fuel pump sensor relay. The vehicle senses I am out of fuel, which is not the case. Honda dealer will replace the sensor/relay and I will pay for it. The dealer states this vehicle is not part of a fuel pump recall. This issue needs to be addressed before it creates a scenario with fatalities, which can easily occur.
- Forward collision avoidance › Warnings
I have had 2 occasions when I experienced inadvertent spontaneous braking. Both times there was no vehicle in front of me. Both times the car stopped completely while driving in the city between 25 to 35mph. Fortunately there was no vehicle behind me either time and I did not sustain any injuries.
- Electrical system · Service brakes
The contact owns a 2020 Honda Insight. The contact stated that while driving at various speeds, the brake engaged erroneously. The contact stated that the failure was intermittent. The contact stated that there was no object or vehicle nearby during the failure. The vehicle was driven to the dealer…
The contact owns a 2020 Honda Insight. The contact stated that while driving at various speeds, the brake engaged erroneously. The contact stated that the failure was intermittent. The contact stated that there was no object or vehicle nearby during the failure. The vehicle was driven to the dealer to be diagnosed; however, the vehicle remained at the dealer unrepaired. The manufacturer was not notified of the failure. The contact stated that he has not contacted the manufacturer. The failure mileage was 33,000.
- Forward collision avoidance › Automatic emergency braking
In 3 instances the emergency braking system has activated when the car was being driven on the freeway and the lane was curving with no obstacles in front of the car in the lane but a semi truck in the next lane over in one instance and cars in the next lane over in the other instances.
- Forward collision avoidance › Automatic emergency braking
Two instances of braking system activating at highway speeds. In one instance, it was broad daylight, there was some traffic but nothing in my lane for a good distance, highway speed (approximately 65 mph) short sharp braking maneuver that dropped the speed approximately 10mph. I assumed there was…
Two instances of braking system activating at highway speeds. In one instance, it was broad daylight, there was some traffic but nothing in my lane for a good distance, highway speed (approximately 65 mph) short sharp braking maneuver that dropped the speed approximately 10mph. I assumed there was some reflected light off of a sign that messed with the sensors, but the second instance was at midnight, same highway, same speed, no one else on the road. In these instances, with light traffic, there was no danger to my safety but if this happens again under heavier traffic, it could conceivably cause someone to rear end the vehicle. I have not been able to reproduce the problem. There might’ve been a flash on the dashboard warning the system was activated, but I couldn’t say for sure. Vehicle is available for inspection.
- Vehicle speed control › Cruise control
The contact stated 2020 Honda Insight. The contact stated while driving approximately 4-5 MPH through a drive-thru, the cruise control set button was tapped and the speed increased to 25 mph without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 2,800. The VIN was not available.
- Electrical system · Engine · Power train
While driving on the interstate where speed limit IS 70 miles per hour, I looked in my rear view mirror and saw smoke coming out of the back of my car. I then saw warnings flashing from my dash board saying: ac malfunction, lkas malfunction,and then another warning flashed saying - low oil fluid, stop car do not drive. I coasted car to the side of the interstate and got out of vehicle and called towing service.
- Forward collision avoidance › Warnings · Steering · Unknown or other
Damage to the power steering linkage cable and oxygen sensor caused all adas systems to be offline including power steering. If this unit were to be damaged just enough and fail while driving this will likely result in a crash/collision as the car becomes completely undrivable. Luckily so far, this…
Damage to the power steering linkage cable and oxygen sensor caused all adas systems to be offline including power steering. If this unit were to be damaged just enough and fail while driving this will likely result in a crash/collision as the car becomes completely undrivable. Luckily so far, this has happened when the vehicle was parked and did not cause any injury. I feel the vehicle IS unsafe until they fix this issue. It has happened 3 times now and nothing seems to be being done about this issue as of yet from honda. This was brought forward to honda's attention with no affirmation that this IS a problem. It first happened in september last year and has happened two additional times since.
- Back over prevention · Electrical system · Visibility/wiper
TL* the contact owns a 2020 honda insight. The contact received notification of nhtsa campaign number: 20v771000 (electrical system, back over prevention, visibility/wiper, visibility, exterior lighting). The contact stated while approaching the vehicle on 3/1/2021, she noticed someone sleeping…
TL* the contact owns a 2020 honda insight. The contact received notification of nhtsa campaign number: 20v771000 (electrical system, back over prevention, visibility/wiper, visibility, exterior lighting). The contact stated while approaching the vehicle on 3/1/2021, she noticed someone sleeping inside the vehicle. The contact stated while calling the police department, the person got away. A police report was filed. The contact stated her anti-theft alert failed. The contact associated the failure with the recall campaign. The vehicle was taken to the local dealer vacaville honda (751 orange dr, vacaville, ca 95687, (707) 449-5900) to diagnosed. The results were still pending. The manufacturer had not been informed of the failure. The failure mileage was 3,126. Consumer was notified transmission needed to be replaced, vehicle is currently not a year old.
- Unknown or other
When putting the car in reverse, the car IS making very loud 'dong dong dong' noise. This issue also occurs when the car IS in idle (stop for the traffic light). I am not sure if the noise IS from the hybrid system, but the noise make one's ears very uncomfortable.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Inadvertent Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB…
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
- Inadvertent Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB…
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10244663Service Bulletin - The ACC system error message comes on while driving when outside temperatures are low/near freezing due to snow and ice getting stuck to the front of the millimeter wave radar. This can cause DTC P2583-76 (Temporary stop of Integrated Driver Support System [Misalignment Millimeter Wave Radar]) to be stored.
- 10244299Service News - If an Adaptive Cruise Control System Problem comes back on when the vehicle is driven in freezing conditions, inform the customer it is likely due to snow or ice buildup on the radar. Advise the customer of the following procedure to clean the front grille where the radar is located.
- 10233670Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10232967Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10232246Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10231829Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10230593Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below.
- 10229680Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below.
- 10228194Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10227233Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10226207Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10225474"Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously"
- 10222812Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Drivers door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.
- 10222437Service Bulletin - (Repair Procedure Revision) Due to swelling of the fuel pump motor impeller, the fuel pump may seize and stop working. If this occurs, the check engine light may be displayed with DTC P0087 (Fuel Rail Pressure Too Low) stored, the engine may not start, or the engine could stall while driving, increasing the risk of a crash. Replace the fuel pump motor.
- 10222421Service Bulletin - (Repair Procedure Revision) Due to swelling of the fuel pump motor impeller, the fuel pump may seize and stop working. If this occurs, the engine may not start, or the engine could stall while driving, increasing the risk of a crash. Replace the fuel pump motor.
- 10219531Service bulletin - On February of 2022, the 3G network will no longer support the in-vehicle services that the vehicle has previously supported. As of August 23, 2022, the Product Improvement Campaign has ended. The TCU can no longer be updated using Over The Air updates. If the customer needs to restore TCU services, the only option is to replace the TCU. This would be done as a customer pay repair.
- 10215483"Notice - Our records indicate that a PRODUCT IMPROVEMENT UPDATE has not been completed on this vehicle (Vehicle Identification Number [VIN NUMBER]). The date for updating vehicles was extended from February 22, 2022 to August 22, 2022. As of August 23, 2022, the 3G network will no longer support the in-vehicle services that the vehicle has previously supported. The Telematics Control Unit (TCU) using the Over the Air (OTA) update is required to connect to the VoLTE network to continue communications. Honda strongly recommends updating your vehicle as soon as possible, or risk having to replace the TCU at your cost."
- 10213582Service bulletin - Booming or rumbling through the speakers. ANC microphone insulating foam is damaged or folded over.
- 10211075Service bulletin - There is a rattling coming from the front of the vehicle. The rubber damper cap(s) are faulty.
- 10208840ServiceNews Article - Are you hearing a booming or rumbling through the speakers? If you get a vehicle in for this, remove the covers in the headliner for the ANC microphones and check if the insulating foam is damaged or folded over as shown below. We've found this may be the reason for the noise.
- 10206988ServiceNews Article - There are several possible causes for the SRS DTC U3000-49 (Internal Failure of the SRS Unit) to be stored. If you can duplicate the DTC, the troubleshooting will take you through the step-by-step process in isolating the faulty component. In most situations, the SRS Unit should be last on the list of components to replace. Here is a quick tip for troubleshooting a faulty seat weight sensor.
- 10206395ServiceNews Article - There are several possible causes for the SRS DTC U3000-49 (Internal Failure of the SRS Unit) to be stored. If you can duplicate the DTC, the troubleshooting will take you through the step-by-step process in isolating the faulty component. In most situations, the SRS Unit should be last on the list of components to replace. Here is a quick tip for troubleshooting a faulty seat weight sensor.
- 10205951Service Bulletin - In February of 2022, the 3G network will no longer support the in-vehicle services that the vehicle has previously supported. The Telematics Control Unit (TCU) using the Over the Air (OTA) update is required to connect to the VoLTE network to continue communications.
- 10204245Owner Notification Letter - On February of 2022, the 3G network will no longer support the in-vehicle services that previously were supported for your vehicle. The Telematics Control Unit (TCU) in your vehicle must be updated using the Over the Air (OTA) update to connect to the VoLTE network to continue communications. Honda strongly recommends updating your vehicle as soon as possible. After February 2022, restoring services, will require a customer pay TCU replacement performed by a service technician at an authorized dealer.
- 10203503Dealer Message - Today, November 9, 2021, American Honda is announcing a product improvement campaign (PIC) for certain 2018-2020 Accord and 2019-2020 Insight vehicles to update the telematics control unit (TCU) software for an upcoming network service change. Do an iN VIN status inquiry to determine which units in your inventory are affected.
- 10203502Service Bulletin - In February of 2022, the 3G network will no longer support the in-vehicle services that the vehicle has previously supported. The Telematics Control Unit (TCU) using the Over the Air (OTA) update is required to connect to the VoLTE network to continue communications.
- 10202598ServiceNews Article - There are several possible causes for the SRS DTC U3000-49 (Internal Failure of the SRS Unit) to be stored. If you can duplicate the DTC, the troubleshooting will take you through the step-by-step process in isolating the faulty component. In most situations, the SRS Unit should be last on the list of components to replace. Here is a quick tip for troubleshooting a faulty seat weight sensor.
- 10200835"ServiceNews Article - When returning the vehicle to the client, inform them that if the message Adaptive Cruise Control System Problem comes back on when the vehicle is driven in freezing conditions, it is likely because of snow or ice buildup on the radar. Advise the client of the following procedure to clean the front grille where the radar is located."
- 10200833Service Bulletin - The ACC system error message comes on while driving when outside temperatures are low/near freezing.
- 10199347Owner Notification Letter - On some 2019-21 Insight models, the A/C condenser may leak refrigerant. American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase with unlimited miles. This warranty extension provides coverage for the original owner and any subsequent owners. No action is required on your part unless you experience a problem.
- 10196761Service Bulletin - There is a rattling coming from the front of the vehicle.
- 10194978Dealer Message - Today, May 28, 2021, American Honda is announcing a warranty extension for certain 2018-2020 Accord and Accord Hybrid, 2018-2020 Civic, 2017-2021 Civic Hatch, 2017-2021 Civic Type R, 2018-2021 Clarity PHEV, and 2019-2021 Insight vehicles. This warranty extension covers the A/C condenser to address concerns of leaking refrigerant. American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase.
- 10194954Service Bulletin - American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase with unlimited miles. This warranty extension only covers vehicles that have a defective A/C condenser from the factory. The A/C condenser was not manufactured to specification. As a result, corrosion may develop in the form of tiny holes in the condenser tube walls that allow the refrigerant to leak out. This does not apply to any vehicle that has a leaking condenser due to foreign object damage. It also does not apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state's law.
- 10186012ServiceNews Article - We have received information from the vendor (Alpine) that display panels are being replaced for cracks on the center display screen. When they review these parts, they're finding that an aftermarket screen protector had been installed and that the screen protector is cracked. So, if you have a center display that appears to have a cracked screen, confirm that it does not have an aftermarket screen protector installed. If installed, remove it, and then check if the center display screen itself is cracked.
- 10186009"Service Bulletin - There are several A/C leak detection tools available. -Refrigerant Gas Leak Detector -Ultrasonic Leak Detector -Leak Dye"
- 10182466Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2020 Accords & 2019-2020 Insights with a customer complaint of the Malfunction Indicator Light (MIL) on with the Body Control Module (BCM) related DTCs in active fault. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- 10181404Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2020 Accords & 2019-2020 Insights with a customer complaint of the Malfunction Indicator Light (MIL) on with the Body Control Module (BCM) related DTCs in active fault. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- 10180633Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2020 Accords & 2019-2020 Insights with a customer complaint of the Malfunction Indicator Light (MIL) on with the Body Control Module (BCM) related DTCs in active fault. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- 10179867Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2020 Accords & 2019-2020 Insights with a customer complaint of the Malfunction Indicator Light (MIL) on with the Body Control Module (BCM) related DTCs in active fault. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- 10179396Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for certain 2018-2020 Accords & 2019-2020 Insights with a customer complaint of the Malfunction Indicator Light (MIL) on with the Body Control Module (BCM) related DTCs in active fault. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
Every Honda Insight model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.