2017 Hyundai Ioniq Hybrid
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Ioniq Hybrid › 2017
These records cover every 2017 Hyundai Ioniq Hybrid. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 2017 Hyundai Ioniq Hybrid. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Ioniq HEV and Ionic PHV vehicles previously recalled under recall number 18V-704. The Power Relay Assembly (PRA) located underneath the rear seat may overheat.
Risk and remedy
Risk
An overheated PRA increases the risk of a fire.
Remedy
Dealers will inspect and replace the main relay or PRA, as necessary, free of charge. Owner notification letters were mailed August 23, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 232. This recall replaces NHTSA recall number 18V-704. Vehicles already repaired under the previous recall will need to have the new remedy completed.
Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Hyundai Ioniq Hybrid and 2018 Ioniq Plug-In Hybrid vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance.
Risk and remedy
Risk
The increased electrical resistance can overheat the rear seat which is above the PRA, increasing the risk of a fire.
Remedy
Hyundai will notify owners, and dealers will inspect the Power Relay Assembly (PRA) for damage. If no damage is found, the main relay will be replaced. If damage is found, the PRA will be replaced. These repairs will be performed free of charge. The recall began February 28, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 178.
Hyundai Motor America (Hyundai) is recalling certain 2017 Hyundai Ioniq Hybrid vehicles. The Hydraulic Clutch Actuator (HCA) inner oil seal may leak, allowing oil to accumulate in the cap area, possibly resulting in an electrical short.
Risk and remedy
Risk
An electrical short can increase the risk of a fire.
Remedy
Hyundai will notify owners, and dealers will inspect the HCA caps for leaked oil and replace the HCA assembly if needed, free of charge. The recall is expected to begin June 20, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 176.
Owner complaints
42 complaints4 involved a crash3 involved a fire1 injuries
What owners report most
Latest complaints
- Electrical system · Engine · Power train
After the Dealership, Michigan City Hyundai (MCH), performed part of the needed repairs, I became aware of what could/would have been a fire hazard (as evidenced by brownish/black heat spots, on the metal cover of the hybrid battery, under the rear seat. To maintain its recall-denial, MCH blames…
After the Dealership, Michigan City Hyundai (MCH), performed part of the needed repairs, I became aware of what could/would have been a fire hazard (as evidenced by brownish/black heat spots, on the metal cover of the hybrid battery, under the rear seat. To maintain its recall-denial, MCH blames the hybrid starter generator (HSG) for the damage to the hybrid battery. The noted heat-spots prove otherwise - the power relay assembly (the subject of one of the recalls related to my car), and its malfunction and consequent generation of excessive heat, is what caused severe damage to the hybrid battery. The other failed component (hybrid system generator - HSG) is directly related to the hybrid clutch actuator (HCA), which is the subject of the 2nd recall affecting my car. The malfunction of the HCA is what damaged the HSG. The NHTSA database shows no open recall affecting my car VIN, is because dealer IL093 (who sold me the car around April 2025), logged both recall remedies as applied in Hyundai's internal database. The selling dealer (IL093), which claims to have completed the Power Relay Assembly and Hydraulic Clutch Actuator recalls on my vehicle, was under the ownership of Leader Automotive Group during the timeline of the alleged repairs and my April 2025 purchase. Leader Automotive Group was sued and penalized $20 million by the FTC and the State of Illinois for systematic consumer fraud, deceptive practices, and concealing voided manufacturer warranties. Because the physical components have now suffered the exact catastrophic failures these recalls were designed to prevent, there is a high probability that dealer IL093 fraudulently logged these recall remedies as completed without physically performing the work. I request that the NHTSA Office of Defects Investigation immediately audit IL093's repair logs for this VIN in light of the FTC enforcement action.
- Electrical system · Power train
I was driving my two young daughters (ages [XXX] and [XXX]) to school, in clear conditions, when we suddenly heard a static-like noise. Instantly, the car's check engine light and check EV battery light came on, and I realized I could no longer accelerate. I immediately pulled off to a safe…
I was driving my two young daughters (ages [XXX] and [XXX]) to school, in clear conditions, when we suddenly heard a static-like noise. Instantly, the car's check engine light and check EV battery light came on, and I realized I could no longer accelerate. I immediately pulled off to a safe shoulder and turned the car off and then back on. The car would not move. I exited the vehicle and THANKFULLY left my car door open. I walked around the vehicle and immediately called my husband for help. Within seconds, my [XXX] daughter, who was sitting directly behind me in the rear driver's seat, told me she saw smoke. I went to open her door and realized it was locked. My key fob and door lock would not unlock her door. I reached through my seat to open her door and instantly saw the smoke coming from a vent just to the left of her legs. I unbuckled her and pulled her out, and climbed through the vehicle to get my [XXX] unbuckled and safely out of the vehicle. I cannot stress enough how grateful I am that my car door was left open because I don't believe I would have been able to break the glass to get my daughters out. The could have easily died. Within a minute of the smoke starting from my daughter's vent, the flames began from the same vent. I got both daughters away from the vehicle asap. While trying to grab what I could from the vehicle, my fires on my right hand were caught in the fire. The vehicle became fully engulfed in fire and was a total loss. Two volunteer fire departments responded. I have both the fire incident report as well as the police incident report. The police report only mentioned one daughter but witnesses can attest that I had to get BOTH daughters out. Following the incident, I went to the doctor to receive care for my burns and received a chest x-ray due to smoke inhalation. My [XXX] daughter has been traumatized and keeps thinking something is wrong with her. She told me her bottom felt very warm just before I pulled her out. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
- Electrical system · Engine · Unknown or other
The vehicle has suffered a catastrophic failure of the hybrid drive motor rotor, transmission, and engine clutch, resulting in a $14,993 repair quote. This is a direct consequence of a failed remedy for NHTSA Recall 18V260 (Hyundai Campaign 176).In February 2020, a dealer performed an…
The vehicle has suffered a catastrophic failure of the hybrid drive motor rotor, transmission, and engine clutch, resulting in a $14,993 repair quote. This is a direct consequence of a failed remedy for NHTSA Recall 18V260 (Hyundai Campaign 176).In February 2020, a dealer performed an 'inspection/cap' remedy under Campaign 176. However, this did not permanently fix the manufacturing burrs on the hydraulic clutch actuator housing. Over time, the inner oil seals degraded exactly as warned in the original defect report. Hydraulic fluid leaked into the electric stepper motor, causing an electrical short circuit that destroyed the entire hybrid powertrain. The vehicle lost propulsion and threw a severe Hybrid Warning Light on the dashboard. This represents a complete failure of a mandated safety recall remedy, introducing an active electrical short circuit and a severe vehicle fire hazard.
- Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated that the vehicle failed to start with several unknown warning lights illuminated. Additionally, the message "Starting Engine to Avoid Battery Discharge" was displayed. The vehicle was later towed to the local dealer who diagnosed…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated that the vehicle failed to start with several unknown warning lights illuminated. Additionally, the message "Starting Engine to Avoid Battery Discharge" was displayed. The vehicle was later towed to the local dealer who diagnosed that the 12-volt lithium battery had melted and expanded and needed to be replaced, along with the power relay assembly and fuse. The vehicle was not repaired. The manufacturer was contacted. The contacted stated that the vehicle was previously serviced and inspected under NHTSA Campaign Numbers: 22V459000 (HYBRID PROPULSION SYSTEM) and 18V704000 (HYBRID PROPULSION SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recalls. The failure mileage was 135,262.
- Power train
January 2022. The car was brought to dealership because the transmission was slipping in 3rd gear. Service light was on. On my way the problem fixed itself. I explained that it happened only in the extreme cold here in michigan. They documented for warranty. Said it may be due to clutch…
January 2022. The car was brought to dealership because the transmission was slipping in 3rd gear. Service light was on. On my way the problem fixed itself. I explained that it happened only in the extreme cold here in michigan. They documented for warranty. Said it may be due to clutch overheating on slippery roads. IT WAS NOT. The cars was not used for 2 winters as we were in Florida. Dec. 2025 it happened again and expressed my concerns that if this happened in traffic it could be dangerous. Both the dealership and Hyundai washed there hands of it even though I was assured that it would be covered and addressed it it happened again. The service light came on but the problem fixed itself . I do not believe this is a mechanical issue, it sure would have failed by now. Software/electronic.
- Engine · Power train
Engine failure occurred on interstate. Car was jerking and smoke coming from the hood and exhaust while engine was giving out. Hyundai dealership confirmed something blew up within the engine and blew a hole out the side of it. Check engine light came on about 2 weeks prior notified Hyundai dealership as soon as this happened and they stated I had to wait 2 weeks to have the vehicle checked out.
- Electrical system · Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while at a complete stop at a red traffic light, the vehicle stalled. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the power relay assembly (PRA) located underneath the rear seat…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while at a complete stop at a red traffic light, the vehicle stalled. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the power relay assembly (PRA) located underneath the rear seat had failed and needed to be replaced; however, the part was not available. The vehicle was not repaired, but the mechanic overrode the computer system. The mechanic related the failure to NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). The contact stated that the VIN was previously included in the recall; however, the recall was marked as complete after the vehicle passed the inspection test. The contact stated while driving 20-25 MPH, the failure recurred. The vehicle was towed to the dealer, where the contact was informed that the vehicle could not be repaired under the recall. The vehicle was then towed to a second dealer, Keyes Hyundai of Mission Hills(10240 Sepulveda Blvd, Mission Hills, CA 91345), where it was diagnosed that the power relay assembly (PRA) located underneath the rear seat and the 12-Volt battery had failed and needed to be replaced; however, the part was on backorder. The manufacturer was notified of the failure and advised the contact that a goodwill discount could be provided at the dealer's discretion. A case was filed. The contact stated that after the manufacturer contacted the dealer, the dealer doubled the cost of the repair and provided a goodwill discount. The vehicle was not repaired due to the cost. The failure mileage was approximately 153,000.
- Electrical system · Fuel/propulsion system
I own a 2017 Hyundai Ioniq Hybrid VIN: [XXX] that is covered under Recall 232 (NHTSA 22V-459) related to a defective Power Relay Assembly that poses a fire risk. I brought this issue to Hyundai 3 years ago and was told my vehicle was serviced. That turned out to be false. Recently, my car…
I own a 2017 Hyundai Ioniq Hybrid VIN: [XXX] that is covered under Recall 232 (NHTSA 22V-459) related to a defective Power Relay Assembly that poses a fire risk. I brought this issue to Hyundai 3 years ago and was told my vehicle was serviced. That turned out to be false. Recently, my car stalled on the road due to the exact electrical issue covered in Recall 232. I had it diagnosed by an independent mechanic, who confirmed it’s tied to the recall. I had the vehicle towed to a Hyundai dealership to have it repaired, but they: •Refused to prioritize the recall inspection •Attempted to charge me $230 for diagnostics •Told me it would take a week or more just to inspect the vehicle •Denied the urgency of the recall, despite the known fire hazard I informed the dealership service manager Tom Swire I was recording, and he still refused to put his denial in writing. I have the recording. Due to their refusal, I was forced to tow the vehicle to a second dealership at my own expense. Hyundai Corporate has opened a case file, but told me I must wait 2–3 days just to speak with a case manager despite this being a federally mandated safety recall tied to real-world safety fire risk. I am requesting NHTSA review this case and hold Hyundai and its dealership accountable for failing to honor Recall 232 within a reasonable and safe timeframe. I am also seeking reimbursement for towing and other out-of-pocket costs caused by their mishandling of this urgent safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Service brakes · Steering
The 12V ion battery system part number 37507-g2120 (iccu) battery failed while driving, causing gas engine to turn off, which cancels power braking and steering, making vehicle impossible to control. Read many reports on reddit and ioniq forums of this happening. No. It IS unoperable there was no…
The 12V ion battery system part number 37507-g2120 (iccu) battery failed while driving, causing gas engine to turn off, which cancels power braking and steering, making vehicle impossible to control. Read many reports on reddit and ioniq forums of this happening. No. It IS unoperable there was no warning what so ever. No light, no symbol, nothing. was traveling 40 mph on a busy road with family, during a lane change this happend and the vehicle turned off completely. I could not control vehicle, and went into a ditch. In the process we were nearly side swiped by a large pick up truck whom also went in ditch. The 12V battery was dead completely, would not start the gas engine. Just was dead. Im lucky to be here telling our experience.
- Electrical system · Engine · Steering
I have had issues with the car losing speed and start to flutter. The last time it did this it locked up my steering wheel and engine cut off this has been an ongoing issue with this car only had it less than a year and the dealership cannot remedy the issue there is some kind of electrical issue…
I have had issues with the car losing speed and start to flutter. The last time it did this it locked up my steering wheel and engine cut off this has been an ongoing issue with this car only had it less than a year and the dealership cannot remedy the issue there is some kind of electrical issue because all lights come on car has less than 50k moles on it this is my 5 visit to the dealership with no resolution have contacted the manufacturer
- Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while driving at undisclosed speeds, several unknown warning lights illuminated, and the vehicle started to lose motive power. The contact pulled over and shut off the vehicle but was unable to restart the vehicle. Upon investigation…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while driving at undisclosed speeds, several unknown warning lights illuminated, and the vehicle started to lose motive power. The contact pulled over and shut off the vehicle but was unable to restart the vehicle. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). The vehicle was then towed to the dealer to be repaired; however, the contact was informed that the battery management system was defective and needed to be replaced. The contact was informed that the vehicle was out of warranty and was provided an estimate for the repair. The manufacturer was notified of the failure and referred the contact to the Better Business Bureau for assistance. The vehicle remained with the dealer unrepaired. The failure mileage was 12,903.
- Engine · Power train
Unable for many time to get recall complete old recall was told not complete and now that i have an issue they are telling me it was done trans clutch . My car has been at the dealer for three months . It is at lafontaine hyuandi dearborn mi. The part i need to fix my engine /clutch has an…
Unable for many time to get recall complete old recall was told not complete and now that i have an issue they are telling me it was done trans clutch . My car has been at the dealer for three months . It is at lafontaine hyuandi dearborn mi. The part i need to fix my engine /clutch has an indefinite date when it will be available. I had this same problem when my car was less than a year old with the drive shaft. I have been in contact with corporate Hyundai and the dealer we cannot get a hold of sometimes for a whole week. These engine problems have been a huge issue with Hyundai. The engine will suddenly slow down to 20s being a hazard risk. Dealers when i have tried to get recall wont do recall they say they only have one person who can do it. I have had recalls scheduled months out and then they cancel. The problem i am having directly relates to a closed recall per multiple mechanics. The recall caused oil to leak which is what dealer said happened . Please help!!
- Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while driving 20 MPH, the check engine warning light illuminated. The vehicle lurched forward and then stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to an independent…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated while driving 20 MPH, the check engine warning light illuminated. The vehicle lurched forward and then stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the main power relay assembly had overheated, and the main power relay fuse was blown. The mechanic determined that the main power relay assembly and the fuse needed to be replaced. The mechanic determined that the failure was related to NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). The vehicle was then towed to the dealer for the recall repair; however, the dealer informed the contact that the recall repair was not necessary, and that the picture of the main power relay part would be sent to the manufacturer. The manufacturer was notified of the failure and a case was opened. The manufacturer contacted the dealer regarding the recall repair. The dealer then informed the contact that the recall repair was performed per the manufacturer's instructions. The contact was later informed by the dealer that the recall repair had not been performed and only the picture of the main power relay part had been sent to the manufacturer. The manufacturer was contacted and informed the contact that they had not received a proof of the service that the dealer had performed on the vehicle. The vehicle was towed back to the independent mechanic, where it was confirmed that the recall repair had not been performed on the vehicle. The mechanic informed the contact that the failure was related to NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000. Parts distribution disconnect.
- Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated that while driving at various speeds, the vehicle stalled. The contact stated that the failure had been progressing, and the vehicle had become undrivable. The vehicle was taken to a local dealer, where it was diagnosed with a…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact stated that while driving at various speeds, the vehicle stalled. The contact stated that the failure had been progressing, and the vehicle had become undrivable. The vehicle was taken to a local dealer, where it was diagnosed with a defective battery. The contact related the failure to NHTSA Campaign Number: 18V704000 (Hybrid Propulsion System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 120,000. The VIN was not available.
- Service brakes
Integrated Brake Accuation Unit failed per dealer repair location. Codes indicated on attached repair invoice receipt. (Document is Uploaded). This was a very expensive repair. Per dealer service advisor and technician they had never seen this before. 2 brake lights on the dash indicated major…
Integrated Brake Accuation Unit failed per dealer repair location. Codes indicated on attached repair invoice receipt. (Document is Uploaded). This was a very expensive repair. Per dealer service advisor and technician they had never seen this before. 2 brake lights on the dash indicated major brake failure. The vehicle was immediately taken to the dealer for repair. See additional details regarding concern, cause. correction, and parts replaced on invoice. If this had not been repaired immediately, this could have put others at risk and caused an accident. Although there are several internet references to brake problems with this model of Hundai Ioniq Hybrid, there are no recalls. The powertrain and engine are warrantied for 100K miles and the batteries have an original lifetime owner warranty. Due to the critical nature of a braking system, I believe braking systems on hybrids for this part should have a lifetime warranty. I want to make it clear that parts that wear out due to use for example brake pads, rotors, master cylinder etc. are not what I am referencing. Since the integrated brake accuation unit is a part commonly seen on hybrid products, I think this a part that warrants investigation and recall. This investigation may go beyond the Hyndai hybrid products. Due to the expense of the repair, I believe this repair could put the owners of all hybrid auto products at risk.
- Unknown or other
I brought my Hyundai on November 18, 2022 to Huntington Hyundai at 1221 E. Jericho Tpke., for service to take care of a recall. My paperwork from Huntington Hyundai shows that recall 232 was performed. But in 2023 I began plans to move to Canada and to import my Hyundai into Canada. The Canadian…
I brought my Hyundai on November 18, 2022 to Huntington Hyundai at 1221 E. Jericho Tpke., for service to take care of a recall. My paperwork from Huntington Hyundai shows that recall 232 was performed. But in 2023 I began plans to move to Canada and to import my Hyundai into Canada. The Canadian registrar of imported vehicles told me that according to recall records, there is an outstanding recall on the vehicle. Recall 232! I learned from visiting a dealer in Buffalo New York that not Huntington Hyundai never applied to Hyundai USA for reimbursement for work performed on recall 232. Huntington Hyundai failed to even perform the recall that they stated they performed.
- Unknown or other
I have received a couple of notices from Hyundai concerning a recall for my Hyundai. Here’s been my experience—called Motor World Hyundai (150 MotorWorld Dr Wilkes-Barre, PA 18702). I was told that they didn’t have any parts in but would call me when the parts are in. They insisted on getting my…
I have received a couple of notices from Hyundai concerning a recall for my Hyundai. Here’s been my experience—called Motor World Hyundai (150 MotorWorld Dr Wilkes-Barre, PA 18702). I was told that they didn’t have any parts in but would call me when the parts are in. They insisted on getting my contact information and since have barraged me with sales calls, but no information on “the parts”. After a few weeks, my wife called again, they claimed they have no idea when parts will come in, this person did not ask her name, did not offer to check status, did not offer to call back. (by the way, we tried to buy a new Ioniq last year and while they kept asking us to “come in to test drive” (not sure what we were test driving because they said they didn’t have the car) So, no Ioniq purchase. Our next call was to Dickson City Hyundai, (1519 Scranton Carbondale Highway, Scranton, PA 18508). They indicated a lack of parts as well. We requested they order the parts. They indicated that they require that we go there first (about an hour away) to have the car inspected. If they determine that they should order the parts, then they’ll order them and we’ll have to come back to get them installed. So according to the recall letter, the situation is dangerous, we need a recall done, you’ve notified us more than once, but we apparently can’t get it done without a significant effort on our part. A Safety Recall has been issued on your 2017 Ioniq Hybrid/Plug-In Hybrid’s Power Relay Assembly (PRA). Recall 232 Remedy is Available This notice applies to your vehicle, VIN: KMHC05LC7HU030998 I tried to click on “make an appointment” and it goes to “Page can’t be found” So, I was so happy with my Hyundai I was going to buy another, no test drive, no shopping for other brands but no can do. Now I’m told that I need a recall, but no one is interested in doing it.
- Electrical system · Engine · Fuel/propulsion system
I was driving on the freeway when my car started smoking. Pulled over immediately and 30 seconds later the entire front of the car was engulfed in flames. I hadn’t received a second recall notice, but I did take it in the first time when a fire risk was mentioned.
- Hybrid propulsion system
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact received recall notification of NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had…
The contact owns a 2017 Hyundai Ioniq Hybrid. The contact received recall notification of NHTSA Campaign Number: 22V459000 (Hybrid Propulsion System). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Unknown or other
Hyundai has no date for remedy. Theres a remedy for same car but different vins. They told me our car was produced in a different manufacturer place so no remedy and they said it is what it is. It has almost been 30 days and I cant use the car for my business when this safety recall is out that was fixed in 2018.
- Electrical system
Electrical resistance main relay
- Electrical system · Electronic stability control (esc) · Fuel/propulsion system
Hello my vehicle vin number IS : [xxx] I import my car from USA to jordan and there are two items for recall . there's a fire smell in the vechicle and my car IS broken at the current for the second reason of the recall . The agent refused to replace the parts because it's imported. Note…
Hello my vehicle vin number IS : [xxx] I import my car from USA to jordan and there are two items for recall . there's a fire smell in the vechicle and my car IS broken at the current for the second reason of the recall . The agent refused to replace the parts because it's imported. Note that this recall IS for manufacturers ?failure and for all vehicles around the world. Please help and give an opinion. with many thanks information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *tr
- Vehicle speed control
TL* the contact owns a 2017 hyundai ioniq hybrid. While driving 4 mph and 65 mph, the vehicle violently accelerated on its own. As a result, the contact's vehicle crashed into another vehicle. The air bags did not deploy. A police report was filed. There were no injuries. The vehicle was taken to…
TL* the contact owns a 2017 hyundai ioniq hybrid. While driving 4 mph and 65 mph, the vehicle violently accelerated on its own. As a result, the contact's vehicle crashed into another vehicle. The air bags did not deploy. A police report was filed. There were no injuries. The vehicle was taken to kearny mesa hyundai (4797 convoy st, san diego, ca 92111, (858) 278-7100) where it was determined that the body damage needed to be repaired before it could be diagnosed. The body work was repaired and the contact was informed that there were no failures. The manufacturer was made aware of the failure. The failure mileage was approximately 8,000.*dt the consumer stated the crash IS the result of the third incident. *Tr
- Engine
Takara recall - my car was shut off and parked in my driveway. About an hour later, (my car was still off), as I went outside to talk to my family outside which we happened to be only about 15 feet of where my car was parked and still the engine was off! the next thing to my surprise and dismay…
Takara recall - my car was shut off and parked in my driveway. About an hour later, (my car was still off), as I went outside to talk to my family outside which we happened to be only about 15 feet of where my car was parked and still the engine was off! the next thing to my surprise and dismay, my car engine started up all by its self!!!??? I have 2 family witness verifying my engine was in fact running and there IS absolutely no way I had anything to do with it! I am very concerned about this happening again especially if it did it once and I don't know what would have happened if I was not around my for 2 - unknown long hours! It IS very unsettling to know my engine stars on it's own and will it go into reverse or forward and kill someone!!?? please get back to me asap. [Xxx] [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *Tt
- Exterior lighting · Unknown or other
I have been having this problem for a while. I would be driving my car during the after and the dash (speedometer) would dim at first, but just yesterday the whole thing turned off except the green indicator as seen in the picture
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10240087This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundais Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous version. As a countermeasure, an update with a frame skip logic has been added to resolve the data congestion with Google Maps.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10215599Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10213725If you are servicing an applicable model with Hybrid Drive Motor (Traction Motor) improper operation or any DTC listed in the related shop manual, Motor Control System, refer to the shop manual for diagnosis. If the diagnosis indicates a faulty hybrid drive motor, refer to the Service Procedure and replace the hybrid drive motor.
- 10211680Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10211678Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
- 10206367When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) may not be available. This TSB# 21-01-080H describes the 3-part software to correct this condition and activate Blue Link Services.
- 10206363When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) information is not available. This bulletin describes the 3-part Software to correct this condition and activate Blue Link Services.
- 10203272Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190038This bulletin provides best practice recommendations when performing brake service procedures.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10185450This bulletin provides information related to the Engine Control Module (ECM) software logic update for DTC P0128 Coolant thermostat - Coolant temp Below thermostat regulating Temperature. There is no drivability issue with this DTC.
- 10183963This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10180985Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
- 10180981This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
- 10179246Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft assembly.
- 10179244This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
- 10178175This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes, or during normal driving operation.
- 10176182This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.
- 10176178This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.
- 10174808This bulletin provides information on identifying dealer stock vehicles with either: A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. A 30 Day alert - vehicle has not started and reported an SOC in 30 days.
- 10174807The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:
- 10174804Certain Ioniq hybrid 2017-2019 vehicles may experience check engine light ON with the following DTC stored: DTC P0456 - Evaporative System (EVAP) - Very Small Leak This bulletin provides instructions to install an Air Filter Kit and a Natural Vacuum Leak Detection sensor (NVLD).
- 10173552This bulletin provides additional service diagnostic information and repair procedures related to electric A/C compressors equipped in hybrid electric vehicles, plug-in hybrid electric vehicles, and electric vehicles.
- 10173546This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.
- 10173545This bulletin describes the mandatory procedure to submit battery test data electronically for battery warranty claims by running the GDS Battery Claim App. The App must be run right after an incident battery is removed from the vehicle or after a battery charge is completed which qualifies for a warranty. It must be run at any time between RO open and close dates.
- 10172147This bulletin describes the procedure to properly bleed the brakes on Sonata HEV/PHEV (LF) and Ioniq EV/HEV/PHEV (AE) vehicles. This procedure applies when any air is introduced into the Active Hydraulic Boost (AHB) system, which consists of the pressure supply unit (PSU), and the integrated brake actuation unit (IBAU). Improper bleeding of the brake system can result in the presence of air, which may reduce braking effectiveness.
- 10172142This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.
- 10170896This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
- 10170883This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bulletin provides physical differences between the USB 2.0 port and USB 3.0 port.
- 10169370The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects vehicles within the blind spot zone and gives off an alarm (visual and audible). The two magnetic radar sensors provide these functions for BSD/BCW: ? Senses other vehicles in the BSD/BCW zone and turns on the BSD/BCW warning lamp for the driver. The warning lamp starts blinking, along with an audible sound, when the driver turns on the turn signal lamp to enter the lane where another vehicle is driving.
- 10167770Hyundai is conducting a Service Campaign to install a new Air Filter Kit with an updated filter to help prevent DTC P0456 on certain 2017-2019 Ioniq (AE) HEV vehicles.
- 10167766Certain 2017-2019 vehicles may experience check engine light ?ON? with the following DTC stored: ? DTC P0456 - Evaporative System (EVAP) - Very Small LeakThese conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) which may cause intermittent operation prompting the DTC P0456 and the check engine light ?ON?. This bulletin provides the procedure to install a new Air Filter Kit with an updated filter to help prevent entry of the salt particulates. In addition, vehicles with check engine light ?ON? and DTC P0456 found stored in the Engine Control Module (ECM) must also replace the NVLD part.
Every Hyundai Ioniq Hybrid model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.