2012 Hyundai Sonata Hybrid
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Sonata Hybrid › 2012
These records cover every 2012 Hyundai Sonata Hybrid. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2012 Hyundai Sonata Hybrid. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally…
Risk and remedy
Risk
An engine compartment fire while parked or driving can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Risk and remedy
Risk
A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Remedy
Hyundai will notify owners, and dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. The recall began March 31, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 198.
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air…
Risk and remedy
Risk
An overheated accessory outlet increases the risk of fire.
Remedy
Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and…
Risk and remedy
Risk
If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy
Hyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Risk and remedy
Risk
If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Remedy
Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.
Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.
Risk and remedy
Risk
In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Remedy
Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.
Owner complaints
155 complaints2 involved a crash5 involved a fire2 injuries
What owners report most
Latest complaints
- Engine · Power train
1. It spun a main rod bearing. It is at the Hyundai Dealership in Evansville, In. 2. Loss or power in roadway. 3.Yes it has, by the dealership. 4.Yes, by the manufacturer & the Hyundai Dealership. 5. Yes, as I backed out onto the street all the dashboard lights came on and buzzers and alarms…
1. It spun a main rod bearing. It is at the Hyundai Dealership in Evansville, In. 2. Loss or power in roadway. 3.Yes it has, by the dealership. 4.Yes, by the manufacturer & the Hyundai Dealership. 5. Yes, as I backed out onto the street all the dashboard lights came on and buzzers and alarms started going off. When I finally got the car in gear then I was able to drive it about 25 feet back into the driveway and I turned it off. I had to have it towed to the dealership and they would not stand behind the warranty for the engine & transmission.
- Power train
While driving and everything is going along fine it will suddenly jerk and make a sound as if I've been hit behind. I'm not sure if it's part of the detached shift cables or transmission or something else. Sometimes it will jerk violently while going uphill also.
- Electrical system · Service brakes · Unknown or other
2012 Hyundai Sonata Hybrid well maintained by original owner, under 130,000 miles. May of 2025 AC stopped working intermittently (Hyundai dealer replaced AC hose). Aug 2025 AC stopped working AGAIN (same dealer could NOT identify problem). Car has consistent Hybrid System Warning! Safely Stop and…
2012 Hyundai Sonata Hybrid well maintained by original owner, under 130,000 miles. May of 2025 AC stopped working intermittently (Hyundai dealer replaced AC hose). Aug 2025 AC stopped working AGAIN (same dealer could NOT identify problem). Car has consistent Hybrid System Warning! Safely Stop and Do not Drive messages lights and sirens when braking. Code PA186 comes up (low state of charge code for hybrid battery). December 2025 brought car back to SAME Hyundai dealer who NOW says car suddenly needs a 10k transmission (BUT still no idea what PA186 code is related to). Got transmission drained at different shop and NO NEW TRANSMISSION NEEDED! Every repair shop OUTSIDE OF HYUNDAI who has scanned for codes gets the PA186 error and say it is related to HYBRID BATTERY LOW STATE OF CHARGE (I am the original owner THUS lifetime hybrid battery warranty). June 2026 different Hyundai dealer for repair of AC and PA186 code. NEW Hyundai dealer says AC issue is NOT related to the PA186 code. They still dont know what PA186 code is but want to charge me $5100 for engine wiring harness electrical short. SIDE NOTE!! Engine wiring harness electrical short is known issue for ABS module recall 251 for this car. Hyundai has denied the engine wiring harness electrical short repair as part of ABS recall 251 warranty and STILL cant tell me why Hybrid System Warning Lights and PA186 code is come on. Is electrical issue really harness or HYBRID battery?? Car is currently at Hyundai dealer.
- Engine
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving at 75 MPH on the highway, while depressing the accelerator pedal, the vehicle failed to accelerate. No warning lights illuminated. The contact veered over to the right side of the road, turned the vehicle off, and she…
The contact owned a 2012 Hyundai Sonata. The contact stated that while driving at 75 MPH on the highway, while depressing the accelerator pedal, the vehicle failed to accelerate. No warning lights illuminated. The contact veered over to the right side of the road, turned the vehicle off, and she noticed smoke coming from the engine. A bystander behind her noticed the flames coming up from the engine. The contact mentioned she exited the vehicle and called 911. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to Atow lot. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 160,000.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the ABS warning light was illuminated. The contact stated that the vehicle had to be…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the ABS warning light was illuminated. The contact stated that the vehicle had to be turned off and restarted every ten minutes. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the vehicle was recently serviced by the dealer and NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) was completed. The contact stated that the failure was present prior to the recall repair being performed. In addition, the contact stated that the failure reoccurred a week after the recall repair was completed. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.
- Latches/locks/linkages
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while attempting to close the passenger’s side rear door, the door failed to lock as needed. The contact tied the door closed. The contact stated that the driver's side rear door was locked, and the contact was unable to open the…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while attempting to close the passenger’s side rear door, the door failed to lock as needed. The contact tied the door closed. The contact stated that the driver's side rear door was locked, and the contact was unable to open the door. The contact had taken the vehicle to a dealer when the passenger’s side door was not locking. The dealer diagnosed the vehicle and determined that the latch and locking mechanism needed to be replaced. The vehicle was not repaired. The contact stated that when the driver's side rear door failed to lock securely, the vehicle was not returned to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 41,000.
- Engine · Hybrid propulsion system · Power train
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and the low battery warning light illuminated. In addition, the contact heard a rattling sound coming from the engine before the engine seized. The vehicle was…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and the low battery warning light illuminated. In addition, the contact heard a rattling sound coming from the engine before the engine seized. The vehicle was towed to the dealer where it was diagnosed with a failed hybrid system and that the hybrid system needed to be replaced. The contact was also informed that the transmission was not the original transmission, and the cooler was damaged. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The contact pulled over on the side of the road and the vehicle was towed to the dealer to be diagnosed. The contact was informed that the ABS and…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The contact pulled over on the side of the road and the vehicle was towed to the dealer to be diagnosed. The contact was informed that the ABS and hydraulic pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) that was previously performed. The manufacturer was made aware of the failure and informed the contact the failure was not related to the recall repair. The failure mileage was approximately 151,020.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Power train › Automatic transmission
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, the vehicle lunged forward. The vehicle was taken to an independent mechanic and diagnosed with automatic transmission failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 76,000.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the brakes became inoperable. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at an undisclosed speed, the brakes became inoperable. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The approximate failure mileage was 155,290. Parts distribution disconnect.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) and would like to be removed from the recall distribution list because she no longer owns the vehicle. The local dealer was contacted. The manufacturer was not contacted.
- Steering
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, he became aware that the electronic power steering was not functioning properly, noticing an excessive amount of understeer. No warning lights were illuminated. The vehicle was taken to the…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, he became aware that the electronic power steering was not functioning properly, noticing an excessive amount of understeer. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the steering column. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 80,000.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Red McCombs…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called another local dealer, Red McCombs Hyundai Northwest, (13663 I-10, San Antonio, TX 78249) who informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that when the vehicle was started, the check brake and hybrid system message was displayed. Additionally, the contact stated that…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The contact stated that when the vehicle was started, the check brake and hybrid system message was displayed. Additionally, the contact stated that while driving at various speeds on several occasions, the ABS activated inadvertently. The vehicle was taken to a dealer where it was determined that unknown parts needed to be replaced; however, the parts were unavailable. The manufacturer was not notified of the failure. The failure mileage was approximately 126,000.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Service brakes, hydraulic
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the Check Brakes and…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the Check Brakes and Hybrid System Warning: Safely Stop and Do Not Drive messages were displayed. The brakes then made a grinding sound while the brake pedal was depressed. Additionally, the vehicle lost motive power while driving. The contact pulled over and restarted the vehicle. The vehicle was taken to the dealer, where it was diagnosed with a faulty HCU (Hybrid Control Unit) and AHB (Active Hydraulic Boost). The dealer retrieved DTC Codes: P1886 (Inappropriate and Low SOC) and C1237: (Primary Pressure Sensor Signal). The dealer replaced the oil valve gasket and recalibrated the brakes. The manufacturer was made aware of the failure. The failure mileage was approximately 113,340. VIN tool confirms parts not available.
- Engine · Power train
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the message "Pull Over. Stop the Vehicle" was displayed, and the vehicle failed to respond upon depressing the accelerator pedal. The contact veered to the side of the road and turned off the vehicle.…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the message "Pull Over. Stop the Vehicle" was displayed, and the vehicle failed to respond upon depressing the accelerator pedal. The contact veered to the side of the road and turned off the vehicle. The contact stated that the vehicle became drivable after waiting 30 minutes to an hour. The contact stated that the failure had been recurring while driving. Additionally, the contact stated that while reversing and depressing the accelerator pedal, the vehicle jerked, made an abnormally loud sound, and failed to respond. The contact shifted into park(P) and shifted back into reverse(R), and the vehicle jerked and responded. The contact stated that while driving at various speeds and depressing the accelerator pedal, the vehicle jerked and hesitated to respond. There was no warning light illuminated. The contact stated that she had taken the vehicle to an independent mechanic, where a diagnostic test was performed. The contact was referred to the dealer for assistance. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
- Engine · Power train
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and attempting to accelerate up a hill, the vehicle inadvertently lost motive power. Several attempts to restart and jumpstart the vehicle failed. The hybrid system warning light was…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed and attempting to accelerate up a hill, the vehicle inadvertently lost motive power. Several attempts to restart and jumpstart the vehicle failed. The hybrid system warning light was illuminated on the instrument panel. The vehicle was towed to the residence and later towed to an independent mechanic, who determined that the engine had failed due to metal shavings in the engine oil. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 55,000.
- Engine and engine cooling › Engine › Engine control module (ecu/ecm) › Software
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at approximately 50 MPH, the brake pedal was depressed and the vehicle began to stall. The contact stated that the accelerator pedal was then depressed but the vehicle would not accelerate as needed. The contact…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at approximately 50 MPH, the brake pedal was depressed and the vehicle began to stall. The contact stated that the accelerator pedal was then depressed but the vehicle would not accelerate as needed. The contact stated that the check engine warning light and the hybrid engine warning message was displayed and advised the driver to “Safely Stop and Do Not Drive” the vehicle. The contact pulled over and turned off the vehicle. The vehicle was restarted and the contact parked the vehicle in a parking lot and turned off the vehicle and waited for a while. The contact then restarted the vehicle and the check engine warning light remained illuminated. The vehicle was taken to the local dealer where it was diagnosed that the engine control module (ECM) needed to be replaced. The vehicle was not repaired and remained at the dealer awaiting the parts for the repair. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 130,000.
- Service brakes
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at various speeds, the brake pedal was depressed; however, the vehicle failed to stop. The contact stated that he heard a grinding sound in the wheels. The contact stated that the Hybrid System and brake warning…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that while driving at various speeds, the brake pedal was depressed; however, the vehicle failed to stop. The contact stated that he heard a grinding sound in the wheels. The contact stated that the Hybrid System and brake warning lights were illuminated. The vehicle was taken to an independent mechanic where the brake pads, rotors, and calipers were replaced; however, the failure recurred. The vehicle was taken to several independent mechanics however, the failure could not be duplicated. The dealer was notified of the failure and an appointment was scheduled for October. The manufacturer was not notified of the failure. The failure mileage was 204,900.
- Engine · Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving approximately 20 MPH, there were abnormal sounds coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer and diagnosed with a catalytic converter and engine failure.…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated while driving approximately 20 MPH, there were abnormal sounds coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer and diagnosed with a catalytic converter and engine failure. Additionally, the vehicle was consuming an excessive amount of engine oil. The check engine warning light was illuminated. The dealer replaced the engine; however, the failure reoccurred. The manufacturer was notified of the failure. The approximate failure mileage was 68,000.
- Engine
The contact owns a 2012 Hyundai Sonata. The contact stated while driving at 70 MPH, the oil pressure warning light illuminated and the vehicle started losing motive power. The accelerator pedal was depressed but the vehicle failed to respond and jolted. The contact veered to the side of the road.…
The contact owns a 2012 Hyundai Sonata. The contact stated while driving at 70 MPH, the oil pressure warning light illuminated and the vehicle started losing motive power. The accelerator pedal was depressed but the vehicle failed to respond and jolted. The contact veered to the side of the road. The contact turned off and restarted the vehicle. The contact continued to drive at a slower speed however, the failure reoccurred several times while driving to her residence. The vehicle was taken to the dealer who informed the contact that the failure was associated to Manufacturer Recall Number: 198. However, the dealer informed the contact that they could not repair the vehicle under the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 168,000.
- Engine
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that he had received notification of NHTSA Campaign Number: 15V568000 (Engine). The contact took the vehicle to a dealer where the recall was serviced. Soon after the recalled pair, the "Hybrid System Warning Light, Safely Stop and…
The contact owns a 2012 Hyundai Sonata Hybrid. The contact stated that he had received notification of NHTSA Campaign Number: 15V568000 (Engine). The contact took the vehicle to a dealer where the recall was serviced. Soon after the recalled pair, the "Hybrid System Warning Light, Safely Stop and Do Not Drive," warning message appeared on the instrument panel. The contact had the vehicle towed to a dealer where it remained in their possession. The manufacturer was notified of the failure but offered no assistance. The contact was given an estimate for the repair but was declined. The vehicle had yet to be repaired. The failure mileage was 155,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Hyundai and Kia ABS Module Fires
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by…
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
- Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles…
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Engine Fires
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE…
On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Non-crash Vehicle Fires
During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe…
During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Hyundai Sonata and Santa Fe vehicles equipped with Theta II and Lambda II engines (approximately 1.3 million vehicles). ODI also reviewed field data of other Hyundai vehicles equipped with Theta II, Gamma, Nu and Lambda engines (approximately 4.8 million). As a result of this PE, Hyundai has issued NHTSA Recalls 20V-746 and 21V-727 to address potential engine failures and fires in certain Hyundai vehicles equipped with various engine types. Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov. In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure rewlated recalls mentioned above and conducted previously. See the EA21-003 Opening Resume available at NHTSA.gov for more information. Also available in the downloadable version of this resume is a list of the reference numbers for the 302 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021. Note that the Manufacturer reports cited above are customer complaints received through March 2019.
- Non-crash Vehicle Fires
In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter…
In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.
- Air bags may be disabled during crash
The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2011 Hyundai Sonata…
The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2011 Hyundai Sonata, MY 2012-2013 Kia Forte and Forte Koup vehicles. ODI also evaluated data from the automotive air bag system supplier, ZF-TRW (ZF), to review vehicles that may contain the same air bag control unit (ACU) used in the subject vehicles. Hyundai Motor America (HMA) issued recall No. 18V-137 for MY 2011-2013 Sonata and MY 2012 Sonata Hybrid vehicles. Kia Motors America (KMA) issued recall No. 18V-363 for MY 2010-2013 Kia Forte and Forte Koup, MY 2011-2013 Optima, MY 2011-2012 Optima Hybrid, and MY2011-2012 Sedona vehicles. The two recalls address vehicles containing ACUs manufactured without adequate circuit protection by installing a wire harness filter kit to prevent internal damage to the ACU. In the event of a crash, ACU damage may result in the disablement of the vehicle's airbags. Each respective manufacturer has mailed letters to affected vehicle owners informing them of the remedy and its availability. ODI plans to evaluate the susceptibility of the subject ACU to electrical signals, as well as other vehicle factors that can either lead to, or reduce the likelihood of, an electrical overstress event in other vehicles manufactured with the subject ZF ACU.Accordingly, this Preliminary Evaluation has been upgraded to an Engineering Analysis (EA19-001), to expand the scope of the investigation to include the Tier-one supplier and any manufacturers who installed the subject ACU in production vehicles. Additional information is available with the closing resume available at NHTSA.gov (see Associated Documents).The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 10781050, 10849839, 11099038, 11080341.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11006829Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10241797On certain Sonata hybrid (YF HEV) vehicles, the HEV safety plug or power relay assembly (PRA) may cause the following symptoms and one or more current related DTCs. Follow the Service Procedure before diagnosing the hybrid battery. Please review the following instructions carefully to determine applicability depending on the model year of your vehicle. Warning light: No EV Ready mode, or Ready light blinks on and off Check Engine warning light on Charging system warning light on Wrench symbol (service indicator) blinks on and off Drivability symptoms: Vehicle will not move from a stop or gasoline engine will not turn on. Warning in the instrument cluster display: Hybrid System Warning! Safely stop and Do Not Drive and/or alarm sound.
- 10240082A class action lawsuit against Hyundai Motor America (HMA) alleges that certain Hyundai vehicles (Class Vehicles) were manufactured, marketed, sold, and/or leased with an engine defect that can result in sudden engine seizure, stalling, engine failure, and in some circumstances, engine fire, and that some owners and lessees of Class Vehicles have been improperly denied repairs under warranty. Neither HMA nor Hyundai Motor Company have been found liable for any of the claims alleged in the lawsuit. The parties have instead reached a voluntary settlement (the Settlement) to avoid lengthy litigation and to provide owners of Class Vehicles certain benefits.
- 10238380On certain Sonata hybrid (YF HEV) vehicles, the HEV safety plug or power relay assembly (PRA) may cause the following symptoms and one or more current related DTCs. Follow the Service Procedure before diagnosing the hybrid battery. Please review the following instructions carefully to determine applicability depending on the model year of your vehicle.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
- 10227320Certain vehicles may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise, or no crank/no start condition related to connecting rod bearing wear or damage. This Dealer Best Practice outlines the service process to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results, as well as related warranty coverage for the conditions outlined above.
- 10227317Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10227316The warranty coverage for engine repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners. Commercial entities and individuals engaged in the buying, selling, leasing, or renting of motor vehicles, as well as salvaged vehicles, are ineligible for the extended warranty.
- 10227313Op code/part number (reference guide for service campaign T6G)
- 10217258Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
- 10217251Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
- 10211675The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
- 10211667Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10211666Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10211664Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10211662Certain vehicles that have completed Service Campaign 966 may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10210206Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
- 10210205Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10207803Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10206366Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203282Hyundai is conducting a service campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203280Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10203277The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage or malfunction is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
- 10202189Hyundai is conducting a product improvement campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 10202180Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM.
- 102014722011-2015MY Sonata Hybrid (YFE) vehicles Onboard Refueling Vapor Recovery (ORVR) system may exceed its capacity in certain situations. This campaign provides information on the procedures to install an Auxiliary Canister to increase the ORVR system capacity. There are no drivability concerns associated with this condition.
- 102014662011-2015MY Sonata Hybrid (YF HEV) vehicles Onboard Refueling Vapor Recovery (ORVR) system may exceed its capacity in certain situations. This bulletin provides the procedure to install an Auxiliary Canister to increase the ORVR system capacity. There are no drivability concerns associated with this condition.
- 10199108Certain 2011 2015 Sonata Hybrid vehicles (YF HEV) may experience a check engine light illumination with an Evaporative System (EVAP) leakage related DTC P0442 Small Leak, P0455 Large Leak, or P0456 Very Small Leak stored. Salt particulate deposits can form inside the Natural Vacuum Leak Detection (NVLD) sensor, which may cause intermittent operation, prompting the check engine light illumination and DTC P0442, P0455, or P0456.
- 10199095Certain 2011 2015 Sonata Hybrid vehicles (YF HEV) may experience check engine light illumination with Evaporative System (EVAP) leakage related DTC P0442 Small Leak, P0455 Large Leak or P0456 Very Small Leak stored. These conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) sensor which may cause intermittent operation prompting the DTC P0442, P0455 or P0456 and check engine light illumination. This bulletin provides the procedure to install a new Air Filter Kit with an updated filter to help prevent entry of the salt particulates. In addition, replace NVLD sensor if DTC P0442, P0455 or P0456 is stored in the Engine Control Module (ECM).
- 10190049The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage, defect, or failure is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
- 10190044This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
- 10190038This bulletin provides best practice recommendations when performing brake service procedures.
- 10189989This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
- 10183963This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
- 10183960This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the Tire Balance Data Sheet must be fully completed including imbalance and Road Force Variation (RFV) data. The Data Sheet can be found at the end of this bulletin.
- 10180981This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
- 10179244This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components.
Every Hyundai Sonata Hybrid model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.