2004 Oldsmobile Alero
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Oldsmobile › Alero › 2004
These records cover every 2004 Oldsmobile Alero. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2004 Oldsmobile Alero. Newest first.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model…
Risk and remedy
Risk
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Risk and remedy
Risk
Fuel may leak, possibly resulting in a fire.
Remedy
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Owner complaints
109 complaints7 involved a crash2 involved a fire7 injuries
What owners report most
Latest complaints
- Electrical system · Exterior lighting › Turn signal
The contact owns a 2004 Oldsmobile Alero. The contact stated that while turning the key the vehicle failed to start. The blinkers were inoperable at times. There was an abnormal grinding sound detected while turning the ignition. There were no warning lights illuminated. The vehicle was taken to…
The contact owns a 2004 Oldsmobile Alero. The contact stated that while turning the key the vehicle failed to start. The blinkers were inoperable at times. There was an abnormal grinding sound detected while turning the ignition. There were no warning lights illuminated. The vehicle was taken to the local dealer for NHTSA Campaign Number: 14V400000 (Electrical System). The vehicle was taken back to the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who test drove the vehicle and determined the failure was due to the ignition switch. The manufacturer was not notified. The failure mileage was approximately 63,000.
- Structure › Body · Suspension
Lo que debes resaltar en el reporte: Kilometraje: 60,000 millas (especifica que el daño grave se notó a las 40,000). Componente: "Structure: Frame and Members" (Estructura: Chasis y travesaños). Riesgo: "Complete structural failure" (Fallo estructural completo
- Electrical system · Exterior lighting · Service brakes
I have exhaust coming into the car through the vent when thermostat is in use, my back seats are not in the clip and flip up with no problem and I have a 8 year old son who sits back there, my break pedal will lock and I cannot apply pressure, my dash lights just stopped working I believe the ECM is bad, my headlights go from bright to dim, car does not seem to keep acceleration power very well
- Unknown or other
Friendly Chevrolet 62704 has refused the open recall on my vehicle after being on schedule for tommrow 8a.m Service Manager Sir Richard said it's a waste of time and not my issue.
- Air bags · Electrical system · Engine
Airbag no deployment Loss of power steering Brakes to floor Car died Recall ignored prior and still today after set up now off their schedule Friendly Chevrolet rich Gardner
- Vehicle speed control › Accelerator pedal
The contact owns a 2004 Oldsmobile Alero. The contact stated while driving 35 MPH, the vehicle accelerated independently. The contact stated no warning light was illuminated. The contact stated she was able to drive to her destination. The contact called multiple local dealers: Les Stanford…
The contact owns a 2004 Oldsmobile Alero. The contact stated while driving 35 MPH, the vehicle accelerated independently. The contact stated no warning light was illuminated. The contact stated she was able to drive to her destination. The contact called multiple local dealers: Les Stanford Cadillac (21730 Michigan Ave, Dearborn, MI 48124, (313) 565-6000), Gordon Chevrolet, INC. (31850 Ford Rd, Garden City, MI 48135, (734) 237-6089) and James-Martin Chevrolet, INC. (6250 Woodward Ave, Detroit, MI 48202, (313) 444-8226) and was informed that the accelerator pedal was no longer being manufactured. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 04V528000 (Vehicle Speed Control) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 112,000.
- Electrical system · Unknown or other
The hazard and turn signals doesn't work at all. I bought a new turn switch, put a new fuse in and everything and nothing works. When I drive on the road the turn signal doesnt come on and sometimes it causes a lot of problems.
- Electrical system · Engine · Power train
Noticed the windshield was leaking which cause to leak on equipment under inside and out dashboard witch caused erosion and defects to other operating equipment lead to car stalling while driving,some operations of will work, some won't. It has a mind of it's own,the security system on car does not…
Noticed the windshield was leaking which cause to leak on equipment under inside and out dashboard witch caused erosion and defects to other operating equipment lead to car stalling while driving,some operations of will work, some won't. It has a mind of it's own,the security system on car does not work. I do not feel safe since I was driving down road on highway 55mph. And the car completely turn off, I turned ignition switch to turn car back on it was very scary moment. I didn't know what to do. But I wish I can afford to fix the car problems that has caused me a lot of misery financially emotionally feel safe with gm sealing front window properly on alero I wouldn't have these problems in the first place! So not properly sealing and wiring diagram needs to be examined in my opinion all I want IS to feel safe in any gm motors models not just me but others too . I wish someone would help me as much I help others in my car n my daily life to get by not much to ask to feel safe! the car was not sealed right in first place. This IS what caused my problems owning this car. I need either help with car to get fix pthe right way. Or I need a new car I have a disabled mother and grandpa that depend on me and I need a reliable car to provide daily tasks appointments the list goes on. I could really use a piece of mind just to know I'm driving a safe reliable car to do my god services every day I'm begging!!
- Electrical system
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the vehicle was taken to autonation chevrolet amarillo (2200 e I-40, amarillo, tx 79103) to be repaired per nhtsa campaign number: 14v400000 (electrical system). The contact received two new keys from the dealer, but they did not…
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the vehicle was taken to autonation chevrolet amarillo (2200 e I-40, amarillo, tx 79103) to be repaired per nhtsa campaign number: 14v400000 (electrical system). The contact received two new keys from the dealer, but they did not start the vehicle and the security indicator flashed. The vehicle was not taken to a dealer or independent mechanic for diagnostic testing or repairs. The manufacturer was not made aware of the failure. The failure mileage was 133,000.
- Air bags
Recently started financing a vehicle through car hop. They had me sign a form saying that there was a possibility of a recall on the vehicle, but didn't specify what. Reading it over now the form states they will not be responsible to correct this recall. Recall number IS 14v400.
- Air bags · Seat belts
TL* the contact owns a 2004 oldsmobile alero. While driving 30 mph, another vehicle crashed into the rear of the contact's vehicle. The air bags did not deploy and the seat belts failed to lock. The contact sustained a leg injury and a concussion, which required medical attention. A police report…
TL* the contact owns a 2004 oldsmobile alero. While driving 30 mph, another vehicle crashed into the rear of the contact's vehicle. The air bags did not deploy and the seat belts failed to lock. The contact sustained a leg injury and a concussion, which required medical attention. A police report was filed. The vehicle was not taken to a dealer to be diagnosed or repaired. the manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
- Electrical system
The hazard light button fell into the dashboard and the blinker signals only intermittently work. They will sometimes stop working while in the middle of a turn, other times will work for a few days, and then randomly stop again for no consistent amount of time. Upon researching this issue to repair I see that it IS very common with other cars of this make and model.
- Electrical system · Exterior lighting · Unknown or other
I own a 2004 alero oldsmobile I purchased the car used in 2008. It later only had one recall which was for the ignition issues. While the car IS on and in drive the key IS still able to be pulled out of the ignition and the car still remains on and in drive. I am also experiencing my blinkers not…
I own a 2004 alero oldsmobile I purchased the car used in 2008. It later only had one recall which was for the ignition issues. While the car IS on and in drive the key IS still able to be pulled out of the ignition and the car still remains on and in drive. I am also experiencing my blinkers not working 100% of the time, (nhtsa campaign # for this issue IS 03v327000). I can press the hazard light button quickly and frequently while pushing on the signal stick and that sometimes will make them work, other times that doesn't work and neither my signals nor hazard signals work at all. Lastly, and most frightening, in the midst of driving the vehicle has stalled, and will jump as the rpm's bounce back and forth, (nhtsa campaign # for this issue IS 07e021000). There had been several times this has happened and a few times the vehicle actually did shut off in the middle of driving, I've had to push the car off the road, and wait 10-15 minutes before I attempt to start the vehicle again. The car was tested for over 3 hours and they found nothing wrong with the engine or battery, which IS why I am certain it IS the fuel pressure recall. I took the car in for the key recall I brought this up to them as well, (as my windows also do not work), I purchased a new gas cap as instructed hoping that would fix this dangerous situation with the car stalling out, it did not fix the issue. there are recalls that my car falls under and that I am experiencing, I asked why these life threatening recalls weren't able to be fixed on my car, I was told they weren't listed on my vin. Please help my vehicle and the millions others be updated with the nhtsa to request the manufacturer to review this more closely in relation to the ones actually affected by these issues. These issues are extremely dangerous and pose as a threat not only to myself and family but to other drivers around me.
- Electrical system › Ignition
TL* the contact owns a 2004 oldsmobile alero. After driving and arriving at her destination, the contact stated that the vehicle key came out of the ignition switch on its own. The contact stated that this was an every day occurrence ever since the vehicle was repaired for an ignition switch recall…
TL* the contact owns a 2004 oldsmobile alero. After driving and arriving at her destination, the contact stated that the vehicle key came out of the ignition switch on its own. The contact stated that this was an every day occurrence ever since the vehicle was repaired for an ignition switch recall issued by the manufacturer in april of 2017. The manufacturer was notified of the failure and case number: 8-2930117201 was filed. The vehicle was not repaired. The nhtsa campaign number was not provided. The approximate failure mileage was 150,000.
- Electrical system
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the vehicle failed to start without warning. The vehicle was towed to an independent dealer where it was diagnosed that the ignition switch needed to be replaced. The vehicle was repaired. The contact received notification of…
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the vehicle failed to start without warning. The vehicle was towed to an independent dealer where it was diagnosed that the ignition switch needed to be replaced. The vehicle was repaired. The contact received notification of nhtsa campaign number: 14v400000 (electrical system). The part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 202,640.
- Electrical system · Fuel/propulsion system
"Takata recall" I was having trouble startting my car so I went to auto dealership and bought a key which cost $38.. it worked great for maybe a month. then I took my car to car wash and turned the ignation switch off and got out of car. When I was ready to go, the car would not start. had to hire a wreaker to haul it to the house. the car still won't start.
- Electrical system · Engine
Bought car a year ago, it had issues with turn signals not working. I googled issue and replaced hazard switch 125,000 miles. Now at 155,000 timing chain slipped, it's replacement worth more than car value. I heard after 2004 a change was made because of issues but no recall. Car was pulled to end…
Bought car a year ago, it had issues with turn signals not working. I googled issue and replaced hazard switch 125,000 miles. Now at 155,000 timing chain slipped, it's replacement worth more than car value. I heard after 2004 a change was made because of issues but no recall. Car was pulled to end of driveway before taking a close out of town trip, turned off to check oil and such, wouldn't start. Estimate received to repair 2,500$. I am furious!
- Electrical system · Electronic stability control (esc)
My turning signals work, but when not in use the signal noise does a rapid beep, beep noise, even when I drive and sit idly.
- Air bags
My granddaugher to be ran into the back of another can going only about 25 mph. the airbags came out but did not deflate. they had a cut in them. she did not get hurt but if she had been going faster or if I had been driving and had a wreck it could have caused major damage. she was on a side street
- Tires › Tread/belt
TL* the contact owns a 2004 oldsmobile alero equipped with firestone fr710 tires, size: p215/60r16. While driving 35 mph, the thread on the front driver side tire separated and caused the front fender and wheel well liner to partially detach. In addition, the door trim and rear brake light housing…
TL* the contact owns a 2004 oldsmobile alero equipped with firestone fr710 tires, size: p215/60r16. While driving 35 mph, the thread on the front driver side tire separated and caused the front fender and wheel well liner to partially detach. In addition, the door trim and rear brake light housing fractured. The vehicle was towed to the contact's residence and was not diagnosed or repaired. The manufacturer was not notified of the failure. The vin was unknown. The tire failure mileage was unavailable. The vehicle failure mileage was 100,000.
- Engine
TL* the contact owns a 2004 oldsmobile alero. While driving 55 mph, the engine stalled without warning. The vehicle was repaired per nhtsa campaign number: 14v400000 (electrical system). The failure recurred numerous times. The vehicle was able to restart after several attempts. The manufacturer was not notified of the failure. The failure mileage was approximately 162,000.
- Electrical system · Exterior lighting › Turn signal
TL* the contact owns a 2004 oldsmobile alero. While driving various speeds, the turn signals functioned intermittently. The failure recurred on numerous occasions. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was 125,000. updated 08/02/16*lj
- Electrical system › Ignition
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the engine stalled without warning while driving 35 mph. The vehicle was towed to an independent mechanic who performed diagnostic testing, which located a failure code at the ignition switch. The vehicle was not repaired. The…
TL* the contact owns a 2004 oldsmobile alero. The contact stated that the engine stalled without warning while driving 35 mph. The vehicle was towed to an independent mechanic who performed diagnostic testing, which located a failure code at the ignition switch. The vehicle was not repaired. The manufacturer stated that nhtsa campaign number: 14v400000 (electrical system) would only update the keys; it would not replace the ignition switch. The failure mileage was 200,000.
- Electrical system
TL* the contact owns a 2004 oldsmobile alero. The contact stated that while attempting to start the vehicle and turning the ignition switch with the key, the ignition switch caught on fire. The contact stated that the vehicle was repaired under nhtsa campaign number: 14v400000 (electrical system)…
TL* the contact owns a 2004 oldsmobile alero. The contact stated that while attempting to start the vehicle and turning the ignition switch with the key, the ignition switch caught on fire. The contact stated that the vehicle was repaired under nhtsa campaign number: 14v400000 (electrical system) but the failure recurred. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000. The vin was not available.
- Air bags · Electrical system
TL* the contact owns a 2004 oldsmobile alero. While driving at approximately 45 mph, the vehicle stalled and the security and air bag warning lights illuminated. The vehicle was taken to a dealer where it was repaired under nhtsa campaign number: 14v400000 (electrical system). The technician stated…
TL* the contact owns a 2004 oldsmobile alero. While driving at approximately 45 mph, the vehicle stalled and the security and air bag warning lights illuminated. The vehicle was taken to a dealer where it was repaired under nhtsa campaign number: 14v400000 (electrical system). The technician stated that the power control module also needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 150,000.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10249980This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include ?Vibration? ?Business Associate Code? and the last 8 of the Vehicle Identification Number.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248778Unintended Ignition Key Rotation
- 10248444Vehicle Recalls
- 10247780This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 10247681Information On Requests To Add OnStar Bluetooth Option.
- 10246952Programming And Activation Of Replacement OnStar Modules.
- 10246951Programming And Activation Of Replacement OnStar Modules.
- 10246631Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- 10245951Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
- 10245950Canadian Customers Unable To Place Calls In The United States
- 10245891Unintended Ignition Key Rotation
- 10245890Unintended Ignition Key Rotation
- 10245395This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.
- 10244274This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
- 10244214This informational bulletin provides information for the IPC odometer programming method quick reference guide.
- 10244201This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
- 10242298This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10242262This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
- 10240793This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
- 10236164This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10235802This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 10235799This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
- 10234141This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 10234110This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
- 10232811This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10232287This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
Every Oldsmobile Alero model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.