2018 Volkswagen Tiguan
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volkswagen › Tiguan › 2018
These records cover every 2018 Volkswagen Tiguan. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
14 recalls name the 2018 Volkswagen Tiguan. Newest first.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Risk and remedy
Risk
A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy
Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Risk and remedy
Risk
An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy
Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Risk and remedy
Risk
The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy
Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Risk and remedy
Risk
A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy
Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles.…
Risk and remedy
Risk
If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy
Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Risk and remedy
Risk
If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy
Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply…
Risk and remedy
Risk
If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy
Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Risk and remedy
Risk
A short-circuit can increase the risk of a fire.
Remedy
Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Risk and remedy
Risk
If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy
Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Risk and remedy
Risk
A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy
Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Risk and remedy
Risk
If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy
Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Risk and remedy
Risk
If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy
Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant…
Risk and remedy
Risk
In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy
Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and…
Risk and remedy
Risk
If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy
Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Owner complaints
288 complaints5 involved a crash3 involved a fire11 injuries
What owners report most
Latest complaints
- Steering
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving at various speeds, there was a clunking sound coming from the vehicle while depressing the brake pedal and making left turns. The contact stated that the failure became worse over time. The vehicle was taken to the…
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving at various speeds, there was a clunking sound coming from the vehicle while depressing the brake pedal and making left turns. The contact stated that the failure became worse over time. The vehicle was taken to the local dealer to be diagnosed, and it was determined that the steering rack mounting bolt was fractured due to corrosion and half of the bolt had seized. The contact was advised that the steering rack needed to be replaced. The vehicle was not yet repaired. The contact was notified about NHTSA Campaign Number: 26V590000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 82,000.
- Steering
My vehicle is under safety recall NHTSA 26V590 (Volkswagen 48LG / 48VT). The steering rack mounting bolt can corrode and break, which can cause a loss of steering control. I was notified of this recall about a month ago. As of October 21, 2026, there is still no remedy available, and I am told…
My vehicle is under safety recall NHTSA 26V590 (Volkswagen 48LG / 48VT). The steering rack mounting bolt can corrode and break, which can cause a loss of steering control. I was notified of this recall about a month ago. As of October 21, 2026, there is still no remedy available, and I am told owner letters may not go out until around November 10 — nearly two months after the recall was announced — with no date for when a repair will actually exist. This is my only vehicle, and I have to commute to work in it every day. On October 21, 2026, I contacted Volkswagen customer care and asked for a loaner or alternative transportation until the remedy is available. I was offered nothing — only told to keep driving the vehicle and wait. I do not think it is acceptable for owners to be told to keep driving a car with a known steering defect, with no repair available and no alternative transportation offered. I am asking NHTSA to press Volkswagen on the remedy timeline and on providing interim transportation for owners who have no other vehicle.
- Electrical system · Engine · Fuel/propulsion system
Within 6 months of purchasing car CPO from dealer, car went into limp mode. Was less than 35k miles, still having same issues at 85k miles. Took to dealer, they said nothing was wrong with car. Car began to have ECU light come on frequently in the middle of driving, took back to dealer. They…
Within 6 months of purchasing car CPO from dealer, car went into limp mode. Was less than 35k miles, still having same issues at 85k miles. Took to dealer, they said nothing was wrong with car. Car began to have ECU light come on frequently in the middle of driving, took back to dealer. They replaced the fuel injector harness under warranty. Began to have issues with fuel injector misfires, car stalling and lagging at stop signs, sputtering when given gas. When driven for long periods at a time, would intermittently not start. Took back to dealer within a year, spent 1800 on maybe fixes, modules and carbon filter replacement. Same issues. Took back again, spent another 1800 replacing modules. Same issues repeated. Took to a european car specialist as we were frustrated with not getting the vehicle properly fixed for years at the dealer, had the engine walnut blasted for any carbon buildup and fuel injectors cleaned, they diagnosed and said the fuel rail harness is bad. Took back to Volkswagen, they re-evaluated and said there was no issue- my husband had to explain to them that there was a repair just done so code reading would not be sufficient and they needed to get under the car and use a multimeter to diagnose the wiring harness. Service team needs additional training- after doing so they found the fuel harness used may in fact be bad and replaced it a second time. Called VW corporate who was no help and told me we are at the discretion of the dealer and they years of the same issues are just what happens at times when the vehicle is out of warranty. There are thousands of reports online- I have been out of use of the vehicle for at least 6 months in my 5 years of ownership. I cannot believe that VW has consistently faulty product relating to the fuel rail system and has not recalled the vehicles.
- Electrical system · Exterior lighting · Steering
Suspected Electrical Defect and Potential Fire Hazard – 2018 Volkswagen Tiguan SEL I am reporting a suspected electrical safety defect involving the sunroof wiring harness in my 2018 Volkswagen Tiguan SEL. While my vehicle was parked, an attempt was made to replace a blown F23 fuse. Smoke began…
Suspected Electrical Defect and Potential Fire Hazard – 2018 Volkswagen Tiguan SEL I am reporting a suspected electrical safety defect involving the sunroof wiring harness in my 2018 Volkswagen Tiguan SEL. While my vehicle was parked, an attempt was made to replace a blown F23 fuse. Smoke began coming from the sunroof area and filled the cabin. Afterward, multiple warning lights illuminated, the vehicle displayed a “turn car off” warning, the door locks repeatedly cycled, the climate control stopped working, and the infotainment/navigation screen shut off and restarted. A mechanic subsequently determined that the sunroof wiring harness had melted and required replacement. I was informed that the wiring harness (part number 5NA971648C) is unavailable and has been placed under Volkswagen’s “quality inspection” process due to suspected fire-hazard concerns. Volkswagen reportedly no longer supplies this harness separately, requiring replacement of the entire sunroof assembly, including the glass, even though the glass is not the source of the problem. The repair is estimated at $3,900 and requires extensive labor, including dashboard removal and a VIN-specific part from Germany. My primary concern is safety, not cost. A wiring harness that melts and produces enough smoke to fill a vehicle’s cabin could potentially cause a fire, damage other electrical systems, or endanger occupants. I am concerned other owners may face the same hazard. I request that NHTSA investigate whether the sunroof wiring harness or associated electrical system in 2018 Volkswagen Tiguan vehicles presents a safety defect, review similar reports, and determine whether further investigation or corrective action is warranted.
- Electrical system · Unknown or other
While opening the sunroof, the front end of the sunroof began to billow smoke. The cabin filled with smoke. The car was immediately turned off and the fuse was removed. While attempting to drive the vehicle closer to the dealership, the car experienced a total electrical failure and stalled on the…
While opening the sunroof, the front end of the sunroof began to billow smoke. The cabin filled with smoke. The car was immediately turned off and the fuse was removed. While attempting to drive the vehicle closer to the dealership, the car experienced a total electrical failure and stalled on the side of the road. The car will require a tow. There is a known recall on this matter, however, my VIN does not fall under this recall. The recall explains the exact issue we experienced with the smoking sunroof motor from the faulty lighting causing a serious fire risk.
- Engine · Unknown or other
We have to add 1-2 quarts of oil every 600 miles. Our check engine light came on 02/2026 for carbon buildup. We had it cleaned, had timing chain replaced, piston rings, oil valves, manifold. Cost us $5300. The car ran fine before the light came on and all of a sudden it started making grinding…
We have to add 1-2 quarts of oil every 600 miles. Our check engine light came on 02/2026 for carbon buildup. We had it cleaned, had timing chain replaced, piston rings, oil valves, manifold. Cost us $5300. The car ran fine before the light came on and all of a sudden it started making grinding noises and idling rough. We change the oil every 3,000 miles and the car burns through oil constantly. Our car stalled 4 times on the highway since then almost causing wrecks, it runs rough and now our check engine light is back on for the same issue. It’s causing emotional and financial distress. There are multiple lawsuits pending for this but something needs done. This is exhausting.
- Fuel/propulsion system
The car went into limp mode on an Interstate Highway. It was taken to a VW dealer in Mooresville, NC after two other private garages could not diagnose the problem. Their is a current Factory Warranty Extension for 2017, 2018, 2019 VW Tiguan's. The dealer in Mooresville kept the car for two weeks.…
The car went into limp mode on an Interstate Highway. It was taken to a VW dealer in Mooresville, NC after two other private garages could not diagnose the problem. Their is a current Factory Warranty Extension for 2017, 2018, 2019 VW Tiguan's. The dealer in Mooresville kept the car for two weeks. Drove it for over 100 miles. They claim They can see the code in the computer but it is not active so VW will not pay for the known problem. I feel this is a safety issue as the car will not only possibly go into limp mode at any time but when stepping on the accelerator when not in limp mode the exhibits another known fault. The engine initially sputters as if it is going to stall then accelerates very quickly.
- Engine
This vehicle goes through oil at a rapid rate. I am adding oil to my car every week. I have had to add at least 2 quarts between oil changes for the duration of owning the vehicle.
- Fuel/propulsion system
I began intermittently noticing a gasoline/fuel odor shortly after taking possession of the vehicle in June 2026. The odor became significantly worse, and I formally reported it to the selling dealership on July 9, 2026. The vehicle was subsequently taken to an authorized Volkswagen dealership for…
I began intermittently noticing a gasoline/fuel odor shortly after taking possession of the vehicle in June 2026. The odor became significantly worse, and I formally reported it to the selling dealership on July 9, 2026. The vehicle was subsequently taken to an authorized Volkswagen dealership for evaluation. A repair order dated July 23, 2026 documents: “Customer states that the vehicle smells of fuel. Could not duplicate customer concern.” Before the evaluation, I explained that the odor becomes most noticeable after the vehicle has been driven for an extended period, particularly in extreme Arizona heat. My normal commute is approximately one hour each way and 60 miles per day. I do not know how far or under what conditions the vehicle was road-tested during the evaluation. The vehicle remained with the dealership during the repair process and was returned to me on August 13, 2026. The condition has continued and has become substantially worse. After extended driving in extreme heat, the gasoline odor can become unbearable and is now noticeable inside the passenger compartment while I am driving. When parked in my home garage, the gasoline odor becomes strong enough to enter the house, and neighbors have also noticed it. The odor has also resulted in complaints from others in the parking garage at my workplace. I’m currently using approximately one tank of gasoline every two and a half days. I do not know whether the fuel consumption and gasoline odor are related. The specific failed component is UNKNOWN. The vehicle remains available for inspection. The concern has previously been presented to both the selling dealership and an authorized Volkswagen dealership, but the cause has not been identified and the condition continues.
- Suspension
While I was driving down a flat road this past week, the front left coil spring on my 2018 VW Tiguan S spontaneously broke, causing a large chunk of the coil spring to bounce around in the wheel well of the car and ultimately flying out into oncoming traffic as well as the left front end of my car…
While I was driving down a flat road this past week, the front left coil spring on my 2018 VW Tiguan S spontaneously broke, causing a large chunk of the coil spring to bounce around in the wheel well of the car and ultimately flying out into oncoming traffic as well as the left front end of my car to dip forward due to the shortening of the leftover coil spring. After going to the repair shop, I learned that this is a very common issue among VW products of these years. I also came to find out that my front control arms bearings are in need of replacement due to loose bushings, which is an already recalled issue on certain 2018 VW Tiguan vehicles, but of course, my vehicle is not listed under the recall. I am extremely upset and disappointed that my vehicle is being affected by all of these known recalled issues, yet when I run my VIN number, my car is never "affected". Suspension issues can be extremely dangerous, and I feel as if the issues that I have been having are known issues; I should have the right to get them repaired under recall rather than having to pay out of pocket once the part ultimately fails, putting me and others at risk for injury.
- Back over prevention › Warnings · Electrical system · Visibility/wiper
I purchased this 2018 Volkswagen Tiguan in September 2019 and began noticing an intermittent rearview-camera problem around that time. I do not remember the exact date of the first occurrence because the problem initially happened only occasionally and was not persistent. When the vehicle is…
I purchased this 2018 Volkswagen Tiguan in September 2019 and began noticing an intermittent rearview-camera problem around that time. I do not remember the exact date of the first occurrence because the problem initially happened only occasionally and was not persistent. When the vehicle is placed in reverse, the rearview camera intermittently fails to provide a reliable image. At other times, it operates normally. Because the problem is intermittent, it has been difficult for the dealership to reproduce consistently. Loss of the camera image reduces visibility behind the vehicle and creates a safety concern while backing up. An authorized Volkswagen dealership inspected the vehicle. The service manager stated that the stored fault indicates an intermittent open circuit in the video cable. The dealer’s diagnostic history reportedly shows approximately 90 fault occurrences beginning July 19, 2026. During recent testing, the dealership was able to get the fault to set once. The dealership has not conclusively confirmed that the camera control module failed. It proposes replacing the module as the first repair step for approximately $1,165 and stated that additional repairs may be necessary if the module replacement does not correct the problem. Volkswagen Customer CARE documented the concern under Case Number 07696586. I am submitting this report because the intermittent loss of the rearview-camera image may reduce the driver’s view behind the vehicle and increase the risk of a backing collision.
- Other/i am not sure · Tether, lower anchor (on car seat or vehicle)
I discovered a potential safety defect while inspecting and preparing my Graco Turn2Me child restraint for eventual forward-facing use. The seat is Model 2170122, manufactured 08/26/2024. The physical SnugLock/LATCH configuration of my seat appears inconsistent with Graco’s published Turn2Me…
I discovered a potential safety defect while inspecting and preparing my Graco Turn2Me child restraint for eventual forward-facing use. The seat is Model 2170122, manufactured 08/26/2024. The physical SnugLock/LATCH configuration of my seat appears inconsistent with Graco’s published Turn2Me instructions and installation videos. The rear-facing SnugLock lock-off/release mechanism shown by Graco does not appear to be present or accessible on my seat. The gray InRight lower-anchor/LATCH strap is routed through the blue rear-facing belt path and cannot be repositioned in the manner shown in Graco’s instructions. I cannot move the lower-anchor system into its designated storage location or reroute it through the orange forward-facing belt path as required for forward-facing LATCH installation. This child restraint has been used to transport my child before I discovered the condition. There was no crash, fire, injury, or fatality associated with the discovery. I have stopped using the seat. I reported the issue directly to Graco. Graco created Case #52041838 and Case #52041872, cross-referenced them for Product Safety review, and instructed me in writing to “refrain from using the product until further advice is given.” I am requesting that NHTSA review this as a potential manufacturing/assembly or child-restraint safety defect. Photographs documenting the seat, lower-anchor routing, apparent SnugLock discrepancy, and manufacturer label are available.
- Engine
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving 70 MPH, there was an engine failure, and internal parts fell apart and started grinding into the oil pan. The message "LIMP Mode” and the vehicle failed to exceed 4,000 RPM. The vehicle was towed to the dealer. The…
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving 70 MPH, there was an engine failure, and internal parts fell apart and started grinding into the oil pan. The message "LIMP Mode” and the vehicle failed to exceed 4,000 RPM. The vehicle was towed to the dealer. The dealer stated that the engine needed to be disassembled to be fully diagnosed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 37,000.
- Engine
Our 2018 Volkswagen had a light that came on so we took to dealership. The part that needs replaced is the cylinder head assembly which will be over $6000 plus $3k for timing. It will take over 28 weeks to get the part. So the car is not able to be driven. After looking into this, this is a known…
Our 2018 Volkswagen had a light that came on so we took to dealership. The part that needs replaced is the cylinder head assembly which will be over $6000 plus $3k for timing. It will take over 28 weeks to get the part. So the car is not able to be driven. After looking into this, this is a known issue and there is a class action lawsuits going on right now. There are 4,600 back order parts nationwide. This is a defective part that the company has not recalled. The dealership is aware also that this is a known issue. There was not an injury but they say it is unsafe to drive. Volkswagen has no resolution for problem for a known defect part.
- Back over prevention › Warnings · Lane departure › Blind spot detection · Unknown or other
A few weeks ago i noticed that a car passed me and the little blind spot alert light didn't light up. when i arrived at my destination I did some scanning through the menus and i discovered that the blind spot (side assist) was not on, but when i attempted to turn it on, the car said "function not…
A few weeks ago i noticed that a car passed me and the little blind spot alert light didn't light up. when i arrived at my destination I did some scanning through the menus and i discovered that the blind spot (side assist) was not on, but when i attempted to turn it on, the car said "function not available". After some investigation (using a odbeleven scanner) i discovered that the blind spot assist functionality has a fault with "no communication". This system, upon failure, give NO indication anywhere, plus this also means my rear back up alert ( a kid running behind my car, for example, which would normally cause a huge alert, nothing happens). I also learned that there is a technical bulletin : [XXX] related to this. This should be a recall, its dangerous to have no indication that a safety feature system like this is completely nonfunctional (without an ODBeleven read). a light on the dash should alert me, or a message on the screen. this is just plain dangerous! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Fuel/propulsion system
First purchased this car from a dealership in 2023, used at128,051 miles. Did not have any problems with it in the first year I would say. Then suddenly while driving down the road the epc light would come on limiting my speed to 4,000 rpm. It would come on and off also causing my check engine…
First purchased this car from a dealership in 2023, used at128,051 miles. Did not have any problems with it in the first year I would say. Then suddenly while driving down the road the epc light would come on limiting my speed to 4,000 rpm. It would come on and off also causing my check engine light to come on and off. It has now become more frequent, the epc and check engine lights will come on and off creating a major hazard while driving. Got it scanned while the check engine light was on and it ran a code for a cylinder 4 engine misfire from my fuel injector wiring rail harness. It looks to be a common problem with this model but it’s showing my vin is not attached to a recall.
- Electrical system · Fuel/propulsion system
2018 VW Tiguan. The fuel injector harness failed. There is a NHTSA letter stating 2018-2019 Tiguans had this issue and there’s an extended warranty up to 120,000 miles. My Tiguan is at 91,000 miles, but VW is saying the warranty isn’t assigned to my VIN. So there’s a warranty for this exact issue…
2018 VW Tiguan. The fuel injector harness failed. There is a NHTSA letter stating 2018-2019 Tiguans had this issue and there’s an extended warranty up to 120,000 miles. My Tiguan is at 91,000 miles, but VW is saying the warranty isn’t assigned to my VIN. So there’s a warranty for this exact issue and year, but my vehicle isn’t covered. This warranty obviously needs to be extended by build date as it’s a pretty costly repair.
- Suspension
Front coil spring fractured at 84,554 miles. I am the original owner with full dealer-maintained service history. VW issued Safety Recall 42J5 for premature rear coil spring fracture on 2018–2019 Tiguans due to material specification and manufacturing process defects at the spring supplier. The…
Front coil spring fractured at 84,554 miles. I am the original owner with full dealer-maintained service history. VW issued Safety Recall 42J5 for premature rear coil spring fracture on 2018–2019 Tiguans due to material specification and manufacturing process defects at the spring supplier. The front springs on this vehicle came from the same supply chain and production window. VW dealer in [XXX] noted that spring failures are common in this area on these vehicles. VW Customer CARE declined goodwill assistance. Requesting investigation into expanding Recall 42J5 to include front axle coil springs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Air bags · Electrical system
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the parking brake independently activated, and the air bag warning light illuminated. In addition, while attempting to turn off the vehicle, the key failed to function as intended. The vehicle…
The contact owns a 2018 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the parking brake independently activated, and the air bag warning light illuminated. In addition, while attempting to turn off the vehicle, the key failed to function as intended. The vehicle was driven to the shoulder of the road and turned off. The contact stated that while attempting to start the vehicle, several unknown warning lights were illuminated. The parking brake was not activated. Additionally, the front driver's side door latch failed to unlatch as needed. The contact stated that none of the electrical system features functioned as intended. The vehicle was taken to the dealer, where it was diagnosed with a failed wiring harness and a failed front driver's side door harness. The contact was informed that the wiring harness and front driver's side door harness needed to be replaced. The vehicle was not repaired. The dealer reset the codes. The contact was informed that until the repair was performed, the failure would recur. The contact referenced an unknown recall with a similar failure; however, the VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was unknown.
- Air bags · Electrical system · Structure › Body
My 2018 Volkswagen Tiguan experienced a failure of the airbag control module caused by water intrusion through the HVAC access area and failed seam seal tape at the cowl support. The dealership confirmed that water leaked through a factory seam, accumulated at the airbag module, and caused the…
My 2018 Volkswagen Tiguan experienced a failure of the airbag control module caused by water intrusion through the HVAC access area and failed seam seal tape at the cowl support. The dealership confirmed that water leaked through a factory seam, accumulated at the airbag module, and caused the module to fail. The airbag warning light is illuminated, and the system is inoperable. This failure matches the same defect pattern covered under Volkswagen’s recall campaigns for the Atlas and Atlas Cross Sport (water intrusion leading to airbag control module failure), but my VIN is not included. The root cause and safety implications are identical: water entering through a body seam/HVAC area and compromising the airbag system. This is a safety‑critical issue that disables the airbags and creates a risk of injury in a crash. I am requesting NHTSA review this defect for potential recall expansion. Dealership Findings: • Water present at airbag control module • Water leaking through HVAC access hole • Failed seam seal tape at cowl support • Water accumulation damaging the airbag module • Cowl trim cracked and repaired • Recommended replacement of airbag control module and seam sealing tape • Estimated repair cost: $1,377 + tax Safety Concern: Airbag system is disabled due to water intrusion from a factory seam. This creates a risk of injury or death in the event of a collision.
- Unknown or other
I just bought this 2018 Volkswagen Tiguan Ford, cylinder All wheel Drive in the Angel light came on and it says recalls will never fixed. I would like to know if you can help me and fix this problems. My name is [XXX] , Lodi New Jersey. My phone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train › Driveline › Chain/belt
The contact's daughter owns a 2018 Volkswagen Tiguan. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle shook and decelerated abnormally. The vehicle was taken to the dealer, who determined that the vehicle should not be driven because the drive belt needed…
The contact's daughter owns a 2018 Volkswagen Tiguan. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle shook and decelerated abnormally. The vehicle was taken to the dealer, who determined that the vehicle should not be driven because the drive belt needed to be replaced; however, the part was on backorder with no ETA. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 60,000.
- Engine
I own a 2018 Volkswagen Tiguan with approximately 70,000 miles. The vehicle requires a full cylinder head replacement due to faulty valve seals. I have been having to add engine oil frequently between oil changes. The repair has been confirmed by an authorized Volkswagen dealership. The required…
I own a 2018 Volkswagen Tiguan with approximately 70,000 miles. The vehicle requires a full cylinder head replacement due to faulty valve seals. I have been having to add engine oil frequently between oil changes. The repair has been confirmed by an authorized Volkswagen dealership. The required cylinder head part is currently on manufacturer backorder with no estimated time of arrival. Dealership told me to check in every 2-3 months, as no additional cylinder heads can be ordered due to excessive backorder. Dealership charges $6,000+ for this repair. Volkswagen has not provided a solution or timeline for repair with this ongoing issue. There were no warning lights prior to the issue, and the vehicle has been routinely maintained. A major engine component failure at this mileage raises concerns about a potential defect rather than normal wear. This situation creates a safety and reliability concern, with no reasonable repair timeframe due to parts unavailability as well as no communication from Volkswagen regarding this ongoing issue.
- Suspension
This vehicle experienced a rear shock spring failure identical to the symptoms noted in VW recall 42i7. We paid out of pocket for the springs to be repaired, and VW corporate along with the dealer reported this VIN does not qualify for the recall. They are unable to tell me why our particular VIN…
This vehicle experienced a rear shock spring failure identical to the symptoms noted in VW recall 42i7. We paid out of pocket for the springs to be repaired, and VW corporate along with the dealer reported this VIN does not qualify for the recall. They are unable to tell me why our particular VIN does not, other than it simply wasn't on the list. It seems unlikely the exact year/model/failure occurred on our vehicle as what was stated in the recall but somehow it didn't qualify I would expect VW to cover the spring replacement and required alignment
- Unknown or other
On [XXX] I discovered water in my car. ~2.5 inch front passenger and back driver and passenger side. Condensation on the sunroof. My sunroof was not opened/completely shut. I called VW service was advised my car was not covered under the class action or warranty and advised to report to my…
On [XXX] I discovered water in my car. ~2.5 inch front passenger and back driver and passenger side. Condensation on the sunroof. My sunroof was not opened/completely shut. I called VW service was advised my car was not covered under the class action or warranty and advised to report to my insurance. I did not want to report and risk my insurance rate increasing. I have never filed a claim in the 20+ years of having the car. After researching and taking my call for repairs I discovered that my vehicle should be covered on the extended warranty IF the recall 60E5/60E2 was repaired. I am in Ohio where the damage was discovered my regular service dealer is in Illinois. 1)The service dealer in Illinois did complete the 60E5/60E2 recall. 2) the extend warranty % coverage should cover my car however I was told my VIN was not apart of the class action although the recall was performed an no record in the system with VW and if it were I would not be covered because I am 5 months out of the in service date. 3) the damage is ~ 3000.00 and increasing because now the sunroof switch doesn’t work and the screen is damaged from water. There is mold in my car which is a health hazard. I have exhausted trying to navigate through this issue! If my car was not apart of the class action it should have been. The insurance minus my deductible does not cover the cost of repairs. I have been without a call since this incident. This is a health hazard consumer driving hazard and should be investigated ASAP. I have attached the initial estimate which will be supplementally adjusted, the service 60E5 document . Please advise if this should be reported to the attorney general office and or what my next course of action should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Seat Belt Webbing Failure
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right…
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
- Seat Belt Webbing Failure
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right…
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011379This is a notice for software changes with the ODIS diagnostic program to correct the communication for the keyless start system. 00B7 - Interface for Access/Start: U101300: Control module not coded & Software Configuration incorrect coding hotfix
- 11010028This is a notice for software changes with the ODIS diagnostic program to correct the communication during ECM Component Adaptation Test after component replacement.
- 11010024Lack of paint under roof
- 11010022Engine Oil Standards
- 11010021Additional reporting
- 11010011Vehicle Concerns Before Recall Repair Available
- 11008866Inspecting sensors for damage
- 11008861Fluid requirements
- 11008860Manual transmission noise diagnosing
- 11008858A list of engine oil that meet Volkswagen Engine Oil Standards
- 11008857How to perform the engine oil consumption measurement
- 11008856Checking Engine Oil and correctly reading dip stick
- 11008853How to manage software versions using VW diagnostic Tool
- 11008852Recommended Gasoline Quality
- 11008851Engine Misfire Diagnostic Aid
- 11008850Fuel additive to help with misfire faults
- 11008846Wind & Water Leak Checking
- 11008845This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
- 11007398Battery testing
- 11007393Engine Oil Standards
- 11005825Engine oil quality standards
- 11005820Engine Assembly Tip
- 11005819Engine Replacement Tip
- 11005818Engine No Start, ECM shorted due to incorrect battery removal
- 11002875Engine oil quality standards
- 11002874Remnants of the valve stem seal on the valve guide can interfere with the installation of new valve stem seals
- 11001522These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the Class Action Settlement
- 11001508Engine oil quality standards
- 11001503Forigen objects inside seat belt buckle
- 11001494These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the Class Action Settlement
- 10253481Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year 2015 and Newer
- 10253477Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- 10253474This communication contains important information and SAGA claim entry requirements for the Volkswagen Carefree Maintenance Program for all Model Year 2015 and newer VW models with Gasoline Engines.
- 10253262VW Engine oil quality standards
- 10253192Infotainment Worksheet (U.S. Only)
- 10252087In some sunroof-equipped vehicles, the front sunroof drains can become blocked with moist debris. If this happens, water could leak into the passenger compartment. Expiration date announcement
- 10251674Air Conditioning, Cleaning of the R1234yf Refrigerant Circuit (U.S. Only) updated to adjust Flush machine filter pricing.
- 10250803Bevel box leaking, update to Arteon labor operation numbers.
- 10250798VW Engine oil quality standards
- 10250766Engine Crank, No Start or No -J623- ECM Communication with DTC U0100 Stored in ECM Fault Memory
Every Volkswagen Tiguan model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.