2007 Volvo S40

Recalls

2 recalls name the 2007 Volvo S40. Newest first.

• Equipment › Electrical › Navigational system(global positioning system)

  Nov 8, 2010NHTSA 10V566000416 vehicles

  Volvo IS recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.

  Risk and remedy

  Risk

  An overheated battery could lead to a fire.

  Remedy

  Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit IS affected. the unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. this service will be performed free of charge. the safety recall began on november 18, 2010. owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

  Full recall details →

• Service brakes, hydraulic › Foundation components › Master cylinder

  Mar 5, 2008NHTSA 08V1010001,114 vehicles

  Volvo IS recalling 1,114 my 2007 C30, C70, S40, and V50 passenger vehicles. a soft anodized layer in the master cylinder may trigger early wear on a rubber seal that can result in internal leakage of brake fluid. if affected, the driver may experience reduced brake performance when applying and maintaining force of the brake pedal.

  Risk and remedy

  Risk

  The capacity to brake will gradually deteriorate forcing the driver to use a higher than expected force on the brake pedal when compared to an intact brake system. the deterioration can eventually result in complete loss of the brake system functionality increasing the risk of a crash.

  Remedy

  Dealers will inspect the master cylinder. the brake master cylinder and brake fluid reservoir will be replaced and certain brake lines cleaned free of charge. the recall began on march 11, 2008. owners may contact volvo at 1-800-458-1552.

  Full recall details →

Owner complaints

What owners report most

1. Electrical system5
2. Service brakes, hydraulic4
3. Engine and engine cooling3
4. Unknown or other3
5. Seat belts2
6. Steering2
7. Vehicle speed control2
8. Engine2
9. Air bags2
10. Power train2

Latest complaints

• Sep 22, 2020CA99,000 mi
  Electrical system · Unknown or other · Visibility/wiper
  On or about 12/04/2019 during a flash rain storm last winter, my husband and I was headed home on the 215 fwy northbound in san bernardino, ca when the center dome area and the electric sunroof inside our car begin pouring in huge amounts of very cold rain water on us and on the dashboard, stereo…

  On or about 12/04/2019 during a flash rain storm last winter, my husband and I was headed home on the 215 fwy northbound in san bernardino, ca when the center dome area and the electric sunroof inside our car begin pouring in huge amounts of very cold rain water on us and on the dashboard, stereo console, gear shifter, floor and seats. until it was safe to exit the freeway, my husband tried to soak up as much of the leaking rainwater as he could with his coat but the water continued to pouring into the car. once it was safe to exit the freeway, we pulled into a gas station and examine the sunroof to make sure it was shut properly, which it was, not understanding why this was happening, he and I used as many pieces of napkins and cloth that we could find to sop up as much water as we could and as best as we could. we drove on the streets the remaining few miles to get home because it was much safer to do so at this point. later, we researched as much as we could find out about the problem via online complaints and reviews from other volvo owners. we then tried one of the fixes offered: clearing potential debris from the sunroof drain hoses. however, when we took the car to a drive-thru carwash shortly afterwards, the exact same thing happen. we are looking forward to selling the volvo, but due to the leaky center dome and sunroof, there IS no way we will consider selling the car without disclosing this safety issue to the next buyer, even though when we purchased the car in 2013, the dealer who sold it to us did not tell us about the safety defect. Undoubtedly, if caught off guard while driving (i.e. Without a passenger's helping hand), not knowing about the defect may result in a major accident or fatality. please help!!!

• May 6, 2019PA124,000 mi
  Steering
  I was driving and the engine shut off causing me to lose control of my vehicle as the power steering shut down. I was able to steer my vehicle with difficulty to the side of the road where it stopped. About one week later this happened again. This time I was coming out of a parking lot and had to…

  I was driving and the engine shut off causing me to lose control of my vehicle as the power steering shut down. I was able to steer my vehicle with difficulty to the side of the road where it stopped. About one week later this happened again. This time I was coming out of a parking lot and had to aim my vehicle in a way to avoid hitting other vehicles. both time, after a few minutes the car started right up and I was able to drive again. Last friday, may 3, I pulled my vehicle over and when I stopped the vehicle shut down. this time it did not restart. the error message displayed on the dash was that the "steering was locked, try again." after several attempts including jump starting the vehicle, which was unnecessary, the vehicle would not start. I had my vehicle towed to the nearest volvo dealership and was told that the "steering column lock" had failed. The part needed to be replaced at a cost of over $830.

• Oct 19, 2018NC60,000 miCrash1 injury
  Air bags · Seat belts
  TL* the contact owned a 2007 volvo S40. The contact called on behalf of the driver. The contact stated that the vehicle was struck on the front passenger side by another vehicle. The speed was unknown. The air bag failed to deploy and the seat belt detached. The driver sustained leg, back, and…

  TL* the contact owned a 2007 volvo S40. The contact called on behalf of the driver. The contact stated that the vehicle was struck on the front passenger side by another vehicle. The speed was unknown. The air bag failed to deploy and the seat belt detached. The driver sustained leg, back, and shoulder injuries that required medical attention. A police report was filed. The vehicle was destroyed and towed to a tow lot. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing. The manufacturer was not notified of the failure. The approximate failure mileage was 60,000.

• May 31, 2018VA104,000 mi
  Electrical system · Electronic stability control (esc) · Unknown or other

  After parking car and turning car off, airbag, brake, and information warning lights stay on, as does ventilation system. passenger seat has excess water underneath. now car will not start.

• Feb 2, 2017CO10 mi
  Vehicle speed control
  Vehicle loses power due to accelerator pedal low voltage/signal. this occurs in multiple situations. safest IS shortly after starting the car an engine light stating 'engine system urgent' appears. unsafe occurrence includes power loss while pedal IS depresses such as on the highway with…

  Vehicle loses power due to accelerator pedal low voltage/signal. this occurs in multiple situations. safest IS shortly after starting the car an engine light stating 'engine system urgent' appears. unsafe occurrence includes power loss while pedal IS depresses such as on the highway with constant pressure or most severe when turning left through an intersection power IS reduced to idle. if the vent occurs with the pedal repressed, power IS reduced to idle momentarily (2-3 seconds) and after 'pumping' the pedal several times it returns to normal. I have brought this vehicle several times to repair. deal changed pedal, changed wiring connectors (also cleaned several times) and ultimately replaced engine computer. problem still occurs and dealer does not know what else to do. most recent occurrence was 27 jan but this issues appears about every two months after repair and occurs daily once to problem returns.

• Jan 25, 2017AZ129,401 mi
  Engine · Unknown or other · Vehicle speed control
  Safety concern: 2007 volvo S40 electronic throttle module failure - causing "reduced engine performance" message and vehicle (2007 volvo S40) suddenly slows down while in motion, limps and cannot go higher speed. Had barely exited the freeway on 1/24/2017 and this happened as I was on ramp. Could…

  Safety concern: 2007 volvo S40 electronic throttle module failure - causing "reduced engine performance" message and vehicle (2007 volvo S40) suddenly slows down while in motion, limps and cannot go higher speed. Had barely exited the freeway on 1/24/2017 and this happened as I was on ramp. Could be extremely dangerous if it happened 1 minute before when on freeway. Turned vehicle in right away to local volvo dealership (which was luckily within 15 minutes) and they diagnosed it to be faulty electronic throttle module needing replacement. Mileage on car 129,000 miles. Wanted to report so this issue can be looked into for safety concern and if the huge cost of replacement can be offset so owners can have peace of mind replacing it timely if there IS a recommendation or bulletin (similar to timing belts etc. - which I don't believe there IS currently for electronic throttle module).

• Jul 23, 2016TX
  Air bags

  Takata recall something IS wrong with the airbags. I t IS showing me that it needs to be repaired.

• Aug 24, 2015TX117,000 mi
  Engine

  TL* the contact owns a 2007 volvo S40. While driving, there was an abnormal noise coming from the engine and the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the pvc valve failed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 117,000.

• Jul 30, 2015CA51,104 mi
  Steering

  My car would not start because there was a message indicating the steering wheel was locked, but, it was not locked. I had to tow the car to the shop. They reported a defective steering column lock module. I found this IS a common problem for this cars which IS totally unsafe and unacceptable.

• Dec 5, 2014OH
  Engine and engine cooling · Visibility › Defroster/defogger/hvac system

  The cooling system and defrost shut down after driving for a while. Turns out the clutch went bad on the compressor. After researching further online, there are many complaints about this failure. Unfortunately, this IS a very expensive repair that I cannot afford. *tr

• Oct 20, 2014CA65,000 mi
  Service brakes
  TL* the contact owns a 2007 volvo S40. The contact stated that the brake sensor illuminated indicating low brake fluid. The vehicle was taken to an authorized dealer. The technician replenished the brake fluid and reset the brake sensor. The contact indicated that shortly after the brake sensor…

  TL* the contact owns a 2007 volvo S40. The contact stated that the brake sensor illuminated indicating low brake fluid. The vehicle was taken to an authorized dealer. The technician replenished the brake fluid and reset the brake sensor. The contact indicated that shortly after the brake sensor was reset by the dealer, the failure recurred. The vehicle was taken to an independent repair shop who was not able to replicate or diagnose the failure. The vehicle was not repaired. The contact was not included in nhtsa campaign number: 08v101000 (brakes). The manufacturer was notified of the failure. The approximate failure mileage was 65,000.

• Oct 20, 2014WA54,000 mi
  Electrical system · Seats · Structure
  Sunroof drain became clogged. this caused the poorly designed drains to leak at a junction inside the vehicle along the door pillar and behind the instrument panel. the water collects on the rear passenger floorboards and around the drivers seat. The car owner IS unaware of the leak until a large…

  Sunroof drain became clogged. this caused the poorly designed drains to leak at a junction inside the vehicle along the door pillar and behind the instrument panel. the water collects on the rear passenger floorboards and around the drivers seat. The car owner IS unaware of the leak until a large amount of water has accumulated. I am very concerned about the potential for an electrical fault or short circuit that could potentially result in a fire, malfunction or could lead to an accident. volvo should make checking these drains a regular part of it's service procedures or consider a redesign or recall. this issue IS widespread. *tr

• Nov 9, 2013FL55,000 mi
  Tires

  Michelin primacy MXV4 tires - dry rot on all 4 tires after only 20,000 miles. the warranty IS for 60,000 miles. this dry rot IS a huge safety concern. *tr

• Dec 10, 2011VA23,000 miCrash1 injury
  Service brakes, hydraulic
  12/9/2011 while on an incline driving at approximately 25 mph brakes failed, even after pressing pedal all the way to the floor, car failed to stop causing collision with vehicle in front despite more than necessary braking distance maintained between two vehicles and under clear, sunny conditions.…

  12/9/2011 while on an incline driving at approximately 25 mph brakes failed, even after pressing pedal all the way to the floor, car failed to stop causing collision with vehicle in front despite more than necessary braking distance maintained between two vehicles and under clear, sunny conditions. note: dealer had completed 10-point inspection during oil change 14 days before occurrence. 8/2011 car flooded with water internally and on floor/carpet. second occurrence. sunroof drain pipes replaced and car seats, carpets, foam padding removed and dried. owner required to pay 50% of cost of labor and parts, even though was to have been repaired in 2/2011.2/2011 first incident of car flood with water internally and on floor/carpet. sunroof replaced and car seats, carpets, foam padding removed and dried. sunroof replaced by volvo, owner incurred labor costs. warranty expired 2 months and 1 week before taken in. car had undergone 22500 mile check with nothing noticed by volvo while under warranty! Regular maintenance was done at dealers at recommended schedule and dealer performed state-required safety and emission inspections. *tr

• Nov 29, 2011FL78,000 mi
  Engine and engine cooling
  I own a '07 volvo S40 with 78,000 miles. It began making a loud whistling noise coming from the oil dipstick. After researching online I found that it was a known problem by volvo and the defective part IS covered under an extended warranty, however this defective part causes excessive damage to…

  I own a '07 volvo S40 with 78,000 miles. It began making a loud whistling noise coming from the oil dipstick. After researching online I found that it was a known problem by volvo and the defective part IS covered under an extended warranty, however this defective part causes excessive damage to the engine that IS not covered by volvo. It IS now up to the consumer to pay for the engine damage or it will cause the timing belt to snap and the engine to explode. An unsuspecting consumer can be fatally injured by this problem and something must be done about it! *kb

• Oct 18, 2011FL76,000 mi
  Service brakes, hydraulic
  TL* the contact owns a 2007 volvo S40. The contact stated while driving 30 mph, she applied the brakes and a brake light illuminated on the instrument panel. The vehicle was taken to an independent repair shop and the contact was informed that the vehicle was leaking brake fluid. Brake fluid was…

  TL* the contact owns a 2007 volvo S40. The contact stated while driving 30 mph, she applied the brakes and a brake light illuminated on the instrument panel. The vehicle was taken to an independent repair shop and the contact was informed that the vehicle was leaking brake fluid. Brake fluid was added to the vehicle as a temporary remedy. The vehicle was then taken to an authorized dealer and the contact was informed that the vehicle was not included in the recall associated nhtsa campaign ID number 08v101000 (service brakes, hydraulic:foundation components:master cylinder). The vehicle was not repaired. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 76,000. The vin was unavailable.

• Feb 10, 2011MDCrash2 injuries
  Seat belts › Front
  2007 volvo S-40. Consumer writes regarding a seat belt defect after suffering an injury to the eye due to a rear end collision *tgw the consumer stated he was struck from the rear while stopped yielding to traffic. The consumer stated he and his wife were hit with such force that the vehicle…

  2007 volvo S-40. Consumer writes regarding a seat belt defect after suffering an injury to the eye due to a rear end collision *tgw the consumer stated he was struck from the rear while stopped yielding to traffic. The consumer stated he and his wife were hit with such force that the vehicle rolled approximately 25 feet from where they were originally stopped. the driver's side seat belt did not retrain the consumers upper body which allowed his torso to go forward; consequently, his head struck the left windshield pillar. From the impact of his head striking the windshield pillar, his upper eye lid was lacerated by the frame of his eyeglasses and severely bruised his eye as a result. The consumers wife sustained whiplash. *Jb

• Jan 26, 2011FL63,000 miCrash1 injury
  Service brakes, hydraulic
  Tl*the contact owns a 2007 volvo S40. The contact stated that while driving approximately 30 mph the brakes failed causing her to crash into the rear of a vehicle. The driver sustained minor injuries, whiplash and was not transported to the hospital. A police report was filed. The vehicle was…

  Tl*the contact owns a 2007 volvo S40. The contact stated that while driving approximately 30 mph the brakes failed causing her to crash into the rear of a vehicle. The driver sustained minor injuries, whiplash and was not transported to the hospital. A police report was filed. The vehicle was inspected by an insurance adjuster who confirmed that it was destroyed. The failure and current mileages were approximately 63,000.

• Feb 22, 2010CO70,004 mi
  Electrical system › Ignition › Switch
  I parked the 2007 S40 volvo and can't remove the key from the ignition switch. The car IS in park, brake on, all necessary checks are checked. Still can't get the key to release, had to turn it several times (30 minutes) right to left until I heard a click and the key came out. I have seem post on…

  I parked the 2007 S40 volvo and can't remove the key from the ignition switch. The car IS in park, brake on, all necessary checks are checked. Still can't get the key to release, had to turn it several times (30 minutes) right to left until I heard a click and the key came out. I have seem post on the internet about this and that IS how I figured out how to get my key and lock the doors. I called volvo and the response was go to the dealer and you are out of warranty?! the key will not go past the I position. I don't mind paying to get it fixed but according to the volvo makers it IS isolated and not known how to fix. I beg to differ based on talking to other owners and the info on the web. Please assist as much as possible or a direction to get resolution. *Tr

• Feb 20, 2010SC35,000 mi
  Service brakes, electric

  I drove into a hotel parking garage , came into my spot and the car accelerated and went into a wall. I shut the engine off to prevent my whole car going thru the wall. Just the front of the car went into the wall. *Tr

• Jul 11, 2008NY9,500 mi
  Electrical system · Latches/locks/linkages
  On june 28, 2008, my garage door came down on my 2007 volvo S40 sedan, without warning, causing damage to the roof of the car (est. $2000.00) as well as irreparable damage to the garage door (replaced at a cost of $1150.00). a technician from genie (mfg of garage door opener) thoroughly inspected…

  On june 28, 2008, my garage door came down on my 2007 volvo S40 sedan, without warning, causing damage to the roof of the car (est. $2000.00) as well as irreparable damage to the garage door (replaced at a cost of $1150.00). a technician from genie (mfg of garage door opener) thoroughly inspected and tested the opener on june 30, 2008, and found the unit to be working properly. it was discovered that the action of unlocking and locking the car doors with the remote as well as starting the ignition of the car caused the garage door to open and close without warning. each time the car remote was pressed, it transmitted to the garage door opener. after de programming the homelink in the car, the situation no longer occurred. I no longer felt safe having the homelink active, as I did not want to chance further vehicle damage or bodily harm. The problem was clearly a transmitter/electrical problem with the car remote/homelink. I contacted volvo on june 30, who assigned a field representative to inspect the car at a local volvo dealership on july 9, 2008. I had requested they come to my home to witness the problem, but that request was denied. On july 10, 2008 the product investigation coordinator from volvo informed me that the findings of the field representative showed no operational issues, therefore, it was not a volvo problem. I have tried contacting homelink, to no avail. nothing has been done to correct the malfunction, nor have I received any compensation for damage caused by this malfunction. *Tr

• May 2, 2008MA3,000 mi
  Power train › Automatic transmission
  Tl*the contact owns a 2007 volvo S40. the contact stated that her vehicle feels as if it were downshifting; however, it has an automatic transmission. when she begins to accelerate, the reduced engine performance light illuminates when the downshifting occurs. the dealer replaced the accelerator…

  Tl*the contact owns a 2007 volvo S40. the contact stated that her vehicle feels as if it were downshifting; however, it has an automatic transmission. when she begins to accelerate, the reduced engine performance light illuminates when the downshifting occurs. the dealer replaced the accelerator pedal and cleaned the computer after the first failure. after the second failure, they replaced the computer. the failures still persist and the contact IS scheduled to take the vehicle to the dealer next week. the speed was unknown. the failure mileage was 3,000.

• Nov 12, 2007CA2,939 miFire
  Service brakes, hydraulic › Foundation components › Disc › Caliper
  The rear brakes on this vehicle caught on fire after a short drive (1 mile) having to be extinguished with a fire extinguisher. the rear brake assembly (left rear) completely failed and overheated to the point of causing flames to appear needing to be extinguished. this car had 2939 miles on it…

  The rear brakes on this vehicle caught on fire after a short drive (1 mile) having to be extinguished with a fire extinguisher. the rear brake assembly (left rear) completely failed and overheated to the point of causing flames to appear needing to be extinguished. this car had 2939 miles on it as a new volvo S40. This catastrophic failure was unexplained and without an apparent error by driver as this vehicle IS used by a college student for very short distances. the emergency brake was not left on. *tr

• Jul 12, 2007CA40 mi
  Engine and engine cooling › Cooling system
  Tl*the contact owns a 2007 volvo S40. the contact has recently rented three zip-cars within the past few months and has detected an unusual scent coming from the vents. the pants he had hanging inside the vehicle had a faint smell to them once he arrived home. he believes there could be asbestos…

  Tl*the contact owns a 2007 volvo S40. the contact has recently rented three zip-cars within the past few months and has detected an unusual scent coming from the vents. the pants he had hanging inside the vehicle had a faint smell to them once he arrived home. he believes there could be asbestos inside the vehicles. the dealer and manufacturer have not been notified. the vin and engine size were unknown. the current and failure mileages were 40.

• Jan 10, 2007TN400 mi
  Power train › Clutch assembly › Pedal/hand lever(motorcycle)
  On my brand new S-40 volvo with a manual 5 speed transmission operating the clutch pedal to be fully depressed to the floor can be obstructed easily by an adjacent protruding panel on the floor board. when my left foot IS blocked by this protruding panel, I am inhibited from shifting gears. this…

  On my brand new S-40 volvo with a manual 5 speed transmission operating the clutch pedal to be fully depressed to the floor can be obstructed easily by an adjacent protruding panel on the floor board. when my left foot IS blocked by this protruding panel, I am inhibited from shifting gears. this condition IS very dangerous in heavy traffic. volvo customer service has been advised of this problem and has refused to acknowledge it as a defect. volvo has refused to provide a simple solution to the problem by supplying a properly formed clutch lever that positions the clutch pedal far enough away from the protruding panel for consistently proper depression of the clutch during shifting. *jb

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11007925Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
• 10249191This is a Technical Journal: 12V Battery Testing Method
• 10241661Complimentary upgrade c00009 description.
• 10241651Rubber cushion
• 10219421Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
• 10213885The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
• 10213883ICUP/Google Built-In Diagnostic Operations
• 10213882Battery Charger/maintainer requirement
• 10212892Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
• 10212891VIDA QR Scanner Mobile App
• 10205650News Letter 69
• 10188881Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. By setting clear performance expectations and parameters and assisting retailers in focusing on individual processes and procedures, all retailers are provided with adequate tools to help achieve the ultimate goal of qualifying for self-authorization status.
• 10182703This is a Technical Journal: It has been noticed on requested materials that PAS sensors are analyzed without finding any fault on the parts. As a help to the troubleshooting on parking assistance system, we have developed some points of possible actions in case of problems. False detection may be caused by various reason explained in this Technical Journal.
• 10181041Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
• 10179681This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
• 10178520This is a Service Manager Bulletin: Volvo Lithium-ion Hybrid Battery Packs shipping and handling to Volvo Reman
• 10178516This is a Service Manager Bulletin: Volvo Lithium-ion Hybrid Battery Packs shipping and handling to Volvo Reman
• 10178503Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
• 10177386Service Manager Bulletin: Vehicle Type and Platform Information
• 10173760This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
• 10171676Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
• 10170147Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
• 10169394This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
• 10169393This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
• 10169391Software Installation Policy changes.
• 10169389This is a Service Manager Bulletin: Technician Skillset Requirments
• 10169388This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other vehicles.The attached checklists can be used for restoring customer settings, where applicable.
• 10169036Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
• 10169030This is a Technical Journal: Oil in cooling system. New cleaning method developed.
• 10169022This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
• 10169021Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
• 10168247VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer - to - Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 337 REFERENCE BULLETINS : DATE : YEAR MONTH DAY SERVICE SERVICE WARRANTY 2015 01 19 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 17 ? Right first time in Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2015 VOLVO CARS OF NORTH AMERICA , LLC Service Manager Bulletin 00 - 337 Page 2 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 3 of 17 Service Manager Bulletin 00 - 337 Page 4 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 5 of 17 Service Manager Bulletin 00 - 337 Page 6 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 7 of 17 Service Manager Bulletin 00 - 337 Page 8 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 9 of 17 Service Manager Bulletin 00 - 337 Page 10 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 11 of 17 Service Manager Bulletin 00 - 337 Page 12 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 13 of 17 Service Manager Bulletin 00 - 337 Page 14 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 15 of 17 Service Manager Bulletin 00 - 337 Page 16 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 17 of 17
• 10168245This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
• 10167953Software Installation Policy changes.
• 10167952Descripition of Goodwill Policy and Guidelines.
• 10167907This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017
• 10167901This is a Technical Journal: Replacing CEM or Recommunicating with a 'sleeping' vehicle
• 10167895This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other vehicles.The attached checklists can be used for restoring customer settings, where applicable.
• 10167887Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes active. The advantage of using the EFF function is that error frames are usually transmitted on the network before a vehicle symptom can occur. Hence, if the fault is very intermittent in nature, it may be possible, for example, to induce the wiring fault for a short duration by manipulating the vehicle harnesses and connectors. The electrical fault will occur and be detected by the EFF without ever having a vehicle symptom appear. The instructions for setting up the tool have been simplified.
• 10167872This is a Service Manager Bulletin: Service Scheduling system enhancements. Improving Service Action/Recall scheduling.

Every Volvo S40 model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.