1994 BMW 530I
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 1994 BMW 530I. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 1994 BMW 530I. Newest first.
Vehicle description: passenger vehicles. a malfunction or failure of a coolant system component, such as a thermostat, water pump, or fan belt, can result in significantly increased coolant temperature and system pressure. if the indications of a critical overheating condition IS not noticed by the driver, it IS possible that damage to, or failure of, a…
Risk and remedy
Risk
If a crack were to form or a seam were to separate in the heater core end piece, hot coolant could suddenly be expelled, increasing the risk of personal injury to a vehicle occupant.
Remedy
Dealers will install a new design radiator cap to control pressure and provide greater coolant overflow in the event of overheating.
The cruise control and throttle cables are attached to the same throttle valve actuating lever at the throttle housing. it IS possible that the plastic bushing on either cable could break due to environmental influences coupled with vibration. if the bushing breaks, the outer cable housing can separate from the bushing. in this case, during application…
Risk and remedy
Risk
This could cause the throttle valve to remain partially open. it his were to occur, the car might not decelerate as expected increasing the risk of a vehicle crash.
Remedy
Dealers will install a spring steel clip on the outer tube of each cable in the area of the adjusting screw and plastic bushing. the clip IS designed to prevent the outer tube from dislodging from the bushing.
The brake light switch can fail allowing the switch to remain in the "brake lights off" position or in the "brake lights on" position.
Risk and remedy
Risk
If this happens, the brake lights either will not operate or will be continuously on, regardless of brake pedal position. Following drivers would not be able to determine whether the vehicle IS stopping, increasing the potential for a vehicle accident.
Remedy
Dealers will replace the existing brake light switch with a newly designed switch.
Owner complaints
9 complaints
What owners report most
Latest complaints
- Engine and engine cooling › Cooling system › Fan
1994 BMW 530I engine's fan clutch seized causing the fan to shatter violently. *nj the failure of the fan clutch caused extensive amounts of damage to many components in the engine bay. *Jb
- Electrical system
Dt: the contact bought a BMW. she complained about electrical problems. On 4-26-05 she got into the car and closed the door and it started smoking. She could not get out of the car. Someone got it started. When she arrived home she turned it off. When she turned it back on vehicle started to…
Dt: the contact bought a BMW. she complained about electrical problems. On 4-26-05 she got into the car and closed the door and it started smoking. She could not get out of the car. Someone got it started. When she arrived home she turned it off. When she turned it back on vehicle started to smoke again. She called the dealer, and he promised fix i, but it never was fixed. She took vehicle to BMW. It took BMW 4 weeks to check the car. She was told by BMW the car was only worth $1,500 and there was $8,000 in minor damages , and over $10,000 in major damages. she eventually had to give the car back to the dealer. She claimed the dealer was trying to sell the car to someone else. *ak
- Engine and engine cooling › Engine
Engine block fails on all M60 BMW V8'S from 1993-1995 contact me for details. *Ak
- Seats
Seat rocks on rails noticeably. *Ak
- Engine and engine cooling › Cooling system · Engine and engine cooling › Cooling system › Radiator assembly
Water pump was replaced. also, thermostat was causing the radiator to overheat. also needed a radiator cap. *ak
- Engine and engine cooling › Engine · Vehicle speed control › Cruise control
BMW was aware of a problem where sulpher from us fuels was causing the cylinder walls of the M60 V8 motor to deteriorate. apparently they used a new metal called nikasil (aluminum impregnated with nickel and silicone). once the cylinder walls become damaged, the piston rings can no longer seal…
BMW was aware of a problem where sulpher from us fuels was causing the cylinder walls of the M60 V8 motor to deteriorate. apparently they used a new metal called nikasil (aluminum impregnated with nickel and silicone). once the cylinder walls become damaged, the piston rings can no longer seal properly, causing "leakdown" or air to escape past the piston as it attempts to compress air into the combustion chamber. although BMW knew of the defect, there was no recall issued. through reasearch, and talks with BMW mechanics, I found that BMW has replaced thousands of the effected motors. BMW even extended the warranty period on the engine to 100K miles. I own a BMW 530I with the 3.0 litre M60 nikasil motor. it began having problems at around 96K miles. I now have 109K miles. the car ran fine, but had a rough idle. apparently this IS a syptom of the "leakdown" problem. I brought the car to girard BMW to have it tested. they confirmed the engine had the problem associated with the defective engine block. however, when I got my car back, it ran very poorly. before leaving the dealer, I told them that it was running worst then when I brought it to them. they indicated it was due to the engine block problem. I informed them I was concerned taking the car for fear I would get stuck somewhere. They assured me I would not. two days later, my car would not start. girard had a tow truck pick up my car. I have receipts from a local garage showing that the car was experiencing the problem while it was still covered under warranty. at the time, I was unaware that BMW had extended the warranty, or that there was any known problems with the motor, as I received nothing from BMW indicating such. I did receive other recall information on the car however nothing regarding potential engine problems. my car IS now barely over the warranty period (9K miles) and BMW will not fix it. *ak
- Electrical system › Wiring › Fuses and circuit breakers
When turning steering wheel, the fuse would blow. No interior lighting or windshield wipers, if raining. The dashboard lights would be out. Taken to dealer & mechanic found nothing wrong the first 2 times. Finally, the 3RD time, the problem (electrical) was found & repaired. *ak
- Engine and engine cooling › Engine › Gasoline · Power train › Automatic transmission
Transmission failed resulting in slipping.
- Seats › Front assembly › Recliner
When transporting cargo behind rear seats, if cargo hits back of seats, seats fly forward, happens when suddenly applying brakes, dealer readjusted latches, snapped latches do not hold, referred by ga state attorney, lemon law.. *ak
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10249437The basic conditions for initializing the power windows are not met.
- 10218384Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.
Every BMW 530I model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.