2020 BMW X1
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2020 BMW X1. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2020 BMW X1. Newest first.
BMW of North America, LLC (BMW) is recalling certain 2020 X1 xDrive28i, X1 sDrive28i, X2 xDrive28i and X2 sDrive28i, 2020 MINI Clubman Cooper S All4, 2021 MINI Hardtop 2 Door (Cooper, Cooper S, John Cooper Works and Cooper S E) and MINI Hardtop 4 Door (Cooper and Cooper S) vehicles. Due to a problem with the rollover sensor within the air bag control unit…
Risk and remedy
Risk
If the safety systems do not deploy as intended in a roll over crash, it may increase the risk of injury.
Remedy
BMW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began July 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.
Owner complaints
13 complaints1 involved a crash1 involved a fire3 injuries
What owners report most
Latest complaints
- Fuel system, gasoline › Fuel injection system › Throttlebody/manifold · Power train · Vehicle speed control › Throttle
The contact owns a 2020 BMW X1. The contact stated that while driving 75 MPH, the vehicle suddenly decelerated to 10 MPH. There was no warning light illuminated. During the failure, the messages, "Chassis Stabilization: Drive Moderately," "Collision Warning System Malfunction," "Pedestrian Warning…
The contact owns a 2020 BMW X1. The contact stated that while driving 75 MPH, the vehicle suddenly decelerated to 10 MPH. There was no warning light illuminated. During the failure, the messages, "Chassis Stabilization: Drive Moderately," "Collision Warning System Malfunction," "Pedestrian Warning Reduced," and "Drivetrain: Continued Driving Possible" were displayed. The vehicle was pulled over into a remote emergency lane and driven 10 miles to an exit. The vehicle was towed to the dealer, where it was diagnosed with a short circuit to ground at the throttle body. The contact was informed that the throttle ground wire and controller needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 67,000.
- Fuel/propulsion system
The fuel tank got punctured on the freeway causing the car to lose power. The problem seems that BMW plastic fuel tank is located on the right side at the bottom of the car so any stone or particle on the freeway can puncture the plastic tank from the bottom causing no fuel and the car losing…
The fuel tank got punctured on the freeway causing the car to lose power. The problem seems that BMW plastic fuel tank is located on the right side at the bottom of the car so any stone or particle on the freeway can puncture the plastic tank from the bottom causing no fuel and the car losing power. Seems like that is problem with design and BMW is aware of it since the new models of the car starting 2023 have an extra underbody protection for the fuel tank which is missing on the previous year models.
- Engine · Power train
Wastegate actuator turbo failure. Causes sudden loss of power to engine. Turbo function impacted. Drivetrain malfunction warning on dashboard. No prior warning sent. Problem with wastegate has been confirmed by Independent Service Center. Found similar issue with BMW E-Series Model 530e…
Wastegate actuator turbo failure. Causes sudden loss of power to engine. Turbo function impacted. Drivetrain malfunction warning on dashboard. No prior warning sent. Problem with wastegate has been confirmed by Independent Service Center. Found similar issue with BMW E-Series Model 530e xdrive sedan Production dates 2/22/17-6/18/20 which extended warranty to 15 yr/150000 miles for same part. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Back over prevention › Warnings · Electrical system · Power train
I had a series of concerning incidents with my car. The trunk door was getting stuck halfway, but I was able to close it after turning on the engine. I also encountered a malfunction error on the backup camera, a Drive Train warning sign, and the car alarm going off by itself. The most alarming…
I had a series of concerning incidents with my car. The trunk door was getting stuck halfway, but I was able to close it after turning on the engine. I also encountered a malfunction error on the backup camera, a Drive Train warning sign, and the car alarm going off by itself. The most alarming issue was when the car started smoking and then caught fire underneath the hood near the driver's side windshield. Thankfully, my father and I were able to put out the flames with a water hose before calling 911 to report the incident to the fire department. The car is considered a total per Geico Insurance.
- Electrical system · Power train · Service brakes
it all started with the Battery and Powertrain and lound Loud niose from under my vehicle and my rear tail light code default. service forgetting to put the clamps back on i took the vehicle back from service and drove over 200 miles when the code for the above mention malfuntion appeared again…
it all started with the Battery and Powertrain and lound Loud niose from under my vehicle and my rear tail light code default. service forgetting to put the clamps back on i took the vehicle back from service and drove over 200 miles when the code for the above mention malfuntion appeared again they admitted the negilence of the service team...from that point on they my car was in and out of service for weeks at a time from September 2023 until Febuary 2024. I endlessly tried to resovle reimbursement and prove my vehicle was unsafe to drive and manufacture defects. i also consulted corporate several times submitting claim and nothing was esculated or followed up. listed below are the issues I have experienced on sevaral trips in my vehicle.I am in panic state each and every time I drive this vehicle. the codes and invetigation numbers are associted with the creen shots I obtained with the service machanics virtual video of my visits: 10228427 B220222 10177616 B010419 10176377 B610520 10228428 B120723 1024907 B611305 10178993 B160319 My Request would be a Brand Buy Back or my Rights for claim under Indiana lemon law consumer act.
- Seat belts
I got my BMW X1 in December of 2020 and currently has 21,000 miles. I've notice unusual wear and tear on the driver side seatbelt so I brought it into the dealer but all they said was that it needs to be replaced. I don't think this is a normal wear and tear because as I've said, I only drove this…
I got my BMW X1 in December of 2020 and currently has 21,000 miles. I've notice unusual wear and tear on the driver side seatbelt so I brought it into the dealer but all they said was that it needs to be replaced. I don't think this is a normal wear and tear because as I've said, I only drove this vehicle for 21,000 miles. The tear is expanding and I believe this can be a serious safety issue during an accident or sudden stops. I was concerned if this was an issue to similar vehicles or if it's just my vehicle.
- Fuel/propulsion system
Check Engine light checked at dealership revealed Fuel in the NVLD System! They had to replace the NVLD, Charcoal canister, and the Tank vent valve. They accused me of overfilling my fuel tank! I am 100% certain that I NEVER overfill fuel whatsoever. I am afraid this may cause other drivers to…
Check Engine light checked at dealership revealed Fuel in the NVLD System! They had to replace the NVLD, Charcoal canister, and the Tank vent valve. They accused me of overfilling my fuel tank! I am 100% certain that I NEVER overfill fuel whatsoever. I am afraid this may cause other drivers to ignore the problem resulting in vehicle fires! Please investigate further or ask for repair frequency of this problem from BMW. I owned a BMW for almost 20 years and never experienced this problem! Thanks
- Unknown or other
The vehicle’s sunroof exploded spontaneously. This occured on an elevated expressway with no access above the vehicle. There was no physical impact to the vehicle. There were no visible warning signs. The sunroof shattered into small shards.
- Service brakes
On 7/1/22, my Vehicle Alert came on advising that the front brake pads need replacement and to schedule an appointment within 1,000 miles. I called the same day to schedule an appointment with my local dealer. However, the next available date was on 7/13/22. I specifically requested an earlier…
On 7/1/22, my Vehicle Alert came on advising that the front brake pads need replacement and to schedule an appointment within 1,000 miles. I called the same day to schedule an appointment with my local dealer. However, the next available date was on 7/13/22. I specifically requested an earlier date, but that was the only available slot they had. I brought my vehicle in on 7/13/22 (alert now says schedule an appointment within 800 miles so i had driven 200 miles) and was given an estimate to replace the front brake pads. On the same day, i get a call from the dealer service advisor that the front rotors also needs replacement as they were damaged due to continued driving with worn down brake pads. They also advised the engine mount was cracked and leaking. My safety concern is that the alert should have came on sooner as I called to schedule an appointment the same day the alert came on but the only available time for almost two weeks later. There should have been a more urgent alert (i.e. replace within 50 miles) as I would have then made separate arrangements immediately. Alternatively, the alert should come on much earlier in the brake pads' wear detection. Instead, I was unknowingly driving my vehicle with dangerously damaged rotors due to the false sense of safety as the alert said schedule appointment within the next 1000 miles and I had only driven 200 miles. This put not only my safety at risk but others on the road as well should my brakes have failed. A crash would have been more dangerous in light of the cracked engine mount and leak. I understand brakes are wear and tear and customer pay but i feel that the alert system design and logic needs to be looked at as non-savvy drivers rely on them to make appointments accordingly.
- Engine
On Sept 8, 2021, on I-5, North of Marysville, WA, a truck threw a rock through the lower radiator of our X1. We lost all coolant and car was hauled to BMW, Seattle on 9/9/21. On 9/10 service rep Josh Logan advised: "We confirmed that it does not come with a guard, but when you order a new part…
On Sept 8, 2021, on I-5, North of Marysville, WA, a truck threw a rock through the lower radiator of our X1. We lost all coolant and car was hauled to BMW, Seattle on 9/9/21. On 9/10 service rep Josh Logan advised: "We confirmed that it does not come with a guard, but when you order a new part, that does come in conjunction." and that: "no warranty coverage, as it does not cover damages, so you would have to go through your insurance for that one." We did so and USAA covered the amount above the $1000 deductible. It is unacceptable that the need for the rock shield was clearly a known condition, yet when damage occurred due to it not being installed from new, that the replacement was not covered under warranty. First Name: [XXX] Last Name: [XXX] Email Address: [XXX] Phone Number: [XXX] Preferred Contact Method: Email Address: [XXX] City: [XXX] State: [XXX] ZIP Code: [XXX] Own a BMW: Yes Year: 2020 Series: X Model: X1 xDrive28i VIN: [XXX] Month Purchased: November Year Purchased: 2020 INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
- Engine
On Sept 8, 2021, on I-5, North of Marysville, WA, a truck threw a rock through the lower radiator of our X1. We were very lucky that we stopped and found the coolant running out. Otherwise the engine might have seized at highway speed , causing an accident. We lost all coolant and car was hauled…
On Sept 8, 2021, on I-5, North of Marysville, WA, a truck threw a rock through the lower radiator of our X1. We were very lucky that we stopped and found the coolant running out. Otherwise the engine might have seized at highway speed , causing an accident. We lost all coolant and car was hauled to BMW, Seattle on 9/9/21. On 9/10 service rep Josh Logan advised: "We confirmed that it does not come with a guard, but when you order a new part, that does come in conjunction." and that: "no warranty coverage, as it does not cover damages, so you would have to go through your insurance for that one." We did so and USAA covered the amount above the $1000 deductible. It is unacceptable that the need for the rock shield was clearly a known condition, yet when damage occurred due to it not being installed from new, that the replacement was not covered under warranty.
- Air bags · Seat belts
I was in a front end crash at approximately 30 to 35 miles per hour and airbags did not deploy nor did the seatbelt lock. My chest hit the steering wheel and I was transported by EMS to hospital. Nothing was broken. I had a bruise upper right chest but my pain is in my sternum which is not visibly…
I was in a front end crash at approximately 30 to 35 miles per hour and airbags did not deploy nor did the seatbelt lock. My chest hit the steering wheel and I was transported by EMS to hospital. Nothing was broken. I had a bruise upper right chest but my pain is in my sternum which is not visibly bruised but is very sore and my activity and mobility is impaired. My radiator was busted and car was towed by local police department to tow yard which is where it is right now. Soon to be moved to a repair center as the police report becomes available. It has not been inspected at this point. Just want to make the issue known.
- Unknown or other
The trunk cover has pieces of either plexi or fiber glass that gets into your skin. I have gotten tiny shards of the glass in my skin and it become unimaginably painful and it IS very hard to get out of the skin.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009005The End of life or Emergency call system error Check Control message appears in the vehicle. The following fault memory entry is stored: B7F341 Emergency battery: Hardware faulty
- 10249435Customer complains of a musty odor or damp front footwell carpet.
- 10249027The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints.
- 10249023Customer states one of the front seats is inoperative. The seat heater and power supply are inoperative. During the vehicle test, the seat module does not respond. The power supply fuse for the seat module isfound to have blown.
- 10247578When using the Key Reader to retrieve CBS information from the customer key, no current vehicle data is available, or the data does not match the maintenance schedule.
- 10247576Customer states one of the front seats is inoperative. The seat heater and power supply are inoperative .During the vehicle test, the seat module does not respond. The power supply fuse for the seat module is found to have blown.
- 10247567Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
- 10245422Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicles equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. Additionally, the red anti-theft alarm LED in the interior mirror does not briefly flash every 2 seconds, indicating the alarm is armed.
- 10245377When using the Key Reader to retrieve CBS information from the customer key, no current vehicle data is available, or the data does not match the maintenance schedule.
- 10245376The steering wheel heating takes a long time to achieve the desired temperature.
- 10245372The paint finish on the door jamb (above the door striker) is scratched due to the inner door cavity window seal.
- 10245368Vehicle exhibits a slight acceleration delay when taking off from a MSA (automatic engine start-stopfunction) stop.
- 10244242Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints.
- 10238090After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails.
- 10238081Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
- 10235205The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
- 10235192The buttons on the gear selector switch (GWS) do not work, or the function indicator lighting has failed.
- 10235183While driving on rough roads, a knocking sound can be heard coming from top of the instrument panel (aka dashboard) in the bulkhead area.
- 10228428During load reversal or taking off from a stop, there is a creaking or droning noise heard from the lower engine area.
- 10228427During a vehicle inspection and/or while addressing a customer's concern, the engine stabilizer bar/link appears to be worn.
- 10218420The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via Voice over LTE (VoLTE) function. For this purpose the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
- 10215752The following complaints may be noticed while slow maneuvering with a steering input of 80-100% (at or near full lock, e.g., parking lot maneuvers) or accelerating with a medium to large steering angle: Humming or creaking noises from the rear area, slight vibrations also noticeable from the driver's seat. The vehicle may also jerk slightly.
- 10214989Mist formation on the windshield inside surface may occur at departure or after MSA (automaticstart/stop). Acoustic abnormality in the area of the recirculated air flap (recirculation flap closing and opening severaltimes). The above may occur individually or in combination.
- 10212796The Check Control message "Door open" appears in the instrument cluster (Kombi) even though all vehicle doors are closed and locked. The locking operation of the doors is not affected.
- 10212525Customer complains of musty odor or damp front footwell carpet.
- 10206685Any or all of the following CCM ID code 14/15/16/17 "door open" appear in the instrument cluster when the door is properly closed and locked. The locking operation of the door is not affected by the incorrect display.
- 10204657Different air temperatures are felt from left to right out of the front fresh air grilles (air vents).
- 10202472The contactless tailgate opening/closing function (Smart Opener) is inoperative.
- 10201145Different air temperatures are felt from left to right out of the front fresh air grilles (air vent). The following fault code is saved in the IHKA (integrated automatic heating/air conditioning system) control unit: 801189 - Engine mixed air right: Initialization fault.
- 10200487TELEMATICS UNIT DEACTIVATION DUE TO 3G CELLULAR TECHNOLOGY DISCONTINUATION: The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule) can no longer be supported by the cellular network provider starting February 2022.
- 10200246Customer states the Central Information Display is flickering and the picture is shifting.
- 10188941DOOR PAINT STREAKS: Streaks are found running mostly vertically down along the door outer skin from the lower window trim. This can affect any of the 4 side doors.
- 10184587Water Ingress In Footwell Area From A/C Condensate Drain: Water Ingress In Footwell Area From A/C Condensate Drain. Customer complains of musty odor or damp front footwell carpet.
- 10184584Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full: Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full.There are no faults stored in the system for the washer fluid level switch.
- 10182921CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. During assembly, the cover of the fresh air intake was not fully seated when the screws were tightened. This cover can then leak condensation out through the existing gap.
- 10182920BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and cooling properly. A/C compressor, or The power supply to the A/C compressor is too low.
- 10182622CONDENSATION FROM AIR CONDITIONING LEAKS INTO PASSENGER FOOTWELL: Condensation from the air conditioning systems evaporator drips, below the instrument panel, into the passenger's footwell. During assembly, the cover of the fresh air intake was not fully seated when the screws were tightened. This cover can then leak condensation out through the existing gap.
- 10182621BUZZING NOISE IS HEARD WHEN AIR CONDITIONING IS DEACTIVATED: A buzzing noise is heard when the air conditioning (A/C) is deactivated while the vehicle is in park or neutral. Prior to turning off the A/C, the system was functional and cooling properly. A/C compressor, or The power supply to the A/C compressor is too low.
- 10181224SERVICE ACTION - PROGRAM THE BODY DOMAIN CONTROL (BDC) UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On-Board Diagnostic (OBD) socket. The DSC data is not processed correctly in the BDC and therefore cannot transmit any diagnostic requests via the OBD using aftermarket scan tools.
- 10179813DELIVERY STOP - OBD ACCESS IN DSC CONTROL UNIT: Aftermarket scan tools cannot read fault codes in the Dynamic Stability Control (DSC) unit via the On Board Diagnostic (OBD) socket. The DSC data is not processed correctly in the BDC and therefore cannot transmit any diagnostic requests via the OBD using aftermarket scan tools.
Every BMW X1 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.