2007 Chevrolet Aveo
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Aveo › 2007
These records cover every 2007 Chevrolet Aveo. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2007 Chevrolet Aveo. Newest first.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Risk and remedy
Risk
If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
On certain passenger vehicles equipped with a 1.6L engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. in addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the ground.
Risk and remedy
Risk
If these conditions occurred in an actual crash, a vehicle fire could occur.
Remedy
Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. the recall began on november 16, 2006. owners may contact chevrolet at 1-800-630-2438.
Owner complaints
216 complaints25 involved a crash13 involved a fire25 injuries2 deaths
What owners report most
Latest complaints
- Air bags
The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy…
The airbag warning light has remained illuminated since I acquired the vehicle in January 2025. The warning light stays on continuously and does not reset. This indicates a fault in the airbag system, and I have been advised that when this light is on, the airbags may be disabled and may not deploy in a crash. The vehicle has also experienced ongoing electrical problems, including lighting failures, blown fuses, and shift-interlock malfunctions, which suggests an electrical system fault affecting multiple safety-related systems. These issues create concern that the airbag control system may be impacted by the same electrical malfunction. The vehicle has not been repaired or diagnosed by a dealer for the airbag issue. The condition is still present and the warning light remains illuminated. This failure creates a serious safety risk because the airbags may not function in the event of a collision.
- Air bags · Electrical system · Exterior lighting
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving…
While driving, the vehicle began experiencing repeated electrical failures including blown fuses, inoperative headlights and brake lights, and the transmission becoming locked in PARK. When the fuse blows, the gear shift cannot be moved out of PARK and the ignition key cannot be removed, leaving the vehicle stuck and unable to be driven or safely turned off. The brake lights and daytime running lights also stop working, making the vehicle unsafe to operate in traffic. This condition has been occurring repeatedly and requires frequent fuse replacement just to move or shut off the vehicle. An emergency override hole on the shifter had already been exposed, indicating the problem existed before and the vehicle was previously being forced out of PARK manually. A tow truck driver had to use this override to move the vehicle. The airbag warning light is also illuminated, indicating the safety restraint system may not function properly in a crash. These failures create a serious safety risk due to loss of exterior lighting, inability to shift, inability to turn the ignition off, and possible airbag malfunction. This failure is consistent with a known defect involving the Daytime Running Light (DRL) module overheating and causing electrical shorts, as documented in manufacturer recall and technical service bulletins for this vehicle. The problem has been reproduced multiple times and remains unresolved.
- Fuel system, gasoline
The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart…
The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.
- Air bags
The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with…
The contact owns a 2007 Chevrolet Aveo. The contact stated while starting the vehicle, the driver’s side front air bag sensor warning light illuminated. The contact took the vehicle to an independent mechanic who inspected the vehicle and completed a diagnostic test which displayed a failure with the front driver’s side air bag. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately of 52,000.
- Electrical system · Engine · Exterior lighting
Out of no where it cought on fire
- Engine
TL* the contact owns a 2007 chevrolet aveo. The contact stated that while driving at an undisclosed speed, the vehicle shuddered with the check engine warning light illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to an…
TL* the contact owns a 2007 chevrolet aveo. The contact stated that while driving at an undisclosed speed, the vehicle shuddered with the check engine warning light illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to an unknown engine cylinder failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 96,000.
- Air bags · Exterior lighting · Fuel/propulsion system
I have problems with whenever I go to put gas in my car, some of it goes on the ground. not all of the gas goes on the ground, but a little less than half of what I purchased. my headlights are so dim that I can't hardly see when I'm driving at night. Also, my passenger side air bag light IS…
I have problems with whenever I go to put gas in my car, some of it goes on the ground. not all of the gas goes on the ground, but a little less than half of what I purchased. my headlights are so dim that I can't hardly see when I'm driving at night. Also, my passenger side air bag light IS constantly on? There's one there and nothing bigamy wrong with it that I can see. the stereo.....only the driver side front speaker works, the other three doesn't work at all....please look into these few things or give me some sort of idea of what I can do
- Exterior lighting
Vehicle headlights failed. Car was parked in the driveway. An hour later when it was started again, the headlights failed to come on and remain inoperable. Bulbs, switch, and relay have all been checked and verified to be operable.
- Air bags
"Takata recall" I bought my car in 2009. About 6 months later the airbag light came on and the dealer went out of business. When I checked the vin number it was not among the many, many aveos tagged for recall to replace faulty airbag systems. And I'm not alone. Complaints keep piling in from aveo…
"Takata recall" I bought my car in 2009. About 6 months later the airbag light came on and the dealer went out of business. When I checked the vin number it was not among the many, many aveos tagged for recall to replace faulty airbag systems. And I'm not alone. Complaints keep piling in from aveo owners about the airbag safety lights that never turn off, nearly catching up with 20 years of "complaints involving takata inflators..." my car was parked when an individual backed into my passenger door. The collision was so severe the door had to be replaced. Yet it triggered no airbags. Did you know while the airbag light IS engaged, the car cannot be sold? You think this might be due to the fact that it indicates a serious problem with the airbag system - that most prominent feature in aveo's highly touted "5-point" safety rating? So what's its rating without airbags? Or do we need a higher body count before the makers and safety regulators are willing to talk about that? Need we really toil with the question about why america lost its place in the auto industry? We need go no further than right here.
- Fuel/propulsion system
Tamara recall my car combusted into frames after being wrecked into a curve of last year of june.
- Exterior lighting
Recall for daylight running lights over heating didn't apply to my particular car, but seems to be a problem in my car regardless. Ground wires in my headlight assembly have fried and left scorch marks on headlight connection. No actual fire yet just a melted plastic under the hood. Not sure if my car IS invalid as have been fixed or just not covered but in either case part IS failing.
- Electronic stability control (esc)
Blows a fuse and will not come out of park
- Air bags · Unknown or other
1. Airbag readiness light remains on for duration of vehicle's operation. 2. Driver side inside door latch IS cracked and will not open door.
- Electrical system · Exterior lighting
TL* the contact owns a 2007 chevrolet aveo. When the contact pulled in the driveway and attempted to turn off the vehicle, the electrical power shut off. As a result, the contact was unable to roll the windows up or down, unlock the door with the switch, and the key would not turn to the off…
TL* the contact owns a 2007 chevrolet aveo. When the contact pulled in the driveway and attempted to turn off the vehicle, the electrical power shut off. As a result, the contact was unable to roll the windows up or down, unlock the door with the switch, and the key would not turn to the off position in the ignition. The dealer was not contacted. The manufacturer was contacted and stated that the vehicle was not included in nhtsa campaign number: 14v261000 (exterior lighting). The vehicle was not repaired. The approximate failure mileage was 120,000.
- Vehicle speed control
TL* the contact owns a 2007 chevrolet aveo. While attempting to park the vehicle, it independently accelerated uphill. The contact stated that the failure recurred twice. The vehicle was taken to an independent mechanic, but the failure was not determined. The local dealer was not contacted. The manufacturer was notified of the failure and provided case number: 8-3467846222. The failure mileage was unknown.
- Exterior lighting · Seat belts
TL* the contact owns a 2008 chevrolet aveo. The contact stated the seat belt warning light illuminated and the wires for the parking lights were burnt. The contact took the vehicle to an independent mechanic who replaced the vehicle's front light assembly. The dealer was not contacted. The…
TL* the contact owns a 2008 chevrolet aveo. The contact stated the seat belt warning light illuminated and the wires for the parking lights were burnt. The contact took the vehicle to an independent mechanic who replaced the vehicle's front light assembly. The dealer was not contacted. The manufacturer was not made aware of the failure. The contact stated that the failure was related to nhtsa campaign number: 14v261000 (exterior lighting) however, the vin was not included. The approximate failure mileage was 120,000.
- Electrical system
TL* the contact owns a 2007 chevrolet aveo. While the vehicle was parked or while driving, a burning electrical odor was detected in the vehicle. There were no warning indicators illuminated. The vehicle was taken to an independent mechanic, but the cause of the odor could not be determined. The…
TL* the contact owns a 2007 chevrolet aveo. While the vehicle was parked or while driving, a burning electrical odor was detected in the vehicle. There were no warning indicators illuminated. The vehicle was taken to an independent mechanic, but the cause of the odor could not be determined. The contact was referred to an electrical specialist by the independent mechanic, but the vehicle was not diagnosed due to the diagnostic fees. The contact stated that the independent mechanic advised her to disconnect the vehicle's battery. The contact researched the issues online and found nhtsa campaign number: 14v261000 (exterior lighting), but the vin was not included in the recall. The manufacturer was notified of the issue, confirmed that the vin was not included in the recall, and referred the contact to nhtsa. The approximate failure mileage was 120,000. updated 10/25/17*lj the consumer stated the vehicle was traded in. *js
- Air bags
Airbag light came on and has stayed on for 2 months. Unable to detect what IS wrong with electronic reader. Airbags are disengaged, and I can't find out why without paying more money than I have to spend because each component has to be checked, and that doesn't include actually fixing the problem…
Airbag light came on and has stayed on for 2 months. Unable to detect what IS wrong with electronic reader. Airbags are disengaged, and I can't find out why without paying more money than I have to spend because each component has to be checked, and that doesn't include actually fixing the problem, just figuring out what the problem IS. I've seen that many people have complained about this. Passenger airbag sensor started acting weird/ not working first. Occurred around 100 k miles. When will a recall happen? This IS apparently a common safety issue.
- Engine · Engine and engine cooling
TL* the contact owns a 2007 chevrolet aveo. While driving 55 mph, the accelerator pedal failed to operate and the gear failed to shift and went straight into neutral. The vehicle was towed to an independent mechanic where it was diagnosed that the coolant level sensor module needed to be repaired.…
TL* the contact owns a 2007 chevrolet aveo. While driving 55 mph, the accelerator pedal failed to operate and the gear failed to shift and went straight into neutral. The vehicle was towed to an independent mechanic where it was diagnosed that the coolant level sensor module needed to be repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 130,000.
- Steering
TL* the contact owns a 2007 chevrolet aveo. While driving approximately 35 mph, the steering column seized without warning. The vehicle was manually restarted and the steering operated normally. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 127,429.
- Air bags
The air bag warning light came on while driving 20mph while turning and has never went off (started around 125,000miles). I took it to the local mechanic, he checked wires and hooked it up to a diagnostic machine and believes it IS either the module or the sensor in the seat, but can't/won't give…
The air bag warning light came on while driving 20mph while turning and has never went off (started around 125,000miles). I took it to the local mechanic, he checked wires and hooked it up to a diagnostic machine and believes it IS either the module or the sensor in the seat, but can't/won't give an exact cause. when I tried to contact gm they kept saying I was just going off what the internet said and needed to see a dealer. just made it feel like that didn't care about my safety or the safety of any one in one of these vehicles. *tr
- Air bags
TL* the contact owns a 2007 chevrolet aveo. The contact stated that the air bag warning indicator illuminated the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 65,000. updated 05/04/17*lj *tr
- Air bags · Unknown or other
Takata recall my 2007 chevy aveo on 9/ 10 2016 wen I started it up the passenger side air bag light saying that the airbag IS off! Has just come on and will not go off! It IS on every time I start the car and wile driving it with or with out a passenger in it. this from what I have read on…
Takata recall my 2007 chevy aveo on 9/ 10 2016 wen I started it up the passenger side air bag light saying that the airbag IS off! Has just come on and will not go off! It IS on every time I start the car and wile driving it with or with out a passenger in it. this from what I have read on line means the air bag IS bad and will not deploy or will deploy for no reason there needs to be a recall I have read many post from others with this same problem in the 2007 chevy aveo please recall this car before someone IS killed!!!
- Unknown or other
Dashboard caught fire whilst car was parked for hours in secure parking lot. Car fire was put off by firefighters who cut battery and cables broke windows in order to stop fire. Now car does not turn on at all and dashboard center IS completely melted.
- Air bags
Light stay on always.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007116This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006682This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11006421GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
- 11004761This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 11004727This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 11000158This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.
- 11000119This service bulletin provides technicians with information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
- 10254240Information on COAX Repair Kit Availability.
- 10253770This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10251888This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250347This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle service record retention and proper handling of assembly returns for Canadian Dealers only.
- 10250013High Voltage Safety ? High Voltage Disabling
- 10249590This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249535This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248444Vehicle Recalls
- 10247716J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
- 10247715Terminal Test Probe And Replacement Terminal.
- 10247681Information On Requests To Add OnStar Bluetooth Option.
- 10247552This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
- 10247063A/C Blows Warm Or Poor Performance.
- 10247061J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
Every Chevrolet Aveo model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.