2008 Chevrolet Aveo
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Aveo › 2008
These records cover every 2008 Chevrolet Aveo. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2008 Chevrolet Aveo. Newest first.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Risk and remedy
Risk
If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Owner complaints
163 complaints17 involved a crash16 involved a fire19 injuries
What owners report most
Latest complaints
- Exterior lighting
The wiring to my headlights have overheated and melted twice. I found the really on the year and model of my car but wasn't on the list when I entered my vin
- Engine
California catalytic converter breaking
- Electrical system · Unknown or other
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely…
There was no prior warnings or notices that there was an issue. While diving on a major road with my children, smoke started coming into the cabin from the vents, and around the stereo. Luckily I was near a very vacant parking lot and immediately pulled over. I removed the kids from the car safely and did open the hood to try troubleshoot the problem. There was no smoke anywhere under the hood. Immediately after, sparks started falling from under the steering wheel to the gas pedal. Immediately after that the car was engulfed in flames. The car is currently located at my local police impound and is available for inspection upon request. From the time the smoke started to when the car was engulfed, it was approximately 5 minutes. This could have been dangerous had we been on a highway and unable to pull over and get out of the car safely within that time. It was only inspected briefly by the fire department who arrived to put out the fire and they reported it was an electrical issue that caused the fire.
- Engine · Power train
The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local…
The contact owns a 2008 Chevrolet Aveo. The contact stated that while driving approximately 15 MPH, the transmission became unbolted and separated from the vehicle. Additionally, the engine separated from the motor mounts rendering the vehicle undrivable. The vehicle was later towed the local mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 121,000.
- Power train
The left side mount-to-mount bracket bolt broke when accelerating normally from a stop. This is one of the bolts that holds the engine to the frame. This caused my shift stick to be thrown back on every acceleration. This is an obvious safety risk. I have not yet had this problem verified or confirmed by anyone. The car seemed to drive well and normal before and up to this incident.
- Air bags › Sensor › Occupant classification › Status indicator lamp/light
The contact's son owns a 2008 Chevrolet Aveo. The contact stated that while her son was driving at an undisclosed speed, the passenger's side air bag warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable.
- Electrical system
In-dash clock module contains the vehicle 'Check Engine Light' - required to pass inspection. Solder joints are defective ('cold' or cracked) creating intermittent electrical connections. Prevents warning of engine defects to driver. Solder defects eventually cause destruction of the module incurring unreimbursed denial of transport and expense to driver to repair.
- Exterior lighting
The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to…
The contact owns a 2008 Chevrolet Aveo. The contact stated that the vehicle was parked and had the headlights illuminated. The contact's wife went to start the vehicle and turned off the lights when smoke began to emit from the dashboard and the engine compartment. The contact was able to disconnect the battery and the smoke had stopped. The contact stated no warning lights were illuminated. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 14V261000 (EXTERIOR LIGHTING) however the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was informed of failure and told the contact that they were able to assist but would not without the contact having computer access. The failure mileage was approximately 110,000.
- Engine · Vehicle speed control
TL* the contact owns a 2008 chevrolet aveo. The contact stated that the vehicle started losing motive power and decelerated however, the vehicle did not stall. The contact pulled over and waited for the vehicle to regain full power. The failure recurred intermittently. The vehicle was diagnosed by…
TL* the contact owns a 2008 chevrolet aveo. The contact stated that the vehicle started losing motive power and decelerated however, the vehicle did not stall. The contact pulled over and waited for the vehicle to regain full power. The failure recurred intermittently. The vehicle was diagnosed by an independent mechanic however, the cause of the failure was not determined. The vehicle was not repaired. Neither a dealer nor the manufacturer were made aware of the failure. The approximate failure mileage was unknown.
- Air bags
2008 chevy aveo sedan - [xxx] - airbag warning light remains on at all times - no body codes are present / detected - (using foxwell elite nt630 scanner which claims to read / clear airbag codes) - I've already researched this issue - "mucho problemos" - with over half of all chevy…
2008 chevy aveo sedan - [xxx] - airbag warning light remains on at all times - no body codes are present / detected - (using foxwell elite nt630 scanner which claims to read / clear airbag codes) - I've already researched this issue - "mucho problemos" - with over half of all chevy aveo complaints including airbag warning light remains on. it's most likely either the clock module - which passes the passenger side airbag signals to the main srs controller, the srs controller module (located under center shift console area) or the passenger side airbag itself - code scanner only sees passenger side airbag stage 2 - (no stage 1 seen) ... Driver's side shows both stage 1 and stage 2 ... all pretensioners are proper (2 ohms circuit resistance) ... Battery strong / good / new - 1 year old - 13.5 volts - I'm worried dealer (hawthorne chevrolet - hawthorne nj) will actually not know the extensive issue with chevy aveo airbag warning light coming on - and will wrongly diagnose and try to charge big bucks - and problem will return - this IS a safety issue - since with airbag warning light staying on - srs airbag system will not operate, no airbag protection - I have also now contacted chevrolet on this subject / problem - waiting for their reply - located in northern nj - hawthorne chevrolet would be the proper dealership - (i purchased the car there - 10 years ago - they have serviced the car for routine repairs) ... will be contacting them on this srs airbag warning light problem - but worried they are not really knowledgeable on it ... there should be a recall on this problem - srs / airbag warning light staying on - safety related failure - chevy knows about this by now for sure - information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *tr
- Electrical system › Wiring › Interior/under dash · Exterior lighting
TL* the contact owned a 2008 chevrolet aveo. While driving 20 mph, smoke entered the cabin of the vehicle from under the steering panel. The contact was able to safely exit the vehicle. The fire department was called and was able to extinguish the fire. A fire report was filed. There were no…
TL* the contact owned a 2008 chevrolet aveo. While driving 20 mph, smoke entered the cabin of the vehicle from under the steering panel. The contact was able to safely exit the vehicle. The fire department was called and was able to extinguish the fire. A fire report was filed. There were no injuries sustained. The vehicle was towed to a salvage yard. Prior to the fire, the vehicle was taken to an independent mechanic due to an abnormal chemical odor in the vehicle. The contact was informed to lubricate the wires in the instrument panel, remove the fuses from the fuse panel, and do the same with the proper di-electric grease. The contact stated that the vehicle caught fire before performing the lubrication. The vehicle was included in nhtsa campaign number: 14v261000 (exterior lighting). The dealer and manufacturer were not contacted. The vehicle was destroyed. The approximate failure mileage was 124,000.
- Engine · Power train
TL* the contact owns a 2008 chevrolet aveo. While driving approximately 15 mph, the vehicle shut off without warning. The vehicle restarted and was taken to antelope valley chevrolet (877-385-0885, located at 1160 motor ln, lancaster, ca). The dealer replaced the throttle body. The contact also…
TL* the contact owns a 2008 chevrolet aveo. While driving approximately 15 mph, the vehicle shut off without warning. The vehicle restarted and was taken to antelope valley chevrolet (877-385-0885, located at 1160 motor ln, lancaster, ca). The dealer replaced the throttle body. The contact also stated that the vehicle lost power in the middle of traffic. The contact shifted into park, shut off the engine, and restarted the vehicle. When the vehicle was in park, the engine revved and jerked when it was shifted into drive. The contact stated that the failure recurred several times, but the vehicle restarted each time. The vehicle was taken to an independent mechanic who replaced the throttle body again, but the failure recurred. The manufacturer was made aware of the failures and stated that there was no recall. The vehicle was not repaired. The failure mileage was approximately 50,000.
- Electrical system · Engine
TL* the contact called on behalf of their mother who owned a 2008 chevrolet aveo. The contact stated that while the driver was driving approximately 35 mph, a white smoke was present coming from the rear of the vehicle and the instrument gauges began to malfunction. The engine rpms violently…
TL* the contact called on behalf of their mother who owned a 2008 chevrolet aveo. The contact stated that while the driver was driving approximately 35 mph, a white smoke was present coming from the rear of the vehicle and the instrument gauges began to malfunction. The engine rpms violently increased and decreased. The hazards were engaged and moments later smoke was scene coming from under the hood of the vehicle. After stopping and exiting the vehicle, flames were seen coming from under the vehicle and from under the hood. The fire department was called to the scene and extinguished the flames. During the incident the vehicle was destroyed. A fire report was taken at the scene. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not notified. The vin was not available. The failure mileage was 124,000.
- Air bags · Electrical system · Engine
Car shutoff while driving
- Air bags
Airbag light IS on, has been on when I bought the car from the dealer, said passenger side airbag fuse was bad, needed replaced. noted that the passenger on/off will at random turn on or off or not even show at times, I have also noted the seat making some sort of noise when turning the car on.
- Engine
Somewhere in between the 81,100 - 81,300 miles mark my vehicle has received the check engine light p2135 code, for throttle/pedal sensor/switch a / b voltage correlation. At the time of receiving the code I did not notice anything irregular until I researched the problem. One of the symptoms being…
Somewhere in between the 81,100 - 81,300 miles mark my vehicle has received the check engine light p2135 code, for throttle/pedal sensor/switch a / b voltage correlation. At the time of receiving the code I did not notice anything irregular until I researched the problem. One of the symptoms being, revving of the engine when gas pedal IS not pressed. That's when I realized my car had been doing that just recently on start up before receiving the code. Finally after about a month, driving very minimally maybe 10 shorts trips or less, the car stalled out after approximately 0.1 miles of below 15mph driving. I got out and checked under the hood and I didnt see anything wrong so I began to push the car back home. After I realized it would take some maneuvering I decided to try starting the car backup and it did so I quickly turned it around and drove it back home. Stalling of the engine IS also a symptom of the p2135 code. Since than out of necessity I've driven the car twice for 13 mile trips without stalling out but the check engine light has not gone away. The engine still revs on its on start up until finally settling into consistency. After trying to figure out what exactly needs replacing online, it appears evident to me that a large amount chevy aveos no matter the year or specific model, encounter this problem. It's just a matter of how many owners talked about the problem online and reported it. Those who have taken it online fixed the problem by cleaning the throttle body, which only lasted for so long and could result in damage or getting a whole new throttle body assembly with a new throttle position sensor attached.
- Unknown or other
"Takata recall" I was traveling along the garden state parkway northbound when my car stopped accelerating. I pulled over to the shoulder the car completely shut off and caught on fire. The whole car went up into flames while I was still in the car and was able to jump out of the passengeer side door. The car IS totaled.
- Air bags
"Takata recall" the airbag light IS illuminated and never goes out. always on.
- Electrical system · Exterior lighting
Chevrolet 4 door aveo. The passenger rear taillight won't work, the left side works, was looking it up and people was saying that they were having the same problem. The fusebox under the hood wires, need to splice wires electrical problem.
- Power train · Structure › Body › Trunk lid
TL* the contact owns a 2008 chevrolet aveo. While driving at unknown speeds, the trunk lid opened independently. Additionally, the gear shifter failed to engage in gear. There were no warning indicators illuminated. The local dealer and manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was 64,000. *js
- Air bags
Air bag passenger light comes on and multiple times repair shop clears it, stays off for a bit, then comes back on, been told nothing wrong with it.
- Electrical system › 12v/24v/48v battery › Cables · Electrical system › Wiring › Fuses and circuit breakers
TL* the contact owns a 2008 chevrolet aveo. While the air conditioner was activated, the vehicle stalled. When the brake pedal was depressed, the vehicle also stalled. Furthermore, the tire pressure warning indicator illuminated. The vehicle was taken to an independent mechanic where it was…
TL* the contact owns a 2008 chevrolet aveo. While the air conditioner was activated, the vehicle stalled. When the brake pedal was depressed, the vehicle also stalled. Furthermore, the tire pressure warning indicator illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the fuse box was melted. The contact was referred to the local dealer. The vehicle was towed to grey chevrolet (4949 hovde rd, port orchard, wa 98367, (800) 803-8091) where it was diagnosed that the positive battery cable and underhood bussed electrical center fuse box needed to be replaced. The vehicle was repaired. The manufacturer was notified and referred the contact to nhtsa. The failure mileage was 67,396. *js
- Air bags
TL* the contact owns a 2008 chevrolet aveo. While operating the vehicle, the air bag warning indicator remained illuminated. The failure was not diagnosed or repaired. The local dealer (frank bashay in racine, wi) was notified of the failure. The manufacturer was not notified. The vin was not available. The failure mileage was 70,000.
- Air bags
Airbag indicator has disappeared from dashboard. the airbag on/off symbol IS no longer illuminated on my dash and my airbag warning light has turned on. it started as the airbag on/off light would sometimes be illuminated, and sometimes not be illuminated, and now the indicator IS completely gone (never shows on or off).
- Electronic stability control (esc)
The ABS light goes on and off and at times has a hard time stopping. also my doors will lock by them self.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007116This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
- 11007095This bulletin provides information on the TOP TIER Detergent Gasoline Licensed Brands and the TOP TIER Diesel Fuel Licensed Brands that are recommended for use in all GM vehicles and the TOP TIER FUELS website URL.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006682This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11006421GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
- 11004761This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 11004727This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001325This warranty administration bulletin provides policy information to cover GMs policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 11000160This service bulletin provides information on proper use of floor mats.
- 11000158This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.
- 11000119This service bulletin provides technicians with information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
- 10254240Information on COAX Repair Kit Availability.
- 10253770This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
- 10253632Rear and Side Tempered Glass Spots.
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10251888This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250505This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
- 10250347This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle service record retention and proper handling of assembly returns for Canadian Dealers only.
- 10250013High Voltage Safety ? High Voltage Disabling
- 10249590This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249535This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248493Bluetooth Stays Connected After RAP Is Canceled.
- 10248492Bluetooth Stays Connected After RAP Is Canceled.
Every Chevrolet Aveo model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.