2023 Ford Bronco
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Bronco › 2023
These records cover every 2023 Ford Bronco. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
18 recalls name the 2023 Ford Bronco. Newest first.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Risk and remedy
Risk
A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy
Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Risk and remedy
Risk
A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy
Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Risk and remedy
Risk
Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy
Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Risk and remedy
Risk
A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy
The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Risk and remedy
Risk
A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy
Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk and remedy
Risk
An electrical short circuit can increase the risk of a fire.
Remedy
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated December 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Risk and remedy
Risk
An engine stall increases the risk of a crash.
Remedy
Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.
Risk and remedy
Risk
Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to…
Risk and remedy
Risk
A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy
The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Risk and remedy
Risk
An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.
Remedy
Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco 4-door vehicles. The left-side rear door may be opened from the inside of the vehicle when the child safety lock is in the "ON" position.
Risk and remedy
Risk
A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.
Remedy
Dealers will inspect the child safety locks and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S15.
Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco and Bronco Heritage vehicles. The rear quarter glass panels may have been improperly installed to the vehicle hard top, which can allow them to detach.
Risk and remedy
Risk
Detached rear glass panels may create a road hazard and increase the risk of a crash.
Remedy
Dealers will inspect and reinstall the rear glass panels on Bronco vehicles. On Bronco Heritage vehicles, dealers will replace the rear left-hand removable quarter glass panel. Repairs will be performed free of charge. Bronco owner notification letters were mailed June 6, 2024. Bronco Heritage owner letters were mailed June 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S10.
Ford Motor Company (Ford) is recalling certain 2023 Bronco vehicles. The transmission park system may have been damaged during assembly, which can prevent the parking pawl from fully engaging and result in a vehicle rollaway.
Risk and remedy
Risk
A vehicle rollaway can increase the risk of a crash.
Remedy
Dealers will replace the transmission, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S44.
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard…
Risk and remedy
Risk
An overloaded vehicle increases the risk of a crash.
Remedy
Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk and remedy
Risk
Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.
Remedy
Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.
Ford Motor Company (Ford) is recalling certain 2023 Bronco and Ranger vehicles. The lug nuts on the driver's side wheels may have been improperly tightened.
Risk and remedy
Risk
Loose lug nuts may result in wheel detachment while driving, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect, and if necessary, retighten the lug nuts, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S17.
Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.
Risk and remedy
Risk
A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to…
Risk and remedy
Risk
The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy
Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Owner complaints
230 complaints6 involved a crash3 involved a fire3 injuries
What owners report most
Latest complaints
- Unknown or other
Infotainment screen went entirely black, causing a driver distraction and making vehicle features inaccessible. Rear camera works. Identical to current APIM overheating recall. Carson city ford has been unable to diagnose issue claiming software glitch or corruption. Dealer asking for out of pocket…
Infotainment screen went entirely black, causing a driver distraction and making vehicle features inaccessible. Rear camera works. Identical to current APIM overheating recall. Carson city ford has been unable to diagnose issue claiming software glitch or corruption. Dealer asking for out of pocket cost to “repair” with no resolution 4 days later while vehicle has been at dealer. This is a manufacturing issue causing consumer safety liability. Ford is responsible for cost and repair.
- Electrical system
After rainfall, my 2023 Ford Bronco would not start. The dealership (Stivers Ford Lincoln, Waukee, IA) diagnosed water intrusion behind the dashboard that corroded the body connector electrical harness and Body Control Module (BCM). A warranty claim (#109441186) was submitted to Ford and denied on…
After rainfall, my 2023 Ford Bronco would not start. The dealership (Stivers Ford Lincoln, Waukee, IA) diagnosed water intrusion behind the dashboard that corroded the body connector electrical harness and Body Control Module (BCM). A warranty claim (#109441186) was submitted to Ford and denied on the basis that the affected component was not listed under a current Special Service Message or Technical Service Bulletin. The vehicle was subsequently taken to a second Ford dealership (Dewey Ford) for a second opinion. That dealership identified the root cause as an inadequate factory seal between the dashboard and the wiring harness, allowing water to repeatedly enter the electrical system — consistent with Ford's own Special Service Message 53814 and Technical Service Bulletin 21-2403/22-2074, which document water intrusion at the A-pillar/windshield header area on 2021-2024 Bronco vehicles. This is also consistent with NHTSA Recall 25V546/Ford 25C43, in which Ford recalled 2024-2025 Mustang vehicles for water intrusion into the Body Control Module caused by improperly sealed body seams. Repair costs for this failure were quoted at approximately $8,400. Ford ultimately agreed to a partial goodwill adjustment, but I was required to pay a significant amount out of pocket for a failure I believe stems from a factory sealing defect rather than normal wear or owner-caused damage. I am filing this complaint because this appears to be part of a broader, recurring pattern of water-intrusion-related electrical failures on the Bronco platform that has not yet been addressed by a formal recall.
- Structure
The contact owns a 2023 Ford Bronco equipped with an aftermarket Bestop Skyrider retractable rooftop, Part Number: 5246217. The contact stated that while driving, the mounting bolts on the roof loosened up. The contact was concerned that the rooftop might detach and fly off while driving at highway…
The contact owns a 2023 Ford Bronco equipped with an aftermarket Bestop Skyrider retractable rooftop, Part Number: 5246217. The contact stated that while driving, the mounting bolts on the roof loosened up. The contact was concerned that the rooftop might detach and fly off while driving at highway speeds. The contact stated that water was entering the vehicle from the rooftop. The contact was concerned that water leaking into the vehicle could cause damages to the air bag system. The manufacturer and service center were notified of the failure. The aftermarket top was replaced, and the factory roof was reinstalled.
- Power train
Transmission failed while towing in Neutral Flat Tow mode and destroyed the entire transmission resulting in a $7,600 repair bill. Ford will not warranty this as they claim is was might fault. Not true, I had flat towed the vehicle for months without an issue and its their electronic system that failed and destroyed my transmission.
- Unknown or other
My 2023 Ford Bronco is experiencing cracking and delamination on its Molded-in-Color (MIC) hardtop roof. [ADD A SENTENCE HERE DESCRIBING YOUR SPECIFIC DAMAGE, E.G., The cracks are visible on the exterior corners / The roof is beginning to leak water into the cabin].This structural failure matches…
My 2023 Ford Bronco is experiencing cracking and delamination on its Molded-in-Color (MIC) hardtop roof. [ADD A SENTENCE HERE DESCRIBING YOUR SPECIFIC DAMAGE, E.G., The cracks are visible on the exterior corners / The roof is beginning to leak water into the cabin].This structural failure matches the exact defect described in Ford's May 2026 recall for 2021–2022 models. Ford has excluded the 2023 model year from the recall, claiming a manufacturing change fixed the issue, but the root material defect and the resulting safety risks—potential roof panel structural failure, pieces detaching at highway speeds, or water intrusion damaging electrical components—are identical. I am requesting that NHTSA investigate and force Ford to expand the recall parameters to include 2023 models.
- Back over prevention · Engine and engine cooling
The contact owns a 2023 Ford Bronco. The contact stated that the vehicle experienced an issue with the rearview camera while in use. The contact received a notice for NHTSA Campaign Number: 26V124000 (Back Over Prevention), and the recall repair was subsequently performed. However, after the recall…
The contact owns a 2023 Ford Bronco. The contact stated that the vehicle experienced an issue with the rearview camera while in use. The contact received a notice for NHTSA Campaign Number: 26V124000 (Back Over Prevention), and the recall repair was subsequently performed. However, after the recall repair was completed, a new 'overheating' warning appeared on the infotainment system. The vehicle was returned to the dealer, where technicians tested the system and confirmed that during a single operation, the system's temperature spiked from 93°F to 150°F. The contact confirmed that they received an overheating warning on the infotainment system display. The manufacturer has been notified of the failure, but the vehicle has not yet been repaired. The failure mileage was 32,752.
- Steering
The steering rack on my 2023 Ford Bronco Outer Banks failed at approximately 23,000 miles. This caused my steering wheel to lock up and become very difficult to turn, especially while making turns. The dealer confirmed that the steering rack failed and needed to be replaced. They performed the repair. There were no other warning lights or indicators.
- Visibility/wiper
Rear defroster connector becomes detached from the defroster grid rendering it inoperable. Ford has acknowledged it is a common issue due to poor design. My local dealership repaired the broken tab and it once again broke off within a week or two. When I returned to the dealership, they refused to…
Rear defroster connector becomes detached from the defroster grid rendering it inoperable. Ford has acknowledged it is a common issue due to poor design. My local dealership repaired the broken tab and it once again broke off within a week or two. When I returned to the dealership, they refused to cover it under the vehicles original owner warranty or their labor warranty for working on it previously. After some back and forth with management and Ford Customer Care, they told me they have changed the design of the entire rear glass and the only way to fix it would be to pay $1600~ to have it replaced with the updated design. Upon researching the issue online, it is clear that the rear defroster has an astonishingly high failure rate, and Ford should be pushed to offer a better solution than to charge owners to fix something that was sold to them defective. To learn more about this issue, simply search “Bronco Rear Defroster” and you will see the amount of owners complaining
- Power train
We sometime have loss of drive power while driving or a total failure to engage a gear. Happens sometimes when moving from a stop sign or stop light. Like the transmission is slipping in def case.
- Structure › Body · Unknown or other
Cracking of the roof which has caused leaks. Common issue for Broncos, but only recalled for 2021-2022 Broncos. My Bronco is 2023 and has the same issue. It should also be a recall.
- Structure › Body
Front roof panel is cracking and chipping. Rear roof panel is cracking around the side windows. Bronco is never in direct sunlight unless driving. And the vehicle is never driven off-road.
- Unknown or other
When making a right turn with the turn signal on, as you complete the turn and straighten the steering wheel the left turn signal turns on as the right turn signal turns off. This is intermittent and occurs when turning from a complete stop or a turn while moving. This is very unsafe as it looks…
When making a right turn with the turn signal on, as you complete the turn and straighten the steering wheel the left turn signal turns on as the right turn signal turns off. This is intermittent and occurs when turning from a complete stop or a turn while moving. This is very unsafe as it looks like your making a quick left after completing your right turn to the driver behind you. This has happened many times over the last couple of months so I don’t have a date of incident but it happened 6 times while running errands on 8/29. Lafontaine Ford has had my vehicle in service all day today, 9/1, without resolution.
- Unknown or other
On XXX, our 2023 Ford Bronco, VIN [XXX], was stopped on an incline. The vehicle was not moving, and the driver exited the vehicle believing it was in Park. The vehicle was actually still in Drive. A passenger remained in the vehicle. While the Bronco was stationary, the passenger pressed the…
On XXX, our 2023 Ford Bronco, VIN [XXX], was stopped on an incline. The vehicle was not moving, and the driver exited the vehicle believing it was in Park. The vehicle was actually still in Drive. A passenger remained in the vehicle. While the Bronco was stationary, the passenger pressed the START/STOP button from the passenger seat to turn the vehicle off. Immediately after the vehicle was switched off, it began rolling backward down the incline. The passenger was unable to safely stop the vehicle and attempted to exit the moving Bronco. The open vehicle door struck the passenger in the back of the leg/hip area. The passenger had to throw herself to the ground to avoid being dragged, run over, or more seriously injured. The Bronco went off a significant drop off and crashed into a tree. The passenger narrowly escaped the vehicle before it went over the drop off. After the incident, the vehicle displayed a "Park Aid Fault" warning. Ford's 2023 Bronco Owner's Manual states that a "Transmission Not In Park (P)" audible warning is supposed to sound if the vehicle is switched off before being shifted into Park and also if the driver's door is opened before the vehicle is shifted into Park. [IF TRUE: We do not recall hearing a Transmission Not In Park warning before the rollaway.] I am concerned that the vehicle remained stationary on the incline while still in Drive, creating the appearance that it was secured, but began rolling backward when the START/STOP button was pressed. I am also concerned about whether the transmission-not-in-park warning, braking/holding systems, ignition system, and related safety systems functioned as designed. The unexpected rollaway resulted in an injury and created an immediate risk of the passenger being crushed, dragged, or run over. I request that NHTSA investigate whether this vehicle's behavior and warning systems operated as designed and whether this represents a potential vehicle safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.
- Steering
Steering rack component failure, vague steering, play during steering directional change, Light grinding noise when turning steering wheel.
- Structure › Body
The MIC hardtop is bubbling some at the top and has a line where it looks like perhaps it is assembled on the back panel over the top that is discolored in comparison to the rest of the top. Furthermore, the middle panel is a different color than the rest of the hardtop. It is available for…
The MIC hardtop is bubbling some at the top and has a line where it looks like perhaps it is assembled on the back panel over the top that is discolored in comparison to the rest of the top. Furthermore, the middle panel is a different color than the rest of the hardtop. It is available for complete inspection upon request. The car has not been inspected by dealer but was bought used and did not show the bubbling whenever it was purchased--but rather it has happened in the months since it was purchased. It was found when the top was removed and the bubbling was noticeable when running my hand over it. Note that it is not visible to be seen via picture, and the bubble must be felt. It cannot be seen in a photo.
- Steering
I was going really slow down an easy dirt road in 4L and all of the sudden the steering wheel spun violently two full turns left in under a second on its own. This threw my right arm off the wheel where it hit the shifter with force leaving a large bruise. Steering system fault warning appeared…
I was going really slow down an easy dirt road in 4L and all of the sudden the steering wheel spun violently two full turns left in under a second on its own. This threw my right arm off the wheel where it hit the shifter with force leaving a large bruise. Steering system fault warning appeared, the tire position on the camera screen was stuck all the way left, and i could no longer disconnect my stabilizer bar. i turned the car off for 5 minutes then back on and everything was fine. If this steering glitch happened at highway speeds I could have rolled the car and dies. Luckily i was going really slow on a relatively smooth part of the trail when this occurred and it only shook me and my passengers up a little and bruised my arm. If the trail had been more steep or if there were rocks on the trail, this could have flipped my vehicle.
- Structure › Body
The MIC hard top component on my Ford Bronco is cracking. I have gotten it replaced twice through Ford for the same issue, but now this is my 3rd top and the issue keeps coming back.
- Power train
2023 Ford Bronco with 7 speed manual transmission. The transmission started grinding while shifting into 3rd gear and occasionally popping out of 3rd gear. This mostly occurred while upshifting and rarely while downshifting. All other gears are operating as normal. While the grinding problem would pop up occasionally around the 40,000 mile mark, it became chronic at 58,000 mile mark (24Jun2026)
- Unknown or other
After making a right hand turn, when the steering wheel recenters for some unknown reason it is turning on the left turn signal. I had noticed it in the past and thought I was wrong, but it continuing to do it.
- Service brakes
TOTAL BRAKE FAILURE IN 2023 BRONCO. What happened is exactly what is described for current recall of the electronic brake booster for 2025 broncos. Mine is a 2023.
- Lane departure › Blind spot detection
Camera and sensor on driver side does not indicate movement/stops working. This results in the Blindspot detection not working or any cross traffic alerts or object detection, which can lead to an accident. occurs intermittently and car does not issue a warning that the system is not working or down. Also causing an issue when backing up
- Steering · Suspension
-Complete steering and suspension failure occurred while driving on highway. Vehicle is currently sitting at Ford dealer. - The safety of all passengers was put at risk and nearly caused a fatal accident. -Dealer and another shop are saying it was lower control arm and bushing failure. They are…
-Complete steering and suspension failure occurred while driving on highway. Vehicle is currently sitting at Ford dealer. - The safety of all passengers was put at risk and nearly caused a fatal accident. -Dealer and another shop are saying it was lower control arm and bushing failure. They are unclear on path forward for repairs and it seems like something bigger is going on they do not want to disclose. They deny problem has been reproduced on this model, however a similar recall for this type of failure has occurred on other bronco models under recall number 26S36. That recall report matches what happened to my vehicle. -It has been inspected by Ford and Bronco Barn in Las Vegas. I will be getting a third opinion for a clear path forward since none has been supplied by ford or the third party company. -There were no warning lamps, check engine lights, or messages prior to failure. There was a slight misalignment of tires felt while driving just prior to losing full steering control.
- Structure › Body
Delamination of roof and cracking with leaks
- Firerelated · Fuel system, gasoline
The contact owned a 2023 Ford Bronco. The contact stated that while her boyfriend was driving at an undisclosed speed, the vehicle made an abnormal noise. The contact's boyfriend had pulled over. They discovered an unknown fluid leaking under the vehicle and a spark coming from the engine before…
The contact owned a 2023 Ford Bronco. The contact stated that while her boyfriend was driving at an undisclosed speed, the vehicle made an abnormal noise. The contact's boyfriend had pulled over. They discovered an unknown fluid leaking under the vehicle and a spark coming from the engine before the vehicle caught fire. There were no injuries were sustained. The firefighters arrived and extinguished the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. Upon research, the contact related the failure to the fuel injector. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 10,000.
- Engine · Fuel/propulsion system
My husband was sitting at a stop light when he noticed what appeared to be steam/smoke coming out from under the hood of the Bronco. Then smoke came into the vehicle through the air vents. When he looked up, flames were coming out from under the hood. He got out and the whole front of the car burst into flames and torched the car.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011954Some 2021-2024 Bronco vehicles equipped with a 2.3L/2.7L engine may exhibit a loud front end clink/clunk noise that leads to the identification of a cracked or broken front differential frame mount bracket.
- 11011953Some 2021-2024 Bronco vehicles equipped with a factory subwoofer may exhibit a rattle from right loadspace trim panel at high audio system volumes.
- 11011813Some 2021-2023 Bronco vehicles equipped with a 2.7L EcoBoost engine may exhibit an illuminated MIL with DTC P0456 stored in the PCM.
- 11011091Quality improvements: -Enhances vehicle's center screen stability -Latest security enhancements
- 11010950Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs. Various vehicles equipped with a 2.7L or a 3.0L gas engine may require a crankshaft bolt replacement during repairs.
- 11010799Some 2022-2024 Bronco vehicles built on or before 13-Feb-2024 equipped with a 3.0L EcoBoost engine and 2021-2024 Broncos equipped with a 2.3L EcoBoost engine may exhibit an illuminated MIL with ignition system DTCs P0352, P0353, P0354, P0355, P2303, P2306, P2309, P2312, P2304, P2307, P2310, and/or P2313 set in the PCM.
- 11010033Quality Improvements: - Customer should be able to enable and disable Intelligent power toggle button. -Adresses SYNC reboots and improves the vehicle's conectivity with the user's phone
- 11009835Quality improvements include: -Robustness action to reduce the false window bounce back occurrences.
- 11009445Some 2018-2024 F150/Edge, 2018 MKX, 2019-2023 Nautilus, 2020-2025 Explorer/Aviator, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L EcoBoost or a 3.0L EcoBoost engine may exhibit an engine oil leak from the crankshaft rear seal with retaining plate.
- 11009438Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed.
- 11008948While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
- 11008921Some 2021-2024 Bronco vehicles equipped with a factory soft top roof and built on or before 14-Jul-2024 may experience snow or sand accumulation on the vehicles interior during a strong storm with high winds. To correct this condition, follow the Service Procedure to retrofit the soft top assembly.
- 11008702Some 20212024 Bronco and 2024 Ranger vehicles may exhibit a loss of driver's door switch pack control along with any of the following symptoms: * inability to open or close the windows * driver's window switch not working or not working intermittently * cannot fold or unfold the side mirror * cannot adjust the side mirror in any direction * diagnostic trouble code (DTC) B1087:87 stored in the driver's door module (DDM) and/or the passenger door module (PDM) * DTC U2013:23 stored in the DDM and/or PDM
- 11008677Quality improvements include: -Robustness action to enhance the Connectivity, Networking and Cellular Data Services and power management. -Ensuring reliable functionality of Stolen Vehicle Services.
- 11007977Some 2020-2024 Explorer/Aviator/Corsair, 2021-2024 F-150/Bronco, 2023-2024 F-Super Duty, and 2024-2025 Nautilus vehicles may experience the overhead console sunglass bin cannot be locked in a closed position.
- 11007908Some 2021-2024 Bronco may exhibit the upper rail front trim panel with an excessive gap. This may be due to the misalignment of the upper rail front trim panel.
- 1100787220212024 Bronco, 2024 Ranger - Door Window Switch Inoperative With DTC B1087:87 And/Or U2013:23
- 11007144Quality Improvements include: - Addresses potential vehicle no start after OTA update. - Improved Phone as A Key functionality post Enhanced Central Gateway module (ECG) reset. - Minor quality fixes in Enhanced Central Gateway module (ECG) Software, not affecting vehicle operation.
- 11007141Quality Improvement include: -Update to Enhanced Central Gateway (ECG) module software to prevent battery draining when vehicle is parked.
- 11006879Some 2021-2024 Bronco vehicles may exhibit a rattle from the front windows with the windows placed in the partially down position and driving over rough roads and/or bumps.
- 11006779This article supersedes 24-2186 to update the model years affected. Some 2021-2023 Bronco vehicles equipped with a factory soft top roof may exhibit a headliner that is detaching from the soft top material. This may be due to the factory installation process. To correct this condition, follow the Service Procedure to reattach the headliner or replace the soft top roof material.
- 11006443Some 2020-2024 F-150, 2021-2024 Bronco, and 2024 Ranger vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to a stuck internal component of the variable cam timing (VCT) unit.
- 11006016Quality improvements include: - Robustness action to correct Phone as a Key Feature cease. -Numerous minor quality fixes in ECG Software, not affecting vehicle operation. - Improves connectivity
- 11005837Some 2021-2024 Bronco/F-150 (non-Lightning) vehicles may exhibit a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is fully operational and there are no diagnostic trouble codes (DTC) stored related to the charging system. This may be due to the customer using an aftermarket programmer to change body control module (BCM) configuration.
- 11005749Some 2023 Bronco vehicles equipped with a B & O sound system built on 15-Jun-2023 and through 21-Jul-2023 may exhibit a pop sound originating from the vehicle's speakers when the door(s) are opened to enter the vehicle. This may be due to the software in the digital signal processing module (DSP).
- 11005698Some 2021-2024 Bronco vehicles may require servicing of the interior door handle lock cable mounting bracket on the interior door handle. The interior door handle cable mounting bracket, base part number 78219A64 (right) and 78219A65 (left), are now available to service separately from the cables and latch mechanisms. It is no longer necessary to replace the complete latch assembly for a damaged interior door handle lock indicator mounting bracket.
- 11005694Some 2021-2024 Bronco vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC)s P0096 and/or P007B stored in the powertrain control module (PCM) which may be more prevalent in high ambient air temperatures. For vehicles that meet this criteria, inspect the front of the vehicle for the presence of an aftermarket bumper and/or accessories which may restrict air flow to the charge air cooler and surrounding sensors. Remove the aftermarket accessory and return the vehicle to stock and reevaluate. If the concern returns with the stock bumper/accessories removed, proceed to normal Workshop Manual diagnostics.
- 11003144Some 2021-2024 F-150/Bronco and 2023-2024 Escape/F-Super Duty vehicles built with SYNC 4 require a connected phone with Android Auto or Apple CarPlay active to enable voice interactions and use of the steering wheel voice control button. This is due to the affected vehicles not having built in voice interactions capability. Vehicles with built in voice interaction capability can be identified as also being equipped with the built in connected navigation feature which includes a navigation tab on the center display screen. Diagnostics should only be performed for voice interactions on vehicles equipped with built in voice interaction capability or with Android Auto or Apple CarPlay active.
- 11001584This article supersedes 24-2080 to add 2024 model year vehicles. Some 2021-2024 Bronco vehicles equipped with a factory soft top roof may exhibit a headliner that is detaching from the soft top material. This may be due to the factory installation process. To correct this condition, follow the Service Procedure to reattach the headliner or replace the soft top roof material.
- 11001112Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent system reboots. - Intermittent Wireless CarPlay or Android Auto function. - Phone related concerns with intermittent No Audio or Static. - Navigation/global positioning system (GPS) related concerns through CarPlay and Android Auto. - Alexa function consistency and stability. These symptoms may be due to the software in the APIM. Replacing the APIM will not resolve these symptoms for the customer. Before returning the vehicle to the customer, review the procedures within Workshop Manual, Section 415-00 and ensure the latest APIM software is installed. Refer to General Service Bulletin (GSB) 23-7146 for help determining the latest available level of software. IMPORTANT: some module software updates will only display as available on Ford Diagnosis and Repair System (FDRS) after prerequisite modules are updated. This may require the technician to update certain modules multiple times during the service visit, before the latest APIM software is accessible in FDRS. If symptoms continue after latest APIM software has been installed, inform customers that Ford is working on additional software enhancements which are expected to be delivered over-the-air (OTA) by Q4 2024 on F-150, F-150 Lightning, Mustang Mach-E, Mustang, Escape, Corsair, Expedition, Navigator, Bronco, Mustang, and 2023-2024 F-Super Duty. Software will update automatically if vehicle connectivity is enabled in the vehicle's settings. For all other vehicles with SYNC4, schedule a service visit for customers in October 2024, when the updated APIM software is expected to be available to dealers. Monitor OASIS for additional information.
- 11000848'Quality improvements include: -Fix the vehicle battery drain issue due to the Key-Off Load caused by the Instrument Cluster Panel staying on.
- 11000555Some 2021-2024 Bronco vehicles may exhibit paint wearing along on the top inner edge of the tailgate where the rear window weather strip contacts the tailgate. This may be due to the accumulation of dirt between the rear window seal and tailgate. Inform customers that engineering is aware of this condition and is currently working on a solution which is expected in Q3 2024. Schedule a service visit for customers when the repair is available in Q3 2024. Monitor OASIS for additional information.
- 11000299Some 2021-2024 Bronco vehicles equipped with a factory soft top roof may experience snow or sand accumulation on the vehicles interior during a strong storm with high winds. Inform customers that repair kits are currently on backorder and are expected to be available Q3 2024. Schedule a service visit for customers when the repair is available in Q3 2024. Monitor OASIS for additional information.
- 10254319Quality improvements include: -Fix the infrequent random audio noises issue and improve the audio quality of the vehicle
- 10254159Some 2021-2023 Bronco vehicles equipped with a 2.7L or 3.0L engine may exhibit an illuminated MIL with DTC P25B4, P25B6, and/or P0299 stored in the powertrain control module (PCM). This may be due to a loose nut on the turbo actuator arm causing an under boost condition
- 10254138All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
- 10254136Some 2021-2024 Bronco vehicles may experience a repeat loss of window initialization which results in a loss of short drop and/or one-touch up and one-touch down feature operation. This may be due to a recent short drop enhancement that is contained in the driver door module (DDM) and passenger door module (PDM) software. To correct this condition, update the DDM and PDM to the latest software levels then download and run the Loss Of Power Window Initialization Concern application using Ford Diagnosis and Repair System (FDRS). When prompted by the application for a password, use DSPWR-308. If the vehicles DDM and PDM had software part numbers ending with CN or CR when it arrived, advise the customer that the vehicle will no longer exhibit a short drop event to all door windows anytime the vehicle is unlocked using the remote keyless entry (RKE), accessory keyless entry keypad, or the interior door unlock switch.
- 10254122Some 2020-2024 F-150 and 2021-2024 Bronco vehicles equipped with a 2.7L or 3.0L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. This may be due to a stuck internal component of the variable cam timing (VCT) unit. To correct the condition, replace all 4 of the VCT units following Workshop Manual (WSM), Section 303-01. For claiming, use causal part 6C525 and applicable labor operations in Section 6 of the Service Labor Time Standards (SLTS) Manual. If labor times are not available, claim M-time.
- 10253892Some 2022-2024 Bronco Raptor vehicles may exhibit an intermittent no crank/no start/discharged battery due to the presence of a parasitic battery drain. This may be due to the instrument panel cluster (IPC) software.
- 10253890This article supersedes TSB 23-2400 to update the parts list. Some 2021-2023 Bronco vehicles may encounter a Sta-bar Disconnect Service Required message in the instrument panel cluster and an illuminated warning light with diagnostic trouble codes (DTCs) stored in the chassis control module (CHCM)
Every Ford Bronco model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.