2025 Ford Bronco
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Bronco › 2025
These records cover every 2025 Ford Bronco. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
19 recalls name the 2025 Ford Bronco. Newest first.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.
Risk and remedy
Risk
A short circuit in the engine compartment can create heat or spark, increasing the risk of a fire.
Remedy
Dealers will install sheathing over the wiring, free of charge. This is a Phased campaign. Phase 1 will include 2026 Bronco Raptor notified owners on 7/31/2026. Phase 2 will include 2021-2025 Bronco Raptor vehicle will notify owners on or about 8/14/2026. Phase 3 will include 2021-2026 Bronco will notify owners on or about 9/1/2026. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S55. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 23, 2026.
Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.
Risk and remedy
Risk
A detached fender flare can become a road hazard and increase the risk of a crash.
Remedy
Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Owner notification letters were mailed September 1, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Risk and remedy
Risk
A sudden loss of drive power can increase the risk of a crash.
Remedy
Dealers will replace the engine long block, free of charge. Owner notification letters were mailed October 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.
Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.
Risk and remedy
Risk
A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.
Remedy
Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford’s number for this recall is 26S30. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning April 30, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.
Risk and remedy
Risk
Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.
Remedy
Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.
Risk and remedy
Risk
An unexpected loss of drive power increases the risk of a crash.
Remedy
Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.
Risk and remedy
Risk
A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy
The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Risk and remedy
Risk
An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy
Dealers will replace the electronic brake booster, free of charge. Owner notification letters were mailed February 26, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco and Bronco Sport vehicles. The Instrument Panel Cluster (IPC) may fail at startup.
Risk and remedy
Risk
An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.
Remedy
The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC3.
Ford Motor Company (Ford) is recalling certain 2025 Bronco and Ranger vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Risk and remedy
Risk
In the event of a crash, windshield detachment can increase the risk of injury.
Remedy
Dealers will remove and replace the windshield, free charge. Owner notification letters were mailed October 20, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 14, 2025.
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Risk and remedy
Risk
An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy
The EBB module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed on August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S77.
Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The active vent flap on the passenger side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk and remedy
Risk
An air bag that does not deploy as intended increases the risk of injury during a crash.
Remedy
Dealers will replace the passenger air bag module, free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C27.
Ford Motor Company (Ford) is recalling certain 2025 Bronco four-door vehicles. The left-hand rear door may be able to be opened from inside the vehicle when the child safety lock is in the "ON" position.
Risk and remedy
Risk
A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.
Remedy
Dealers will inspect and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S64.
Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco vehicles. The front lower control arm fasteners may not have been tightened properly, allowing the control arm to detach from the frame.
Risk and remedy
Risk
A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the lower control arm fasteners are tightened properly. If a fastener is loose or missing, the dealer will replace the fastener. Repairs will be performed free of charge. Owner notification letters were mailed June 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S48.
Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco and Ranger vehicles. The front upper control arm ball joint fastener may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.
Risk and remedy
Risk
A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy
Dealers will inspect and tighten, or replace the ball joint fastener as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S45.
Ford Motor Company (Ford) is recalling certain 2025 Ranger and Bronco vehicles. The bolts that secure the driver's seat frame to the body may be loose or missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems."
Risk and remedy
Risk
A seat with loose or missing fasteners may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy
Dealers will inspect the seat fasteners and tighten or install new fasteners as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C16.
Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The front upper control arm ball joint nut may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.
Risk and remedy
Risk
A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly. Repairs will be performed free of charge. Owner notification letters are expected to be mailed in April 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S40.
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Risk and remedy
Risk
Unexpected vehicle movement increases the risk of a crash.
Remedy
Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Ford Motor Company (Ford) is recalling certain 2024 Ranger, and 2024-2025 Bronco vehicles. The front upper control arm ball joint nut may not have been installed or tightened properly, allowing the front upper control arm to detach from the knuckle assembly.
Risk and remedy
Risk
A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy
Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly as necessary, free of charge. Owner notification letters were mailed on November 20, 2024. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S64.
Owner complaints
56 complaints5 involved a crash2 involved a fire2 injuries1 deaths
What owners report most
Latest complaints
- Electrical system · Visibility/wiper
The tubes running along the roof line according to my service report could not handle the heavy rain and was the resulted in a heavy stream of water inside my vehicle while driving. The water "backfilled" into the cabin through dome light just behind the sunglasses holder. Incident occurred on…
The tubes running along the roof line according to my service report could not handle the heavy rain and was the resulted in a heavy stream of water inside my vehicle while driving. The water "backfilled" into the cabin through dome light just behind the sunglasses holder. Incident occurred on October 1, 2026 while I was driving with my two children in the vehicle. The incident was witnessed by the construction manager over seeing the construction of our home. There was so much rain inside the vehicle that it soaked my pants, my seat, the carpet, ran down the navigation screen into the cup holders and warped my dash. I wash my vehicle 2 to 3 times a week and have never had an issue with the roof leaking until driving in this storm. When I arrived home I lifted the t-top on the drivers side and there was no water in the weather stripping. I did take my vehicle to the dealer and was told this is a "common issue" with Broncos, for the tubing to wear out and that it and the electrical would be replaced. The dealer did not inspect the tubes or the electrical components in the over head compartment. They reported that several trips through the car wash did not result in a leak and that the tubes "may have been too much water for drain tubes to keep up and it over flowed into the cab." I had limited visibility with a faucet style stream of water pouring into my lap a I drove. I am concerned the wet electrical components will cause a fire.
- Electrical system
The contact owns a 2025 Ford Bronco. The contact received recall service at the local dealer under NHTSA Campaign Number: 26V468000 (Engine, Electrical System). The contact's daughter drove the vehicle to the residence and parked it inside the garage. The contact's daughter heard a noise coming…
The contact owns a 2025 Ford Bronco. The contact received recall service at the local dealer under NHTSA Campaign Number: 26V468000 (Engine, Electrical System). The contact's daughter drove the vehicle to the residence and parked it inside the garage. The contact's daughter heard a noise coming from the garage, investigated, and discovered the engine had erroneously activated and was running. At the time of discovery, the keys were hanging on the wall, and the mobile phone was charging, unused. The contact indicated that the failure created a severe carbon monoxide poisoning hazard. The vehicle was returned to the dealer; however, the dealer was unable to duplicate the failure. The manufacturer was notified of the failure. The failure mileage was 13,192.
- Electrical system · Fuel/propulsion system · Vehicle speed control
Instrument Cluster screen blank on start up so vehicle does not show Speedometer, gear selection, RPM, fuel gauge, lane keeping selection, and adaptive cruise control selection/engagement. Vehicle however would start up and remain drivable. Instrument cluster screen return to its normal state of…
Instrument Cluster screen blank on start up so vehicle does not show Speedometer, gear selection, RPM, fuel gauge, lane keeping selection, and adaptive cruise control selection/engagement. Vehicle however would start up and remain drivable. Instrument cluster screen return to its normal state of his morning after leaving vehicle turned off overnight. This occurred on one other occasion back in May 2026 shortly after purchasing the vehicle. This was only this second instance of this happening since receiving the vehicle in May 2026. I have attached a picture showing both instances. I believe there where previous Bronco models recalled for a similar issue, but don’t believe my model/VIN was included in that recall.
- Electrical system
Summary: Software bug incorrectly shows hood to be unlatched; the alert covers important driver information on gauge cluster and can not be dismissed. Issue is 100% reproduceable. - With vehicle off, open hood (maintenance, inspection, etc) - Start vehicle - Close hood - Drive vehicle A false 'hood…
Summary: Software bug incorrectly shows hood to be unlatched; the alert covers important driver information on gauge cluster and can not be dismissed. Issue is 100% reproduceable. - With vehicle off, open hood (maintenance, inspection, etc) - Start vehicle - Close hood - Drive vehicle A false 'hood open' alarm will be triggered and it can not be dismissed. If driving, and unable to stop, audible alarm will continue, and visual alert obscures cluster information. Alarm an not be dismissed, paused, or simple acknowledged. Dismissing the false alert requires shutting the vehicle off, which can be dangerous if the driver has already entered a busy road.
- Electrical system · Forward collision avoidance › Automatic emergency braking · Service brakes
I purchased a 2025 Ford Bronco Outer Banks to flat tow behind my motorhome. Ford dealership in [XXX] said the Bronco can be flat towed and I reviewed the owners [XXX] , regarding flat towing, with the dealership prior to purchase. I went to a reputable hitch installer to add a demco/Air Force one…
I purchased a 2025 Ford Bronco Outer Banks to flat tow behind my motorhome. Ford dealership in [XXX] said the Bronco can be flat towed and I reviewed the owners [XXX] , regarding flat towing, with the dealership prior to purchase. I went to a reputable hitch installer to add a demco/Air Force one braking system. We went on a 3 month trip out west and followed the directions in the Ford owners [XXX] to flat towing. Unfortunately while being towed the car came out of neutral tow 3 times while and there is no warning system to alert us when this happens. It cannot be felt or detected in our 44 ft coach. Luckily kind strangers saw our rear tires dragging and smoking and signaled to us. The last time we were on I55 near [XXX]. This was quite frightening as this could have easily turned into an accident for us and others on the road. I was able to drive a nearby Ford dealership who assessed the damage. We were lucky that only the rear tires were badly damaged and Ford replaced them for free. It was only at this time that we learned Ford sends out bulletins to dealerships re: updates. Per the dealership a bulletin was sent out in March 2026 stating that fuses 28 and 29 needed to be pulled. I asked why owners do not receive these updates and the dealer did not know. So thereafter we pulled the two fuses and waited 5 min for the Bronco to go in sleep mode. Even after all this, the Bronco would come out of sleep mode at times (2x) while being towed. For our safety and others on the road, we stopped flat towing the Bronco and my husband drove the coach and I drove the Bronco back to our home in [XXX]. Ford does not have a consistent fix for this issue and it scares me that there will be a horrific accident at some point. We tried to tell Ford of this issue and looked into a buy back or lemon law;however, Ford denied any problems( but they did replace our rear tires for free). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Electrical system · Engine · Structure
The contact's wife owns a 2025 Ford Bronco. Upon taking delivery of the vehicle, the door stops on both rear doors began detaching and the plastic fender components fell off while the vehicle was parked. Additionally, the rear passenger’s side window intermittently failed to roll up. The contact…
The contact's wife owns a 2025 Ford Bronco. Upon taking delivery of the vehicle, the door stops on both rear doors began detaching and the plastic fender components fell off while the vehicle was parked. Additionally, the rear passenger’s side window intermittently failed to roll up. The contact then received notifications of NHTSA Campaign Numbers: 26V468000 (Engine, Electrical System) and 26V403000 (Structure). The vehicle was taken to the dealer for a wiring harness recall repair; however, the dealer stated that the fix was ineffective and too complex to perform. The manufacturer was notified of the issue and confirmed that parts were available; however, the vehicle was unrepaired. The failure mileage was approximately 500.
- Air bags · Seat belts · Suspension
Possible suspension on front driver side caused loss of control of vehicle and separation of front tire from body. Failure of front airbags to deploy despite impact, Recall of front seat or seatbelt entire malfunction caused ejection and death of driver.
- Electrical system · Engine
The contact owns a 2025 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.
- Forward collision avoidance › Automatic emergency braking
The contact owns a 2025 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, and the Forward Collision Avoidance Automatic Emergency Braking and several unknown warning lights illuminated. The vehicle was taken to the dealer several times…
The contact owns a 2025 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, and the Forward Collision Avoidance Automatic Emergency Braking and several unknown warning lights illuminated. The vehicle was taken to the dealer several times; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 14,000.
- Electrical system · Forward collision avoidance › Automatic emergency braking · Service brakes
Flat towing a 2025 Bronco behind a 2025 Newmar Dutchstar using a Blue Ox tow bar with Demco AirForce Braking System. Ford has a setting called neutral towing. It allows you to tow behind a motorhome with brake lights, braking, etc. When the Ford is in neutral tow, and in neutral gear, all 4 wheel…
Flat towing a 2025 Bronco behind a 2025 Newmar Dutchstar using a Blue Ox tow bar with Demco AirForce Braking System. Ford has a setting called neutral towing. It allows you to tow behind a motorhome with brake lights, braking, etc. When the Ford is in neutral tow, and in neutral gear, all 4 wheel roll freely and you can tow safely. What's happening is the Ford is waking up out of neutral tow when the 12V battery gets low. This isn't supposed to happen as there is a 7 Pin electrical connector from the motorhome to the 6 pin electrical connected to the Bronco. Once the 12v battery gets low, the Ford computer wakes up, see's it moving the back tow tires, so the system is applying the emergency brake locking up the 2 back tires. This has now happened three times as we have traveled from [XXX] to [XXX] (had it looked at Crossroads of Ford of Apex where I bought it). I took it in to Schmop Ford in Denver and after almost a deadly accident on XXX near [XXX], to XXX. They found the back two tires destroyed. Ford replaced the tires at no charge, but the issue remains. THIS SUV SHOULD NOT BE APPROVED FOR FLAT TOWING. It is dangerous and could be deadly. You have no way of knowing unless someone else tells you. Thanks to the stranger on XXX on XXX. They told us of our issue so we pulled over. If we were to continue driving the motorhome, the tires would've been totally destroyed, a fire, or cause us to flip over. There are so many complaints on the internet about this issue. You must make Ford fix this issue with a software fix immediately. Don't make my complaint for another unlucky traveler like myself. I have enclosed the back tire picture. You can see one tire with the tread completely gone, the other tire tread missing is not shown. You can also see how the tires are mis-shaped from rubbing across the highway cement. I AM TRYING TO UPLOAD PICTURES BUT YOUR SYSTEM IS GIVING ME AN ERROR FOR A JPEG LESS THAN 10MB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Seats
They have yet to repair this recall even though a remedy has been available. I have asked multiple times at my dealer and they always have a reason they can’t do it. They text me one time and never set the appointment. I have called and called and even went in. I asked at my oil change and at first…
They have yet to repair this recall even though a remedy has been available. I have asked multiple times at my dealer and they always have a reason they can’t do it. They text me one time and never set the appointment. I have called and called and even went in. I asked at my oil change and at first they said yes but then they said they couldn’t check because “it would take all day and they did not have the time”. I went in at 8:15 or 9:15am. I even called after I made my oil change appointment and verified on the phone they can check for the recall that day and they said yes. But changed it when I showed up. I haven’t heard back since then. Here is the recall information; Manufacturer Recall Number26S30 NHTSA Recall Number26V268 They also have yet to notify me of the second recall on the vehicle causing engine fires. I only found out because I have a news app and saw an article. I have the Ford app and it “alerts me to recalls” but I’ve found out about every recall from the news not Ford until months after. Why aren’t they notifying customers promptly?
- Unknown or other
2025 Ford Bronco Raptor right passenger fender flew off at highway speed on JUN 10, 2026 - took it to Ford for repair, repaired, and it has happened again today JUL 23, 2026; was able to reattach fender with clasps still in place; have also notified local Ford Dealership on issue again.
- Structure › Body
Bronco hard top is beginning to warp really bad and delaminate. Classic problem happening with there and ford still refuses to come up with a real solution. Every day the warping gets worse and I’m just waiting for it to get bad enough so I can take it in and ford actually do something about it.…
Bronco hard top is beginning to warp really bad and delaminate. Classic problem happening with there and ford still refuses to come up with a real solution. Every day the warping gets worse and I’m just waiting for it to get bad enough so I can take it in and ford actually do something about it. The warping and delaminating also impacts the seals of the hardtop panels on the car. The top also rattles really bad. Absolutely crazy for an expensive car. It’s very obvious that climate and humidity have the largest impact on this issue and STILL they do nothing about it.
- Electrical system
On June 22, 2026, my 2025 Ford Bronco caught fire while parked outside a store. The vehicle had been parked for approximately five minutes when the fire began. There were no warning lights, alerts, unusual odors, or other indications of a problem before the incident. The fire and heavy smoke…
On June 22, 2026, my 2025 Ford Bronco caught fire while parked outside a store. The vehicle had been parked for approximately five minutes when the fire began. There were no warning lights, alerts, unusual odors, or other indications of a problem before the incident. The fire and heavy smoke appeared to originate from the center console area near the gear shifter. The flames quickly spread throughout the driver’s side, center console, front passenger area, and the rest of the vehicle’s interior. The entire interior sustained severe fire and heat damage and was substantially melted. The responding fire department advised that temperatures inside the vehicle were well over 300 degrees. Firefighters disconnected the vehicle’s battery, after which the vehicle began to cool. Based on their initial observations, they indicated that the fire appeared to be electrical in nature. The vehicle had recently been filled with gasoline, which made the situation even more dangerous. Fortunately, no one was inside the Bronco, no other vehicles were parked nearby, and the fire department responded quickly. The vehicle has been transported to a repair facility but has not yet been inspected to determine the precise cause of the fire. I am extremely concerned that a nearly new vehicle could suddenly catch fire while turned off and parked, without any warning. This could have occurred while I was driving, with passengers inside, or while the Bronco was parked in my garage. Under those circumstances, the fire could have caused serious injury or death, destroyed my home, or endangered other people and property. I am submitting this complaint because I believe this incident presents a serious public-safety concern. I respectfully request that NHTSA investigate whether other 2025 Ford Bronco owners have experienced similar electrical fires and whether a defect exists that could place drivers, passengers, families, first responders, and the public at risk.
- Unknown or other
When the vehicle is in "Eco" mode, and an attempt is made to rapidly accelerate in an emergency situation, pressing the accelerator pedal to the floor results in a significant delay before *any* engine response is detected, far beyond what is reasonable for a normal gasoline powered vehicle. In…
When the vehicle is in "Eco" mode, and an attempt is made to rapidly accelerate in an emergency situation, pressing the accelerator pedal to the floor results in a significant delay before *any* engine response is detected, far beyond what is reasonable for a normal gasoline powered vehicle. In several situations, I was in heavy traffic; traffic in the lane in which I was travelling was relatively slow. I attempted to change lanes into an adjacent lane in which traffic was moving much faster. When traffic allowed, I merged into the faster lane, and pressed the accelerator pedal to the floor. Prior to pressing the accelerator pedal, the vehicle was moving approximately 20 mph. Nothing happened for several seconds, and then the vehicle suddenly accelerated. During the period of non-response, traffic in the faster lane caught up to my vehicle. I am able to reproduce the issue 100%. The dealer's response is that "it's normal" (typical service response) and there was no attempt to investigate. I have driven several identical make/model vehicles belonging to friends, and one dealer vehicle (test drive) and they all exhibit the same issue. There are no warning lamps, errors, codes, or any indication that any system is faulty. The high latency in the throttle control system is clearly an ECU programming issue, and it increases the risk of collision. I have only observed this issue in models of this vehicle with an automatic transmission. I do own an identical model of this vehicle with a manual transmission, and this issue is not present.
- Visibility/wiper
I have a 2025 Ford Bronco Big Bend with 5233 miles. The windshield wipers stopped working. I checked the fuse and the fuse was good. I changed the fuse anyway and the wipers still do not work.
- Service brakes
Its becoming more frequent and a huge safety issue. When you're driving the car, it feels like the emergency parking brake automatically engages. And when you push the brake pedal, it almost feels like it's dead, meaning there's no pressure back against your foot, which is really unusual for this…
Its becoming more frequent and a huge safety issue. When you're driving the car, it feels like the emergency parking brake automatically engages. And when you push the brake pedal, it almost feels like it's dead, meaning there's no pressure back against your foot, which is really unusual for this vehicle, period. You don't necessarily lose control of the car, but you certainly don't have complete control of the braking system, period. Then you are in a period of time to get off the road safely and turn the vehicle off and restart it. Then the system seems to correct itself, and you can drive away. But I'm concerned about this from a safety perspective,
- Visibility/wiper
Vehicle was parked in a secured location and the back windshield spontaneously broke more likely due to hot weather.
- Engine · Lane departure › Assist · Steering
Car would shut off shortly after using remote start on key fob then display a warning on digital instrument cluster for two days now. It would also show my speed going back and forth from 0 to 1mph while parked.
- Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings
The Pre-Collision Assist false-triggers on turns daily, flashing the red collision warning and actively applying autonomous emergency braking without any obstruction present. This phantom braking is a severe safety hazard. The vehicle has been serviced before for this issue - and is going back to the shop next week (for the same issue).
- Visibility/wiper
I am filing a safety complaint regarding repeated windshield cracking on my new 2025 Ford Bronco. I purchased the vehicle approximately 2 months ago. Since purchase, the vehicle has experienced 3 separate windshield cracks under normal commuting use only. The vehicle has not been used off-road or…
I am filing a safety complaint regarding repeated windshield cracking on my new 2025 Ford Bronco. I purchased the vehicle approximately 2 months ago. Since purchase, the vehicle has experienced 3 separate windshield cracks under normal commuting use only. The vehicle has not been used off-road or in extreme driving conditions. The most concerning issue is that after the windshield was replaced, the replacement windshield developed another crack within approximately 24 hours of installation. The dealership has repeatedly classified the damage as “normal road debris” or “rock impact,” but I am concerned this may involve a structural, installation, or manufacturing defect rather than ordinary wear and tear. My concerns are based on the following: Multiple windshield failures in a very short period of ownership Failure occurring on a brand-new replacement windshield within 24 hours Normal commuting use only Concern for stress-related cracking, improper installation, body/frame flex, or windshield mounting issues Potential safety hazard involving driver visibility and windshield integrity I am requesting investigation into possible manufacturing, installation, or structural defects involving windshield cracking or windshield mounting systems on the 2025 Ford Bronco. I am also aware of other Ford Bronco owner complaints involving repeated windshield cracking and windshield-related issues. This issue creates ongoing safety concerns due to impaired visibility and repeated glass failure in a nearly new vehicle.
- Engine
On [XXX] at [XXX] PM I was driving westbound on [XXX] at [XXX] while traveling through the intersection, my vehicle started shaking, lost acceleration, and nearly caused me to have a collision. My vehicles check engine light began flashing, and I was able to safely exit the highway. On May 20…
On [XXX] at [XXX] PM I was driving westbound on [XXX] at [XXX] while traveling through the intersection, my vehicle started shaking, lost acceleration, and nearly caused me to have a collision. My vehicles check engine light began flashing, and I was able to safely exit the highway. On May 20, 2026, Crouse Ford diagnosed a “cylinder #6”, however attributed the event as “an anomaly”, and no corrective action was taken despite the seriousness of the safety concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Structure › Body
This is in reference to Safety Campaign 26S32. My fiancé owns a 2025 Ford Bronco 5 door and her roof has the same exact issue that is described in this safety campaign. Before the vehicle had 5000 miles on it the roof had already begun to show cracks, honeycombing and is beginning to show signs of…
This is in reference to Safety Campaign 26S32. My fiancé owns a 2025 Ford Bronco 5 door and her roof has the same exact issue that is described in this safety campaign. Before the vehicle had 5000 miles on it the roof had already begun to show cracks, honeycombing and is beginning to show signs of delamination. The vehicle is going to our local dealer in a week to hopefully have the roof replaced under warranty but I doubt that permanently fixes the issue. Fords comment that they have resolved the issue is patently false. I will gladly send photos of the cracks as soon as possible but this safety campaign, in my opinion, should be extended to all of Broncos from 2021 to current.
- Power train
The contact owns a 2025 Ford Bronco. The contact stated while attempting to start the vehicle depressing the brake pedal, heard a clunking noise and on for second the vehicle attempts to move while in park. The contact mention he could hear clunking sound coming from the front of the vehicle. A…
The contact owns a 2025 Ford Bronco. The contact stated while attempting to start the vehicle depressing the brake pedal, heard a clunking noise and on for second the vehicle attempts to move while in park. The contact mention he could hear clunking sound coming from the front of the vehicle. A dealer was contacted. The vehicle was taken a dealer to be diagnosed, however the diagnoses was unknown. The vehicle was not repaired. The contact was relating the failure to NHTSA Campaign Number:25V164000 (Power Train), however the VIN was not included in the recall The manufacturer was not notified on the failure, and they informed him to take the vehicle to dealer. failure mileage was 2,200.
- Power train
After only 880 miles, the clutch and cylinder have failed.
Every Ford Bronco model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.