2022 Ford Bronco Sport
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Bronco Sport › 2022
These records cover every 2022 Ford Bronco Sport. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
15 recalls name the 2022 Ford Bronco Sport. Newest first.
Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.
Risk and remedy
Risk
A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk and remedy
Risk
An electrical short circuit can increase the risk of a fire.
Remedy
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated December 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A…
Risk and remedy
Risk
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk and remedy
Risk
An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy
Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Risk and remedy
Risk
Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy
Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Risk and remedy
Risk
An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy
Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Owner notification letters were mailed on April 24, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S16. This recall is an expansion of previous recall number 22V-859.
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Ford Motor Company (Ford) is recalling certain 2022 Bronco Sport vehicles. The fuel pump control module (FPCM) bracket may not be secured to the fuel tank assembly, which can lead to FPCM failure and cause an engine stall.
Risk and remedy
Risk
An engine stall can increase the risk of a crash.
Remedy
Dealers will replace the fuel tank, free of charge. Owner notification letters were mailed December 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S66.
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk and remedy
Risk
Flickering parking lights can reduce visibility, increasing the risk of a crash.
Remedy
Dealers will replace the LED Driver module, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C22.
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Risk and remedy
Risk
An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy
Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Risk and remedy
Risk
During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Remedy
Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.
Risk and remedy
Risk
An engine stall increases the risk of a crash.
Remedy
Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.
Owner complaints
370 complaints13 involved a crash13 involved a fire17 injuries
What owners report most
Latest complaints
- Engine · Fuel/propulsion system
I am experiencing a fuel smell in my vehicle when I cold start it in the morning. I took it to the dealership and they could not identify the smell but claimed that if I call Ford customer service they might be able to escalate the issue. Ford customer service just said there is nothing they can do…
I am experiencing a fuel smell in my vehicle when I cold start it in the morning. I took it to the dealership and they could not identify the smell but claimed that if I call Ford customer service they might be able to escalate the issue. Ford customer service just said there is nothing they can do until the recall Campaign 25S76 is done but it is currently on pause even though it was issued 7/16/25 and it is currently 10/23/26. I said that these is a safety issue since Ford has identified that it can lead to the engine igniting which has happened to 8 vehicles according to Ford. They said they recommend waiting for the recall to happen despite my safety concerns on a known flaw with the vehicle. No resolution or any type of compromise provided even though I can identify the fuel smell that they say is a sign of the fuel injector issue that should be fixed under customer satisfaction program Campaign: 22N18
- Fuel system, gasoline
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to complete the recall repair was not available. The local dealer was contacted several times and confirmed that the parts were unavailable.…
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to complete the recall repair was not available. The local dealer was contacted several times and confirmed that the parts were unavailable. The contact stated the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue.
- Unknown or other
I’m reporting that this vehicle has been under recall literally since I purchased it over 4 years ago. It has a potential fire issue with the fuel injector, which several trips to the dealership have not fixed it. Ford sends a letter out once a year and says they’ll let me know when they have a…
I’m reporting that this vehicle has been under recall literally since I purchased it over 4 years ago. It has a potential fire issue with the fuel injector, which several trips to the dealership have not fixed it. Ford sends a letter out once a year and says they’ll let me know when they have a fix. I keep a fire blanket stuffed into my glovebox and I’d like to know why over 4 years isn’t long enough to fix it! NHTSA Recall #25V467 This recall used to show up in my Ford app, but they removed it some time ago. Like that would fix the problem!
- Electrical system · Exterior lighting · Steering
Water is entering the vehicle and dripping onto the interior floorboards, particularly when the air conditioning is running.This has caused growth of mold and rust inside the vehicle. The vehicle has developed multiple dashboard warning lights, and the turn signals and windshield wipers have…
Water is entering the vehicle and dripping onto the interior floorboards, particularly when the air conditioning is running.This has caused growth of mold and rust inside the vehicle. The vehicle has developed multiple dashboard warning lights, and the turn signals and windshield wipers have stopped functioning. Most concerning, the steering wheel has locked while the vehicle was in motion, leaving me unable to steer even though the engine remained running.This created a serious and immediate safety hazard. The vehicle has since become inoperable and will no longer start. The source of the water intrusion and the underlying causes of the electrical and steering failures have not been confirmed. However, the combination of water entering the vehicle, multiple warning lights, loss of turn signals and windshield wiper operation, loss of steering control while the engine remained running, and the subsequent failure to start raises serious concerns about the vehicle’s safety and possible electrical system damage. I took the vehicle in for an inspection to determine the cause of these problems\. I was informed that diagnostic testing would cost approximately $250 per dashboard warning light, potentially exceeding $1,000 before the underlying problems could be identified. I have not received a confirmed diagnosis of the cause of these failures. The vehicle is available for inspection upon request. Given the loss of steering control while driving, the failure of essential safety-related components, the water intrusion, and the vehicle’s current inability to start, I am requesting a thorough investigation into the cause of these failures and whether they are related to a known vehicle defect. The vehicle should not be operated until the safety issues have been properly diagnosed and corrected.
- Power train
The rear drive unit (RDU) deteriorated at 78k miles. I began to notice a shudder during low-speed turns with high steering angle. Upon inspection, metallic flakes were discovered in the RDU’s fluid, apparently indicating mechanical degradation of the internal clutch packs. Two separate Ford…
The rear drive unit (RDU) deteriorated at 78k miles. I began to notice a shudder during low-speed turns with high steering angle. Upon inspection, metallic flakes were discovered in the RDU’s fluid, apparently indicating mechanical degradation of the internal clutch packs. Two separate Ford dealerships recommended complete RDU assembly replacement at a significant expense. I am concerned that an important drivetrain component could deteriorate this quickly, from normal driving use. I believe this could result in wheel drag/lockup or seizure while operating the vehicle. I have not experienced it yet and I’m not sure whether a total mechanical failure would cause it either. Ford has numerous technical service bulletins on this issue, so it is known to them (TSB 26-2328). I am currently waiting for a dealership to receive parts so that the RDU may be replaced.
- Engine · Power train
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at approximately 35 MPH, the vehicle failed to accelerate and lost motive power. The vehicle was towed to the dealer for inspection. The contact stated that the failure was related to the powertrain control module…
The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at approximately 35 MPH, the vehicle failed to accelerate and lost motive power. The vehicle was towed to the dealer for inspection. The contact stated that the failure was related to the powertrain control module (PCM). The dealer reportedly found a transmission failure, and the vehicle was not covered under warranty. The contact stated that there was sand and debris in the transmission. The vehicle had been driven on the beach. It was unknown whether any repairs were completed. The contact associated the failure with NHTSA Campaign Number: 24V267000 (Power Train). The manufacturer was notified by phone, and a case was filed. The failure mileage was approximately 46,580.
- Fuel/propulsion system
misfire from fuel injectors
- Power train · Unknown or other
Stripped differential. I was told by a service tech that the vehicle is safe to drive until it isn’t that Ford is aware but does not have a fix. It is available for inspection. The vehicle is getting worse, and I only drive short distances. Olathe Ford did the inspection. They will not give me a copy of the inspection. I have never received any warning lights whatsoever.
- Electrical system · Engine · Power train
after the dealership executed Safety Recall 25S76, the vehicle immediately began violently sputtering and surging on public roads, and the service department actively concealed the resulting diagnostic fault codes.
- Fuel/propulsion system
Formal Complaint: Unresolved Safety Hazard and Delayed Remedy (NHTSA Campaign 25V-467 / Ford Recall 25S76) I am writing to express severe concern regarding Ford Motor Company's ongoing failure to provide a permanent, physical fix for the cracked fuel injector fire hazard in my vehicle. Since the…
Formal Complaint: Unresolved Safety Hazard and Delayed Remedy (NHTSA Campaign 25V-467 / Ford Recall 25S76) I am writing to express severe concern regarding Ford Motor Company's ongoing failure to provide a permanent, physical fix for the cracked fuel injector fire hazard in my vehicle. Since the initial recall action in late 2022 (22V-859), Ford has repeatedly issued interim software updates and drain tubes rather than replacing the inherently defective hardware. It has been over four years without a definitive hardware remedy for a critical defect that carries a severe underhood fire risk. Driving a vehicle with a known fuel-leak fire risk without a permanent solution poses an ongoing safety hazard to myself and my family. I request that NHTSA compel Ford to expedite the production and distribution of replacement fuel injectors for all affected owners immediately.
- Fuel/propulsion system
Car has a recall that can’t be correctly repaired with no projected date for repair. Causing decreasing value of the car.
- Electrical system · Engine · Fuel/propulsion system
My 2022 Ford Bronco Sport exhibits severe engine knocking and low fuel pressure, which are primary symptoms of open safety recalls 24S16 and 25S76. On 9/29/26, Seelye Ford of Kalamazoo charged me $220.21 out-of-pocket for a powertrain recall system software update. They are now refusing to inspect…
My 2022 Ford Bronco Sport exhibits severe engine knocking and low fuel pressure, which are primary symptoms of open safety recalls 24S16 and 25S76. On 9/29/26, Seelye Ford of Kalamazoo charged me $220.21 out-of-pocket for a powertrain recall system software update. They are now refusing to inspect the physical fuel injectors or complete the safety recalls unless I pay out-of-pocket to replace an unrelated push-to-start button module, holding a federal safety recall hostage. The vehicle continues to malfunction identically after their software flash, making it a severe stalling and fire hazard. It is currently stranded on the dealer's lot.
- Electrical system · Engine · Structure › Body
My 2022 Bronco Sport suffered a physical underhood engine fire due to Recall 25S76 / Campaign 25V467. Ford Corporate is refusing to provide a loaner vehicle or alternative transportation, leaving me stranded while the vehicle sits unrepairable at a Ford dealership awaiting a final hardware remedy…
My 2022 Bronco Sport suffered a physical underhood engine fire due to Recall 25S76 / Campaign 25V467. Ford Corporate is refusing to provide a loaner vehicle or alternative transportation, leaving me stranded while the vehicle sits unrepairable at a Ford dealership awaiting a final hardware remedy that does not yet exist. We have also been denied the Ford Buy Back program even though we COULDNT and were BLOCKED to set a maintenance appointment for said recall to attempt to prevent this from happening because they do not have a permanent fix. The dealership and Progressive insurance want to replace all burnt parts with the same defective recalled parts which should be illegal and is unsafe. We just want the means to get our family into a safe vehicle.
- Power train · Steering · Suspension
Front and rear axle, 4 wheel drive, and differential issues, causing steering, wheel, and driving issues. There is a nationwide back order on parts needed to repair this common, and known issue, leaving Ford service to return customers to continue driving unsafe vehicles until parts arrive. Despite Ford having knowledge of this safety hazard, there has been no recall.
- Unknown or other
The A/C condensate drain valve on the 2022 Ford Bronco Sport features a severe engineering defect that causes water to back up directly into the passenger cabin. The soft rubber "duckbill" drain valve is sandwiched blindly behind a tight underbody exhaust heat shield. Normal exhaust heat causes the…
The A/C condensate drain valve on the 2022 Ford Bronco Sport features a severe engineering defect that causes water to back up directly into the passenger cabin. The soft rubber "duckbill" drain valve is sandwiched blindly behind a tight underbody exhaust heat shield. Normal exhaust heat causes the rubber valve to stick permanently shut, turning the HVAC assembly into a water tank. Additionally, factory carpet insulation is wedged tightly against the internal housing, pinching the line shut.Safety Risk & Hazards:When the drain fails, large volumes of water flood the interior passenger floorboards. This water pools directly over sensitive electrical wiring harnesses and modules located beneath the dash, creating a severe risk of electrical shorts, sudden component failure, or a vehicle fire. Furthermore, the backed-up water completely saturates the cabin air filter and window defroster system, causing sudden, severe windshield fogging while driving, which severely impairs driver visibility.
- Power train
I have a 2022 Ford Bronco Sport Outer Banks that I bought brand new. I special ordered it and had it delivered to a dealership in Jacksonville IL. The vehicle has 107,000 miles on it. On XXX while driving to work my car completely quite running in the middle of a busy intersection with cars…
I have a 2022 Ford Bronco Sport Outer Banks that I bought brand new. I special ordered it and had it delivered to a dealership in Jacksonville IL. The vehicle has 107,000 miles on it. On XXX while driving to work my car completely quite running in the middle of a busy intersection with cars speeding by us and me and my fiance were both in danger of being hit by multiple Semi trucks, this road leads directly to an industrial park. I had the vehicle towed to the nearest ford dealer who told me the Transmission failed completely. I have read online that this is a known issue with a series of Bronco products that ford has produced. there are endless online forums and from what i can find Ford has not addressed or notified consumers that their product may quit unexpectedly out of no where putting lives at risk. This could kill people. We had just got off one of the most busy interstates in the united states. [XXX] in [XXX] if my car would have quit on I24 its very likely me and my fiance would both be dead and possibly others injured as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Unknown or other
The APIM completely failed disabling my rear back up camera. Ford had a know issue with this car model that they issued a customer satisfaction program that has expired but the systems are still failing and they are refusing to replace and address.
- Fuel/propulsion system · Lane departure › Assist
The charcoal canister, connection, wires and felt cover has been broken. This is the second time something has went through the cover and broke the charcoal canister. First time it was covered under warranty and only the canister and cover had a hole. This time several things were broken. It caused…
The charcoal canister, connection, wires and felt cover has been broken. This is the second time something has went through the cover and broke the charcoal canister. First time it was covered under warranty and only the canister and cover had a hole. This time several things were broken. It caused the engine light to come on. It has also caused the lane assist to stay on. There are bare wires underneath the vehicle. The Ford company wanted to charge me over $2,000. to repair. I do not take this Bronco out on trails four wheeling, it is a family vehicle. It has been caused, I assume by a rock coming up and hitting underneath it.
- Fuel system, gasoline · Power train › Driveline › Differential unit
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer and manufacturer were contacted. The contact stated that the manufacturer had…
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer and manufacturer were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure associated with the recall. The contact stated that while turning at slow speeds and while turning while in reverse, the vehicle was vibrating and shaking abnormally with a loud grinding sound. The vehicle was taken to the local dealer and was diagnosed with rear differential failure. The contact was informed that the rear differential needed to be replaced. The vehicle was not repaired, and the contact was informed that parts were not available. The contact was concerned that the rear differential failure might cause the vehicle to become inoperable. The manufacturer was notified of the failure and confirmed that parts were not yet available. The failure mileage was 41,000.
- Steering · Structure › Body · Suspension
When turning any direction or hitting speeds of 75 mph +, vehicle makes loud noise and starts shaking. Took it to an independent mechanic and ran a diagnostic, they said the rear differential is going out which isn't normal for vehicles with this mileage and said it was a manufacturer defect. When…
When turning any direction or hitting speeds of 75 mph +, vehicle makes loud noise and starts shaking. Took it to an independent mechanic and ran a diagnostic, they said the rear differential is going out which isn't normal for vehicles with this mileage and said it was a manufacturer defect. When I took the vehicle to a Ford dealership, the tech laughed and said there's a one month wait for parts and 15 other Broncos in front of me dealing with the same issue.
- Unknown or other
On [XXX], my 2022 Ford Bronco Sport was stationary under my residential carport. I was seated in the front passenger seat with the passenger door open. I reached across and depressed the brake pedal with my hand and pressed the engine Start/Stop button. I did NOT touch or move the rotary gear…
On [XXX], my 2022 Ford Bronco Sport was stationary under my residential carport. I was seated in the front passenger seat with the passenger door open. I reached across and depressed the brake pedal with my hand and pressed the engine Start/Stop button. I did NOT touch or move the rotary gear selector before starting the vehicle. Immediately after the vehicle started, it unexpectedly began moving backward. I reached over and moved the gear selector to PARK to stop the vehicle. Before I was able to stop it, the open passenger door was caught and bent backward, causing damage to the vehicle. I did not intentionally select REVERSE or command the vehicle to move backward. I am reporting this because I am concerned that an unintended transmission/gear-selection or electronic control malfunction allowed the vehicle to move backward upon startup without Reverse being selected. VIN: [XXX] I am requesting that this incident be documented and evaluated as a potential vehicle safety defect involving unintended vehicle movement. Insurance claim will be filed for damage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train
I first noticed noise from the rear of the vehicle in early July 2026, within days of picking it up from Louisburg Ford following a turbocharger repair completed June 29, 2026. The rear drive unit (rear differential) has since been diagnosed as failing at 82,053 miles, with a repair quoted at…
I first noticed noise from the rear of the vehicle in early July 2026, within days of picking it up from Louisburg Ford following a turbocharger repair completed June 29, 2026. The rear drive unit (rear differential) has since been diagnosed as failing at 82,053 miles, with a repair quoted at approximately $4,000. Ford documented this failure mode in Technical Service Bulletin 23-2335, issued October 2023 and superseded by 24-2185 and 24-2386, identifying the rear drive unit vent hose as an entry point for fluid contamination that destroys the unit. My vehicle is within the affected population — 2022 Bronco Sport Outer Banks with the 1.5L engine, delivered October 29, 2022. In October 2023, when Ford documented this defect, my vehicle had approximately 25,000 miles and was under its bumper-to-bumper warranty. The vehicle has been serviced exclusively at Louisburg Ford since delivery at 11 miles, and the records show the vent hose has never been replaced — the original design remains installed. This vehicle has also required repairs to engine sealing at three separate leak sources, the high-pressure fuel injectors, the exhaust converter, and a complete turbocharger and wastegate assembly, all before 83,000 miles. Ford has offered partial assistance, leaving $1,685 as my share. The vehicle is currently not drivable.
- Service brakes
Brake components showing signs of failure at 28,000 miles on both front and rear brakes. Safety placed at risk given speed and general use of vehicle which includes passengers. This includes grinding stops, increasing foot pressure used to stop car, and under certain conditions reconsidering use of…
Brake components showing signs of failure at 28,000 miles on both front and rear brakes. Safety placed at risk given speed and general use of vehicle which includes passengers. This includes grinding stops, increasing foot pressure used to stop car, and under certain conditions reconsidering use of vehicle. Ford dealership inspected vehicle and is aware of issue and noted TSB (T25-2438) in service visit diagnosis. No warning lights present. Signs first appear as increased brake dust covering rim and tire areas, increasingly loud grinding and squealing of brakes whether in drive or reverse. No remedy provided by Ford despite low mileage and understanding that the issue is not normal wear and tear on vehicle.
- Engine · Fuel/propulsion system
My vehicle is subject to NHTSA Recall 25V467 / Ford Recall 25S76 for a fuel injector that may crack and leak fuel into the engine compartment, creating a risk of fire. The recall was issued in July 2025 and remains open more than a year later. Ford has provided an interim PCM software update…
My vehicle is subject to NHTSA Recall 25V467 / Ford Recall 25S76 for a fuel injector that may crack and leak fuel into the engine compartment, creating a risk of fire. The recall was issued in July 2025 and remains open more than a year later. Ford has provided an interim PCM software update intended to detect a leaking injector and mitigate the fire risk, but this does not replace the defective fuel injectors and the recall remains open. Ford states that a final remedy is still being developed / is not currently available for my vehicle. I am concerned about the length of time this safety defect has remained without an available permanent repair. The vehicle continues to be operated while subject to a known fuel-leak and underhood-fire risk, and I do not have the ability to have the defective components permanently repaired despite the recall having been open since July 2025. I am requesting that NHTSA review the delay in Ford providing the final remedy for Recall 25V467. The vehicle is available for inspection upon request. I have not experienced a fuel leak, fire, crash, or injury at this time.
- Fuel system, gasoline
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was…
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was unavailable. The contact was advised to take the vehicle to the dealer if the vehicle experienced the failure. The manufacturer was contacted. The contact had not experienced a failure.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Loss of Motive Power
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving…
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Underhood fires caused by fuel leak
On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with…
On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with these recalls includes certain MY 2020-2022 Ford Escape vehicles and MY 2021-2023 Ford Bronco Sport vehicles equipped with 1.5L engines. The safety defect in each recall involves high-pressure fuel injectors that are susceptible to cracking, allowing liquid fuel and fuel vapor to migrate onto hot surfaces within the engine compartment potentially resulting in underhood vehicle fires. The remedy programs described in recalls 22V-859 and 24V-187 are identical and involve both a software component and a hardware component. Specifically, Ford developed an updated engine control software designed to detect a pressure drop in the high-pressure fuel rail, provide instrument cluster messaging to the driver, invoke a strategy to disable the high-pressure fuel pump, derate the engine output, and lower the temperatures of possible ignition sources within the engine compartment. Additionally, Ford would install a tube into the engine’s cylinder head drain hole to shunt spilled liquid fuel past the various hot surfaces within the engine compartment and ultimately discard the spilled liquid fuel onto the roadway. ODI identified various safety concerns with this remedy program, which, among other things, notably did not include repairing or replacing the defective part and potentially did include the introduction of new safety defects (like fuel spilling near the spark plugs and fuel spilling onto the public roadway). NHTSA opened this investigation to evaluate these concerns with the remedy program, including whether the vehicles were still susceptible to underhood fires even post-remedy. As described in more detail in the Additional Summary posted simultaneously with this resume, ODI conducted a thorough investigation that included analyzing data and other materials received in response to two Information Requests, as well as inspections of post-remedy vehicles that experienced an underhood fire. ODI and Ford worked to identify and locate vehicles that experienced post-remedy fires and conduct joint vehicle inspections. ODI’s investigation also prompted Ford to initiate a more in-depth evaluation of the defect, including Ford’s conducting component level testing of high-pressure fuel injectors. ODI met with Ford on several occasions throughout this investigation to jointly conduct certain of these described tasks and to discuss test results. A collateral issue surfaced as a result of this investigation: in March 2025, Ford realized that despite relevant repairs having been recorded as successfully completed, approximately 33,576 vehicles subject to recalls 22V-859 and 24V-187 did not have the software component of the remedy program installed correctly. Thus, on March 27, 2025, Ford filed a new related recall (25V-165) for these vehicles, notifying NHTSA and the public that they were still at risk of experiencing an underhood vehicle fire due to cracked fuel injectors despite the consumer having had their vehicle remedied pursuant to one of the two earlier recalls. In June 2025, Ford committed to implementing a new remedy program to repair the vehicles. On July 11, 2025, Ford documented this commitment in a new recall filing (25V-467), which explains that Ford’s upcoming remedy program will involve proactive replacement of all high-pressure fuel injectors within the recall population. In view of the recall action taken by Ford, ODI is closing this Recall Query, which was opened given NHTSA’s concerns that the initial remedy programs of the software to detect the pressure drop plus installation of the drain tube did not constitute an adequate repair. The agency reserves the right to take additional action if warranted by future circumstances.
- Loss of Motive Power
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power…
On January 31, 2024, the Office of Defects Investigation (ODI) opened PE24002 to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco Sport vehicles. At that time, ODI had received 31 Vehicle Owner Questionnaires (VOQs), with consumers commonly reporting a loss of engine power accompanied by complete electrical system failure which occurred either while driving, or after coming to a stop. The investigation revealed that MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles are equipped with a 12V enhanced flooded battery (EFB), which may experience an abrupt failure during a drive cycle. The failure is the result of an internal corrosion issue, which is influenced by long exposure to high under-hood temperatures. If the sudden loss of 12V battery voltage is not detected by the vehicle’s battery management sensor, the vehicle can experience a loss of power event without providing any warning to the driver. Following a loss of power due to battery failure, the vehicle may be without all 12V accessories including hazard lights and typically will not be able to be restarted. In its March 2024 response to ODI’s information request, Ford provided 367 customer complaints (including field reports, lawsuits, and legal claims) and 1005 warranty claims relating to the alleged defect. When combining ODI and manufacturer failure report data, there are 1,368 unique VINs represented across MY 2021-2023 Ford Bronco Sport vehicles. One of the VOQs submitted to NHTSA reported a minor rear-end collision resulting from a loss of power event. Included within Ford’s complaints were a reported single-vehicle collision and a vehicle fire which occurred following a loss of power event at a traffic light (fire cause and origin was not determined). Additionally, across ODI and manufacturer data, there were 12 allegations of either acid leaking from the 12V battery or smoke emitting from the battery area within the engine compartment. On April 12, 2024, Ford submitted recall 24V267 for MY 2021-2024 Ford Bronco Sport and certain MY 2022-2023 Ford Maverick vehicles (total population 456,565). The recall remedy provides updated calibrations to the body control module and powertrain control module. Ford indicated that the update will result in improved detection of 12V battery state of charge during drive cycles and will provide notification to the driver if the battery significantly degrades while driving. Additionally, Ford has replaced the EFB with an absorbed glass mat (AGM) battery as both a service component for the subject vehicles and as original equipment for Bronco Sport vehicles with production dates beginning in mid-March 2024. The warranty claim rate for peer vehicles equipped with an AGM battery is substantially lower than that for the subject vehicle population. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010795Some 2021-2023 Bronco Sport vehicles equipped with a 1.5L engine built on or before 30-Nov-2022, 2021-2022 Bronco Sport vehicles equipped with a 2.0L engine built on or before 28-Feb-2022, 2020-2022 Escape/Corsair vehicles equipped with 1.5L/2.0L/2.3L engines built on or before 30-Apr-2022, 2020-2022 Escape vehicles equipped with 2.5L FHEV powertrain built on or before 31-Mar-2022 may exhibit a chatter/shudder during low speed turning events.
- 11009564Some 2020-2024 Escape and 2021-2024 Bronco Sport vehicles may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity.
- 11009190Some 2020-2024 Escape and 2021-2024 Bronco Sport vehicles may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity. This may be due to the suspension sensitivity of the vehicle. To correct the condition, follow the Service Procedure to install brake pads with clips and if necessary, install the rear reinforced caliper bushings.
- 11008948While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.
- 11008947Some 2022 Escape built on or before 03-Mar-2022, 2022 Bronco Sport built on or before 04-Mar-2022 and 2022 Maverick built on or before 25-Jan-2022 may exhibit a powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0929:77 stored in the gear shift module (GSM).
- 11008213Some 2021-2024 Bronco Sport vehicles equipped with a 1.5L EcoBoost engine may exhibit water coolant pump leaks.
- 11007962Some 2020-2024 Escape, 2021-2024 Bronco Sport and 2022-2024 Maverick vehicles may exhibit the uncommanded locking of the driver door after the door is closed.
- 11006862Some 2019-2024 Ford and Lincoln vehicles equipped with a telematics control unit module (TCU) may exhibit the Location toggle button in the Connectivity setting menu grayed out with an inability to switch it off.
- 11006036Certain 2018 - 2024 Model Year Various Vehicles Update SYNC Software In all the affected vehicles, due to an error in the SYNC software, you may experience SYNC system instability concerns and/or a failure to preserve certain settings across ignition cycles. This may result in a black infotainment screen that does not affect rear view camera, incorrect language setting, erased or unsaved radio presets, and potential inability to perform software updates.
- 11005746Some 2019-2024 Ford and Lincoln vehicles equipped with SYNC3 may experience various FordPass/LincolnWay connectivity concerns including but not limited to: missing activation prompt (pop-up) on the vehicle's center display screen when attempting to activate vehicle through FordPass/LincolnWay, incorrect location/global positioning system (GPS) reported through FordPass/LincolnWay, problems with remote commands being performed through FordPass/LincolnWay, incorrect data/information reported on FordPass/LincolnWay. These symptoms will be accompanied by diagnostic trouble code (DTC) B156D:89 in the TCU. This may be due the accessory protocol interface module (APIM) software
- 11005710Some 2019-2024 vehicles equipped with SYNC 3 may experience a programming Error - "INSTL_ERR12" while programming APIM using the Ford Diagnosis and Repair System (FDRS) or experience a frozen screen which says "updating system software" or no progress/response from module using the universal USB updater. This may be due to low memory in the APIM commonly occurring on software level NU5T-14G381-AB/BB. The current software level can be verified in the SYNC tab of Professional Technician System (PTS) or using the vehicle's center display screen, Settings > General > About. To correct the condition, run the universal USB updater. If unsuccessful, using the latest software version of the FDRS scan tool, run the service function "APIM - Reset the Accessory Protocol Interface Module Application" and select "Clear All User Data" option. The center display screen will reboot. As soon as the vehicle's center display screen displays the boot up logo, immediately reinsert the same universal serial bus (USB) drive that was utilized during the prior failed programming attempt.
- 11003146Some 2019-2024 vehicles equipped with SYNC 3 may experience a programming Error - "INSTL_ERR12" while programming APIM using the Ford Diagnosis and Repair System, or experience a frozen screen which says "updating system software" or no progress/response from module using the universal USB updater. This may be due to low memory in the APIM commonly occurring on software level
- 11003136Some 2020-2024 Escape/Corsair, 2021-2024 Bronco Sport/F-150, and 2022-2024 Maverick vehicles may exhibit a condition where the door(s) do not open using the exterior door handle(s). This may be due to an enabled door reinforcement inertia lock within the exterior door handle. This condition occurs when the doors are closed or opened with excessive force. To correct this condition, follow the door reinforcement inertia lock rest procedure that has been added to Section 501-14 of the Workshop Manual under General Procedures. For claiming, use causal part 78219A64.
- 11001646This article supersedes TSB 23-2307 to update the Service Procedure and vehicle model years affected. Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Transit Connect, 2019-2023 Mustang, 2019-2023 Ranger, 2020-2021 Expedition/Navigator, 2020-2022 Escape/Corsair/Super Duty/EcoSport, 2020-2024 Explorer/Aviator/Transit, 2021-2024 Bronco Sport, 2022-2024 Maverick vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update theaccesory protocol interface module (APIM) software.
- 11001583This article supersedes TSB 23-2335 to update the TSB title, vehicles affected and parts list. Some 2021-2023 Bronco Sport vehicles equipped with a 1.5L engine built on or before 30-Nov-2022, 2021-2022 Bronco Sport vehicles equipped with a 2.0L engine built on or before 28-Feb-2022, 2020-2022 Escape/Corsair vehicles equipped with 1.5L/2.0L/2.3L engines built on or before 30-Apr-2022, 2020-2022 Escape vehicles equipped with 2.5L full hybrid electric vehicle (FHEV) powertrain built on or before 31-Mar-2022 may exhibit a chatter/shudder during low speed turning events. This may be due to contamination of the rear drive unit (RDU) fluid through the RDU vent hose. To correct the condition, follow the Service Procedure to replace the RDU vent hose.
- 11000733This article supersedes TSB 23-2298 to update the production fix date and parts list. Some 2021-2024 Bronco Sport vehicles equipped with a 1.5L engine built on 24-Jul-2021 and through 14-Dec-2023 may exhibit a hissing noise from rear liftgate area when driving straight between 35-50 mph (5680 km/h). This may be due to the absence of the rear floor insulator located in the spare tire compartment. To correct this condition, follow the Service Procedure to install a rear floor insulator in the spare tire compartment.
- 11000187Some 2020-2024 Escape and 2021-2024 Bronco Sport vehicles may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity. Ford is aware of the concern and this condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected by the 4th quarter of 2024. Monitor OASIS for additional information and schedule service appointments for customers once the repair becomes available.
- 10254138All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.
- 10253552Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or later, select the diagnostics tab and search for related symptoms,DTCs and keywords. The search results will be shown in the search results pane. Read and follow allTechnical Service Bulletins (TSB), Special Service Message (SSM)s or General Service Bulletin (GSB) first if abulletin specifically addresses the vehicle concern. If there are no messages, run the appropriate diagnosticpinpoint test found in the Workshop Manual (WSM). Follow the steps in the pinpoint test. Make sure to note thetitle of the guided routine, using the correct one for the vehicle's symptom or diagnostic trouble code (DTC) iscritical. Depending on the outcome of the pinpoint test, a repair validation code (RVC) may be generated eitherin the pinpoint test or Guided Routine. If the vehicle concern still exists after following the pinpoint tests orguided routine, then a manual RVC can be generated using the RVC Assist Form. A manual RVC can only begenerated once the above process has been followed.
- 10252626Some 2021-2024 Bronco Sport vehicles equipped with a 1.5L EcoBoost engine may exhibit water coolant pump leaks. This may be due to contamination in the coolant system. To correct this condition and prevent recurrent water pump failures, perform a coolant system flush. Refer to the Workshop Manual (WSM), Section 303-03A Engine Cooling - 1.5L EcoBoost > General Procedures > Engine Cooling System Flushing > Steps 1-8. Then replace the coolant pump. Refer to the WSM, Section Engine Cooling - 1.5L EcoBoost > Removal and Installation. Fill and bleed the coolant system properly. Refer to the WSM, Section 303-03A Engine Cooling - 1.5L EcoBoost > General Procedures > Engine Cooling System Draining, Vacuum Filling and Bleeding. Note: Repeat steps 10-12 a total of 10 times to remove any remaining air trapped in the system.
- 10252418Special Field Action 23L05 Certain 2022 - 2023 Model Year Bronco Sport, and Certain 2023 Model Year Maverick Vehicles Mobile Hot Spot Credit
- 10252410Customer Satisfaction Program 22N15 Certain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing Adding Not OTA Capable Owner letters. Other documents submitted 01/02/24 & Received OTA letters submitted on 02/01/24
- 10251952For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
- 10251934During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section, 303-01 is extremely important. The bolt torque procedure can be found in the crankshaft front seal removal and installation procedure or in the engine assembly procedure.
- 10250852Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass/LincolnWay app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep due to one of these conditions, follow normal Workshop Manual (WSM) Section 414-01 procedure to correct the concern. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
- 10249489Certain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing Addinf owner letters. First part submitted 01/02/24
- 10248986When replacing the liftgate latch assembly on 2021-2022 Bronco Sport vehicles, the service part number called out in the parts catalog for the liftgate latch assembly M1PZ-7443150-B is incorrect. The correct service part number is JL1Z-7443150-A.
- 10248066Certain 2020-2023 Model Year Bronco Sport, Escape, Corsair, E-Series, F-650/F-750, F-53 Motorhome Chassis, F-59 Commercial Stripped Chassis Vehicles Equipped with Smart Data Link Connector (SDLC) Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing
- 10244798Some 2021-2023 Bronco Sport vehicles equipped with a 1.5L engine built on or before 30-Nov-2022, 2021-2023 Bronco Sport vehicles equipped with a 2.0L engine built on or before 28-Feb-2022 or 2020-2022 Escape/Corsair non-plug in hybrid electric vehicle (PHEV) vehicles built on or before 30-Apr-2022 may exhibit a chatter/shudder during low speed turning events. This may be due to contamination of the rear drive unit (RDU) fluid through the RDU vent hose. To correct the condition, follow the Service Procedure to replace the RDU vent hose.
- 10244711Some 2020-2023 Escape and 2021-2023 Bronco Sport vehicles may exhibit a moan noise when the vehicle is driven in reverse (R) in cold weather and/or high humidity. This may be due to the suspension sensitivity of the vehicle. To correct this condition, follow the Service Procedure to replace the standard and reinforced rear caliper bushings and apply Kluberpaste to the machined surfaces of the brake caliper and caliper support bracket.
- 10244707Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehicles with SYNC 3 may experience various SYNC performance related concerns. This may be due to the SYNC Software. To correct the condition, follow the Service Procedure to update the SYNC module (APIM) software.
- 102436112022-2023 Escape and Bronco Sport vehicles equipped with 1.5L engines should add local fuel once the vehicle arrive to the dealership to reduce the risk of driving performance issues such as: rough operation, idle quality, engine misfires, lack or loss of engine power. These conditions may occur due to different fuel specifications between manufacturing plant and final market. Make sure that the vehicles in stock have local fuel added.
- 10243474Some 2021-2023 Bronco Sport vehicles equipped with a 1.5L engine built on 24-Jul-2021 and through 31-Aug-2023 may exhibit a hissing noise from rear liftgate area when driving straight between 35-50 MPH (56 80 Km/h). This may be due to the absence of the rear floor insulator located in the spare tire compartment. To correct this condition, follow the Service Procedure to install a rear floor insulator in the spare tire compartment.
- 10241627In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.
- 10241597Some 2021-2023 Bronco Sport and 2020-2023 Escape vehicles may exhibit a rattle or flapping noise coming from the rear air extractors while driving. This may be due to the normal operation of the rear air extractors. To determine if this is a normal condition, perform a road test at 40 mph (65 km/h) or above. Inspect if the noise is coming from the rear extractors. During the road test alternate air conditioning (A/C) between fresh mode and air re-circulation mode. If the noise is eliminated when the A/C is in fresh mode, this is considered a normal characteristic of the vehicle and no repairs should be performed.
- 10241545Some 2022-2023 Bronco Sport/Escape vehicles equipped with a 1.5L engine and 2022-2023 Corsair vehicles equipped with a 2.5L engine, built on 01-Sep-2022 and through 06-Apr-2023, may exhibit a low coolant level with engine oil in the coolant and/or coolant in the engine oil. This may be caused by an internal oil cooler leak. To correct this condition, follow the Service Procedure to test and replace the oil cooler.
- 10241544Some 2021-2023 Bronco Sport vehicles built on or before 01-Nov-2022 equipped with light emitting diode (LED) control module (A2C7636130500 printed onto the module label) may exhibit a condition where the daytime running lamps (DRLs) stay on for up to 10 minutes after the vehicle is turned off and/or daytime running lamps momentarily dim to park intensity when the turn signal lamp is cancelled before returning to full DRL intensity. This may be due to the software in the LED control module. To correct this condition, follow the Service Procedure to replace both LED control modules and update the configuration of the body control module (BCM).
- 10241542Some 2020-2022 Escape built and 2021-2023 Bronco Sport vehicles, built on or before 28-Sep-2022, equipped with a 1.5L Ecoboost engine and a 8F35 transmission may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0420 stored in the powertrain control module (PCM). This may be due to the catalytic converter. To correct this condition, follow the Service Procedure to replace the catalytic converter.
- 10240743The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical service tips and other service information.
- 10240577Some 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with normal WSM diagnostics. For claiming, use base (4000) causal part.
Every Ford Bronco Sport model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.