1997 Ford Windstar
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › Windstar › 1997
These records cover every 1997 Ford Windstar. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 1997 Ford Windstar. Newest first.
Ford IS recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 F-250 sd through F-550 sd diesel, 1992-2003 E-150 through E-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 F53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the…
Risk and remedy
Risk
A vehicle fire could occur with or without the engine running.
Remedy
Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
This IS not a safety recall in accordance with the safety act. however, it IS deemed a safety improvement campaign by the agency. vehicle description: 1995-1998 ford windstar minivans. the front coil springs could potentially fracture due to corrosion. note: the 1997-1998 windstar MINI vans are also covered by nhtsa safety recall 01v-199/ford recall…
Risk and remedy
Risk
Some tires have deflated due to contact with a broken spring.
Remedy
Ford IS extending the warranty for front coil spring replacement to a total of 10 years of service from the warranty start date, with unlimited mileage. this coverage IS automatically transferred to subsequent owners at no charge. if either front coil spring fractures during the coverage period noted above, the dealer will replace both springs at no charge to the owner.
On certain minivans originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, and wisconsin, and in the district of columbia. the front coil springs…
Risk and remedy
Risk
Some tires have deflated due to contact with a broken spring.
Remedy
Dealers will install protective shields around the front coil springs. owner notification began september 6, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Vehicle description: MINI vans, light pickup trucks, and sport utility vehicles. off lease canadian vehicles equipped with daytime running lights which meet canadian requirements and not the photometric requirements of fmvss 108, "lamps, reflective devices, and associated equipment." according to ford, the vehicles were imported into the u.s. Erroneously.
Risk and remedy
Risk
The light given off from the daytime running lights IS brighter than allowed by u.s. Standards.
Remedy
Dealers will be advised to deactivate the running light function and to complete any outstanding safety recalls on these vehicles.
Vehicle description: minivans. the brake fluid master cylinder IS recessed and oriented in the engine compartment so that the brake fluid warning statement embossed on both the top of the filler cap and the side of the reservoir body are not entirely visible by direct view. these vehicles may not fully comply with requirements of fmvss no. 135…
Risk and remedy
Remedy
Owners will be provided with new labels and installation instructions.
Vehicle description: passenger vehicles equipped with AX4S automatic transaxles. the low/intermediate servo cover can separate from the transaxle while the vehicle IS being driven. if this occurs, transmission fluid will leak contacting the catalytic converter.
Risk and remedy
Risk
The catalytic converter temperature may be hot enough to ignite the transmission fluid and cause a vehicle fire.
Remedy
Dealers will inspect the transmission and replace these servo covers.
Owner complaints
192 complaints6 involved a crash9 involved a fire5 injuries
What owners report most
Latest complaints
- Suspension › Rear › Axle › Non-powered axle assembly
TL* the contact owns 1997 ford windstar. The contact stated while traveling 65 mph the rear axle beam became fractured. the manufacturer was notified of the defect. A private mechanic stated that the rear axle beam needed to be replaced. There were no repairs made on the vehicle. the failure mileage was 140,000 and the current mileage was 140,000.
- Structure › Body
TL* the contact owns a 1997 ford windstar. The contact stated that after having the vehicle inspected, he was notified that the vehicle failed to pass the state inspection due to the sub frame being completely corroded. The vehicle was taken to an independent mechanic who stated that the sub-frame needed to be replaced. the vehicle was not repaired. The approximate failure mileage was 130,000.
- Suspension
TL* the contact owns a 1997 ford windstar. The contact stated that while driving 40 mph, the track bar detached from the vehicle. The contact stated that the vehicle began to wobble excessively. The manufacturer was notified of the issue and advised the contact not to drive the vehicle. The failure…
TL* the contact owns a 1997 ford windstar. The contact stated that while driving 40 mph, the track bar detached from the vehicle. The contact stated that the vehicle began to wobble excessively. The manufacturer was notified of the issue and advised the contact not to drive the vehicle. The failure mileage was 90,000. updated 09/21/12*lj the vehicle was repaired by a local mechanic at the owner's expense. The dealer was made aware of failures. Updated 09/26/2012 *js
- Suspension
I purchased a 1997 ford windstar and from what I understand IS that there was a recall on the coil springs/suspension. (Recall#01i00700) < I believe this IS the recall #. Long story short my front tires are flat doue to the coil springs. None of the dealers I took it to are willing to fix this. They say it IS not covered under any recall... Please help me better understand why ford wont fix this defect. *tr
- Electrical system · Service brakes, hydraulic · Vehicle speed control
My windstar GL wouldn't start. I replaced the range selector switch. When I restarted the vehicle I forgot the reconnect the brake pressure sensor wiring connector and the ABS light came on. I tried to get the code cleared but no-one could access the code. I took the van to the dealer for a recall…
My windstar GL wouldn't start. I replaced the range selector switch. When I restarted the vehicle I forgot the reconnect the brake pressure sensor wiring connector and the ABS light came on. I tried to get the code cleared but no-one could access the code. I took the van to the dealer for a recall notice on the speed control system and had them look into why the ABS light was on. I was told the ABS module had quit and needed replaced. The module IS $1500.00 and $300.00 to install. That's more than the van IS worth. I searched online and found out many other windstar owners are having the same problems. The cruise control system has also quit and the dealer rep. Tells me that the cruise control also goes through this module. With the possibility of fire it seems rather irresponsible for ford to do nothing more than install a fusible link as a safety measure. I am looking into buying a used module to repair the cruise and ABS. the failure IS total. Neither the cruise control or the ABS system works at this time. *Tr
- Vehicle speed control
I had my 97 windstar fan fixed due to recall # 09s09:speed control system modification. Ever since then the ABS and parking lights have been coming on. We have had the codes reset, but they keep appearing. I have also called the ford dealer where the repair was done, but they say it IS not covered…
I had my 97 windstar fan fixed due to recall # 09s09:speed control system modification. Ever since then the ABS and parking lights have been coming on. We have had the codes reset, but they keep appearing. I have also called the ford dealer where the repair was done, but they say it IS not covered in the recall to check the scds, or that if it wasn't leaking then, they did not have to replace that part. I am very frustrated. *Tr
- Electrical system · Engine and engine cooling
I turned the air conditioning on in the van and after about 10 minutes, turned it to the 'max ac' position. the hood started steaming so I turned the air completely off. after less than a minute, I noticed the hood was smoking so I pulled to the side of the road immediately. I turned the car off…
I turned the air conditioning on in the van and after about 10 minutes, turned it to the 'max ac' position. the hood started steaming so I turned the air completely off. after less than a minute, I noticed the hood was smoking so I pulled to the side of the road immediately. I turned the car off and exited the van and saw that the passenger side of the hood was on fire. I ran to the passenger side and opened the sliding door, and got my 18 month old and 4 year old out of the vehicle. after we were all a safe distance away I saw that most of the hood of the van was in flames. by the time the fire department arrived about 5 minutes later, the entire hood was on fire with a lot of black smoke. the entire engine compartment looks charred and partially melted. the vehicle IS beyond repair. I'm thankful my children are safe but I am very concerned about the safety (failure) of this vehicle. *Tr
- Vehicle speed control
Our 1997 ford windstar minivan that IS currently subjected to the recall for the faulty cruise control switch burned to the ground on feb 21, 2007 as the result from a fire that started in the engine area. *Tr
- Engine and engine cooling › Exhaust system · Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings · Suspension › Front › Springs › Coil springs
Tl*the contact owns a 1997 ford windstar. the contact stated that the front end of the vehicle was abnormally low. upon further inspection, he noticed that the front coil springs fractured due to excessive rust. the failure caused the tires to deflate. the dealer stated that the vin was…
Tl*the contact owns a 1997 ford windstar. the contact stated that the front end of the vehicle was abnormally low. upon further inspection, he noticed that the front coil springs fractured due to excessive rust. the failure caused the tires to deflate. the dealer stated that the vin was excluded from nhtsa campaign ID number 01v199000 (suspension:front:springs:coil springs); therefore, they would not assume responsibility for any repairs. the vehicle has not been repaired according to the recall. the failure mileage was 70,000 and current mileage was 90,000. updated 6/4/09 *cn the exhaust system was replaced and brake lines snapping. Updated 06/09/09.*jb
- Service brakes, electric
ABS and brake light on same time. Notice brake fluid leak. Refill brake fluid often. Speedometer needle sways erratically for about 2 years. Cruise control inoperable for 2 years. *Tr
- Service brakes, hydraulic › Fluid · Vehicle speed control
Noticed that I was leaking some brake fluid for the last couple of months on my 1997 ford windstar but very little at that. About the same time the cruise control quit working. One day while driving I noticed a lot of smoke coming from under the hood. Raised the hood but the smoke had quit. Got…
Noticed that I was leaking some brake fluid for the last couple of months on my 1997 ford windstar but very little at that. About the same time the cruise control quit working. One day while driving I noticed a lot of smoke coming from under the hood. Raised the hood but the smoke had quit. Got back home and noticed this again when I was stopped in the driveway. Checked under the hood again and found that the cruise control deactivation switch was smoking and very hot. Went to the ford dealer to check if there was a recall on this and there was not . Installed the replacement part with plug adaptor and this fixed the problem with smoking and the cruise started working again. Noticed on the net this same part that IS in my windstar IS also in other vehicles that has been recalled. Why IS this? This could have easily caught fire and been a total loss to the van and if it had been parked in the garage the house also. *tr
- Suspension › Front › Springs › Coil springs
Tl*the contact owns a 1997 ford windstar. While driving 20 mph the passenger side tire exploded causing the front end to hit the ground. The contact observed that the front coil spring was broken. The vehicle was not diagnosed by a dealer. The current and failure mileages were 132,000.
- Suspension › Front › Springs › Coil springs
1997 ford windstar recall for coil springs. Consumer states that the recall was not repaired in 2001 when it was received because the dealer stated that if they were not broken they would not replace it, they would just put plastic shields over them. Now dealer states that the recall expired. *kb
- Suspension › Front › Springs › Coil springs
I have 1997 ford windstar. Feb. 1, 2007 I was going about 20 mph, andpassenger front spring shattered. I had to have it towed. My mechanic saud I was lucky I was not on the expressway when it happened. I had it fixed, it cost me $1036.00. I called ford to try and get reimbursed, and they told me…
I have 1997 ford windstar. Feb. 1, 2007 I was going about 20 mph, andpassenger front spring shattered. I had to have it towed. My mechanic saud I was lucky I was not on the expressway when it happened. I had it fixed, it cost me $1036.00. I called ford to try and get reimbursed, and they told me that I did not have it repaired at a ford dealer. If I had known they were bad I would have. I never received any warning at all. They did not even have me down as the registered owner. Here IS the recall # 011007000, front coil spring corrosion. They said it covers from 1995-1998 windstars. Here IS my vin. #2Fmda514vbd14446. All I would like IS to get some of my money back, I live on $699. A month, and for them to admit I was covered. They are being really nasty about this. I was told to call by fox 6 in milwaukee, katrina cravy consumer reporter. *Ak
- Steering › Hydraulic power assist system · Suspension › Front › Springs › Coil springs
TL* the contact owns a 1997 ford windstar. while driving at 45 mph the power steering failed. the front spring failed and punctured the front passenger tire. the contact was able to drive the vehicle to the side of the road. the contact stated that recall #01i007000…
TL* the contact owns a 1997 ford windstar. while driving at 45 mph the power steering failed. the front spring failed and punctured the front passenger tire. the contact was able to drive the vehicle to the side of the road. the contact stated that recall #01i007000: suspension:front:springs:coil springs was related to the failure. the manufacturer advised the contact that the recall expired. the current and failure mileage was 142,000. *ak
- Seats
TL*- the contact was sitting in van , the vehicle was turned off. The van stated to fill up with smoke. At which point he looked at the driver seat and noticed that the van was on fire. The he put out the initial fire. When he looked under the driver seat he noticed there were more flames. The…
TL*- the contact was sitting in van , the vehicle was turned off. The van stated to fill up with smoke. At which point he looked at the driver seat and noticed that the van was on fire. The he put out the initial fire. When he looked under the driver seat he noticed there were more flames. The next day he saw that there were wires under the seat. he was able to drive the va with the seat IS damaged due to the fire. Contact drive the van home.
- Vehicle speed control
Dt*: the contact stated the check engine light illuminated constantly, and the overdrive light located on the gearshift illuminated intermittently. this was accompanied by a strong smell of something electrical burning. the vehicle was taken to a private repair shop, where it was determined that…
Dt*: the contact stated the check engine light illuminated constantly, and the overdrive light located on the gearshift illuminated intermittently. this was accompanied by a strong smell of something electrical burning. the vehicle was taken to a private repair shop, where it was determined that the sensor on the master cylinder had caught on fire, and also burned the wiring harness between the master cylinder and the transmission. the mechanic replaced the sensor on the master cylinder, on the transmission, and the wiring harness, which corrected the problem. there was a nhtsa recall # 05v388000, which pertains to the vehicle speed control. the vehicle was not included in the recall due to the vin.
- Power train › Automatic transmission
Dt*: the contact stated, while the vehicle was immobile with the engine running, smoke erupted from under the hood. The engine was immediately turned off and the vehicle was vacated. The hood was raised and flames looked as if they it was coming out of the engine compartment. The fire was…
Dt*: the contact stated, while the vehicle was immobile with the engine running, smoke erupted from under the hood. The engine was immediately turned off and the vehicle was vacated. The hood was raised and flames looked as if they it was coming out of the engine compartment. The fire was extinguished and the vehicle was towed to the home of the contact. The manufacturer was alerted. There IS a nhtsa recall #97v097000 pertaining to the power train:automatic transmission. The vehicle IS not included in the recall due to the vin.
- Fuel system, gasoline › Storage
Dt*: the contact stated the fuel tank cracked resulting in fuel leakage. the vehicle was taken to an independent mechanic and the fuel tank was replaced. the contact IS the original owner and explained the vehicle has never been in an accident.
- Seat belts
I own a 1997 ford windstar, over the course of a month my husband and a few friends used my van to go hunting. over the course of that month his friend weighing in at 300 pound sat in the center rear seat. the seat belt snaps into place on the side of that seat. during that month of getting in…
I own a 1997 ford windstar, over the course of a month my husband and a few friends used my van to go hunting. over the course of that month his friend weighing in at 300 pound sat in the center rear seat. the seat belt snaps into place on the side of that seat. during that month of getting in and out and plopping down on it, it broke and now I have to replace it in order to use it again. but im afraid that if it could brake because someone sat on it then how easily could it break during an accident. please take the time to do an in depth investigation of it before someone IS involved in an accident and the seat belt breaks and someone IS hurt or worse killed. *nm
- Vehicle speed control
Driving on interstate with speed limit of 70 mph... Was driving about 77 mph at the time... Vehicle's factory installed cruise control was in use... Speedometer began to fluctuate wildly between about 60 mph and maximum (over 120 mph)... Vehicle's speed remained constant - trouble was just with the…
Driving on interstate with speed limit of 70 mph... Was driving about 77 mph at the time... Vehicle's factory installed cruise control was in use... Speedometer began to fluctuate wildly between about 60 mph and maximum (over 120 mph)... Vehicle's speed remained constant - trouble was just with the speedometer... Vehicle has 90,000 miles on the odometer... 1997 ford windstar... Speedometer doesn't fluctuate wildly at most speeds over 30 mph... From checking on web this has happened to other owners of ford windstars - this IS a safety issue. *jb
- Engine and engine cooling › Engine › Gasoline
Next cars USA in bakersfield california sold us a ford windstar which was defective (a lemon). within two week after our purchase the vehicle cut off jeopardizing the safety of my children each time we pressed the accelerator pedal. We have taken the vehicle to next cars for repairs and to date…
Next cars USA in bakersfield california sold us a ford windstar which was defective (a lemon). within two week after our purchase the vehicle cut off jeopardizing the safety of my children each time we pressed the accelerator pedal. We have taken the vehicle to next cars for repairs and to date we are now moving into our third month without transportation. when we inquired about a loan vehicle juan casillas (manager) response was that "we don't do that." we have filed a complaint with the better business bureau and when next cars received the complaint on march 8, 2006 juan casillas told us that "we just stopped working on the car because you pissed us off." we are at our wits end and so we are submitting this complaint for an investigation. *jb
- Engine and engine cooling › Engine · Latches/locks/linkages › Doors › Latch · Steering › Hydraulic power assist system · Vehicle speed control
Dt: the contact states has been having several problems with vehicle since 2002. On april 28, 2004 the speedometer was not providing an accurate speed reading. on december 9, 2004 the sliding door would not unlock or slide properly. the dealer replaced the door lock actuator and determined that…
Dt: the contact states has been having several problems with vehicle since 2002. On april 28, 2004 the speedometer was not providing an accurate speed reading. on december 9, 2004 the sliding door would not unlock or slide properly. the dealer replaced the door lock actuator and determined that the slide wheels were dry. the dealership replaced the door latch, and now it needed replacement again. On february 5, 2005 the engine was replaced at 75, 172 miles, and on november 21, 2005 the power steering failed and was replaced. All repairs have been done at contact's expense.*ak
- Electrical system
Behind in payments. ford motor credit issued write of summons on 7/3/03, trial scheduled for 9/22/03. on 7/29/03, while at work, vehicle caught on fire, damaging 2 other vehicles parked on either side of me. fire marshall investigated the incident and found to be an electrical problem.…
Behind in payments. ford motor credit issued write of summons on 7/3/03, trial scheduled for 9/22/03. on 7/29/03, while at work, vehicle caught on fire, damaging 2 other vehicles parked on either side of me. fire marshall investigated the incident and found to be an electrical problem. insurance investigated and vehicle was total loss. insurance paid ford motor credit $5,689.25 (claim [xxx]). ford motor credit obtained judgment and wages are currently being garnished on a vehicle that was claimed a total loss due to an electrical problem. *Jb updated 07/18/2012 *js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6)
- Vehicle speed control › Cruise control · Visibility › Power window devices and controls
On august 20TH, while in a repair shop having the motors replaced in the windows of my ford windstar 1997, there was a fire under the hood while the car was off. the mechanic put the fire out and I took it to my mechanic the same day. the cruise control mechanism was what caught fire. after…
On august 20TH, while in a repair shop having the motors replaced in the windows of my ford windstar 1997, there was a fire under the hood while the car was off. the mechanic put the fire out and I took it to my mechanic the same day. the cruise control mechanism was what caught fire. after seeing my mechanic I called the ford hotline and asked about recall information. they said they would get back ahold of me in two days, and they did not. today, august 30TH, while in wal-mart with my children I was paged to the parking lot. my car had caught fire again, while off and with no key in the ignition. the engine was destroyed, and luckily the fire department arrived in time to put the fire out before the interior of the car was destroyed (car seats, strollers, etc.). *nm
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Engine compartment fires
Ea08-021 IS closed with ford's actions in recall 09v-399 recalling approximately 4.5 million vehicles equipped with texas instruments speed control deactivation switches (scds).with this recall ford has now recalled all of the approximate 16 million ford model vehicles that were manufactured from my 1992 through 2003…
Ea08-021 IS closed with ford's actions in recall 09v-399 recalling approximately 4.5 million vehicles equipped with texas instruments speed control deactivation switches (scds).with this recall ford has now recalled all of the approximate 16 million ford model vehicles that were manufactured from my 1992 through 2003 with a texas instruments scds.nhtsa will continue to monitor the recalled vehicles to ensure remedies installed by ford tomitigate the potential for scds related fires are effective.the agency reserves the right to take further action if warranted by the circumstances.see attached closing report for further details.
- Engine compartment fires
Odi has received 134 consumer complaints, 285 manufacturer complaints, and 137 manufacturer warranty claims alleging incidents of engine compartment fire in model year (my) 1995 thru 2003 ford windstar vehicles.two of the odi complaints allege the fires caused structural damage to the complainant's home.of the 134 odi…
Odi has received 134 consumer complaints, 285 manufacturer complaints, and 137 manufacturer warranty claims alleging incidents of engine compartment fire in model year (my) 1995 thru 2003 ford windstar vehicles.two of the odi complaints allege the fires caused structural damage to the complainant's home.of the 134 odi complaints, 36 allege the fire occurred while the vehicle was parked, 72 allege the fire occurred while the vehicle was running and 26 of the complaints do not specify if the vehicle was running or not.further review of the odi complaints shows that 72 allege that the speed control deactivation switch (scds) caused the fire and 10 allege that the scds leaked brake fluid on to the ABS module resulting in the fire.there were 52 that did not identify a cause or that identified miscellaneous other causes.odi has also received 89 complaints ( not counted in this resume) alleging that the scds developed a brake fluid leak.thirteen of these complaints say that the leak at the scds resulted in braked fluid reaching the ABS module.this pe has been upgraded to an engineering analysis (ea) to further evaluate the cause of the fires and assess the scope, frequency, and safety consequences of the alleged defect.
- Wheel stud fracture
The subject vehicles range in age from 4?7 years in service, with average mileages estimated to range from 50 to 100 thousand miles.at these mileages, the subject wheels are likely to have been removed and reinstalled multiple times for various service procedures.odi IS concerned about the high wheel separation rates…
The subject vehicles range in age from 4?7 years in service, with average mileages estimated to range from 50 to 100 thousand miles.at these mileages, the subject wheels are likely to have been removed and reinstalled multiple times for various service procedures.odi IS concerned about the high wheel separation rates in the my 1997-98 windstar vehicles equipped with aluminum alloy wheels.however, analysis of failure data indicates that most of the incidents in that population of vehicles occur after the vehicles had accumulated 30 thousand miles of service. The factors that increase the risk that inadequate clamp loads may be achieved during service-related wheel installation are not unique to the subject vehicles.testing conducted by ford and vrtc indicate that the my 1998 windstar aluminum wheel fastening system performs similar to the wheel fastening systems on peer minivans.no design or manufacturing defects were identified in the wheel fastening systems of the subject vehicles. Ford will send a mailing to owners of windstar vehicles with aluminum wheels that have high wheel separation rates that reviews the appropriate wheel fastening procedures and states that the wheel nuts should be tightened to the nominal torque, 100 ft-lbs (136 nm), and re-tightened to the same torque after 500 miles.ford?s letter also states that it IS ?a good practice to be sure that before installing the wheel the aluminum wheel mounting surface, wheel lug nut area, and the mounting flange are free from dirt, debris, and loose rust to ensure the wheel IS seated correctly and the wheel lug nuts remain fully tightened.? Odi will continue to monitor the incidence of wheel fastener failures in the subject vehicle population.accordingly, this investigation IS closed.the closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.the agency will take further action if warranted by the circumstances. For additional information, see the attached closing report.
- Suspension coil spring breakage
There is no summary currently available
- Suspension coil spring breakage
There is no summary currently available
- Fuel tank cracks
There is no summary currently available
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10183766For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount could separate from the vehicle subframe. Separation of one LCA attachment or both rear body mounts may result in a loss of vehicle directional control, increasing the risk of a crash.
- 10014086General (pcm) power train control module programming procedures.
- 10013060Climate control a/c service tech tips.
- 10010637Literature program 04l23. Customer maintenance reminder - aluminum wheel lug nut torque.
- 10008580Lamp-brake-invadvertent disabling of brake shift interlock.
- 10008304Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application.
- 10008183Groan/buzz/vibration when the gear selector IS in park with the vehicle parked on an incline. This bulletin updates previous bulletin 17358, dated 11/01/2003 to include 2005 models.
- 10004886Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system.
- 10004027Remote keyless entry (rke) - service tips.
- 10003853Slight amount of fluid residue on the outside of the rear wheel cylinder dust boot on vehicles with rear drum brakes.
- 10003748New transmission cooler flusher - service tips. 2003 escort and super duty f series included.
- 10002780Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457.
- 10002684Torque converter clutch not engaging when commanded and/or diagnostic trouble codes p0741 or p1744 stored in memory. Models from 1996 to 2003.
- 10000592Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340.
- 6092131Some vehicles with 3.8L engine may exhibit black soot on the lower section of the right rear quarter panel.
- 6091315Suspension-diagnostic aan inspection for front suspension noise (s)- service tip. Tip.
- 6090716Some vehicles may exhibit black soot emitted from the tailpipe leaving deposits on right rearl lower quarter panel.
- 6090638Information regarding tsb 97-20-08 for 3.8L engines only. *Mjs
- 6090542Information regarding front cover & water pump bolts-torque valve revision/3.8-4.2l. *Mjs
- 6090538Information regarding camshaft position (cmp) sensor alignment tool chart. *Mjs
- 6090310Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes.
- 6090309Information regarding a change in the torque values of the engine front cover water pump bolts.
- 6090087Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems.
- 6090085Service information for musty and mildew type odors coming from the air conditioning / heating system.
- 6090082Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement.
- 6090053Some vehicles equipped with AX4S transaxle, may exhibit a harsh 2-3 downshift may occur when coasting around a corner and then accelerating.
- 6090051Service tip information on revised oil pan gasket replacement procedure.
- 6089681Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses.
- 6089651Subject on engine coolant leaking into the engine oil on some vehicles.
- 637456Subject regarding power steering line part ordering information.
- 636361Some vehicles may exhibit rear drum brakes that drag or will not release properly when operated in wet conditions and / or below freezing temperatures.
- 636312Exhibiting intermittent anti-skid brake system and / or red brake lamp on at times while driving.
- 635987Grunt / popping noise coming from the front suspension at speeds below 20 mph when turning.
- 635966Some vehicles may exhibit a popping / grinding noise from the front of the vehicle when going over bumps or making turns.
- 630515Engine oil system priming procedures, service tips for reports of premature engine failure.
- 630356Some vehicles may exhibit a park pullout clunk noise when shifting from park to another gear position.
- 630354Some vehicles may run rough at cruise or momentarily after stopping, a check engine light,and p030x codes.
- 630351Some vehicles may exhibit a groan/buzz/vibration when the gear selector IS in park.
- 630001Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area.
- 627927Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174.
Every Ford Windstar model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.