2007 International Prostar
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › International › Prostar › 2007
These records cover every 2007 International Prostar. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 2007 International Prostar. Newest first.
Navistar IS recalling 51,588 heavy trucks, commercial buses and school buses manufactured between november 21, 2000 and may 21, 2008, equipped with one or more remote power modules. the potting material that encapsulates the circuit board of the vehicle's remote power module may not sufficiently seal the circuit board from water and contamination…
Risk and remedy
Risk
A fire could cause personal injury or death.
Remedy
Navistar will notify owners and repair the vehicles free of charge. the recall began on july 10, 2008. owners may contact navistar at 1-280-461-1890.
On certain trucks, one or both rear axle housings may contain thinner material than what IS necessary for normal vehicle operation. over time, this thinner material may result in a fatigue failure of the rear axle housing, possibly in the location of the brake flange.
Risk and remedy
Risk
A crack in the brake flange location of the rear axle housing may result in a wheel end lockup or wheel separation possibly resulting in property damage, personal injury, or death.
Remedy
Dealers will inspect the vehicle's rear axles and, if necessary, replace the axle housings. the recall began on may 18, 2007. owners may contact international at 1-800-448-7815.
On certain trucks equipped with davco fuel pro 382 heated fuel filters, when the key IS in the 'on' position, the pre-heater, located in the fuel filter base, IS energized.
Risk and remedy
Risk
If this pre-heater IS energized while maintenance IS being performed on the fuel filter, diesel fuel could ignite within the filter housing. a fire within the fuel filter housing may spread possibly resulting in property damage or personal injury.
Remedy
Dealers will inspect the fuel filters and fuel heaters and, if necessary, will replace the fuel heater. the recall began on may 11, 2007. owners may contact international at 1-800-448-7825.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010428This article addresses chassis lean conditions on all chassis. This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
- 10253979This document is to guide users to eliminate brake pedal rattle noise.
- 10251414Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
- 10251409Suggested alignment target values when performing a vehicle axle alignment.
- 10246231J1939 Data Link Source Address Information
- 10243596General Wheel Speed Sensor Troubleshooting
- 10243595Diagnosis of chassis wander complaints.
- 10241555J1939 Data Link Source Address Information
- 10241554J1939 Data Link Troubleshooting
- 10240193Snap-On torque wrench requirement for all big bore engine connecting rod bolts; A26, MaxxForce 13, N13 engines
- 10236042New Air compressor Incorporates an oil feed dowel O-ring; only models built with MaxxForce 11/13, N13, or A26 Engines
- 10234000Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
- 10227455J1939 Data link source address information
- 10222490Pico Scope CCOS (Crankcase Separator Test)
- 10219330PicoScope Test One Channel RCT
- 10219328PicoScope Wheel Speed Sensor Test
- 10219325PicoScope Test Resistance and Ohmmeter
- 10219319PicoScope Test for Datalink (CAN) Health Shorts & opens
- 10219314PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
- 10219307PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
- 10208432ECM Calibration for DPF Replacement; Applies to MaxxForce Engines
- 10204139Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
- 10204137J1939 Data Link Troubleshooting
- 10201758Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
- 10199915General wheel speed sensor troubleshooting
- 10198708Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
- 10189743Suggested alignment target values when performing a vehicle axle alignment
- 10185108ECM Calibration for DPF Replacement; only trucks and busses built with 2007- 2009 MaxxForce DT/9/10. 2010-2012 MaxxForce DT/9/10, 2007-2009 MaxxForce V8, 2008-2009 MaxxForce 11/13 engines
- 10179294Driveline Information Center and Troubleshooting Procedures
- 10179289Repair Procedures for Vehicles Struck by Lightning
- 10177096A/C Refrigerant and Oil Capacities
- 10173025Cleaning and Disinfecting Trucks and Buses
- 10172045J1939 Data Link Troubleshooting
- 10170952Bendix EC80 Blank Module Replacement Program; This document will guide the user through selecting the correct ABS module when it has been determined a replacement is needed. Only Models with EC-80 ABS Controller
- 10167679SkyRise Roof Replacement
- 10167661Power Windows Stop Randomly or are Inoperative, Power Door Locks are inoperative
- 10167657How To Get A Helios Capture; only 1939 and 1708 multiplexed buses and trucks
- 10167629Updating Body Controller Software
- 10167614Cummins Ambient Air Temperature (AAT) Sensor Located Rear of Vehicle; Only models with Cummins ISX or ISM engines
- 10167608Cummins Active Fault Code 249 / 256 Ambient Air Temperature Sensor; only models with Cummins ISX or ISM engines
Every International Prostar model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.