2020 Mercedes-Benz Metris
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Mercedes-Benz › Metris › 2020
These records cover every 2020 Mercedes-Benz Metris. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
8 recalls name the 2020 Mercedes-Benz Metris. Newest first.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 and 2022-2023 Mercedes-Benz Metris right-hand-drive vehicles. Water may accumulate on the air bag control unit, which can cause the air bags not to deploy as intended.
Risk and remedy
Risk
An air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy
Dealers will install a cover on the air bag control unit, free of charge. Owner notification letters were mailed beginning April 10, 2026. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2KORSRS. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning February 13, 2026.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020-2023 Mercedes-Benz Metris vehicles. The electrical connections for the infotainment system may not be properly secured, which can cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111…
Risk and remedy
Risk
A rearview image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy
Dealers will inspect and repair the infotainment system connection, as necessary, free of charge. Owner notification letters were mailed November 11, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2GARPIN.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Risk and remedy
Risk
A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy
The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017-2022 Mercedes-Benz Metris vehicles. The connection of the upper and lower fuel hoses to the engine may be insecure, which can result in a fuel leak.
Risk and remedy
Risk
A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Dealers will inspect and repair the fuel hose connections, and replace the clamps and fuel hose, as necessary, free of charge. Owner notification letters were mailed May 5, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2KRAUCH.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2021 Mercedes-Benz Metris vehicles. The brake fluid reservoir may be incorrectly mounted, which can allow it to detach.
Risk and remedy
Risk
A detached brake fluid reservoir can leak brake fluid, increasing the risk of a crash.
Remedy
Dealers will inspect and repair the brake fluid reservoir mounting, as necessary, free of charge. Owner notification letters were mailed on May 2, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2BE42BRE.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Risk and remedy
Risk
Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy
DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Metris right-hand drive vehicles. The screwed fittings between the rigid steel brake lines routed through the underbody of the vehicle and the brake hoses in the area of the front and rear axles may not have been correctly installed.
Risk and remedy
Risk
The connection between the brake line and the brake hose may leak, causing a sudden loss of brake fluids, impacting braking performance and increasing the risk of a crash.
Remedy
DVUSA will notify owners, and dealers will check the affected fittings at the connection points of the brake lines to the brake hoses, correcting them as necessary, free of charge. The recall began December 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2BREMPOS.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2019 Mercedes-Benz Metris vehicles. The integrated backup battery compartment located underneath the front passenger's seat may not have its own cover, potentially exposing the battery when the seat is moved forward.
Risk and remedy
Risk
If conductive material, such as metal, unintentionally drops into the opening and contacts the terminals on the battery, an electrical short can occur, increasing the risk of a fire.
Remedy
DVUSA will notify owners, and Mercedes-Benz dealers will install covers over the battery compartment area, free of charge. DVUSA issued owners an interim notification on December 2, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SITZAB.
Owner complaints
7 complaints
What owners report most
Latest complaints
- Wheels
(From factory)continental vanco 4 season 225 17 101H tires premature excessive wear @ 12,000 miles. tires were always inflated to recommended psi with no TPMS warning lamps tires are now unsafe to drive on and could cause a blowout, crash, injury or death. mb IS not owning up to the wrong tire…
(From factory)continental vanco 4 season 225 17 101H tires premature excessive wear @ 12,000 miles. tires were always inflated to recommended psi with no TPMS warning lamps tires are now unsafe to drive on and could cause a blowout, crash, injury or death. mb IS not owning up to the wrong tire size and rating on these vans and being under rated from what what it should be . current mbusa recommended tire is 235/55/r17 with 103H load rating. seems that the tires that came with the van are the incorrect tire size and load rating which put driver at risk for rapid onset tire wear and damage risking in blowout or accident.
- Wheels
My vehicle has a manufacturing defect that has been causing excessive tire wear and alignment issues. New tires are needed every 7k miles and the wheels will not stay in alignment. This has been reported by many other owners. I have put together the following website to detail the problem and…
My vehicle has a manufacturing defect that has been causing excessive tire wear and alignment issues. New tires are needed every 7k miles and the wheels will not stay in alignment. This has been reported by many other owners. I have put together the following website to detail the problem and link to reports of the same: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Steering
Power steering malfunction caused by computer glitch when we had a bump. SeeNHTSA recall #17V-595 for earlier manufactured Metris.Yes- available for inspection. Yes, loss of power steering endangered us an anything in our path as we attempted to steer the van without powered steering I don’t know…
Power steering malfunction caused by computer glitch when we had a bump. SeeNHTSA recall #17V-595 for earlier manufactured Metris.Yes- available for inspection. Yes, loss of power steering endangered us an anything in our path as we attempted to steer the van without powered steering I don’t know if it can be confirmed by a independent service center, but there is a history of this with other owners and I assumed it can. It has been inspected by a Merecedes service center, see the enclosed repair estimate. No warning ,a bell dinged a red service message came on when we hit the bump.
- Electrical system
After one year of ownership, purchased used from dealer with 40 miles) I have to replace control unit due to the location of the unit in the car developing mold from condensation. Is a common problem, is widely discussed on the internet, and MBZ does not cover under warranty. The repair is to replace the unit ($2,700 in labor/parts) and place a plastic bag over the new unit.
- Steering
To whom it may concern, while driving on the highway I lost function of power steering and a message came on stating "power steering malfunction see operator manual".
- Unknown or other
Rear view camera control module broken. This causes rear view camera to be stuck in the housing and inoperable, so this is a safety issue. The rear view camera system was installed improperly. Instead of in the rear door panel, the control module was installed in the right side D panel.…
Rear view camera control module broken. This causes rear view camera to be stuck in the housing and inoperable, so this is a safety issue. The rear view camera system was installed improperly. Instead of in the rear door panel, the control module was installed in the right side D panel. Additionally, it was not secured properly but was just placed loosely in a plastic bag. Rear view camera system available for inspection upon request. I know for a fact that this is the case with other new 2020 Mercedes Metris. Additional information available upon request. I have had multiple conversations with MB Santa Rosa, CA and MB Wilsonville, OR and they have not been helpful. They expect me to pay for the part, even though MB did not install it properly. They refuse to fix the rear view camera system and restore it to factory specifications.
- Electrical system · Unknown or other
Rearview camera broken
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011223SMOG/Emissions Test fail due to one or more Readiness Monitors not set Complaint: The vehicle has failed the State Emissions Certification because one or more of the OBDII readiness monitors are not completely set. Cause: One or more of the following Readiness Monitors are not fully set within XENTRY: Misfire Monitoring - Injection System Fuel System Monitoring - Injection System, Fuel System, EGR Valve, O2 Sensor NMHC Catalyst Monitoring - NMHC/Diesel Oxidation Catalyst NOx Aftertreatment Monitoring - SCR Catalyst System Boost Pressure System Monitoring - Turbocharger, Charge Air System Exhaust Gas Sensor Monitoring - O2 Sensor, NOx Sensors Diesel Particulate Filter Monitoring - Diesel Particulate Filter System Exhaust Gas Recirculation System Monitoring - EGR Valve and system Remedy: Please complete the required driving conditions to fully set the incomplete Readiness Monitor. DO NOT: - Erase any fault codes. If fault codes are present, process these and allow the readiness drives to clear fault codes. - Flash or SCN code the CDI or SCR control units. - Perform a manual DPF regeneration, unless instructed below. - Disconnect the main battery.
- 11009854Complaint: Noises when reversing slowly <5 km/h (squeaking) Cause: There is a seal in the electric drivetrain that seals off the coolant system from the electric motor. This seal is moistened with coolant during forward travel. As a result of the change in rotational direction when reversing slowly, it may be the case that this sealing ring is no longer moistened. Squeaking noises may occur as a result of the so-called "stick-slip effect". This behavior does not impact the function or durability of the sealing ring and electric drivetrain. Remedy: Do not replace any parts. Explain the cause of the noises to the customer.
- 11005572Mercedes-Benz AG, the manufacturer of Mercedes-Benz Vans, has determined that on certain Sprinter and Metris vehicles, the B-pillar certification label might not contain information on the vehicle's rim size, tire size, and cold tire inflation pressure required under FMVSS 110 or, as applicable, FMVSS 120. In this case, relevant regulatory requirements might not be met. Mercedes-Benz believes this issue has no impact on vehicle safety. Mercedes-Benz intends to submit a petition to NHTSA for exemption from the notification and remedy requirements of 49 U.S.C. chapter 301, pursuant to 49 CFR Part 556, on the basis that this non-compliance is inconsequential as it relates to motor vehicle safety. MBUSA will conduct a service campaign to remedy new vehicles in dealer inventory. An authorized Mercedes- Benz dealer will replace the Certification Label on the affected vehicles.
- 10240175The connection of the customer's smartphone connected via the original USB cable is disconnected after an undefined period of time for no apparent reason. The Apple iPhone 12 and subsequent models are primarily affected by this. Hardware for radio control unit (Audio) (N87/15) Modification to hardware for radio control unit (Audio) (N87/15). Note: In isolated cases, the replacement chain is not depicted correctly in XENTRY Parts Information (XPI). Please ensure that one of the following replacement part numbers (suitable for the vehicle equipment) is ordered: Audio30 - A4479002421 Audio40 - A4479002721 Note: Please refer to this LI in the "Notes" section of the warranty claim
- 10240168Various concerns in relation to electric power steering including Rattling/humming noise from electric power steering when steering fully turned (see video recordings 01 and 02).
- 10231020Complaint Various issues including control unit programming procedure will not complete successfully/no newer software found, communication faults, or sporadic malfunction of systems. Cause Aftermarket CAN device could be installed into the vehicle's CAN network. Such devices can be but are not limited to, remote start modules, CAN blockers, or high idle modules. Remedy A successful control unit programming session cannot be ensured while aftermarket devices are connected to the vehicle's CAN network. Some of the device companies supply a bypass to allow control unit programming.
- 10228811Complaint Camera cover of reversing camera does not fold in (see Picture 01, shown on vehicle with code W65 (Tailgate)). Remedy Note: Do not replace any component parts or carry out any diagnostic work! Model 447.6/7 (Metris) As of the introduction of code FR1 (Rearview camera, non-folding), the folding function of the reversing camera is no longer available (discontinuation of camera cover (KAB) control unit (N144)). Consequently, the reversing camera remains open/folded out at all times. The representation of the camera image on the media display of the radio/radio- navigation (N87/15) is not restricted and functions in the usual way. Information: There are no plans for a retrospective adaptation of the folding function through Aftersales.
- 10228605(RC)Update Hermes Communication Module Software
- 10217645(RC)Update Hermes Communication Module Software
- 10217596(SC)Provide Supplementary Operator's Manual
- 10215010Complaint In order to better analyze the situation in the field and the wide variety of complaints relating to the Metris Infotainment System Audio 30/40 (GARMIN), a questionnaire must be completed and a log file created for the aforesaid component when a complaint is made. In addition, please create a PTSS case and add the questionnaire and the log file to this as attachments. The procedure for completing the questionnaire and creating the log file is described under "Remedy" It is particularly important that you pay attention to the checklist and the requirements for creating a PTSS case (see point 5 "Remedy") relating to the Metris Infotainment System Audio 30/40 (GARMIN) Cause Under analysis Remedy IMPORTANT: Before creating a PTSS case, it is essential to check whether a LI for a complaint has already been published and whether the Metris Infotainment System Audio 30/40 (GARMIN) has the latest software release installed.
- 10215008Complaint The volume of the radio/radio - navigation (RD) control unit (N87/15) is too quiet even at maximum volume. Cause Radio/radio - navigation (RD) control unit (N87/15) software Remedy Remedy of new software for radio/radio - navigation (RD) control unit (N87/15) is expected to be available in Q4/2022
- 10215007Complaint The person being called/caller is hard to understand when traveling at speeds greater than 80 km/h(50mph) in the vehicle. Cause Radio/radio - navigation (RD) control unit (N87/15) software Remedy Remedy of new software for radio/radio - navigation (RD) control unit (N87/15) is expected to be available in Q4/2022.
- 10215006Complaint - Regionally strong broadcasting stations are poorly received or not received at all. - Interruptions to reception when driving Cause - Third-party installations (e.g. GPS trackers) - Periphery of antenna (e.g. stone chipping on windshield, antenna amplifier, etc.) - Broadcaster reception area reached, no alternative frequency available - Radio/radio - navigation (RD) control unit (N87/15) Remedy Important note: In light of this, we would like to point out that third-party electrical installations/electrical retrofitting operations in the vehicle can significantly contribute to faults. The vehicle must always be checked in its standard condition.
- 10215003Complaint As soon as a telephone call via Apple CarPlay is ended, the connection to the customer's connected smartphone is disconnected and the radio/radio - navigation (RD) control unit (N87/15) can no longer be operated. Cause 1. Radio/radio - navigation (RD) control unit (N87/15) software 2. Apple iOS software status Remedy 1. Update radio/radio - navigation (RD) control unit (N87/15) software to the latest software status. 2. Update software of customer smartphone to current iOS version.
- 10215002Complaint The connection of the customer's smartphone connected via the original USB cable is disconnected after an undefined period of time for no apparent reason. The Apple iPhone 12 and subsequent models are primarily affected by this. Cause Hardware for radio control unit (Audio) (N87/15) Remedy Modification to hardware for radio control unit (Audio) (N87/15). Due to the worldwide semiconductor crisis and internal development processes, this remedy will only be available by the start of/middle of 2023 at the earliest.
- 10215001Complaint Head unit for Audio 30/40 VIS (Garmin) - Problems at market launch. Information: At market launch of the head unit for Audio 30/40 VIS (Garmin), some of the functions are only available to a limited extent or are not yet available. This can result in various problems. At the workshop, during delivery inspection: 1. After transport mode is deactivated, the Audio 30/40 VIS (Garmin) head unit cannot be commissioned. 2. Apple CarPlay or Android Auto not available (see "Important mail" 16-2020) (Smartphone Integration). Other possible customer complaints: - System: System instability when using Bluetooth telephony, the multimedia system and/or the USB flash drive. - Reversing camera: Reversing camera menu inoperative when starting the system. - Bluetooth telephony: No call list display. - Bluetooth telephony: No name display for calls if telephone number is not stored with country code +34. Cause Software release. Remedy Update control unit software
- 10212905Ecall Hermes Software Update.
- 10212901Check and Replace Fuel Hose Clamps and Hose.
- 10212899Brake Fluid Reservoir Mounting.
- 10206636Replace Certain Seatbelts
- 10206074"Audio 30/40 VIS (Garmin) head unit - Con- nection failure with smartphone integration "
- 10205440Update Fuel System Control Unit
- 10205186Update document with remedy. Newly released purge valve.
- 10199660Coolant warning in instrument cluster - Leak in coolant line
- 10199654"Free browsing, Internet access via Wi-Fi hotspot and Internet radio nonfunctional"
- 10186328Inspect Brake Hose Fittings
- 10186327Update Radio Software
- 10180324Propeller Shaft
- 10179965Head unit for Audio 30/40 VIS (Garmin) - Various Complaints
- 10177565The mobile phone address book is not transferred completely to the multimedia system (COMAND or MBUX). In some cases, the call list shows just the telephone numbers but no names. The problem only occurs in conjunction with the iPhone and software version iOS 13.x.
- 10177554The left windshield wiper contacts the left hood hinge trim when the hood is open.
- 10177552The mobile phone address book is not transferred completely to the multimedia system (COMAND or MBUX). In some cases, the call list shows just the telephone numbers but no names. The problem only occurs in conjunction with the iPhone and software version iOS 13.x.
- 10172503Seat Base Cover
- 10171649Fault message in instrument cluster "SOS not ready" - SOS button in overhead control panel flashes
- 10170541Seat belt does not roll up correctly
- 10168258Initial NCU - Seat Base Cover
- 10162177Supplemental Cruise Control Installation Instructions, 447 without Code MS1
Every Mercedes-Benz Metris model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.