2005 Nissan Armada
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Nissan › Armada › 2005
These records cover every 2005 Nissan Armada. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2005 Nissan Armada. Newest first.
Nissan IS recalling certain model year 2004-2006 armada, titan, infiniti QX56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. The ecm relay may allow silicon vapor to form and…
Risk and remedy
Risk
This could cause engine stalling increasing the risk of a crash.
Remedy
Dealers will replace the ecm relay inside the ipdm assembly. This service will be performed free of charge. the safety recall began on december 6, 2010. owners may contact nissan at 1-800-647-7261.
Nissan IS recalling certain front and rear lower links, p/nos. 54501Zq00a, 54500zq00a, 551a1zq00a, 551a0zq00a , 54501ea00a, 54500ea00a, 551a1ea500, 551a0ea500, 54501zr00a, and 54500zr00a, sold between november 25, 2009 and may 14, 2010 as replacement parts for model year 2004 through 2010 titan, armada, and QX56, and model years 2005 through 2010 frontier…
Risk and remedy
Risk
If the collar weld separates, the vehicle handling will deteriorate, possibly resulting in a vehicle crash.
Remedy
Nissan will notify owners and dealers will replace any affected lower link free of charge. the safety recall began on july 12, 2010. owners may contact nissan at 1-800-647-7261.
Nissan IS recalling certain model year 2005-2009 titan, armada, and infiniti QX56 vehicles. the instrument panel fuel gauge may inaccurately display that the vehicle still has some fuel, typically about one quarter tank, when the fuel tank IS empty.
Risk and remedy
Risk
This could cause the vehicle to run out of gas and stall on the highway, which could cause a crash.
Remedy
Dealers will replace the fuel sender unit inside the fuel tank with a new improved sender card. this service will be performed free of charge. the safety recall began on march 22, 2010. owners may contact nissan at 1-800-647-7261.
Nissan IS recalling 180,664 my 2005-2006 titan, armada and infinity QX56 vehicles manufactured after march 17, 2005, that are equipped with a visteon air conditioning condenser fan motor. The fan motor may not be properly sealed allowing excessive water intrusion and inadequate drainage of moisture.
Risk and remedy
Risk
This could cause corrosion in the motor leading possibly to overheating and a fire.
Remedy
Dealers will install a 'thermal protector kit' and test the air conditioning condenser fan motor and replace it if necessary. the recall began on august 2, 2008. owners may contact nissan at 1-800-647-7261.
Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an…
Risk and remedy
Risk
This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
Remedy
Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
Owner complaints
373 complaints8 involved a crash5 involved a fire7 injuries
What owners report most
Latest complaints
- Air bags
Unknown the light for air bags is on
- Fuel/propulsion system
For several years now since I received this car from a family member gas gauge has been not working I contacted Nissan they said my year or VIN number was it affected but that's not accurate because it is so what can I do
- Seat belts · Service brakes
My breaking system has a malfunction that comes on and off. Sometimes the brakes automatically stop working and start grinding as if I have no brakes, but when I brought it to be looked at they couldn't find the problem. I notice that when you turn the car off and turn it back on the problems of…
My breaking system has a malfunction that comes on and off. Sometimes the brakes automatically stop working and start grinding as if I have no brakes, but when I brought it to be looked at they couldn't find the problem. I notice that when you turn the car off and turn it back on the problems of sides for a little while will eventually come back later. For someone to detect it, they cannot shut the car off at the time that is presenting itself.
- Steering · Visibility/wiper · Wheels
I got this vehicle from a buy here pay here with 355,xxx miles the motor runs and drives great but when I went to go down the interstate after a month having the vehicle it was shaking really bad so I called auto parts and autozone and even took it to a mechanic they all told me alignment and if…
I got this vehicle from a buy here pay here with 355,xxx miles the motor runs and drives great but when I went to go down the interstate after a month having the vehicle it was shaking really bad so I called auto parts and autozone and even took it to a mechanic they all told me alignment and if that doesn't work them put new rotors and breaks and we'll it's still there and if you go 35 you can hear something rubbing and when you hit 60 it starts shaking really bad and the steering wheel is very hard to hold when this happens so still don't know what it is!
- Electrical system · Engine · Forward collision avoidance › Automatic emergency braking
Engine brake transmission speed failure
- Electrical system · Engine · Service brakes
The brakes light comes on frequently and brakes stop working properly when going over a bump in the road decrease speed then engine fails. Has to be turned off then on to start engine.
- Service brakes
I have a 2005 Nissan Armada that has a known problem with its brakes. It has a faulty Delta Brake Sensor and Brake Booster. What happens is that the brake light comeson, the vehicle losses its braking ability and sounds like metal scraping when you apply the brakes. The issue will reset if you…
I have a 2005 Nissan Armada that has a known problem with its brakes. It has a faulty Delta Brake Sensor and Brake Booster. What happens is that the brake light comeson, the vehicle losses its braking ability and sounds like metal scraping when you apply the brakes. The issue will reset if you turn off the car. Nissan knows about this issue but has failed to send 2004-2006 Armada owners of information on how to get this fixed at a local dealer. Here is a link to the class action settlement: https://topclassactions.com/lawsuit-settlements/closed-settlements/nissan-brake-defect-class-action-settlement/ My complaint is this, there were 350,000 affected vehicles and mine was one of them. I was never notified by Nissan of this faulty part and did not know that Nissan would reimburse me for the repair. The settlement date is now closed but the problem still exists in many Nissan affected vehicles. I called Nissan USA and they said Nissan could do nothing for me. I called my local Nissan dealer and described the problem and they said they could do nothing for me but that I could pay out of pocket to have the brake booster replaced at qa cost of $1500f or parts and labor. The error code associated with this problem is C1179. This issue is a safety issue and it affects the vehicles ability to stop. If you do not see the brake warning light on you do not know that the issue is happening. This could result in a dangerous situation at highway speeds. I would like the NHTSA to get involved and to demand that Nissan repair this known problem free of charge. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
- Fuel system, other
The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge inaccurately displayed the fuel level in the tank while the fuel tank was empty; causing the vehicle to stall. The contact refueled the vehicle and was able to restart the vehicle. The vehicle was not diagnosed nor…
The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge inaccurately displayed the fuel level in the tank while the fuel tank was empty; causing the vehicle to stall. The contact refueled the vehicle and was able to restart the vehicle. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the VIN was not included in the recall. The failure mileage was approximately 192,000.
- Air bags · Steering
The contact owned a 2005 Nissan Armada. The contact stated that while driving at 45 MPH, his steering wheel was locked without warning. Due to the failure, the contact veered off the road and hit two parked vehicles. The air bags did not deploy upon impact. The contact stated that a little girl was…
The contact owned a 2005 Nissan Armada. The contact stated that while driving at 45 MPH, his steering wheel was locked without warning. Due to the failure, the contact veered off the road and hit two parked vehicles. The air bags did not deploy upon impact. The contact stated that a little girl was standing near one of the parked vehicles and was knocked into a tree and was airlifted to a child trauma center. The contact stated that from his knowledge, the girl was only treated for cuts and bruises. The contact stated that he was knocked out for a few minutes after impact but refused medical attention at the scene. He later went to the hospital and was treated for a concussion and whiplash. The contact stated that he believed that a police report was filed but was not certain. The vehicle was towed from the scene to an independent tow yard where it was deemed a total loss. The dealer nor the manufacturer have been notified of the failure. The vehicle had been destroyed. The failure mileage was approximately 215,000.
- Fuel system, other
The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge was incorrectly reporting the amount of fuel in the vehicle. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the Vin was not included. The…
The contact owns a 2005 Nissan Armada. The contact stated that the fuel gauge was incorrectly reporting the amount of fuel in the vehicle. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 10V074000 (Fuel System, Other) however, the Vin was not included. The manufacturer was informed of the failure and confirmed that the Vin was not included in the recall. The failure mileage was approximately 172,000.
- Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe
TL* the contact owns a 2005 nissan armada. The contact stated that the muffler had been replaced 3 times due to it cracking around the header. The contact stated that the muffler damaged wiring harness and the computer system, which caused the vehicle to stall. Hummel's nissan (4770 merle hay rd…
TL* the contact owns a 2005 nissan armada. The contact stated that the muffler had been replaced 3 times due to it cracking around the header. The contact stated that the muffler damaged wiring harness and the computer system, which caused the vehicle to stall. Hummel's nissan (4770 merle hay rd, des moines, ia 50322) was made aware of the failure. The muffler was replaced twice by the dealer however, the muffler failure recurred. The muffler was replaced a third time by an independent mechanic. The manufacturer was not made aware of the failure. The failure mileage was 68,000.
- Fuel/propulsion system
We bought this car used. The fuel gauge does not work once it gets down to 1/4 of the tank left. I was driving my car on a city street when all of the sudden my car just turned off. Luckily I was able to slowly steer over to the side of the road. I had no idea what was going on because my fuel…
We bought this car used. The fuel gauge does not work once it gets down to 1/4 of the tank left. I was driving my car on a city street when all of the sudden my car just turned off. Luckily I was able to slowly steer over to the side of the road. I had no idea what was going on because my fuel gauge said I still had 1/4 tank left of gas. This could've been far more dangerous if I would've run out of gas on a freeway or highway. There was a recall for this year and model for the fuel gauge inaccuracy, but when I called they said my vin didn't match the recall.
- Air bags · Service brakes · Steering
I'm driving the car straight 5 to 10 minutes, after that the car start shaking the vdcoff and slip light turn on and the stirring wheel stay turn slightly sideway to drive the car straight I turn off the car for 1 or 2 minute and everything on the car become normal for 5 to 10 more minute I have…
I'm driving the car straight 5 to 10 minutes, after that the car start shaking the vdcoff and slip light turn on and the stirring wheel stay turn slightly sideway to drive the car straight I turn off the car for 1 or 2 minute and everything on the car become normal for 5 to 10 more minute I have no idea what IS wrong with my car IS been park in my garage for two years I dont drive it and can sell it with that problem
- Service brakes
TL* the contact owns a 2005 nissan armada. The contact stated while driving 25 mph, the brakes locked up and the contact felt the vehicle slide when the brake pedal was depressed. The contact stated while making turns, the brakes locked up and made the steering wheel difficult to turn. The contact…
TL* the contact owns a 2005 nissan armada. The contact stated while driving 25 mph, the brakes locked up and the contact felt the vehicle slide when the brake pedal was depressed. The contact stated while making turns, the brakes locked up and made the steering wheel difficult to turn. The contact stated the ABS, the air bags, and the vdc off warning lights were illuminated. The vehicle was taken to an independent dealer to be diagnosed. The contact was informed that the brake booster needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was informed of the failure. The failure mileage was approximately 100,151.
- Service brakes · Traction control system
TL* the contact owns a 2005 nissan armada. The contact stated while driving 30 mph, the brake warning light and vehicle dynamic control (vdc) and slip warning light illuminated. The contact was unable to stop the vehicle using the brake pedal. The contact guided the vehicle to the side of the…
TL* the contact owns a 2005 nissan armada. The contact stated while driving 30 mph, the brake warning light and vehicle dynamic control (vdc) and slip warning light illuminated. The contact was unable to stop the vehicle using the brake pedal. The contact guided the vehicle to the side of the roadway. The contact stated she turned off the vehicle and after restarting, the vehicle functioned as designed. The contact stated she continued to experience the failure. The contact called zeigler nissan of orland park located at 8550 w 159th st, orland park, il 60462, (708) 403-1300, and made the dealer aware of the failure. The vehicle had not been diagnosed nor repaired. Upon investigation, the contact associated the failure with nhtsa campaign number: 07e046000 (equipment) however the vin was not included. The manufacturer had not been informed of failure. The failure mileage was 147,000.
- Service brakes
This IS a major safety issue! the brake light on the control panel comes on and when stepping on the brakes, the car hardly brakes. it feels like the brakes are grinding and skidding. I have to carefully pull the car over and turn the car off and back on. Lately this has been happening around once a week.
- Fuel/propulsion system
The fuel gage gets to one quarter and it starts to be inaccurate and will run out of gas showing one quarter tank. The fuel gage will not work right until you have over three quarters in. I got so low on fuel the light was on three days ago. I put a few gallons in when I got to town it shower…
The fuel gage gets to one quarter and it starts to be inaccurate and will run out of gas showing one quarter tank. The fuel gage will not work right until you have over three quarters in. I got so low on fuel the light was on three days ago. I put a few gallons in when I got to town it shower there was 1/8 of a tank by the time I got home it was showing a little over 1/4 were it was when it ran out of gas 1 1/2 years ago. The next morning I had to go to town and it showed I had almost half a tank by the time I got there. I've put about 7 gallons in it and the fuel gage IS at the same place. When I filled the tank up the fuel gage started working probably. I've looked and there IS a recall on the fuel sending unit on some nissan armada already but this one isn't on the list
- Electronic stability control (esc)
Vdc off
- Fuel/propulsion system
Fuel reads at around 1/4 even when empty. not knowing it needed fuel, the car ran out of gas, stranding the car in the middle of the street. vehicle was going n motion at 35 mph, vehicle was guided to less crowded side street and stalled. Vehicle was pushed to an open space.
- Service brakes
While I was driving I applied the brakes and didn't have any and it made a loud sound I coasted to a stop turned car off. Called mechanic they came out and I had a blown fuse for my ABS system they replaced it but now I am wondering if this will happen again?
- Service brakes
Driving in traffic causes brakes to lock as if the parking brakes were set. I have to pull over safely to the side of the road and place the vehicle in park, press on the parking foot brake to engage and disengage the brakes, turn off and on the vehicle to "reset" the brakes. It happened a few…
Driving in traffic causes brakes to lock as if the parking brakes were set. I have to pull over safely to the side of the road and place the vehicle in park, press on the parking foot brake to engage and disengage the brakes, turn off and on the vehicle to "reset" the brakes. It happened a few times especially on the freeway. In all multiple occasions nearly rear ending the vehicle in front of me especially when I have my family with me in the vehicle. When this occurs the brake light comes on, on the dash. Happens on both the freeway and the city streets in motion and once when the brakes was press in traffic.
- Service brakes · Unknown or other
IS giving a delta stroke sensor c1179 and also suddenly the brake lights turns on and can't use the brakes and I have to turn it off and on again and it will go away but it happens even if I am on the highway and it worries me. Please let me know what IS this code because nobody seems to know. This has happened a couple of times
- Suspension
Badly rusted rear cross member and control arms
- Engine
TL* the contact owns a 2005 nissan armada. On several occasions, while driving approximately 40 mph and making a turn, the accelerator pedal was depressed and the vehicle stalled. Also, while traversing a hill on more than one occasion, the accelerator pedal was depressed and the vehicle failed to…
TL* the contact owns a 2005 nissan armada. On several occasions, while driving approximately 40 mph and making a turn, the accelerator pedal was depressed and the vehicle stalled. Also, while traversing a hill on more than one occasion, the accelerator pedal was depressed and the vehicle failed to respond. Furthermore, while in tow mode and accelerating above 2,000 rpms, the vehicle stalled on several occasions. The vehicle was not diagnosed or repaired. The vehicle was included in nhtsa campaign number: 10v517000 (engine and engine cooling). The dealer and manufacturer were not notified. The approximate failure mileage was 140,000.
- Fuel/propulsion system
TL* the contact owns a 2005 nissan armada. The contact stated that the fuel gauge failed to display the proper fuel level. If the fuel level was below a quarter of a tank, the vehicle would shut off. Rock hill nissan (550 galleria blvd, rock hill, sc 29730, (803) 818-2713) was notified and stated…
TL* the contact owns a 2005 nissan armada. The contact stated that the fuel gauge failed to display the proper fuel level. If the fuel level was below a quarter of a tank, the vehicle would shut off. Rock hill nissan (550 galleria blvd, rock hill, sc 29730, (803) 818-2713) was notified and stated that the vin was excluded from nhtsa campaign number: 10v074000 (fuel system, other). The dealer stated that further diagnostic testing was needed. The manufacturer was notified and confirmed that the vehicle was excluded from the recall. The vehicle was not repaired. The approximate failure mileage was 180,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Engine compartment fire
On may 30, 2008, the office of defects investigation (odi) opened a preliminary evaluation based on consumer complaints alleging that smoke and/or fire erupted in the engine compartment of model year (my) 2005-2006 nissan armada and titan vehicles.by letter dated june 24, 2008, nissan notified the national highway…
On may 30, 2008, the office of defects investigation (odi) opened a preliminary evaluation based on consumer complaints alleging that smoke and/or fire erupted in the engine compartment of model year (my) 2005-2006 nissan armada and titan vehicles.by letter dated june 24, 2008, nissan notified the national highway traffic safety administration (nhtsa) that it will conduct a safety recall (nhtsa #08v284) for my2005-2006 nissan titan, armada and infiniti QX56 vehicles manufactured from march 17, 2005 to august 21, 2006 that are equipped with a 90-watt air conditioning condenser fan.the recall involves approximately 180,664 vehicles.this also includes approximately 5,689 subject condenser fans, some of which may have been installed in my2004 and pre-march 17, 2005 my nissan titan, armada or infiniti QX56 vehicles as a service replacement part.nissan dealers will install a special thermal protector kit on existing fans that will eliminate the potential for a fire to occur.nissan north america, inc. (Nissan) informed odi that the 90-watt air conditioning condenser fan was manufactured out-of-specification allowing for excessive water intrusion and inadequate drainage of moisture that may accumulate in the motor as a result of water intrusion or condensation.if sufficient moisture accumulates in the motor without adequate drainage, corrosion may occur.the corrosion can cause an increase in internal friction and an increase in the electrical current draw, resulting in an increase in the temperature of the motor that could melt its wiring insulation and other plastic components and form a gas.if two wires without insulation touch each other and create a spark, this gas could ignite and result in a fire.the action taken by nissan IS sufficient to resolve the issue raised by this investigation.accordingly, this investigation IS closed.
- Side air bag non-deployment
The subject vehicles are equipped with optional seat-mounted side air bags.all vehicles are equipped with standard frontal air bags and side air curtains.installation of the incorrect srs diagnosis sensor unit does not impair deployment of the frontal air bag and side air curtain in the event of a crash.no reports of…
The subject vehicles are equipped with optional seat-mounted side air bags.all vehicles are equipped with standard frontal air bags and side air curtains.installation of the incorrect srs diagnosis sensor unit does not impair deployment of the frontal air bag and side air curtain in the event of a crash.no reports of non-deployment of the subject seat-mounted side air bags have been received by the manufacturer or by nhtsa.the warranty reports cited above represent vehicle inspections conducted under the service campaign and sensor replacement was required in 32 of these cases.the manufacturer reports a total of 151 sensor units sold as replacement parts for all purposes.investigation disclosed a low incidence of sensor replacement required under the service campaign to date.no incidents of real world non-deployment of the subject air bags were identified.this preliminary evaluation IS closed.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11007000VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2004-2012 Armada, 2004-2012 Titan, and 2004-2009 Quest vehicles, to inspect and if necessary, replace the driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification numbers PC944, PC946, PC947 and PC949 to this campaign. The vehicle specific number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealers responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealers inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11004962VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11004961CAN COMMUNICATION NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11004960CAN COMMUNICATION CODES DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001201WINDOW GLASS WARRANTY INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001194REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 11001191WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10243708DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10239062SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
- 1023906012 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect Test with DCA and Replace results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000 CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/ DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
- 10235710INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
- 10235707VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10233896ABS/VDC CAN DIAGNOSIS INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232658REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232657WHEEL BEARING COLLISION DAMAGE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232656WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10232652DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10208946CAN COMMUNICATION NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- 10192821SERVICE INFORMATION Replacement 5-speed rear wheel drive Automatic Transmission (A/T) assemblies and replacement control valves (valve bodies) now come with blank Transmission Control Modules (TCMs). Blank TCMs come without software and must be programmed (not reprogrammed) and then configured after they are installed. When ordering a replacement A/T or control valve, use the Nissan electronic parts information systems to obtain the correct software program part number See this bulletin for further detail.
- 10192805IF YOU CONFIRM A refrigerant leak at a refrigerant pipe/hose joint location. ACTIONS 1. Inspect the metal surfaces of the pipe/hose joint for damage or contamination. NOTE: Do not replace a refrigerant pipe, hose, or other A/C component if an o-ring seal will solve the leak incident, if it should occur. 2. If no damage is found to the joint metal surfaces, replace the O-ring seal. See this bulletin for further detail.
- 10192801SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement "Certification Label" or "VIN Plate / Label" may be needed. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. See this bulletin for further detail.
- 10192747IF YOU CONFRIM An oil leak at the right side block ball plug behind the alternator. ACTION Use a punch to seat the block ball plug in the hole (refer to the Service Procedure). NOTE - Do not replace the engine block for this incident if it should occur. See this bulletin for further detail.
- 10192727SERVICE INFORMATION The purpose of this bulletin is to give Nissan dealers guidelines to help determine if windshield breakage is covered under warranty or is the customer?s responsibility. Nissan North America (NNA) is not responsible for damage to glass that is a result of objects striking or scratching the glass. However, NNA is responsible for manufacturing issues such as distorted glass and cracks that are due to improper installation or damage to the glass during vehicle assembly. NNA typically does not find any type of cracks in the windshield due to stress after the dealership PDI. See this bulletin for further detail.
- 10192679SERVICE INFORMATION Power moonroof initialization procedures for the Applied Vehicles have been revised. The procedure described in this bulletin differs from the procedure in the Electronic Service Manual (ESM). At a later date and where possible, the applicable ESMs will be updated with the revised procedures. Follow the procedure in this bulletin should the power moonroof in an Applied Vehicle need to be initialized. See this bulletin for further details.
- 10192677SERVICE INFORMATION Windshield "foreign material" that is on the surface of the glass in some cases can be cleaned off with a very particular type and grade of steel wool. * Most any foreign material on the surface of the Windshield can be cleaned off by using #0000 super fine steel wool. >The #0000 grade super fine steel wool can be found in most hardware stores. Please see this bulletin for further details.
- 10192638SERVICE INFORMATION This bulletin has compiled Tire Pressure Monitor System (TPMS) and Low Tire Pressure Warning System (LTPWS) information for: - Basic diagnosing of TPMS/LTPWS systems - Radio frequency interference causing a "No Data" (C1708, C1709, C1710, C1711) condition - Sensor leaks - Moving TPMS/LTPWS wheel assemblies from one vehicle to another and TPMS/LTPWS sensor registration - Air pressure changes with altitude and ambient temperatures - Aftermarket tire sealers - Aftermarket wheels - Inflating/deflating tires with TPMS/LTPWS sensors See this bulletin for further detail.
- 10192591SERVICE INFORMATION After ECM reprogramming, the Calibration Verification Number (CVN) needs to be automatically calculated prior to State emissions testing (also known as Inspection Maintainence, I/M, or SMOG testing depending upon location). Allowing the vehicle to idle for 22 minutes will allow for faster CVN calculation. It is recommended that customers utilize this method if the vehicle needs to be tested for emissions soon after ECM reprogramming. See this bulletin for further detail.
- 10192524SERVICE INFORMATION When diagnosing possible power steering gear (rack and pinion steering rack, or steering rack) leak issues, it may appear the steering rack is leaking when actually, it?s not. Use this service bulletin to help make a more accurate diagnosis of the steering rack. See this bulletin for further detail.
- 10192513SERVICE INFORMATION Changes or modifications to the front seat assembly trim materials may affect the proper operation of the Front Seat-Mounted Side-Impact Supplemental Air Bags and Passenger Occupant Classification Sensor and could result in serious personal injury or death. Nissan STRONGLY RECOMMENDS AGAINST making any change to seat trim materials from the factory equipped condition. This specifically applies to replacing the seat trim with non-factory materials; adding leather/cloth seat covers, seat pads, or seat storage pouches, etc. around or over the seat back and the passenger seat cushion. See this bulletin for further detail.
- 10192474SERVICE INFORMATION If a customer describes lack of power or poor acceleration, perform the following checks before attempting any repair: * Check for stored DTCs. * Check if the driver is resting their left foot on the brake pedal while accelerating. Advise the customer not to rest their foot on the brake while accelerating. * Use CONSULT-III plus in Engine Data Monitor to check operation of the brake lamp circuit signal. Monitor the brake switch during the incident; it should be "OFF". Please see this bulletn for further details.
- 10192394SERVICE INFORMATION Related to communication codes U1000, U1001, U1002, U1010: - Always diagnose the communication codes first. - When a module reports a U1000 code, it is typically operating normally; however, there is a communication error external to that module on the CAN network. - U1000 indicates an error. V-CAN diagram or CAN Diag Support Monitor provides data to determine the location of the error. See this bulletin for more information.
- 10192326SERVICE INFORMATION The specifications for the intake and exhaust valves and valve lifter service parts have been changed. * The valve stem length of both intake and exhaust valve has been increased (Figure 1) and are a direct replacement for the shorter style valve. * The related valve lifter cup has been shortened (Figure 2) and the point at which the valve lifter contacts the valve stem has been shortened (not shown). These service parts will require that the valve and valve lifter be replaced at the same time. See this bulletin for further details.
- 10192305SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the "RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF, disconnect both battery terminals, and wait at least 3 minutes before performing any service on the SRS. See this bulletin for further detail.
- 10192234Two methods are used to update/upgrade Navigation Map Data: 1. The customer goes to www.nissannavigation.com and is mailed update disc(s) or SD Card and installs data, OR 2. The dealership is mailed update disc(s) and the customer must visit the dealership to have data installed. Use the matrix in this bulletin to determine which method is utilized for each Applied Vehicle. See this bulletin for further detail.
- 10192233Nissan Original Equipment or Genuine Accessory Alloy wheels, along with their finish coating (clear, chrome, titanium, etc.), are specifically developed to achieve Nissan design and performance standards. These Original Equipment or Genuine Accessory wheels are subjected to testing to ensure they meet Nissan's standards. Nissan Original Equipment Alloy or Genuine Accessory wheels subjected to aftermarket chroming may no longer continue to meet these standards and may be seriously damaged. Therefore, Nissan most strongly discourages, and recommends that these wheels NEVER be subjected to, aftermarket chroming. See this bulletinfor further detail.
- 10192231SERVICE INFORMATION This TSB is for troubleshooting of CAN Modules with "Diag-On-CAN" Diagnostics. The flow charts below are meant to troubleshoot current CAN DTCs. The flow charts are intended to diagnose one module at a time; repeat the process as needed for additional control units. Please see this bulleitn for further details.
- 10192217If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut PFM Series brake lathe has been chosen as the approved tool for rotor resurfacing. - The ProCut PFM Series brake lathe can be ordered from TECH-MATE at 1-800-662-2001. - ProCut technical support or service can be obtained by calling 1-800-543-6618. NOTE: Brake rotors may need to be resurfaced during routine brake repair or for brake "judder" incidents. - Brake judder: A brake pedal pulsation and/or steering wheel shimmy when braking that occurs when there is too much thickness variation of the brake rotors (see NTB00-033). See this bulletin for further detail.
- 10192216SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into the following categories: a. Brake Noise: A squeak, squeal, clunk, or groan that occurs when the brakes are applied or released. b. Brake Judder: A vibration that can be felt in the vehicle, steering wheel or brake pedal when the brakes are applied. c. Pedal Feel: The effort needed to operate the brakes is too high or too low. SERVICE PROCEDURE 1. Verify the condition by road testing the vehicle with the customer. 2. Determine the specific brake incident based on the description in the Service Information above. 3. Follow the appropriate repair procedure(s), listed on the following pages, for your specific incident. See this bulletin for further details.
- 10192192As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed self diagnosis of major emissions systems and components. - In these instances the State may require completion of the SRT before permitting the emissions inspection to proceed. Refer to this Bulletin for further details.
- 10192145SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition which is considered normal, does not affect strut/shock absorber operation or performance, and does not require replacement. - A strut or shock absorber that should be replaced due to rod resistance/noise issues. See this bulletin for further detail.
Every Nissan Armada model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.