2002 Pontiac Grand Am
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Pontiac › Grand Am › 2002
These records cover every 2002 Pontiac Grand Am. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2002 Pontiac Grand Am. Newest first.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model…
Risk and remedy
Risk
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Risk and remedy
Risk
Fuel may leak, possibly resulting in a fire.
Remedy
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Risk and remedy
Risk
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Remedy
Tradesonic will notify owners and replace the lamps free of charge. the recall IS expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Owner complaints
395 complaints22 involved a crash3 involved a fire23 injuries
What owners report most
Latest complaints
- Unknown or other
My pontiac grand am SE 4DS 3.4 liter engine 2002 has a problem with the security light keeps coming on & stays on & then when I shut it off & then get back in car to start it , it wouldn't start the security light flashes & I have to wait 10 minutes or for it to go out leaving the car in on…
My pontiac grand am SE 4DS 3.4 liter engine 2002 has a problem with the security light keeps coming on & stays on & then when I shut it off & then get back in car to start it , it wouldn't start the security light flashes & I have to wait 10 minutes or for it to go out leaving the car in on position for 10 minutes or more every time I get in the car to start it but once I wait 10 minutes the light go's out & then start car the security light stays on again without flashing then when I get shut the car down & then start again the security light flashes again can't start the car again & this happens continuously non stop this happens every time I park my car at a shopping center or my parking spot at my condo. I tried everything to disconnect the battery under the hood for 20 minutes it resets but it starts all over again with the security light on when I start the car up then have to wait 10 minutes for the security light to stop flashing then restart it again after the stops flashing then it starts but security light comes back on again. Then if I shut off I have to wait 10 minutes every time . What can be done about this problem please.
- Electrical system · Electronic stability control (esc) · Fuel/propulsion system
I was diving down hwy 70 going to pick up my first delivery for the day when, I'm not sure how but the key came out of the on postion and fell out on floor, scared I was going to crash I hurriedly reached down and put it back in and noticed the security light had came on and within minutes it lost…
I was diving down hwy 70 going to pick up my first delivery for the day when, I'm not sure how but the key came out of the on postion and fell out on floor, scared I was going to crash I hurriedly reached down and put it back in and noticed the security light had came on and within minutes it lost all power and shut off, luckily I am a good driver and didn't crash but manage to get off road safely. I'm so glad worse didn't happen. now I have no car and probably lost all 3 jobs I had.
- Air bags · Electrical system · Power train
I replaced the clock spring back in 2018 but the air bag light still on it has to be a airbag control module since I purchased my first car since 2011 it needs to be turned off
- Steering · Unknown or other
Takata recall transmission - shifts hard, went out with out any warning lights. Was at a stop light when I tried to go, it wouldn't go past 10 mph and went all the way up to 4TH rpm. power steering leaks bad.
- Fuel/propulsion system
Since the day I purchased the car it's had a strong gas odor that fills the inside of the car. It gets worse when you run the defrost and when the gas tank IS on e. It's an everyday strong gas odor and most of the time it's everytime you drive it no matter how many times in one day or how long of a period at a time.
- Electrical system · Exterior lighting › Turn signal
TL* the contact owns a 2002 pontiac grand am. While driving approximately 55 mph, the contact attempted to make a turn, but the rear driver side turn signal indicator did not work. The contact replaced the rear tail light bulbs. When the hazard button was depressed, the turn signal indicator…
TL* the contact owns a 2002 pontiac grand am. While driving approximately 55 mph, the contact attempted to make a turn, but the rear driver side turn signal indicator did not work. The contact replaced the rear tail light bulbs. When the hazard button was depressed, the turn signal indicator started to work again. The contact stated that the failure occurred for approximately six months. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired. The approximate failure mileage was 130,000.
- Electrical system
TL* the contact owns a 2002 pontiac grand am. While driving approximately 45 mph, the vehicle stalled and the check engine and security warning indicators illuminated. The vehicle was able to coast to the side of the road, but failed to restart. The vehicle was towed to the contact's residence. The…
TL* the contact owns a 2002 pontiac grand am. While driving approximately 45 mph, the vehicle stalled and the check engine and security warning indicators illuminated. The vehicle was able to coast to the side of the road, but failed to restart. The vehicle was towed to the contact's residence. The contact attempted to drive the vehicle, but it would not start. An independent mechanic diagnosed that the security electrical system wiring failed and needed to be repaired. The contact called autonation chevrolet at (407) 680-0751 (located at 3707 w colonial dr, orlando, fl 32808) and was informed to bring the vehicle in for diagnostic testing. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to nhtsa. The approximate failure mileage was 170,377.
- Air bags
'Takata recall' deterioration of airbags due to the geographical location and the heat of the southern united states
- Electrical system
Tl-contact owns a 2002 pontiac grand am ---- vehicle has 165,478 miles contact was going 10mph when blinkers stopped working, in turn lane to turn off main road at night.. Contact was driving home two nights ago when blinkers both went out and contact went online and looked up vin number and saw…
Tl-contact owns a 2002 pontiac grand am ---- vehicle has 165,478 miles contact was going 10mph when blinkers stopped working, in turn lane to turn off main road at night.. Contact was driving home two nights ago when blinkers both went out and contact went online and looked up vin number and saw two recalls. Contact stated she had called local gm dealer and gm state vehicle has no recalls. Contact took vehicle to mechanic to have fuses replaced . 0 recalls associated with this vin.... Cb
- Exterior lighting
TL* the contact owns a 2002 pontiac grand am. While operating the turn signal either right or left, the signal light failed to illuminate. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 111,000.
- Electrical system · Exterior lighting · Service brakes
The left rear turn signal went out I have replaced all bulbs and nothing the headlights auto dosent work most of the time the turn signal stopped working thrday afterbi bought the car.
- Fuel/propulsion system
TL* the contact owns a 2002 pontiac grand am. While driving at any speed, the vehicle stalled and shut off without warning. The vehicle was pulled over to the side of the road and was restarted after a few minutes. The dealer was unable to diagnose the failure. The failure recurred several times…
TL* the contact owns a 2002 pontiac grand am. While driving at any speed, the vehicle stalled and shut off without warning. The vehicle was pulled over to the side of the road and was restarted after a few minutes. The dealer was unable to diagnose the failure. The failure recurred several times and was taken to a different dealer. The dealer replaced the fuel pump, but the failure recurred. The manufacturer was notified, but did not offer assistance. The failure was not remedied. The failure mileage was approximately 79,000.
- Electrical system › Ignition › Switch · Steering
TL* the contact owns a 2002 pontiac grand am. The contact stated that when she turned the key in the ignition, the engine failed to start the vehicle was previously repaired per an unknown ignition switch recall. It took over ten minutes for the vehicle to start. The manufacturer was not notified…
TL* the contact owns a 2002 pontiac grand am. The contact stated that when she turned the key in the ignition, the engine failed to start the vehicle was previously repaired per an unknown ignition switch recall. It took over ten minutes for the vehicle to start. The manufacturer was not notified of the failure. The failure mileage was 109,848. updated 05/17/17*lj the consumer stated the manufacturer was notified of the failure and did not offer any assistance. The consumer requested to have all the electrical components replaced. Updated 09/20/2017*js
- Power train
Transmission IS slightly slipping I have had to have the wheel hubs changed four times I'm only the second owner the first owner was 80 when the car was sold it has 122K on it and if something IS not done I will be contacting my lawyers very soon
- Engine
Oil leak oil leaking on hot exhaust manifold causing fire while either running or driving may cause engine fire don't seem safe to me someone ownng and driving this car as I smell oil burning when I shut off car not safe to me if gm knows about this problem that's the way I wanna go car fire safty issue hmmmm.
- Unknown or other
Pass lock sensor.wont start due to security light.have to wait 10 min until it stops flashing to turn car on.happened 4 times this month.getting worse.a friend had this problem also,she told me what to do.
- Electrical system
Hello, I'm not sure who to contact in regards to this, but I have a 2002 pontiac grand am and received a safety recall notice in the mail, (the ignition/security recall.) I brought my car to the dealership, only to discover they never fixed it and when I called to address them about it, they…
Hello, I'm not sure who to contact in regards to this, but I have a 2002 pontiac grand am and received a safety recall notice in the mail, (the ignition/security recall.) I brought my car to the dealership, only to discover they never fixed it and when I called to address them about it, they reassured me they did, and have had second and third parties, (mechanics,) look and they if fact, did not. as a result, I've invested so much money and am now in car-less, and am a widow with 4 children going to college full time online. I've tried to fix it myself and having other mechanics who don't specialize in this fix it. please any help or information would be appreciated. thank you for your time. *tr
- Exterior lighting › Turn signal › Flasher unit
TL* the contact owns a 2002 pontiac grand am. While driving approximately 30 to 35 mph and turning right or left, the turn signal lights failed numerous times. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 62,000.
- Engine · Unknown or other
Oil leak oil leaking on hot exhaust manifold causing fire while either running or driving may cause engine fire don't seem safe to me someone ownng and driving this car as I smell oil burning when I shut off car not safe to me if gm knows about this problem that's the way I wanna go car fire safty issue hmmmm.
- Electrical system
TL* the contact owns a 2002 pontiac grand am. When the ignition was turned to the on position, the ignition failed to turn. Thirty minutes after jiggling the key, the ignition turned to the on position. The failure recurred numerous times. The vehicle was not taken to a dealer or diagnosed. The…
TL* the contact owns a 2002 pontiac grand am. When the ignition was turned to the on position, the ignition failed to turn. Thirty minutes after jiggling the key, the ignition turned to the on position. The failure recurred numerous times. The vehicle was not taken to a dealer or diagnosed. The manufacturer was not made aware of the failures. The vin was included in nhtsa campaign number: 14v400000 (electrical system). The failure mileage was approximately 185,000.
- Electrical system
2002 pontiac grand am. consumer writes in regards to ignition switch recall repairs and seeks reimbursement. *smd
- Electrical system
TL* the contact owns a 2002 pontiac grand am. The contact stated that while driving at 70 mph, the vehicle stalled while slowing down to get off the ramp without warning. The contact stated that the brake pedal was depressed to the floorboard in order for the vehicle to stop. the contact coasted…
TL* the contact owns a 2002 pontiac grand am. The contact stated that while driving at 70 mph, the vehicle stalled while slowing down to get off the ramp without warning. The contact stated that the brake pedal was depressed to the floorboard in order for the vehicle to stop. the contact coasted over to the side of the road and was able to restart the vehicle. The vehicle was taken to an independent mechanic but was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 98,000.
- Electrical system · Exterior lighting
TL* the contact owns a 2002 pontiac grand am. While driving at approximately 50 mph, the front and rear turn signal lamps failed to operate. The failure recurred intermittently. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 50,000. updated 03/18/16*lj the consumer stated the signal switch was replaced. updated 03/22/16.*jb
- Electrical system
TL* the contact owns a 2002 pontiac grand am. The contact stated that the ignition key failed to start the vehicle. The vehicle was towed to an independent mechanic where it was diagnosed that the cylinder in the ignition switch needed to be replaced. The vehicle was serviced under nhtsa campaign…
TL* the contact owns a 2002 pontiac grand am. The contact stated that the ignition key failed to start the vehicle. The vehicle was towed to an independent mechanic where it was diagnosed that the cylinder in the ignition switch needed to be replaced. The vehicle was serviced under nhtsa campaign number: 14v400000 (electrical system) but the remedy failed to repair the vehicle. The contact also stated that prior to the recall repair being performed she had not experienced a failure. The manufacturer was made aware of the failure. The failure mileage was approximately 105,000.
- Electrical system
2002 pontiac grand am. consumer writes in regards to ignition switch recall notice issues. *smd the consumer stated on june 3, 3014, the vehicle would not start. The vehicle was towed to a repair shop. The repair shop recommended the consumer visit the dealer, because a recall had been issued…
2002 pontiac grand am. consumer writes in regards to ignition switch recall notice issues. *smd the consumer stated on june 3, 3014, the vehicle would not start. The vehicle was towed to a repair shop. The repair shop recommended the consumer visit the dealer, because a recall had been issued for the problem. The dealer informed the consumer, his vin was not included in the recall. The consumer returned to the repair shop, where he had the ignition lock cylinder housing replaced at his expense. the consumer received the ignition recall notice in october 2014. *Jb
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Turn signal failures
In december 2004, gm issued a special policy for my 1999-2000 alero, grand am and malibu vehicles not covered under recall 03v327. The policy covered turn signal/hazard flasher failure for a period of 10 years or 150,000 miles (whichever occurred first) to provide a no cost replacement of the hazard switch. Gm sent…
In december 2004, gm issued a special policy for my 1999-2000 alero, grand am and malibu vehicles not covered under recall 03v327. The policy covered turn signal/hazard flasher failure for a period of 10 years or 150,000 miles (whichever occurred first) to provide a no cost replacement of the hazard switch. Gm sent letters to owners starting december 30, 2004.in january 2006, gm will update the special policy to include my 2002 alero, grand am and malibu vehicles not covered under recall 03v-327.the policy covers turn signal/hazard flasher failure for a period of 10 years or 150,000 miles (whichever occurs first) to provide a no cost replacement of the hazard switch.gm will send letters to owners starting late april 2006.the actions taken by the manufacturer IS sufficient to resolve the issues raised by this investigation.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take future action if warranted by the circumstances.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10249980This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include ?Vibration? ?Business Associate Code? and the last 8 of the Vehicle Identification Number.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248778Unintended Ignition Key Rotation
- 10248444Vehicle Recalls
- 10247780This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 10247681Information On Requests To Add OnStar Bluetooth Option.
- 10246952Programming And Activation Of Replacement OnStar Modules.
- 10246951Programming And Activation Of Replacement OnStar Modules.
- 10246631Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- 10245951Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
- 10245950Canadian Customers Unable To Place Calls In The United States
- 10245891Unintended Ignition Key Rotation
- 10244274This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
- 10244201This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
- 10242298This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10242262This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
- 10240793This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.
- 10236164This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10235802This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 10235799This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
- 10234141This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 10234110This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
- 10232811This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
- 10232287This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
- 10232136This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
- 10230697This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related components. That any of the listed DTC's may set with or without poor engine performance.
- 10227056This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10224820This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
- 10224309This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole authorized provider of a certification confirmation letter which helps our customers identify if their vehicles meets the required USA regulatory standards necessary for importation into the USA.
Every Pontiac Grand Am model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.