2005 Saturn Ion
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Saturn › Ion › 2005
These records cover every 2005 Saturn Ion. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2005 Saturn Ion. Newest first.
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original…
Risk and remedy
Risk
If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy
UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk and remedy
Risk
If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy
General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while…
Risk and remedy
Risk
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model…
Risk and remedy
Risk
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Owner complaints
573 complaints31 involved a crash4 involved a fire19 injuries
What owners report most
Latest complaints
- Electrical system · Exterior lighting · Steering
This vehicle has an electrical issue from time to time seemingly out of nowhere. There is no power steering it just shuts off sometimes it’ll stay off for an hour sometimes it’ll stay off for weeks and I can’t figure out how to fix it. It randomly fixes itself same can be said for the air…
This vehicle has an electrical issue from time to time seemingly out of nowhere. There is no power steering it just shuts off sometimes it’ll stay off for an hour sometimes it’ll stay off for weeks and I can’t figure out how to fix it. It randomly fixes itself same can be said for the air conditioning And the driver side, headlight all of these electrical functions, seemingly turn themselves up or down for no apparent reason.
- Electrical system › Ignition
The contact owns a 2005 Saturn Ion. The contact stated that the ignition key was stuck inside the ignition key slot, and the vehicle failed to start. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V171000…
The contact owns a 2005 Saturn Ion. The contact stated that the ignition key was stuck inside the ignition key slot, and the vehicle failed to start. The cause of the failure was not yet determined. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V171000 (ELECTRICAL SYSTEM). The dealer was not contacted regarding the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 167,000.
- Electrical system · Exterior lighting · Fuel/propulsion system
My key is stuck in the I can take it out the o2 seners not reading
- Unknown or other
The ignition cylinder was replaced in my vehicle because the key would not turn in the ignition to start the car. It is actually, the fourth time this has happened. I understand that there have been two recalls on this issue in the past. The reason it was recalled is because the ignition has turned…
The ignition cylinder was replaced in my vehicle because the key would not turn in the ignition to start the car. It is actually, the fourth time this has happened. I understand that there have been two recalls on this issue in the past. The reason it was recalled is because the ignition has turned to the off position killing the car's engine while the driver is driving on the road which has caused serious accidents. I was lucky not to get into an accident from this. The last replacement has lasted almost ten years. However, my issue is that General Motors apparently keeps manufacturing a defective part. This is unacceptable because I had to pay $585.02 to have this work done due to the fact that the dealerships apparently are not required to replaced it at no charge to the vehicle owner. It could also be a potential safety issue again.
- Air bags
Hello I am reaching out to complain about Courtesy Chevrolet - San Diego. I’ve been trying to get my car serviced in order to fIx the recalls. Unfortunately I have not been successful. I called the dealer to make an appointment but the dealer told me that the car has been discontinued and they can’t find the parts. The suggested to call somewhere else.
- Electrical system · Fuel/propulsion system
When pressing the gas pedal 2/3 of the way down the pedal got stuck causing the engine to rev high while driving forward. I had to put the car in neutral, shut the engine off and manually get the gas pedal unstuck by reaching down to the floor and pulling the pedal upwards with my hands. Also I had no floor mats in my car for the pedal to get stuck on. This has happened on multiple occasions.
- Electrical system · Steering
Power steering intermittently fails at random and steering wheel suddenly becomes immovable nearly causing serious accidents and endangerment to myself, my family, and others drivers on the roads.
- Exterior lighting
Headlights are to deem even on high beems.cant see anything coming or the on coming traffic can't see me coming.
- Electrical system · Exterior lighting
I turn my turn signals on and nonthing happens in the Frontline bulbs are brand new doesn't matter back turn signal work,front turn signal dont.this has been happening since forever my inlaws didn't know we didn't know until they gave car.so don't know how long seems like forever
- Unknown or other
My 2015 Saturn ION was on a Recalled Warranty issued and concerning faulty ignition Switch problem. I have brought my car in (5) times since (2014) and it has occurred again in (2021) and G,M, dealer Mauer Chevrolet has refused to honor warranty recall stating that Gm has sent them letter to not…
My 2015 Saturn ION was on a Recalled Warranty issued and concerning faulty ignition Switch problem. I have brought my car in (5) times since (2014) and it has occurred again in (2021) and G,M, dealer Mauer Chevrolet has refused to honor warranty recall stating that Gm has sent them letter to not service any more Saturn's ION with this problem due to cost. they refused to take my car in with key stuck ignition switch. I have filed complaint with MN. Attorney General office Consumer Division and they agreed that my consumer rights had been violated but Mauer Chevrolet still refuse's to fix my problem. My car has been sitting for over (3) months due to this problem. I need your assistance and hope you intervene as this has caused stress ,hardship and depression being without a car. Car dealer is Mauer Chevrolet located inInver Grove Heights, MN. 1055 50th Street, 55075. (651-455-6283). Mauer Chevrolet has retained their attorney to assist them, so I need help, also. Please HELP!
- Electrical system › Ignition
2005 saturn ion. Consumer writes in regards to ignition switch problem. the consumer stated the key would frequently become stuck in the ignition. The dealer made multiple repair attempts but, the failure recurred. The consumer requested to have the vehicle repaired under recall.
- Electrical system › Ignition · Steering · Unknown or other
It says I have 0 I repaired recalls. I have had the powers steering fail 2x. More importantly, the ignition cylinder locks up and I can’t get my keys out. I have to wait most times after turning the car off - for 3-5 minutes through a series of clicking noises in the ignition before the key will…
It says I have 0 I repaired recalls. I have had the powers steering fail 2x. More importantly, the ignition cylinder locks up and I can’t get my keys out. I have to wait most times after turning the car off - for 3-5 minutes through a series of clicking noises in the ignition before the key will release. It is concerning because sometimes I have to get out immediately and the keys don’t release. The car automatically locks itself and if I don’t roll the window down- I become locked out. It yesterday had a issue with ignition all together and I wonder if it’s related. I was made aware again there were many recalls on this issue and hoped to get it repaired. However it now states there are none unrepaired. I’m wondering if it is a ongoing problem with the vehicle, it’s repair parts etc and if it’s just not been addressed because it’s so old that so few are left on the road. Thank you. This is a increasing problem and a daily or every time I drive it issue now. I worry too the power steering will just go out in the interstate.
- Steering
The contact owns a 2005 Saturn Ion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel became very difficult to turn in either direction. During the failure, the power steering message was displayed. The cause of the failure was not yet…
The contact owns a 2005 Saturn Ion. The contact stated that while operating the vehicle, the power steering malfunctioned, and the steering wheel became very difficult to turn in either direction. During the failure, the power steering message was displayed. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer was notified of the failure. The manufacturer was not contacted. The contact stated that the vehicle was previously repaired under the NHTSA campaign number: 14V153000 (Steering) but the failure occurred. The failure mileage was 167,000.
- Electrical system · Engine · Steering
TL* the contact owns a 2005 saturn ion. The contact stated that while driving approximately 55 mph, the loss motive power without warning. The contact stated that steering assist and gauges were in operable. The contact coasted to the side of the road and restarted the vehicle. The contact stated…
TL* the contact owns a 2005 saturn ion. The contact stated that while driving approximately 55 mph, the loss motive power without warning. The contact stated that steering assist and gauges were in operable. The contact coasted to the side of the road and restarted the vehicle. The contact stated that several of the electrical functions returned however, the electrical functions failed intermittently. The power steering assist warning light illuminated intermittently when the power steering assist was inoperable. Ocean crest chevrolet buick GMC cadillac (855 alternate hwy 101, warrenton, or 97146, (866)607-2902) was contacted and informed of the failure. The dealer suggested that the vehicle be taken in to be diagnosed which was still pending. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 110,000.
- Electrical system · Exterior lighting · Vehicle speed control
Dash lights go out and all systems are you functioning property
- Exterior lighting
TL* the contact owns a 2005 saturn ion. The contact stated that upon activation of the headlights, the headlights were dim causing poor forward visibility while driving at night or in low light conditions. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired.…
TL* the contact owns a 2005 saturn ion. The contact stated that upon activation of the headlights, the headlights were dim causing poor forward visibility while driving at night or in low light conditions. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The manufacturer had not been notified of the failure. Upon investigation, the contact discovered nhtsa campaign number: 09e012000 (exterior lighting) however, the vin was not included. The failure mileage was approximately 80,000.
- Air bags
TL* the contact owned a 2005 saturn ion. The contact stated that while driving approximately 40 mph, the driver lost control of the vehicle and crashed into a tree. During the crash the passenger side of the vehicle was severely damaged but no air bags had deployed. The driver sustained an injured…
TL* the contact owned a 2005 saturn ion. The contact stated that while driving approximately 40 mph, the driver lost control of the vehicle and crashed into a tree. During the crash the passenger side of the vehicle was severely damaged but no air bags had deployed. The driver sustained an injured neck and was transported to the hosipital. A police report was taken at the scene. The vehicle was destroyed and towed away. The manufacturer and local dealer were not notified of the incident. The failure mileage was 174,000.
- Steering
TL* the contact owns a 2005 saturn ion. The contact stated that the steering wheel would move uncontrollable. The vehicle was towed to the dealer (glenn h. Wright, bs 1517 w garvey ave n, west covina, ca 91706 (626) 962-6061) by roadside assistance and left at the dealer for 6 days. There was no…
TL* the contact owns a 2005 saturn ion. The contact stated that the steering wheel would move uncontrollable. The vehicle was towed to the dealer (glenn h. Wright, bs 1517 w garvey ave n, west covina, ca 91706 (626) 962-6061) by roadside assistance and left at the dealer for 6 days. There was no diagnostic testing performed and the vehicle was not repaired. However, the failure recurred and the vehicle was unsafe to drive. The contact mentioned nhtsa campaign number: 14v153000 (steering) as a possible solution to the failure. The manufacturer was made aware of the failure but no further assistance was taken the contact was provided a case number. The failure mileage was approximately 160,000.
- Engine
TL* the contact owned a 2005 saturn ion. The contact's son observed an orange glare coming from the back of their house. The family ran outside together and discovered that the son's vehicle was on fire. The fire department was down the street, but took twenty minutes to arrive at the scene. The…
TL* the contact owned a 2005 saturn ion. The contact's son observed an orange glare coming from the back of their house. The family ran outside together and discovered that the son's vehicle was on fire. The fire department was down the street, but took twenty minutes to arrive at the scene. The contact's nineteen year old son extinguished the fire with water from the house. A police report was filed and there were no injuries. The vehicle was totaled. The dealer and manufacturer were not made aware of the failure. The failure mileage was 217,000.
- Electrical system · Exterior lighting · Unknown or other
Daytime running light turn signal dont work for the passenger side which can cause a safety problem to other drivers
- Fuel/propulsion system
Vehicle was stationary when problem occurred. Fuel intake and return lines in front of the rear drivers side wheel flaking badly and rusted through, about an 8 inch section of line was flaking and rusted through. Fuel line was rubbed when putting on new oem exhast and broke through the lines. Gas was leaking bad enough that it was deemed not safe to drive as these lines are about 5 inches away from the exhaust.
- Electrical system · Electronic stability control (esc) · Exterior lighting
Driver lights will not work switched bulb and checked fuses
- Steering
12-13-2018. Took my daughter to school. Shut the car off went into the school and came out and started the car from parked position turned the car around was on a side street to cross highway 13 was ready to turn onto highway 13 and no power steering, this was part of a recall that gm issued and this new part didn't even last 38,000 miles. T
- Steering
"Takata recall" I put my key in the ignition. The car stalled for a quick second then came on gully. As I reversed out of my driveway and went to make a slight left I noticed my steering wheel had locked up. I was able to slow turn the wheel as I had to manually steer. I pulled over and parked. This IS not safe.
- Steering · Unknown or other
I had the recall fixed in 2015. the same issues that I had before have returned. when driving and the tank IS full, I will get a service engine light and the tank gauge will read empty. It was fine when I began driving . Upon restarting the car the error goes away. when I put my car in park and…
I had the recall fixed in 2015. the same issues that I had before have returned. when driving and the tank IS full, I will get a service engine light and the tank gauge will read empty. It was fine when I began driving . Upon restarting the car the error goes away. when I put my car in park and try to turn off my ignition I have to put he shiftier in park several times before I can remove my key. today car ran great when trying to move my car after starting my car my power steering was gone. Again upon turning off my car and restarting it , the power steering returned. I called the gm recall number and a case was created but I was told that there were not any current recalls on my car. the service number IS 8-4833918801. but was told that all repairs are my responseability.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Electric Power Steering Failure
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728…
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
- Electric Power Steering Failure
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during…
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250094Special Coverage Adjustment ? Power Steering Assist
- 10249980This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include ?Vibration? ?Business Associate Code? and the last 8 of the Vehicle Identification Number.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249295This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248444Vehicle Recalls
- 10247780This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 10247716J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
- 10247681Information On Requests To Add OnStar Bluetooth Option.
- 10247336Replace Ignition Key
- 10247335Replace Ignition Key
- 10247334Replace Ignition Key
- 10247333Replace Ignition Key
- 10247332Replace Ignition Key
- 10247317Electric Power Steering Assist
- 10247316Electric Power Steering Assist
- 10247315Electric Power Steering Assist
- 10247313Replace Ignition Lock Cylinder and Ignition Key
- 10247312Replace Ignition Lock Cylinder and Ignition Key
- 10247311Replace Ignition Lock Cylinder and Ignition Key
- 10247310Replace Ignition Lock Cylinder and Ignition Key
- 10247309Replace Ignition Lock Cylinder and Ignition Key
- 10247279Ignition Switch Replacement
Every Saturn Ion model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.