2006 Saturn Ion
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Saturn › Ion › 2006
These records cover every 2006 Saturn Ion. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 2006 Saturn Ion. Newest first.
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original…
Risk and remedy
Risk
If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy
UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk and remedy
Risk
If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy
General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while…
Risk and remedy
Risk
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model…
Risk and remedy
Risk
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General motors IS recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac G5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. the…
Risk and remedy
Risk
Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Dealers will replace the fuel pump module free of charge. a special coverage will be implemented in the same time frame for model year 2006 vehicles registered in alabama, arkansas, california, florida, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina, tennessee and texas and model year 2007 vehicles registered in: alabama, arkansas, georgia, hawaii, louisiana, mississippi, north carolina, new mexico, oklahoma, south carolina and tennessee. the safety recall IS expected to begin on or before february 4, 2010. owners may contact chevrolet at 1-800-630-2438, saturn at 1-800-972-8876 and pontiac at 1-800-620-7668 or at the owner center at www.gmownercenter.com.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Owner complaints
1,235 complaints44 involved a crash7 involved a fire33 injuries1 deaths
What owners report most
Latest complaints
- Electrical system · Steering
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the…
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the steering wheel to the right to make a right turn, the steering was significantly wobbly. The contact related the failure to NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V153000 (Steering). Additionally, the contact stated that the vehicle was experiencing a fuel leak. The vehicle was taken to the Subaru dealer, where it was purchased. The vehicle was not diagnosed or repaired. An unknown Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. The manufacturer was notified of the failure and informed the contact that unknown recalls were previously performed on the vehicle. The failure mileage was approximately 85,200.
- Engine · Fuel/propulsion system · Visibility/wiper
Airbags
- Electrical system › Ignition
The contact owns a 2006 Saturn Ion. The contact stated that while driving at an undisclosed speed, the vehicle stalled. Additionally, the key was stuck in the ignition switch. The vehicle was taken to the dealer, who informed the contact that the ignition lock cylinder needed to be replaced. The…
The contact owns a 2006 Saturn Ion. The contact stated that while driving at an undisclosed speed, the vehicle stalled. Additionally, the key was stuck in the ignition switch. The vehicle was taken to the dealer, who informed the contact that the ignition lock cylinder needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer; however, the parts to do the repair were not available. The manufacturer was made aware of the failure. The failure mileage was approximately 100,764.
- Steering
The contact owns a 2006 Saturn Ion. The contact stated while exiting a driveway and making a turn, the steering wheel became difficult to turn. There was no warning light illuminated. The contact checked the power steering fluid reservoir and there was power steering fluid in the reservoir. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 90,000.
- Fuel system, gasoline
The contact's mother owns a 2006 Saturn Ion. The contact stated that after driving the vehicle to his residence and parking the vehicle in the garage, he observed that a puddle of gasoline had accumulated overnight underneath the vehicle from the fuel tank by the driver's side rear wheel. The…
The contact's mother owns a 2006 Saturn Ion. The contact stated that after driving the vehicle to his residence and parking the vehicle in the garage, he observed that a puddle of gasoline had accumulated overnight underneath the vehicle from the fuel tank by the driver's side rear wheel. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The contact stated that the failure might be related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer had been informed of the failure. The failure mileage was approximately 84,000.
- Fuel/propulsion system
Fuel and evap line rusted out inside heat wrap for exhaust pipe near rear drivers tire. Pumped out fuel onto street.
- Power train
The contact owns a 2006 Saturn Ion. The contact stated that upon switching gears to reverse, the vehicle made an abnormal grinding sound. The contact stated that she was unable to shift gears and continued to drive the vehicle in third gear. There were no warning lights illuminated. The independent…
The contact owns a 2006 Saturn Ion. The contact stated that upon switching gears to reverse, the vehicle made an abnormal grinding sound. The contact stated that she was unable to shift gears and continued to drive the vehicle in third gear. There were no warning lights illuminated. The independent mechanic diagnosed that the clutch was fractured and needed to be replaced. The manufacturer was notified of the failure and referred the contact to the dealer. The dealer was notified of the failure and informed the contact to take the vehicle to their location in two weeks for diagnosis. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 195,000.
- Fuel/propulsion system
The year, make, and model of my car has a factory recall for the fuel pump failing. I went to the dealership and they informed me my Vin # wasn't included and their was nothing they could do about it. My vehicle started leaking fuel last week so I dropped the tank and removed the fuel pump. I have…
The year, make, and model of my car has a factory recall for the fuel pump failing. I went to the dealership and they informed me my Vin # wasn't included and their was nothing they could do about it. My vehicle started leaking fuel last week so I dropped the tank and removed the fuel pump. I have done my homework on this including watching several videos on YouTube concerning this issue and I'm 100% positive this fuel pump has failed in the exact location that all the other recalls have and yet my Vin number isn't on the recall according to this GMC service department manager. I am going to have to put a fuel pump in at my expense today because it's my transportation for work but I'm very upset about this situation and GMCs failure to have my vehicle included and having to replace their defected fuel pump. It's very frustrating knowing I'm putting my time and money towards it because I have my hands full trying to replace the house that Hurricane Ida destroyed about a month ago. We need help with this situation because our money is very tight and don't really have it to fix GMCs mistake. I will keep the fuel pump that came out of it along with the receipt for it so anyone can clearly see that I'm not only correct but being shafted on the recall. Thanks have a nice day I'll be eagerly awaiting your response
- Fuel/propulsion system
The car is leaking gas from the gas tank. I see recalls from this year, make and model from this vehicle yet when I put my VIN in it says 0 recalls.
- Air bags · Electrical system
The contact owned a 2006 Saturn Ion. The contact stated while driving at 50 mph and there was a stopped vehicle in the middle of the road, in order to avoid crashing the contact veered to the right lane but crashed into the rear of a truck. The air bags failed to deploy. A police report was not…
The contact owned a 2006 Saturn Ion. The contact stated while driving at 50 mph and there was a stopped vehicle in the middle of the road, in order to avoid crashing the contact veered to the right lane but crashed into the rear of a truck. The air bags failed to deploy. A police report was not filed. The contact sustained neck, shoulder, arm, and chest injuries that required medical attention. The vehicle was not drivable and was towed to an impound lot. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact was relating the failure to NHTSA campaign number: 14V047000 (Air bags, Electrical system). The manufacturer had been informed of the failure and informed the contact to file for the class action lawsuit. The failure mileage was 90,000.
- Steering
We purchased this vehicle recently. 1 week later we discovered loss of power steering assist while attempting to parallel park. We spoke with the seller (repair shop) and they discovered the Recall Notice 14V153000: Loss of Power Steering Assist. When I attempted to schedule a recall service at…
We purchased this vehicle recently. 1 week later we discovered loss of power steering assist while attempting to parallel park. We spoke with the seller (repair shop) and they discovered the Recall Notice 14V153000: Loss of Power Steering Assist. When I attempted to schedule a recall service at a GM dealership it was shown that this vehicle already had this particular recall service performed on the vehicle. 1. Power steering Assist 2. Loss of control of steering. 3. No (issue is intermittent) 4. No (original recall was performed though; it is happening again) 5. No warnings.
- Power train › Manual transmission › Internal › Gears
2006 saturn ion. Consumer writes in regards to defective shifter switch safety recall. the consumer stated the vehicle became difficult to to turn off. The consumer had to jiggle the key to get the vehicle to power off. This occurred on multiple occasions. Repair attempts have been made but, the failure persisted. The manufacturer was contacted and reimbursed the consumer for the repair.
- Air bags · Electrical system · Fuel/propulsion system
The rpms jump around and the a/c makes noise and lights flicker at times. The car will just stall in the middle of an intersection or when I'm turning onto another road. It's quite scary with children in the car. my main concern IS a large SUV put it in reverse and hit the front of my car before…
The rpms jump around and the a/c makes noise and lights flicker at times. The car will just stall in the middle of an intersection or when I'm turning onto another road. It's quite scary with children in the car. my main concern IS a large SUV put it in reverse and hit the front of my car before ending up on the hood near the windshield. She was going pretty fast and pushed my car pretty far but no airbag! then on a separate occasion I was doing 55 miles when a large animal darted out in front of me. My front end and radiator and front end were shot. Even split my passenger side dash open and had to be towed off but no airbags!! exactly how do I have to be going for me to have protection????
- Unknown or other · Visibility/wiper
I had cleared my windows of snow and turned on my rear defrost when I heard a loud pop and discovered my rear window had imploded.. I was parked in my driveway
- Fuel system, gasoline › Delivery › Fuel pump
TL* the contact owns a 2006 saturn ion. The contact stated while the vehicle was being inspected by independent mechanic, she was informed that the vehicle had a fuel leak and needed the fuel pump and fuel tank to be replaced. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had not been informed of failure. The failure mileage was approximately 154,917.
- Steering
Difficult to steer or turn steering wheel.
- Electrical system · Steering
Still having ign. Key problems not turning and can not remove, an electronic steering system light come on when starting and hard to steer. Both problems are intermittent and dealer can't repair unless they see it
- Electrical system
TL* the contact owns a 2006 saturn ion. The contact stated that after the vehicle was park, the contact was unable to remove the key from the ignition. The contact mentioned the vehicle needed to be restarted or the steering wheel needed to be turned to remove the key from the ignition. The vehicle…
TL* the contact owns a 2006 saturn ion. The contact stated that after the vehicle was park, the contact was unable to remove the key from the ignition. The contact mentioned the vehicle needed to be restarted or the steering wheel needed to be turned to remove the key from the ignition. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact stated that the vehicle was repaired under nhtsa campaign number: 14e021000 (electrical system) however, the remedy failed to fix the vehicle. The approximate failure mileage was 68,804
- Fuel/propulsion system
I started smelling gas when getting out of car. Then it got progressively stronger gas smell that lingered on strong an hour after the car had been sitting. So I checked for gas leak on exterior of gas tank and found extreme amount of gas coming from both of the fuel lines of the fuel module on top of tank. This didn't start until the weather has become warm in the 80 s and 90S. *Tr
- Steering
Steering errors
- Steering
TL* the contact owns a 2006 saturn ion. When the vehicle was started, the power steering failed without warning. When the vehicle was restarted, the power steering returned to normal. The vehicle was not diagnosed or repaired. The dealer and manufacturer were not notified. The contact associated the failure with nhtsa campaign number: 14v153000 (steering). The failure mileage was 140,000.
- Air bags
Air bag if IS a re call I will like to know if I have to take my car where to.
- Fuel/propulsion system
Lately have been noticing by myself and others, strong fuel smell around car. while cleaning out various paperwork, I found a recall letter dated 8/2015 regarding cracked fuel tank inlet control valve. I really need this problem looked into as I am hesitant to drive with the horrid gas smell. Please advise as soon as possible. thank you
- Electrical system · Electronic stability control (esc)
Key gets stuck in ignition and car won't start. Unable to retrieve key from ignition switch. Vehicle was stationary.
- Fuel/propulsion system
The car IS having the same difficulties as the other cars covered by the recall. it was made in tennessee. the manufacturer IS refusing to correct the problem and states the car IS not cover under the recall. car can't be driven due to smell of gas and due to the information I have researched it may start a fire. I would like them to correct the problem.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Electric Power Steering Failure
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728…
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
- Electric Power Steering Failure
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during…
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 11000158This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.
- 10254240Information on COAX Repair Kit Availability.
- 10253770This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10251888This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250094Special Coverage Adjustment ? Power Steering Assist
- 10250091Special Coverage Adjustment ? Fuel Odor or Spotting on Ground ? Replace Fuel Pump Module
- 10250013High Voltage Safety ? High Voltage Disabling
- 10249980This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include ?Vibration? ?Business Associate Code? and the last 8 of the Vehicle Identification Number.
- 10249579This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10249535This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).
- 10249295This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 10249011This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
- 10248444Vehicle Recalls
- 10247780This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 10247716J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead.
- 10247681Information On Requests To Add OnStar Bluetooth Option.
- 10247336Replace Ignition Key
- 10247335Replace Ignition Key
- 10247334Replace Ignition Key
- 10247333Replace Ignition Key
- 10247332Replace Ignition Key
- 10247317Electric Power Steering Assist
- 10247316Electric Power Steering Assist
Every Saturn Ion model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.