2021 Thor Motor Coach Chateau
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Thor Motor Coach › Chateau › 2021
These records cover every 2021 Thor Motor Coach Chateau. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2021 Thor Motor Coach Chateau. Newest first.
Thor Motor Coach (TMC) is recalling certain 2021 Daybreak, Four Winds, Quantum, Chateau, and Freedom Elite motorhomes built on the 2020 Ford E-Series chassis. The battery cable may not have been properly secured within the chassis rail, which can cause it to contact the exhaust manifold and heat shield.
Risk and remedy
Risk
Battery cable contact with the exhaust manifold and heat shield can increase the risk of a fire.
Remedy
TMC will notify owners, and dealers will inspect the routing of the battery cable. If needed the cable will be re-routed and properly secured, free of charge. This recall began September 11, 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000197.
Thor Motor Coach (TMC) is recalling certain 2020-2021 Quantum, Chateau and Four Winds, and 2020 Vegas and Axis motorhomes built on a Ford E-series chassis. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Risk and remedy
Risk
Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Remedy
TMC will notify owners, and Ford dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall The recall began June 25, 2020., 2020. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000189.
Owner complaints
2 complaints
What owners report most
Latest complaints
- Engine
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 20V795000 (ENGINE) on the 2021 Thor Motor Coach; however, when the dealer was contacted to schedule an appointment for the recall repair, the contact was informed that the VIN was not under recall. The…
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 20V795000 (ENGINE) on the 2021 Thor Motor Coach; however, when the dealer was contacted to schedule an appointment for the recall repair, the contact was informed that the VIN was not under recall. The manufacturer was not made aware of the issue. The contact stated that the vehicle was purchased recently. The contact had not experienced a failure.
- Unknown or other
Driving on I-10 on December 12, 2024, the Solar Panel flew off the roof of my 2021 Thor Chateaux 27R and into the ditch. My wife following the RV in our other vehicle saw it happen. Luckily no one was hit by the panel as it could have been deadly serious. Looking at the roof later, I found two…
Driving on I-10 on December 12, 2024, the Solar Panel flew off the roof of my 2021 Thor Chateaux 27R and into the ditch. My wife following the RV in our other vehicle saw it happen. Luckily no one was hit by the panel as it could have been deadly serious. Looking at the roof later, I found two brackets (of a total of 4) still intact but missing bolts while the two brackets on the other side were gone with only two small screw holes in the roof. Months before I found one of the brackets loose at the solar panel and secured it. All the other brackets were tight.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10197980MBAG has determined that on certain model year 2019-2020 Sprinter vehicles, the retaining washer on the bolt that connects the brake pedal to its bearing block could come loose. If the retaining washer were to come loose, over time it could detach from the bolt, and in the worst case and with ongoing use of the brake pedal, the bolt might separate from the bearing block on one side. If this were to occur, the brake lamp switch could become continuously activated even when the brake pedal is not pressed. If the brake lamps are continuously illuminated, it would not be possible for following traffic to determine the braking intention of the vehicle, which could increase the risk of a crash. This affects the following Thor Motor Coach products: model year 2020-2021 Citation, Compass, Daybreak, Delano, Four Winds, Freedom Elite, Gemini, Quantum, Siesta, Synergy, and Tiburon motorhomes.
- 10197965On your vehicle, it may be possible that the engine cover insulation does not fully extend to the perimeter of the factory engine cover. In addition, vehicles built on a Ford chassis may have higher engine compartment temperatures during certain idle conditions. This may result in elevated temperatures at certain areas of the engine cover surface in the passenger compartment on both driver and passenger sides. Direct and continuous contact with exposed skin at these locations may cause skin irritation and/or a minor burn. This affects the following Thor Motor Coach products: model year 2021/2022 Axis, Chateau, Coleman, Daybreak, Four Winds, Freedom Elite, Magnitude, Majestic, Outlaw, Quantum, and Vegas motorhomes.
Every Thor Motor Coach Chateau model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.