1995 Chevrolet G20
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › G20 › 1995
These records cover every 1995 Chevrolet G20. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
6 recalls name the 1995 Chevrolet G20. Newest first.
Certain honeywell fram racing brand HP4 and HP8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing…
Risk and remedy
Risk
This condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.
Remedy
Honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.
Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes…
Risk and remedy
Risk
This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
Remedy
Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
This IS not a safety recall in accordance with the safety act. however, it IS deemed a safety improvement campaign by the agency. vehicle description: certain light duty pickup trucks, sport utility vehicles, or minivans equipped with 3-sensor ABS (antilock braking system) EBC4 units.
Risk and remedy
Risk
These vehicles can experience extended stopping distances during ABS stops on certain multiple surfaces, increasing the risk of a crash.
Remedy
Dealers will modify the computer program which operates the ABS unit on some vehicles, or replace the computer on others to improve the performance of the ABS on these surfaces.
Vehicle description: chevrolet and GMC g vans equipped with sliding side doors and remedied during safety campaign (95v197/95-c-58) between july 18, 1997 and february 6, 1999. the sliding side-door rear latch was replaced with a latch that was improperly riveted.
Risk and remedy
Risk
In the event of a vehicle crash, the door may not perform as required and increased injuries could result.
Remedy
Dealers will replace the sliding door rear latch.
These vehicles were built with a sliding side-door rear latch that was improperly riveted. This does not meet the requirements of fmvss no. 206, "door locks and door retention components."
Risk and remedy
Risk
Consequence of non-compliance: in the event of a vehicle crash, the door will not perform as required by the standard.
Remedy
Dealers will replace the sliding door rear latch on all suspect vehicles.
Both the supplemental inflatable restraint (sir) caution label and an engine start label were installed on the same side of the driver's sun visor. This does not comply with fmvss no. 208, "occupant crash protection."
Risk and remedy
Risk
Consequence of non-compliance: operators could fail to notice and heed the warning labels.
Remedy
A new label, with installation instructions, will be sent directly to owners. Owners will install the label or can have their dealer install the label for them.
Owner complaints
82 complaints12 involved a crash2 involved a fire13 injuries1 deaths
What owners report most
Latest complaints
- Visibility/wiper
The contact owns a 1995 Chevrolet G20. The contact stated while driving approximately 55 MPH, the windshield wipers failed to operate as needed. The contact stated that the failure recurred several times. There were no warning lights illuminated. The vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 168,000.
- Service brakes
TL* the contact owns a 1995 chevrolet G20. While driving 40 mph, the brakes failed. The contact was able to stop the vehicle by engaging the emergency brake. The manufacturer was not made aware of the failure. The failure mileage was 140,000.
- Suspension
This complaint adds pdf attachments that I failed to file 10 minutes ago because I misunderstood process.
- Suspension
Traveling straight at highway speeds (65mph), on a very smooth highway, a loud pop was heard and my front end driver's side suspension collapsed. I veered left, started to roll, and was righted by a toyota tacoma in the lane to my left. the tacoma proceeded to wrap around the front of my vehicle…
Traveling straight at highway speeds (65mph), on a very smooth highway, a loud pop was heard and my front end driver's side suspension collapsed. I veered left, started to roll, and was righted by a toyota tacoma in the lane to my left. the tacoma proceeded to wrap around the front of my vehicle colliding with a vehicle in the lane to my right. two vehicles were totaled and the driver of the tacoma sustained injuries. the recently installed suspension (moog components, installed by firestone) had twice been inspected by firestone in the previous 6,000 miles. (suspension installed 10,000 miles prior to accident, inspected 6,000 and 3,000 miles prior to accident because I noted to firestone observed excessive tire wear and a suspension clunking noise). the patrolman on scene did not cite me because he observed the otherwise broken suspension was of new, recently installed condition. a lower ball joint failure appears to have been the cause. given the severity of the accident I requested all failed suspension components be placed in my vehicle. when I arrived to pick up the vehicle I was informed these parts were discarded. two days after I picked up the vehicle I formally requested firestone address a series of suspension concerns I had, one year later, no response on any concern. 500 miles after the suspension re-repair, I once again was experiencing a clunking noise and another firestone retail center determined alignment shims were missing, and on replacement the clunking noise disappeared. firestone has not responded if their could be a connection between shim omission and premature ball joint failure.
- Power train · Service brakes, hydraulic
TL* the contact owns a 1995 chevrolet G20. The contact was driving 20 mph and applied the brakes when the pedal depressed to the floorboard abnormally. The vehicle was maneuvered to the shoulder and coasted to a stop. The vehicle was towed to the contact's home where an independent mechanic…
TL* the contact owns a 1995 chevrolet G20. The contact was driving 20 mph and applied the brakes when the pedal depressed to the floorboard abnormally. The vehicle was maneuvered to the shoulder and coasted to a stop. The vehicle was towed to the contact's home where an independent mechanic examined the vehicle but was unable to diagnose the failure. The vehicle was not repaired. The contact also filed a complaint with the manufacturer. The failure and current mileages were 62,173. the plunger in the master cyclinder was incapable of propelling the brake fluid through the lines and the brake cyclinders could not expand. Vehicle has stop because of transmission. Failure during down grade. Vehicle picked up speed when transmission was used to stop its forward progress. Updated 11/09/2011 *ln *tr
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Dt: the contact stated one month ago he noticed a brake problem. When applying the brake at any speed the pedal went to the floor and there were no brakes. Just as he was pressing the pedal the ABS light came on. After he was off of the pedal the light disappeared. he the contact cited recall 99i006000. He called the manufacturer, and they told him this vehicle was not included in the recall due to vin. *ak
- Visibility › Windshield wiper/washer › Motor
Windshield wipers failed intermittently due to wiring harness connector malfunctioning. recall 98v15001 was issued, however, this vehicle was not included in the recall due to vin. *ak
- Visibility › Windshield wiper/washer
While driving in inclement weather windshield wipers will malfunction and stop working; driver's visibility IS poor. *Ak
- Visibility › Windshield wiper/washer
Vehicle experienced the same defect with it's windshield wiper as stated in recall 03 V159 000 but it's vin number IS not included.
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Front end- when applying the brakes the entire front end shimmies and vibrates making it difficult to control the van. We have only owned this van for less than 2 years but this should not be happening.
- Unknown or other
Anti-lock brake systems does not operate properly. Door hinges previously replace while still under warranty no longer operate properly they are either broken or stuck. seat belts are twisted or fail to retract. Front doors have shifted downward. Rear power reclining seat IS stuck in down…
Anti-lock brake systems does not operate properly. Door hinges previously replace while still under warranty no longer operate properly they are either broken or stuck. seat belts are twisted or fail to retract. Front doors have shifted downward. Rear power reclining seat IS stuck in down position. was struck on front passengers side while traveling about 55mph air bag did not deploy. recently had to have egr valve replaced only to find out that my 1995 van had 1996 parts. could not find this part in any auto parts store in town so I ended up having to go to salvage to get one for $50, it was almost $200.00 new and even after waiting a week for the part the auto parts store did not get one. the hinges for my van are $43 each and I am sure others have had the same problem. the dealership says this should be expected because of the snow and salt in our state. it just seems chevrolet should have redesigned these hinges.
- Suspension › Rear › Springs › Leaf spring assembly
The rear springs on the back part of the vehicle IS causing both front tires to wear excessively. the dealer informed consumer that the cause was due to the wrong size springs used at time of manufacture. ts
- Air bags › Frontal
As a result of vehicle highdroplanning at the rate of speed 45 mph through a water puddle, hitting a tree with front end. air bags did not deploy at any time. Please provide further information.ak
- Electrical system › Ignition · Engine and engine cooling › Engine · Exterior lighting › Brake lights › Switch · Exterior lighting › Turn signal › Flasher unit · Power train › Axle assembly › Axle shaft
We have also had problems with the right side axle and bearings. also the coil went out, as well as the engine small block - which did not fix the problem - they then had to replace the entire engine.
- Power train › Axle assembly › Axle shaft › Seal
Rear drive axel always noisy, seal broke 2 times, causing damage to breaks. There IS scoring of the drive axle and housing damage. I t has been repaired but I am informed I need a new rear end but that chevrolet does not produce them. Nhtsa reports indicate this IS a common problem. I do not want…
Rear drive axel always noisy, seal broke 2 times, causing damage to breaks. There IS scoring of the drive axle and housing damage. I t has been repaired but I am informed I need a new rear end but that chevrolet does not produce them. Nhtsa reports indicate this IS a common problem. I do not want to pay 850.00 to relace my used rear end with a used one that will function just as badly. Where can I get new reliable repair parts from the factory. Do they acknowledge this defect and are they making any compensation. Come on this IS a 44,000.00 G-20 mark III conversion van, I would expect a better drive system than this. Help please. Thank you mrs. Shepherd
- Tires
When turning off highway steering seemed wobbly. Turned into big timber at about 25mph, steering shook as we made turn, all due to tire separation mostly insid area of the wheel.
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip · Service brakes, hydraulic › Power assist › Vacuum
Brakes spongie, pedal goes to floor, break fluid ok. Power assist booster weak. *ak
- Electrical system › Ignition · Engine and engine cooling › Engine › Gasoline · Engine and engine cooling › Engine › Gasoline › Belts and associated pulleys · Engine and engine cooling › Exhaust system · Equipment › Electrical · Equipment › Electrical › Radio/tape deck/cd etc. · Power train › Driveline › Differential unit · Service brakes, hydraulic › Foundation components › Disc · Service brakes, hydraulic › Power assist · Steering › Steering wheel/handle bar · Structure › Body › Door · Suspension · Suspension › Front › Wheel bearing · Tires · Visibility › Windshield
When driving differential would make grinding noise. Noise was like it was straining when acclelrating and/or braking. *ak consumer had a loss of power had to replace sway bushings, vehicle began to over heat in which thermostat was replaced, consumer complained of noises from rear end but was…
When driving differential would make grinding noise. Noise was like it was straining when acclelrating and/or braking. *ak consumer had a loss of power had to replace sway bushings, vehicle began to over heat in which thermostat was replaced, consumer complained of noises from rear end but was advised could not duplicate, consumer also complained of a ticking noise but was advised that was normal, also speaker on left side has static unable to be duplicated, noise in brakes when backing up,front door does not close properly makes a bang noise,drive belt squeaking, serpentine belt was replaced, water leaking into vehicle windshield was fitting pooly replaced windshield, vacuum brake booster was replaced,steering wheel vibrates at 40 mph, cigarrette lighter when in use smokes due to ashes on lighter element also ignition coil had to be relaced due to corrosion hydraulic system was replaced .*jb
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Anti-lock brake system replaced in august 1999. Currently, vehicle IS making grinding sounds when brakes are applied. *ak
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Consumer contacted dealer in reference to recall number 99i006000/ manufacturer's recall 99046/ ABS brakes. Consumer not sure if dealer made the recall repairs. Vehicle was still experiencing problems with extended stopping distance when attempting to stop. *ak the driver IS experiencing brake problem after it was fixed for recall. *yh
- Electrical system › Wiring › Fuses and circuit breakers
No summary
- Air bags › Side/window · Seat belts › Front › Anchorage
In this accident a car and our van impacted both at app. 40Mph each hit with frontal impact causing ext. Damage to our van as well as the pass. Restraint not working and causing injury. Gm sent "expert" but to no avail. repair as well as wrecker and police say driver's side airbag should have deployed even if a small impact of that magnatude. Thank you for your help. michelle and philip camp. *ak
- Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Anti-lock brakes have failed two times in panic stops, brakes will release on rough roads, brakes have failed in reverse, dealer has replaced master cylinder but three failures have occured since. brakes are getting worse with pedal going to floor in panic stops and releasing. had failure in…
Anti-lock brakes have failed two times in panic stops, brakes will release on rough roads, brakes have failed in reverse, dealer has replaced master cylinder but three failures have occured since. brakes are getting worse with pedal going to floor in panic stops and releasing. had failure in mountains this summer in reverse (pedal going to floor and brakes releasing). there IS something very wrong with the design of these brakes! *ak
- Visibility › Windshield wiper/washer › Motor
Windshield wipers work intermittently or not at all this IS due to a faulty circuit board. *ak
- Electrical system › 12v/24v/48v battery · Electrical system › Alternator/generator/regulator · Service brakes, hydraulic › Antilock/traction control/electronic limited slip
Vehicle had trouble starting, replaced battery, starter and alternator wiring to rectify problems. Mjs
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10246631Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- 10232287This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
Every Chevrolet G20 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.