2024 Volvo Vnl
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
These records cover every 2024 Volvo Vnl. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2024 Volvo Vnl. Newest first.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024-2025 VNL and VNR vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.
Risk and remedy
Risk
A fractured steering gear shaft can cause a loss of steering control, increasing the risk of a crash.
Remedy
Dealers will inspect the serial numbers, and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed March 5, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX2401.
Volvo Trucks North America (Volvo Trucks) is recalling one 2024 VNL truck. The bearing journals may not be fully seated in the steering knuckle assembly, preventing the proper installation of the wheel end hub assembly.
Risk and remedy
Risk
An improperly installed wheel end hub assembly can leak oil, causing the axle spindles to loosen or fracture and increasing the risk of a crash.
Remedy
Hendrickson will inspect and replace the steering knuckle assembly as necessary, free of charge. The owner notification letter was mailed February 2, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number for this recall is RVXX2315.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 Volvo VNL and VNR trucks. A software programming error may cause the electronic stability control (ESC) to be inoperative.
Risk and remedy
Risk
Driving with an inoperative electronic stability control system can increase the risk of a crash.
Remedy
Dealers will reprogram the control unit software, free of charge. Owner notification letters are expected to be mailed December 3, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2310.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VNL, VHD, and VNR trucks. The fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control.
Risk and remedy
Risk
A loss of steering control increases the risk of a crash.
Remedy
Dealers will inspect and tighten the castle nuts and install new cotter pins, free of charge. Owner notification letters are expected to be mailed December 4, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2311.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
Risk and remedy
Risk
Inoperative windshield wipers can reduce visibility, increasing the risk of a crash.
Remedy
Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number for this recall is RVXX2309.
Volvo Trucks North America (Volvo Truck) is recalling certain 2022-2024 VNL and VHD vehicles equipped with RollTek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
Risk and remedy
Risk
An air bag that does not deploy, increases the risk of an injury.
Remedy
Dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed August 4, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2305.
Volvo Trucks North America (Volvo Trucks) is recalling certain 2024 VNR, VNL, and VHD vehicles. The hub covers do not properly fit on the hub and can detach from the vehicle.
Risk and remedy
Risk
A detached hub cover can create a road hazard, increasing the risk of a crash.
Remedy
Dealers will remove the hub covers, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2302.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10253829CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
- 10253828CBR: Volvo VN Models - Clicking Or Popping From HVAC When Switching To And From Defrost, Reduced Airflow In Defrost - Model Year 2024 to Present.
- 10253824CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS Communication Faults.
- 10253823CBR: Diagnostic Trouble Code (DTC) P107471 -AMT-F
- 10253821CBR: Turbo Compound 2nd Generation - EGR And / Or DPF Diagnostic Trouble Codes (DTC), Diagnostic And Repair Information.
- 10253819CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.
- 10252326Fleet Improvement Campaign: Certain Volvo VN model trucks have seat cushions that are thinner and wear faster than previous seat model. Follow the instructions below to replace the seat cushion with an alternative cushion that is acceptable.
- 10252324Service Campaign: Volvo trucks has determined that certain VAH, VHD, and VN model trucks built with a D13 engine could experience a reduced clamping load on the turbocharger mounting hardware causing the hardware to become loose. On affected vehicles follow the instructions below to remove the turbocharger and replace the mounting hardware and mounting gasket with new parts.
- 10252322CBR: The Omnitracs ELD may have trouble linking up with the GPS signal. Replacing the Safety Direct Processor (SDP), (FLC), Omnitracs ELD unit, and overhead harness have had no positive affects. When both Bendix components mentioned are in the vehicle alongside the Omnitracs ELD, the GPS signal will not connect. However, if the SDP is disconnected, the GPS signal connects without issues.
- 10252321CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as designed.
- 10252317CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
- 10252316CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
- 10251325CBR - Telematics Gateway (TGW) Connect Ability Issues.
- 10251323CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
- 10251319CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
- 10251317CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
- 10249569CBR: TGW Will Not Connect After SIM Card Replacement
- 10249566CBR: Diagnostic Trouble Code (DTC) P113600 NOx Sensor 1/2 Correlation Calibration Error Bank 1 - Model Year 2024.
- 10249565Service Campaign: VIN Label Engine Serial Number
- 10248099Service Campaign: Volvo Trucks has determined that certain model year 2024 VN/VNE vehicles do not have an adequate amount of door cavity wax installed. Cavity wax is critical for corrosion protection inside the doors.
- 10248098Fleet Campaign: Certain Wegman Volvo trucks could have an issue with the Rear Air Suspension not being set correctly from the factory. The incorrectly adjusted suspension could cause incorrect working angles in the drive line.
- 10248081CBR: Engine Control Module (EMS) Software (MSW) Information October 2023 Improvement List (Change Log) - US20-OBD23 Emissions.
- 10248063CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
- 10246113Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been developed. The new software will be delivered as an updated PAR file to the ABS Module and will help reduce heat load on steer axles brake assemblies during an adaptive cruise control braking event. Follow the instructions below to visually inspect the brake rotors on the steer axle for excessive heat damage and update the ABS software.
- 10246111Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty program on Volvo Reman AMT I-Shift Complete Transmissions. This extended warranty of 3 years or 350,000 miles on the transmission will be applicable when dealer installed, required parts are installed and is registered via eService.
- 10244826Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
- 10244825CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
- 10243465Service Campaign: Upper Radiator Hose Replacement (4.00 Degree Crank Angle)
- 10243461TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- 10243460TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- 10243458CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
- 10241904CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
- 10240294Service Campaign: CLC Fairing Handles
- 10240290Service Campaign: Diesel Exhaust Fluid Tank Breather Replacement
- 10240254CBR: Volvo Chassis - Instrument Cluster (IC) Immobilizer Pass Code Not Working
- 10240252CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
- 10240249CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
- 10240244CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
- 10238759CBR - iLok Fastener Torque
Every Volvo Vnl model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.