2011 Chevrolet Corvette
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Corvette › 2011
These records cover every 2011 Chevrolet Corvette. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2011 Chevrolet Corvette. Newest first.
General motors (gm) IS recalling certain model year 2011-2012 chevrolet corvette coupe vehicles, manufactured from january 24, 2011, through september 1, 2011, for failing to comply with the requirements of federal motor vehicle safety standard number 206, "door locks and door retention components". the rear hatch hinges may not meet the load requirements…
Risk and remedy
Risk
The rear hatch could separate in the event of a crash, increasing the risk of injury.
Remedy
Gm will notify owners and dealers will replace both rear hatch hinges free of charge. the safety recall began on october 14, 2011. owners may contact chevrolet at 1-800-630-2438.
Owner complaints
85 complaints2 involved a crash1 involved a fire
What owners report most
Latest complaints
- Fuel/propulsion system
I bought this vehicle in XXX with about 39k miles. About a year after purchase, I began smelling gasoline in my garage after I filled the tank. I have consulted Corvette forum ([XXX]) and find this is a common problem. If I fill the tank more than halfway, it seems to occur consistently. I…
I bought this vehicle in XXX with about 39k miles. About a year after purchase, I began smelling gasoline in my garage after I filled the tank. I have consulted Corvette forum ([XXX]) and find this is a common problem. If I fill the tank more than halfway, it seems to occur consistently. I recognize this car has no warranty, but this seems to be both common and a serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Fuel/propulsion system
My 2011 Grand Sport Corvette fuel system was repaired on 2/14/22 at no cost to me by special policy 15682-03. Now, 4 years later, the same problem has occurred again. I notice fuel smell in my garage with the tank nearly full after fill-up, and upon inspection, I notice evidence of fuel leaking…
My 2011 Grand Sport Corvette fuel system was repaired on 2/14/22 at no cost to me by special policy 15682-03. Now, 4 years later, the same problem has occurred again. I notice fuel smell in my garage with the tank nearly full after fill-up, and upon inspection, I notice evidence of fuel leaking along the side of the primary tank behind the driver's seat which is the same problem encountered before. GM tells me no additional help for repair is not forthcoming due to the age of the vehicle. My originating dealer has first quoted me $4000.00 and later quoted me $3400.00 to repair the car. I am reluctant to discard my Corvette which remains in excellent condition otherwise. I am currently filling the car 2/3 full so I can continue using and enjoying it without wasting fuel or creating a dangerous vapor condition in my garage.
- Fuel/propulsion system
Fuel pump feeder is known to be a major issues on these cars. These should be a safety recall with no explanation. Feeder fitting tends to crack overtime. Recently purchased and wasn’t aware of that previous recall which the previous owner didn’t handle.
- Fuel/propulsion system
Fuel is leaking from the top of the driver side fuel sending unit. This is a know issue on these cars and should be fixed under a recall. This is a very dangerous issue.
- Fuel/propulsion system
I bought a 2011 Grand Sport Corvette and if I fill the tank over half full the gas smell is unbearable. Some one needs to recall these cars. This issue is very serious. Fuel leaks out the top of the tanks, and will then drip down the back side onto the hot exhaust. If ignored this could result in…
I bought a 2011 Grand Sport Corvette and if I fill the tank over half full the gas smell is unbearable. Some one needs to recall these cars. This issue is very serious. Fuel leaks out the top of the tanks, and will then drip down the back side onto the hot exhaust. If ignored this could result in a fire and possible death. If parked overnight in a garage, the vapor will fill the garage and could easily be triggered into an explosion and fire from a gas water heater or other ignition source.
- Fuel/propulsion system
Fuel pump elbow at top of driver side tank cracks and allows fuel to leak out of plastic piece. Many have the same issue and all we got was a very temporary fuel pump recall. Engine light is on
- Engine · Fuel/propulsion system · Unknown or other
My entire garage is filled with gas fumes after I filled my car up to full yesterday. I drive my car once every 2 weeks and this is filling my garage with fumes. There are no visible leaks, there is a technical service bulletin regarding a gas tank issue that expired. What component or system…
My entire garage is filled with gas fumes after I filled my car up to full yesterday. I drive my car once every 2 weeks and this is filling my garage with fumes. There are no visible leaks, there is a technical service bulletin regarding a gas tank issue that expired. What component or system failed or malfunctioned, and is it available for inspection upon request? UNKNOWN, the vehicle is available for inspection. How was your safety or the safety of others put at risk? I could smell gas fumes from inside my garage door. Has the problem been reproduced or confirmed by a dealer or independent service center? It will be tomorrow. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. Haven't got that far. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Appeared today, drove for 2 hours each direction yesterday after a 75% tank fill.
- Service brakes · Vehicle speed control · Wheels
Driving and service active control system can on feel like brakes locked up, very scary.
- Fuel/propulsion system
Same fuel smell issue as what GM kinda covered with Bulletin #[XXX] However that is a 10 year / 120,000 miles limit. I'm under the miles but over on time. Just purchased the vehicle (was told "there are no recalls" because they were allow to all it a "Special Warranty Adjustment". Of course the…
Same fuel smell issue as what GM kinda covered with Bulletin #[XXX] However that is a 10 year / 120,000 miles limit. I'm under the miles but over on time. Just purchased the vehicle (was told "there are no recalls" because they were allow to all it a "Special Warranty Adjustment". Of course the previous owner didn't get this addressed ... nor WOULD they if the smell started later. So ... still a fire hazard ... even the fix offered is replacing plastic parts with same plastic parts and crossing fingers. Dealers are quoting over 16 hours ALONE for a fix pushing costs to over $3000. And this can reoccur in the future when that plastic also fails. Metal fittings for fuel ... seems like a better choice costing only a few dollars more. Please do something for us chumps that bought the unfixed cars used. At least require dealer to fully inform buyers. "We didn't test for it because we would have to drop the tank with requires removal of exhaust, transmission etc" which is I'm sure more than 1/2 the labor of the fix minus parts. The easy test is fill it near full of gas, drive it, smell it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Fuel/propulsion system
Fuel smell coming from car when parked. Garage smells like fuel. Chevrolet [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Fuel/propulsion system
Gasoline drips out under the car after fill up. About 1/2 quart comes out and makes a puddle about 5 foot in diameter. Happens after every fill up. I turned in a NTHTSA complaint about fuel vapor smells after fill up on 9/6/2020 but heard nothing back. The problem has obviously progressed to leaking liquid gasoline on the ground.
- Fuel/propulsion system
There is a smell of fuel when you get in the car. Looked online and seen several people having the same issue seems to happen when you have more than a half tank of gas. See small drip after sitting under car at front of drivers side rear wheel
- Fuel/propulsion system
Fuel tank is leaking, strong fumes in my garage, I have to park outside, is this a recall? I've heard so many fuel leaking problems with the C6 Corvette
- Air bags
The airbag light stays on due to the connectors under the seats dragging on the carpet when the seats are moved forward or back
- Fuel/propulsion system
Strong odor of gas fumes in driver compartment, seems to eminate from driver side. Plastic flange on top of fuel pump is cracked and spews gas to surrounding area. Smell is constant regardless of fuel level. GM has been aware of problem for years but has yet to issue recall. They did issue…
Strong odor of gas fumes in driver compartment, seems to eminate from driver side. Plastic flange on top of fuel pump is cracked and spews gas to surrounding area. Smell is constant regardless of fuel level. GM has been aware of problem for years but has yet to issue recall. They did issue temporary special coverage adjustment not adequate for earlier model years where issue was systemic. Yes my car is available for inspection. This is health and safety issue which should warrant a recall. Fire hazard as well. No warning lamps appear on dash.
- Fuel/propulsion system
I recently purchased a 2011 Chevy Corvette Grand Sport from a dealer in South Florida named Greico Chevrolet in Del Rey Beach. It was purchased used and as is from this dealer, but this appears to be a quite dangerous problem. I smell gasoline on the drivers side wheel well most of the time and…
I recently purchased a 2011 Chevy Corvette Grand Sport from a dealer in South Florida named Greico Chevrolet in Del Rey Beach. It was purchased used and as is from this dealer, but this appears to be a quite dangerous problem. I smell gasoline on the drivers side wheel well most of the time and sometimes the smell seeps through the car into the cabin. This is not from overfilling the tank (which I do not do anyway). I researched this issue and it appears to be an issue with two GM cars. See this statement and let me know if I have a claim: "GM Special coverage adjustment 15682 update July 2016 .Condition Some 2007 to 2009 model year Cadillac XLR and 2007 to 2013 model year Chevrolet Corvette vehicles may have a condition where a fuel odor is detected, fuel droplets appear below the left-hand fuel tank with fuel gauge level above 1/2, or a malfunction indicator lamp illuminates due to a leak path in the left-hand fuel pump module flange. Special Coverage Adjustment This special coverage covers the condition described above for a period of 10 years or 120,000 miles (193,000 km), whichever occurs first, from the date the vehicle was originally placed in service, regardless of ownership. For vehicles covered by Vehicle Service Contracts, all eligible claims with repair orders on or after July 25, 2016, are covered by this special coverage and must be submitted using the labor operation codes provided with this bulletin. Claims with repair orders prior to July 25, 2016, must be submitted to the Service Contract provider. Correction Dealers are to replace the left hand fuel tank fuel pump module. The repairs will be made at no charge"
- Fuel/propulsion system
I purchased this 2011 corvette on December 31st, 2021. I drove it home and parked it in the garage. The next day I smelled gas but couldn’t find any leaks. Yesterday I had the car on a lift and changed the transmission filter and fluid. While I was underneath it, I noticed liquid streaks on the…
I purchased this 2011 corvette on December 31st, 2021. I drove it home and parked it in the garage. The next day I smelled gas but couldn’t find any leaks. Yesterday I had the car on a lift and changed the transmission filter and fluid. While I was underneath it, I noticed liquid streaks on the left fuel tank and possibly on the right tank also. Today I googled corvette C6 gas leaks and found all the information on the problems regarding plastic on fuel pumps cracking or seals failing. I am sure that my car is having the same problem. It sounds like GM sent owners letters (possibly in 2017) which stated they would extend the warranty for 20 years or 120,000 miles. Many owners stated that their cars were over the time limit or miles when they received the letter. I feel GM should recall these cars since a fuel leak has to be the most dangerous item out there. I worry that my house could burn down or it starts on fire while I drive it.
- Air bags
Air bag light in dashboard seemingly randomly turns on and off while driving and is usually on indicating an issue with the air bag system. To begin with the light was only intermittently on but over time it has reversed and now the light only turns off intermittently.
- Engine
The engine light continues to come on, with the code for emissions leak. changed the gas-cap, put in Catalatic Converter Cleaner, but did not get rid of the constant code. have been shutting the code off with help from the parts store. The car only has 31,000 miles, the system shouldn't be throwing an emissions code.
- Fuel/propulsion system
The fuel component on this vehicle is the concern. The fuel vapor is very strong inside the car and especially outside around the driver's side. When parked in the garage, the fuel smell would seep into the house. I am afraid to park it inside the garage due to strong fuel vapor coming out of…
The fuel component on this vehicle is the concern. The fuel vapor is very strong inside the car and especially outside around the driver's side. When parked in the garage, the fuel smell would seep into the house. I am afraid to park it inside the garage due to strong fuel vapor coming out of the vehicle. I am afraid that the strong fuel vapor might ignite due to other power sources inside the garage. This issue is well known in the Corvette community, on Corvette Forum. I have scheduled to bring it into a Chevy dealership on 6/8/21 for an inspection and repair. There is no drivability issue with vehicle. It starts and drives fine, just the fuel smell that is overwhelming. There is no sign on fuel leaks on the floor. There is no warning lamps, nothing that would indicate a fuel system issue. The car only has less than 19k miles as of this writing.
- Fuel/propulsion system
Upon filling fuel tank and returning home and parking vehicle in garage, fuel smell and leak was confirmed on floor of garage. Vehicle was taken to a automotive center to have inspected and automotive center stated " fuel leaking when filling with fuel." Automotive center states "was able to…
Upon filling fuel tank and returning home and parking vehicle in garage, fuel smell and leak was confirmed on floor of garage. Vehicle was taken to a automotive center to have inspected and automotive center stated " fuel leaking when filling with fuel." Automotive center states "was able to inspect with an inspection camera and found that top of fuel tank is leaking at the fuel pump module seal to the tank. Also can see the vapor valve is wet from fuel as well. Recommend both pumps and evap valve." Concerned for safety of vehicle when driving and parked.
- Fuel/propulsion system
I am a one-time owner of a 2011 corvette grand sport vehicle. I have noticed that following a filling of the gas tank to full, a significant and persistent gasoline smell appears in my garage. I eventually brought my vehicle in for service on february 3, 2021 in order to determine the cause. I…
I am a one-time owner of a 2011 corvette grand sport vehicle. I have noticed that following a filling of the gas tank to full, a significant and persistent gasoline smell appears in my garage. I eventually brought my vehicle in for service on february 3, 2021 in order to determine the cause. I was told that a gas leak was observed from the top of the tank. in addition, I was told that the expensive replacement of the gas tank could not be found. I am now very reluctant to drive the vehicle.
- Power train
I have a 2011 chevrolet corvette with about 34,000 miles on it. The automatic transmission shift linkage cable has plastic grommets that connect the shift handle to the transmission. The plastic grommets broke disabling the ability to shift out of park into any gear. I was parked in a parking lot when this happened. My concern IS if this happens while driving you will lose control of the car.
- Fuel/propulsion system
The 2011 corvette started having strong fuel smell after driving
- Fuel/propulsion system
Every time I fuel up passed half , there IS a strong scent of fuel in the car that won't go away.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011805This Preliminary information communicates a GM part number forreflective high temperature heat or insulating tape when repairing wiring harnesses.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11011709This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
- 11011444This Preliminary information communicates to the dealer a process for accessing the procedure to add attachments to a GM technical assistance case using the dealer case management tool.
- 11011205This informational bulletin explains Unscheduled Supplemental Services and the importance of GM Simplified Maintenance Schedules.
- 11010545This service bulletin provides information on key code security rules and information on GM keycode look-up applications (U.S).
- 11010491This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 11010490This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11010421This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
- 11009764This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
- 11009756This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management.
- 11009532This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009461This service bulletin provides information on Characteristics of Wide Low Aspect Ratio Tires, Vehicle Pulls Left or Right, Wanders, Follows Depressions in Road Surface, Tramlining.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11009039This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11008906This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
- 11008898The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect.
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007196This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies.
- 11007121This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.
- 11007116This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
- 11007115This service bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement.
- 11007095This bulletin provides information on the TOP TIER Detergent Gasoline Licensed Brands and the TOP TIER Diesel Fuel Licensed Brands that are recommended for use in all GM vehicles and the TOP TIER FUELS website URL.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006682This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
- 11006670This service bulletin advises about the possible issues that may occur when using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts.
- 11006644This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11006511This PI provides information on Rear and Side Tempered Glass Spots (Quench Marks) and that they are a normal characteristic.
- 11006421GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
- 11006278This service bulletin describes the U.S. Dealer Special Tool Loan Program process.
- 11005311This service bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operation.
- 11004761This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
Every Chevrolet Corvette model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.