2015 Chevrolet Suburban
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Suburban › 2015
These records cover every 2015 Chevrolet Suburban. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
11 recalls name the 2015 Chevrolet Suburban. Newest first.
General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe vehicles. A component missing from the…
Risk and remedy
Risk
Front or rear wheel lockup increases the risk of a crash.
Remedy
Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262557620. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 7, 2026.
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic…
Risk and remedy
Risk
Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Risk and remedy
Risk
As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Risk and remedy
Risk
If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL…
Risk and remedy
Risk
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and…
Risk and remedy
Risk
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13, 2014. In the affected vehicles, the ignition lock…
Risk and remedy
Risk
If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Remedy
GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
Risk and remedy
Risk
An unexpected loss of power steering increases the risk of a crash.
Remedy
GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
Risk and remedy
Risk
During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
Remedy
GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
Risk and remedy
Risk
If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission…
Risk and remedy
Risk
If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
Remedy
GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
Owner complaints
431 complaints21 involved a crash8 involved a fire34 injuries2 deaths
What owners report most
Latest complaints
- Steering
This has almost caused us to get in an accident several times now. While driving and taking a curve or while gradually turning, the power steering failed. The steering wheel was extremely difficult to turn, and my wife could barely turn it. The message “Steering Assist Reduced – Drive with Care”…
This has almost caused us to get in an accident several times now. While driving and taking a curve or while gradually turning, the power steering failed. The steering wheel was extremely difficult to turn, and my wife could barely turn it. The message “Steering Assist Reduced – Drive with Care” was displayed. When we pulled over and turned off the engine, and then later re-started the Suburban, the power steering worked again. The dealer conducted a diagnostic on it and could not find the problem at first. They later said the Power Steering Gear needed to be replaced. This is a very dangerous problem.
- Service brakes
I experienced a serious brake failure in my 2015 Chevrolet Suburban with 112,500 miles that nearly resulted in a collision. After approximately 90 minutes of driving, I pulled into a parking lot and attempted to stop. Without warning lights or prior symptoms, the brake pedal suddenly became…
I experienced a serious brake failure in my 2015 Chevrolet Suburban with 112,500 miles that nearly resulted in a collision. After approximately 90 minutes of driving, I pulled into a parking lot and attempted to stop. Without warning lights or prior symptoms, the brake pedal suddenly became extremely hard to press, and the vehicle nearly failed to stop. I had to stomp on the brake pedal to stop. The same dangerous condition occurred while reversing into a parking space. This created a serious risk of injury to myself and others. The problem appeared primarily at low speeds. After sitting for several hours, the brakes seemed normal again. This intermittent failure is especially dangerous because it occurs without warning. A GM dealership inspected the vehicle and confirmed: "Vacuum pump has failed internally causing a stiff pedal at times when pumping brakes. Pump can't build vacuum fast enough to keep up with demand to fill brake booster." The failed component is available for inspection. I discovered GM Special Coverage N182202780 addresses this vacuum pump failure. However, GM refused assistance because my vehicle exceeded the 10-year coverage period, despite having only 112,500 miles. In approximately 2020, I had a GM braking safety recall performed. The dealership reprogrammed the vehicle and installed a thicker brake pedal pad rather than replacing the vacuum pump. Despite this previous recall repair, I experienced the dangerous braking condition. I believe this is a serious safety defect, not simply a warranty issue. A critical braking component should not fail without warning, making the vehicle extremely difficult to stop. I request that NHTSA investigate whether the previous recall remedy was adequate and whether GM's special coverage should be expanded into a safety recall regardless of vehicle age.
- Power train
2024 Suburban bought brand new. Service Transmission Warning lights up. Been to the dealership shop about this 4 times now. They replaced the TCM with kit, seals, & tranmission fluid. Problem occurred again 200 miles later. Dealership just stringing us along without actually fixing it!
- Air bags
Door slam caused side impact airbags to deploy
- Steering
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving and taking a curve, the vehicle failed to turn as needed. The contact stated that the steering wheel was extremely difficult to turn. The contact stated that the message “Steering Assist Reduced – Drive with Care” was…
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving and taking a curve, the vehicle failed to turn as needed. The contact stated that the steering wheel was extremely difficult to turn. The contact stated that the message “Steering Assist Reduced – Drive with Care” was displayed. The dealer was contacted, and a diagnostic test was pending. The manufacturer was not made aware of the failure. The failure mileage was unknown.
- Service brakes
When coming to a stop or backing from my inclined driveway the foot brake requires a hard push because it seems to lock up. I couldn't stop when braking. The problem is recurring. It has not been inspected for this recurring problem and no lights or warning signal appears on the dashboard.
- Fuel/propulsion system
Fuel line leak caused by design flaw in which line plastic fuel feed line (GM part #84200271) is installed too close to the undercarriage, causing it to rub against the frame due to vibration and wear a pinhole. This is known by gm in service bulletin Service Bulletin 17-NA-304. This is a fuel…
Fuel line leak caused by design flaw in which line plastic fuel feed line (GM part #84200271) is installed too close to the undercarriage, causing it to rub against the frame due to vibration and wear a pinhole. This is known by gm in service bulletin Service Bulletin 17-NA-304. This is a fuel leak, that can causes significant fire danger to people, property, and nature. Eventually putting first responders at risk. Also the environmental risk of continuous leaking fuel. Luckily, I could smell it before anything bad happened. But if GM knows about this issue, it’s big enough they should do something about it and so should the NHTSA.
- Service brakes
When our new mechanic was checking over the car, he and his other mechanic both noticed that there was an increased brake pedal effort even though the brakes were in ok condition. Every time I’ve had the car serviced I have them check the brakes because they feel off. The car stops and the…
When our new mechanic was checking over the car, he and his other mechanic both noticed that there was an increased brake pedal effort even though the brakes were in ok condition. Every time I’ve had the car serviced I have them check the brakes because they feel off. The car stops and the brakes check out with previous mechanics but something doesn’t feel right. Our new mechanic then gave me a recall bulletin from GM N192268490 and said he thinks our car is experiencing this issue. The recall was attached to our VIN when the mechanic pulled it up but when we called the dealer and checked the NHTSA website, my VIN number was apparently not part of the recall. I am writing to state that I believe my car may be experiencing the issue stated in the recall bulletin as per my mechanic’s findings. Attached is a copy of the recall bulletin given to us by our mechanic. Please advise.
- Power train
Pulling off from a stop sign on a hill, the car wouldn't accelerate and rolled back hitting a pedestrian and then jerked forward aggressively burning rubber on the tires. I smell the transmission burning. Luckily the lady didn't want to press charges.
- Electrical system · Engine · Steering
While driving at highway speeds my vehicle lost steering the radio and the hvac turned off. I had abs and brake lights on the dash as well as a service stabilitrac message. The vehicle completely shutoff and I almost had an auto accident. I have not taken it anywhere as I’m to afraid to drive it for fear of having an accident.
- Electrical system · Unknown or other
When driving down the road, all gauges drop to 0, car continues to drive. When I pull over and try to turn the car off it turns everything off except the engine. I can’t put it into gear or restart the car. Battery has to be unplugged to get it to turn off. All lights will start flash across the dash. Service air bags, service trailer brake, service side detection, etc
- Exterior lighting
The Day Light Running Lights will not go off preventing the low beam light from lighting properly. 08/21/2025
- Power train
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. No warning light was illuminated. The contact veered to the side of the road and had the vehicle towed to an independent mechanic, who determined that the…
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. No warning light was illuminated. The contact veered to the side of the road and had the vehicle towed to an independent mechanic, who determined that the transmission had overheated and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 167,000.
- Engine · Fuel/propulsion system
Replaced lifters 1,3,5,7 and added automatic fuel mgmt system bypass chip after the vehicle went into limp mode ON THE HIGHWAY. Ran for less than 2000 miles and those same lifters failed a second time and had to be replaced AGAIN. The last incident occurred after about 200 miles and had engine…
Replaced lifters 1,3,5,7 and added automatic fuel mgmt system bypass chip after the vehicle went into limp mode ON THE HIGHWAY. Ran for less than 2000 miles and those same lifters failed a second time and had to be replaced AGAIN. The last incident occurred after about 200 miles and had engine failure, limp mode with multiple sensor failures in the middle of the road in the dark. Limited ability to move it safely off the road.
- Steering
On at or about November 1, 2025, I experienced a sudden loss of power steering. I was backing up in a parking and experienced a complete power steering failure. Since that date, it has failed multiple times. There was a recall on the EPS Module in 2015. I have contacted a dealer, they could not…
On at or about November 1, 2025, I experienced a sudden loss of power steering. I was backing up in a parking and experienced a complete power steering failure. Since that date, it has failed multiple times. There was a recall on the EPS Module in 2015. I have contacted a dealer, they could not find a recall for any power steering issues, when there clearly has been. If there has been a recall for the steering of the same model and make and year, and is clearly a SAFETY ISSUE, this recall in 2015 should cover my vehicle also. I was under the assumption that my vehicle was low on power steering fluid. Proceed to look for power steering pump to check fluid level, no reservoir! Start to investigate, find out I have an Electric Power Assist Motor, and an electric module that can not be replaced when it fails, the entire assembly has to be replaced, no way to replace fluid! I’m in the process of getting an estimate of repair as of 11/25/ 2025. There was no indication of any kind, of possibly failure! There is no data stored in the computer indicating any failure, electrical or otherwise!
- Service brakes
The braking system on my 2015 Chevy Suburban LTZ failed at slow speeds in a parking lot. I have replicated the issue in both forward and reverse. My family's safety was put at risk in that while backing up out of a parking spot the brakes failed completely and I had to push extremely hard on the…
The braking system on my 2015 Chevy Suburban LTZ failed at slow speeds in a parking lot. I have replicated the issue in both forward and reverse. My family's safety was put at risk in that while backing up out of a parking spot the brakes failed completely and I had to push extremely hard on the brake to get the vehicle to stop. That same behavior occurred while pulling forward into a parking spot, almost hitting the car in front of me. I took the vehicle into a Chevrolet dealer today indicating the symptoms and they said there was no recall attached to my VIN. This exact same behavior in my vehicle is described in [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed and hauling a boat, the transmission unexpectedly downshifted into second gear. The contact stated that the drive mode indicator light flashed red, and the check engine warning light…
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed and hauling a boat, the transmission unexpectedly downshifted into second gear. The contact stated that the drive mode indicator light flashed red, and the check engine warning light illuminated. The contact stated that the failure had occurred while driving downhill, and the contact pulled over to the shoulder of the roadway. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 116,816.
- Power train
transmission failed causing to replace do to the system on CHEVY motor changing from 8 cylinder to 4 cylinder and a thermostat on a transmission line.
- Structure
The contact owns 2015 Chevrolet Suburban. The contact stated that while inspecting the vehicle, the contact saw rust on the frame and saw horizontal lines that became progressively worse over time. A dealer was contacted. The vehicle was taken to the dealer, and the contact was informed that wax…
The contact owns 2015 Chevrolet Suburban. The contact stated that while inspecting the vehicle, the contact saw rust on the frame and saw horizontal lines that became progressively worse over time. A dealer was contacted. The vehicle was taken to the dealer, and the contact was informed that wax could be added to the rust spot and that the repair would be out-of-pocket because the failure was not under warranty. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 19-NA-255 (Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 114,481.
- Service brakes
If I pull up to a parking spot and I’m slowly creeping into the spot, say at a popular supermarket, and slowing down the brake pedal stiffens up and it’s almost impossible to press. I feel like my truck may not stop. If I’m on a slight incline and in a line behind another vehicle, I’ve noticed the…
If I pull up to a parking spot and I’m slowly creeping into the spot, say at a popular supermarket, and slowing down the brake pedal stiffens up and it’s almost impossible to press. I feel like my truck may not stop. If I’m on a slight incline and in a line behind another vehicle, I’ve noticed the brake pedal stiffens up then as well. Awhile ago I thought there was a recall for this for my truck and it was something about the vacuum in the brake pedal. This is a super problem. I have five kids and we are on the road a lot. This has been happening a lot but most recently would be today.
- Electrical system › Instrument panel › Speedometer/odometer · Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
Odometer Fraud. The contact purchased a 2015 Chevrolet Suburban. The contact stated that while attempting to have the vehicle inspected, it was discovered that the catalytic converter was missing, the wires were cut, and a pipe was inserted to muffle the noise. The contact was told that the check…
Odometer Fraud. The contact purchased a 2015 Chevrolet Suburban. The contact stated that while attempting to have the vehicle inspected, it was discovered that the catalytic converter was missing, the wires were cut, and a pipe was inserted to muffle the noise. The contact was told that the check engine warning light was turned off and the carbon monoxide was not being cleaned, and that fumes were entering the cabin of the vehicle. The contact also discovered that there was a mileage discrepancy on the vehicle. The vehicle was a dealer sale. At the time of purchase, the mileage was 131,000 and at the time of the inspection, it was discovered that the mileage was approximately 231,000.
- Lane departure › Blind spot detection · Power train
The transmission was acting weird and felt like it was revving up and down while going 20-30 mph. After turning into my neighborhood there was a loud clunck like some dropped off the truck and it completely fell out of gear and just rolled to a stop. Shifted it into park, turned the truck off and…
The transmission was acting weird and felt like it was revving up and down while going 20-30 mph. After turning into my neighborhood there was a loud clunck like some dropped off the truck and it completely fell out of gear and just rolled to a stop. Shifted it into park, turned the truck off and back on and put it back in drive it went into gear and allowed me to drive to my house but still acted like it was about to drop out of gear completely again. My neighbor has a 2015 Silverado and 2017 Tahoe and both transmissions did the same thing and had to be replaced, all between 100-125k miles. The blind side system constantly goes off when there’s no threat
- Power train › Automatic transmission
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving on two occasions, the vehicle did not accelerate as intended. The contact stated that when the vehicle reached 55 MPH, the vehicle dead stopped, and she was thrust forward, and on the second occasion, she sustained a…
The contact owns a 2015 Chevrolet Suburban. The contact stated that while driving on two occasions, the vehicle did not accelerate as intended. The contact stated that when the vehicle reached 55 MPH, the vehicle dead stopped, and she was thrust forward, and on the second occasion, she sustained a head injury from hitting her head on the steering wheel. Medical attention was not needed. Additionally, on the second occasion, the vehicle began overheating, and the check engine warning light illuminated. The vehicle was towed to an independent mechanic, where it was codes P0700, P0741, and P0796 populated, and the TCM, torque converter clutch circuit, pressure control solenoid C, and transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
- Engine · Seat belts · Steering
The contact owns a 2015 Chevrolet Suburban. The contact stated while driving at various speeds, the steering wheel became stiff, and the vehicle lost automotive power. The check engine, seat belt, stabili-trak, and ABS warning lights were illuminated. The contact stated that the vehicle was…
The contact owns a 2015 Chevrolet Suburban. The contact stated while driving at various speeds, the steering wheel became stiff, and the vehicle lost automotive power. The check engine, seat belt, stabili-trak, and ABS warning lights were illuminated. The contact stated that the vehicle was occasionally towed and taken to the same local dealer on several occasions, where it was diagnosed; however, the failure was not yet determined. The transmission, fuel pump, battery, alternator, and unknown wiring were replaced at the consumer's expense; however, the failure persisted. In addition, the contact related the failure to NHTSA Campaign Number: 18V586000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.
- Service brakes
Often the brake pedal becomes very hard to push and braking is extremely hindered. There is a recall for this issue that has been done but the vehicle is experiencing the exact same problem again. Dealership says that the vehicle time has expired for anything to be done again. Recall was performed only 5 years ago.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Brake Vacuum Pump Failure
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado…
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011989This service bulletin provides information on the harmful effects of ethylene glycol in transmission fluid.
- 11011900This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
- 11011805This Preliminary information communicates a GM part number forreflective high temperature heat or insulating tape when repairing wiring harnesses.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11011709This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
- 11011444This Preliminary information communicates to the dealer a process for accessing the procedure to add attachments to a GM technical assistance case using the dealer case management tool.
- 11011420This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the dealer contacts TAC.
- 11011205This informational bulletin explains Unscheduled Supplemental Services and the importance of GM Simplified Maintenance Schedules.
- 11011119This Preliminary information communicates to dealers GM is working on a solution for outdated Apps
- 11010576This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
- 11010566This service bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
- 11010545This service bulletin provides information on key code security rules and information on GM keycode look-up applications (U.S).
- 11010544This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
- 11010495This bulletin provides information on Warranty Administration Required Operating Procedures - 8 Points (U.S. Only).
- 11010491This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 11010490This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11010488This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.
- 11010421This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
- 11009764This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
- 11009756This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management.
- 11009532This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009170This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11009039This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only).
- 11009037This service bulletin provides information on Enhancing Field Product Reports with Digital Pictures.
- 11008986This Preliminary information communicatesdirection and examples when diagnosing multiple DTCs, one of which includes U**** Byte 71 DTC.
- 11008966This technical bulletin provides a procedure for the techs to replace the forward check ball and separator plate if found the cause of the customers concern of No Forward Gear When Shifting from Park to Drive and/or Reverse to Drive.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11008906This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
- 11008898The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect.
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007776This Preliminary Information communication advises the technician that some vehicles may have a dim Driver Information Center when the interior of the vehicle is hot from a sun load or extended heater operation. The Driver Information Center is designed to dim with high temperature exposure. This is done to protect the Driver Information Center from damage.
- 11007761This Preliminary Information communication provides information to the technician that a customer may request the factory Integrated Trailer Brake Control be bypassed and their aftermarket trailer brake controller be installed instead. Technician will need to gain access to the body harness. Install trailer brake controller harness General Motors part number 23184088 into Middle Bus Electrical Center (X61A).
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007721This service bulletin provides information on AGM batteries that require less frequent charging in storage.
- 11007691This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicle that may have a "Check Trailer Wiring" or "Service Trailer Brake System message on the Driver Information Center when a trailer is connected to the vehicle. Diagnostic Trouble Code C1114 set in the Chassis Control Module. Chassis Control Module has to determine the type of trailer brake system that is being used. The Chassis Control Module can be sensitive to a variety of trailer wiring issues. The technician will need to make a trailer tester using Electric Trailer Brake Magnets and 7-way trailer connector to determine if it is a vehicle or trailer issue. If the concern is not duplicated with the tester installed, the vehicle is operating correctly and the focus should be on the trailer wiring or 7 way connector.
Every Chevrolet Suburban model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.