2019 Chrysler Pacifica Plug-In Hybrid
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chrysler › Pacifica Plug-In Hybrid › 2019
These records cover every 2019 Chrysler Pacifica Plug-In Hybrid. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2019 Chrysler Pacifica Plug-In Hybrid. Newest first.
Chrysler (FCA US, LLC) is recalling certain 2019-2021 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.
Risk and remedy
Risk
A vehicle fire increases the risk of injury.
Remedy
Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Owner notification letters were mailed March 6, 2025. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 72B. This recall is an expansion of NHTSA recall number 22V-077.
Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.
Risk and remedy
Risk
A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.
Remedy
FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.
Owner complaints
45 complaints
What owners report most
Latest complaints
- Power train
The contact owns a 2019 Chrysler Pacifica Plug-In Hybrid. The contact stated while driving 75 MPH down a winding mountain road, the message “Pull Over Immediately - Vehicle will Shut down Soon” was displayed. The contact pulled over and was able to restart the vehicle. The contact stated that the…
The contact owns a 2019 Chrysler Pacifica Plug-In Hybrid. The contact stated while driving 75 MPH down a winding mountain road, the message “Pull Over Immediately - Vehicle will Shut down Soon” was displayed. The contact pulled over and was able to restart the vehicle. The contact stated that the message was displayed three times. The vehicle was driven to the local dealer, where it was diagnosed that a software update and transmission rebuild were needed. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,200.
- Unknown or other
We received multiple reminders for the recalls to be addressed, but each time we make an appointment at various service centers, they say that they cannot address the recall due to staff shortage and parts not being available. This has been persisting for over 4 years. Chrysler does not make a good…
We received multiple reminders for the recalls to be addressed, but each time we make an appointment at various service centers, they say that they cannot address the recall due to staff shortage and parts not being available. This has been persisting for over 4 years. Chrysler does not make a good faith effort to address these recalls. Most recently, we had an appointment and they (Spring Autonation in Spring, TX) told us that they would have to hold the car for weeks before being able to get to it due to shortage of staff as they only have two service members who can address it. Helfman Dodge said they holding time would be 3-4 weeks before being able to get to it. Teh reminders for the three recalls are coming from the dealerships, and yet they are not able to address them.
- Unknown or other
UNKNOWN/RECALL NOT BEING FIXABLE FOR MONTHS: due to a recall from mid-2024 which cannot be fixed, the vehicle is no longer safe to have parked in my garage, near my home, next to other vehicles, and is now not able to be used as intended. The risk of fire and/or explosion should require a manufacturer buyback. These vehicles have been dangerous for MONTHS.
- Hybrid propulsion system
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded…
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Hybrid propulsion system
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet…
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 24V538000 (HYBRID PROPULSION SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Electrical system · Steering
While driving the car down a busy 4 lane road at 55mph on [XXX] around [XXX] in Irvine, CA, the car began to shake as the steering locked up and alerts came up on the dash that the power steering had failed. After turning the car off and on it did not fix it. Leaving it off for 15 mins seemed to…
While driving the car down a busy 4 lane road at 55mph on [XXX] around [XXX] in Irvine, CA, the car began to shake as the steering locked up and alerts came up on the dash that the power steering had failed. After turning the car off and on it did not fix it. Leaving it off for 15 mins seemed to make the error go away. We had it towed to Tustin Tuttle Chrysler dealership for service. The dealership found the fault code in the log, it was a power steering control failure. They could not replicate the circumstance and insist on releasing the car as safe to drive; putting my family and the public at great risk. The dealership refuse to even run diagnostics on the faulty identified part. They said if they cannot recreate the problem they won’t fix it, even though they see the error code on their scanner. They shouldn’t be telling me the car is safe when it is clearly not. They only drove it 30 miles and did not check wiring or even pop the hood. They have done no work to deem it safe and this is fraud. Rochelle, the service manager, has told us over the phone that she will not work on the car, because she believes she will not be reimbursed for the work. She has said she has had the car for too long and wants it picked up. Her service advisor Erik, has read us the codes found over the phone and also told us that no one has worked on it and only has test driven it. Our greatest concern is the dealership is not servicing or repairing vehicles and putting very dangerous cars on the road. This is a public safety issue for all of Southern California. Additionally, this car was purchased with a full manufacturer’s bumper-to-bumper warranty, of which it is still in its covered in the next 3 years or 40,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Power train
Van engine failed during driving. This is a known issue by Chrysler and they will not repair the underlying problem - this is related to a prior recall. Instead, it only suggested replacing the battery which is a temporary fix. Separately, this van has a pending recall due to a fire risk. Unable…
Van engine failed during driving. This is a known issue by Chrysler and they will not repair the underlying problem - this is related to a prior recall. Instead, it only suggested replacing the battery which is a temporary fix. Separately, this van has a pending recall due to a fire risk. Unable to use the plug-in hybrid function of the van nor park it in a garage due to the recall issue. It has been almost four months since the recall notice without any news of when Chrysler will fix this problem. I requested a buy back due to the inherent risk of severe injury from simply being inside this van but was denied.
- Electrical system
Chrysler issued recall 72B back in July but has failed to provide a repair solution to the issue of a high voltage battery fire. They have advised to park the vehicle away from structures and to not charge. It's disappointing not to have a resolution or fix for this issue, especially going into the colder months and not being able to use the vehicle as intended.
- Power train
On [XXX] around 12:00 PM, while traveling northbound in the HOV lane at 70 MPH on [XXX] near [XXX] , with two small children in the passenger row and two adults in the front, the following error suddenly appeared on the dashboard: "Stop Safely -- Vehicle Will Shut Off Soon." Power to the engine…
On [XXX] around 12:00 PM, while traveling northbound in the HOV lane at 70 MPH on [XXX] near [XXX] , with two small children in the passenger row and two adults in the front, the following error suddenly appeared on the dashboard: "Stop Safely -- Vehicle Will Shut Off Soon." Power to the engine stopped as a result and the car coasted. A "red turtle" warning and a "Check Engine" error also displayed. No other errors, unfamiliar sounds, or mechanical noises preceded these errors, nor had there been any other recent problems with the car. We pulled over to the shoulder immediately and turned the car off for approximately 5 minutes to see whether the errors would persist. With the "Stop Safely" error no longer on the dashboard, we turned the car on again and drove it to the dealership. On that drive, the previous errors appeared a second time. The dealership, Carl Burger Dodge Chrysler Jeep RAM World (La Mesa CA), has confirmed that the transmission needs to be replaced and that it is unsafe to drive the vehicle until the transmission is replaced. On August 30, 2024, the dealership said that they are waiting for Stellantis to release the transmission and "that won't happen any time soon." As of today, September 2, 2024, Carl Burger has failed to provide a timeline for the replacement and have informed us that we must deal with Stellantis in order to get the case escalated and the car repaired. They have also refused to offer us a replacement/loaner vehicle while ours is in the shop. Mileage: 51,000 Stellantis Case Number [XXX] Dealership: https://www.carlburger.com/ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Power train
Check engine light cam on then a message "Stop safely Vehicle will shut off soon" This is related to recall 23V-010
- Engine
Got on freeway on ramp. About 3/4 of a mile later, warning came on “Stop Safely, vehicle will shut off soon” - red turtle appeared, and service engine soon light came on. 1. Transmission - it is at this point, but part has been ordered to replace 2.Going freeway speeds (73MPH) and had to…
Got on freeway on ramp. About 3/4 of a mile later, warning came on “Stop Safely, vehicle will shut off soon” - red turtle appeared, and service engine soon light came on. 1. Transmission - it is at this point, but part has been ordered to replace 2.Going freeway speeds (73MPH) and had to immediately slow and pull over with little warning. If the traffic would have been heavier, there is a good chance a collision would have occurred. 3. Yes - it was taken to a dealership today (5-9-24) and they indicated it is a transmission issue, and are ordering parts to correct this issue 4. No warnings prior to it coming on when I was driving.
- Electrical system · Hybrid propulsion system
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact stated while driving approximately 35 MPH, and ascending a medium grade in the road, the contact heard a "pinging" sound and the "Stop Safely - Vehicle will Shut Off Soon" warning light and a turtle symbol and the check engine warning…
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact stated while driving approximately 35 MPH, and ascending a medium grade in the road, the contact heard a "pinging" sound and the "Stop Safely - Vehicle will Shut Off Soon" warning light and a turtle symbol and the check engine warning light was illuminated. The vehicle lost motive power but was able to drive to the side of the road and shut off the vehicle. The contact stated that she was able to restart the vehicle, but the check engine warning light and the turtle symbol remained illuminated. The contact turned off and restarted the vehicle, and only the check engine warning light was illuminated. The contact was able to drive to her destination. The contact had previously received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) and the recall repair was completed at a local dealer. The contact had not taken the vehicle to a local dealer or independent mechanic for the recent failure. The vehicle was diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 55,000. The contact stated the dealership insisted on replacing the power inverter even though they were told others who had the loss of motive power requires a new transmission. Also, the vehicle shut down once again after the repairs.
- Electrical system · Forward collision avoidance › Adaptive cruise control · Vehicle speed control
The electrical system for the Chrysler Pacificas are dangerous. Beyond the other dangerous recalls, my Horn and cruise control no long work intermittently. I learned this while trying to warn a driver that was cutting into my lane without seeing my vehicle and I couldn’t warn them that they were…
The electrical system for the Chrysler Pacificas are dangerous. Beyond the other dangerous recalls, my Horn and cruise control no long work intermittently. I learned this while trying to warn a driver that was cutting into my lane without seeing my vehicle and I couldn’t warn them that they were about to hit me. Also Cruise control stops randomly. This all started after previous recall repairs. Since I am unable to use my horn in an emergency, I am nervous that my airbag no longer functions. This is a common issue reported online. This all started after previous recall repairs
- Electrical system · Engine · Power train
While driving a message appeared on the dash "SERVICE CHARGING SYSTEM" and vehicle doesn't even accelerate(we stay in Des Moines and visited my cousin in Dallas,TX, this is where this issue happened). Luckily I was on local road I was able to pull off, what would be the situation if it happens on…
While driving a message appeared on the dash "SERVICE CHARGING SYSTEM" and vehicle doesn't even accelerate(we stay in Des Moines and visited my cousin in Dallas,TX, this is where this issue happened). Luckily I was on local road I was able to pull off, what would be the situation if it happens on interstate with such high speed travelling vehicles behind me. I was driving with my 2 kids and wife and I feel it's more dangerous to take a trip with this vehicle. Please try to find a solution or issue an recall and doesn't want this situation to happen to anybody.
- Unknown or other
We had put a ladder on the roof of our van to return to Home Depot, and I opened our rear gate. I didn't know it at the time, but the van's rear gate could not open all the way at the top because of the ladder, which hung a few inches over the top of the gate. Because I didn't know the ladder…
We had put a ladder on the roof of our van to return to Home Depot, and I opened our rear gate. I didn't know it at the time, but the van's rear gate could not open all the way at the top because of the ladder, which hung a few inches over the top of the gate. Because I didn't know the ladder was in the way, when the rear gate opened, I bent over inside the van with my small dog to put her in her crate. Immediately, I heard the warning beeper start to go off, but before I could move out of the way, the gate came zooming down fast on my head and I had to squeeze to the size and fell into my driveway bushes trying to get out of the way. Thankfully, neither I nor my dog were harmed, but we could have both been seriously injured or killed. I have no idea why a rear gate would descend so fast or not sense that I and my dog were present.
- Electrical system · Power train · Unknown or other
Loss of Motive Power reoccurrences (2 incidents) AFTER 1803A182 Safety Recall 03A correction was performed, 9 May 2023, by reprogramming Hybrid Control Processor/Aux Hybrid Control Processor on 2019 Chrysler Pacifica Plug-In Hybrid (mileage: 35,180) Experienced a sudden loss of power twice; 16 and…
Loss of Motive Power reoccurrences (2 incidents) AFTER 1803A182 Safety Recall 03A correction was performed, 9 May 2023, by reprogramming Hybrid Control Processor/Aux Hybrid Control Processor on 2019 Chrysler Pacifica Plug-In Hybrid (mileage: 35,180) Experienced a sudden loss of power twice; 16 and 17 September 2023. - 16 SEPTEMBER: Having just merged into one lane from two and speeding up hill (from approx. 20 mph) to merge onto highway, a sudden loss of power occurred without an adequate shoulder to pull off, resulting in time critical crash avoidance maneuvers by all vehicles behind us. No known crashes occurred within our viewing range. ADDITIONAL DETAILS: Unable to shut down vehicle for 2-3 minutes Check Engine Light illuminated Dash Diagnostic screen: “Service Charging System” error Electric Power available: 56% Fuel: 3/8th) - 17 SEPTEMBER: After running a preliminary diagnostic test with my personal OBD tester, I noticed that the Check Engine Light turned off after the connection activated. I did NOT clear any codes. After printing the list of faults generated from the evening prior, I chose to take it for a short test drive. While waiting at a stop light within a mile from my house, the same issue occurred again, “Service Charging System” error followed by two additional alternating notification on the dash, “Service Shifter” error and “Service Shifter Stop Safely Shut Off Vehicle to Engage Park,” with the transmission indicator selector knob lost illumination and became non-responsive. (as seen in attached pictures from previous incidents) Luckily, everyone was stopped this time. Within 20-30 seconds, the entire vehicle, including dashboard went completely dead then blipped back on as if nothing had happened, allowing me to make it home safely.
- Unknown or other
Hood has rusted throughout most of the entire hood UNDER the paint. no accident has occurred , but extremely concerned hood may break apart and crash into windshield and cause a severe dangerous accident. Other vehicles of this kind may have same serious problem.
- Electrical system · Hybrid propulsion system
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the…
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact received notification of NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
- Electrical system · Engine · Power train
While driving down the road at approximately 45 mph, the car suddenly shut down with no power. The display said there was a charging error and to put the vehicle in park. I parked the vehicle on the shoulder, turned it off, and restarted. The engine started and I drove off, but 5 minutes later it…
While driving down the road at approximately 45 mph, the car suddenly shut down with no power. The display said there was a charging error and to put the vehicle in park. I parked the vehicle on the shoulder, turned it off, and restarted. The engine started and I drove off, but 5 minutes later it suddenly shut off once again. I repeated this process 2 times until the final time, the vehicle would not restart, and we were stranded on the shoulder of a busy road in icy conditions. A mechanic ran a diagnostic on the vehicle and there are no error codes, but it will not start and says there is a charging error, even though it is not plugged in. The sudden stops are very dangerous, especially in snowy/icy conditions. We are 600 miles away from home and do not feel safe operating this vehicle on a long road trip on busy highways.
- Electrical system › Adas › Autonomous/self driving › Software
2019 chrysler pacifica. Consumer writes in regard to nhtsa safety recall 23v-010. The consumer stated the remedy for the recall updating the pim software update opposed to repairing the wire harness IS unsatisfactory.
- Electrical system · Hybrid propulsion system
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact stated while driving at unknown speed, there was an abnormal knocking sound coming from the vehicle. The vehicle was taken to the dealer for diagnostic testing and the contact was informed that the vehicle was unsafe to drive. The…
The contact owns a 2019 Chrysler Pacifica Hybrid. The contact stated while driving at unknown speed, there was an abnormal knocking sound coming from the vehicle. The vehicle was taken to the dealer for diagnostic testing and the contact was informed that the vehicle was unsafe to drive. The contact was informed that there was no fix for the failure. The contact was unsure what failure the vehicle had experienced. The vehicle was not repaired. The manufacturer was contacted and stated that the failure might be related to NHTSA Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) and that the remedy was not available. The failure mileage was 27,000.
- Electrical system · Engine · Vehicle speed control
On Dec 5th, as I was driving downhill on Hwy 54 in Peachtree City, GA, the van jerked, made a beeping noise, and the dash lit up. The van had completely shut off. It said "service charging system" and "shift to park". I was able to get the van off the roadway and into a parking lot by coasting.…
On Dec 5th, as I was driving downhill on Hwy 54 in Peachtree City, GA, the van jerked, made a beeping noise, and the dash lit up. The van had completely shut off. It said "service charging system" and "shift to park". I was able to get the van off the roadway and into a parking lot by coasting. Despite turning it off, it kept turning back on with the ac on full blast. It finally stopped turning back on after I opened the driver door and left it open. It restarted and my husband drove it home. I called Chrysler when I got home. They said to call the local dealership to get recall fixed and have them look at the engine. I called the dealership first thing the next morning. He said the first available appointment would be Dec 28th. They no longer have a loaner program so I had to contact Chrysler cares back regarding rental. I sent them a message asking about a rental. They recommended I try to find an appt at another dealership. They also stated they couldn't speak to if it was safe to drive the van until seen at the dealership. On Friday Dec 9, I had to use the van. It stalled 5 times. I was able to get it off the roadway and restarted immediately. I contacted Chrysler again to request they contact the dealer to try to get me in sooner and they need to provide me a rental. This is a huge safety concern, and this is an issue that has been impacting their vans for a long time now. We love the van, but so disappointed that it is failing us and doesn't even have 50k miles on it! Their customer service is terrible. They are aware of these issues!!!
- Electrical system · Engine · Unknown or other
Driving on the Highway with my entire family of 6 people (with 2 young kids) and my Chrysler Pacifica Hybrid 2019 suddenly stops. When I press the accelerator the vehicle doesn't respond. When I shut it off, wait for a couple of minutes and turn it on again, it gives an error saying service…
Driving on the Highway with my entire family of 6 people (with 2 young kids) and my Chrysler Pacifica Hybrid 2019 suddenly stops. When I press the accelerator the vehicle doesn't respond. When I shut it off, wait for a couple of minutes and turn it on again, it gives an error saying service charging system. I had to shut it down on the highway and get it towed to the nearest dealer. I see several customer complaints with the same issue. I also see a NTHSA investigation of the same :- https://www.autoevolution.com/news/nhtsa-investigates-transmission-issue-affecting-chrysler-pacifica-phev-194678.html This is a fairly new vehicle (~40000 miles) with full service and maintenance done. Last month I took it for service at Chrysler dealership and they did service with 20 point inspection and no one identified or mentioned anything wrong with the vehicle.
- Power train · Wheels
Very LOUD metallic clanking noise while driving 40-50 mph coming from front left wheel. When I inspected it, I saw that the front left wheel bearing hub mounting bolt had backed out of the hub and steering knuckle and onto the CV shaft end, which is what caused the clanking. I have photos of this…
Very LOUD metallic clanking noise while driving 40-50 mph coming from front left wheel. When I inspected it, I saw that the front left wheel bearing hub mounting bolt had backed out of the hub and steering knuckle and onto the CV shaft end, which is what caused the clanking. I have photos of this damage. Vehicle is 3 years old and has 46,000 miles on it. I believe it should be obvious why wheel bearing hub mounting bolts backing out on their own is quite dangerous. This problem has not been confirmed by my local dealer. The manufacturer has not been made aware of this problem. There was no warning sign that this would occur. It happened spontaneously while driving this morning.
- Electrical system
On two occasions, my Pacifica Hybrid van lost electrical power and stalled while driving at high speed on the highway. In each case I was able to safely coast the vehicle over to a breakdown lane but the experiences were terrifying for my family and I. After stalling the vehicle remained frozen in…
On two occasions, my Pacifica Hybrid van lost electrical power and stalled while driving at high speed on the highway. In each case I was able to safely coast the vehicle over to a breakdown lane but the experiences were terrifying for my family and I. After stalling the vehicle remained frozen in a strange electrical system status and would not restart. Eventually I was able to get the system to restart by pulling and replacing fuses. To do this in a narrow breakdown lane while semi trucks are flying by at high speed was, again, terrifying.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Loss of motive power due to an internal wiring connector short.
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler…
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.
- Transmission fault leading to loss of motive power
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010…
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011774Backup Camera Poor Image Quality Inspection
- 11010748Reverse View Camera Inoperative After Recent Repair
- 11010511Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
- 11009570Switch and bezel - front door
- 11009559Module - inverter
- 11007087Warranty Newsletter Volume 10 Issue 8_ID
- 11006965"Updated Front Hub Nut Torque Specification There are no Customer Symptoms for this Information Only Technical Service Bulletin (TSB). "
- 11005525Liftgate Inoperative And Or Intermittently Will Not Open Or Close.
- 11005320"Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels."
- 110048382 nd Row Seat Does Not Fold Using Easy Entry Handle.
- 11002828"Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On "
- 11002752Motor - blower with wheel
- 11001830"Internal Transmission Wiring Connector Short and Motor A Bearing Failure Warranty Extension XE1 **Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs):** P0A3F - Drive Motor A Position Sensor 1 Circuit. P0A43 - Drive Motor A Position Sensor Circuit Intermittent. P0A45 - Drive Motor B Position Sensor 1 Circuit. P0C1A - Drive Motor B Torque Delivered Performance. Customers may also comment on the following: Vehicle is in limp mode. NOTE: Module flashes are also required for this Repair Procedure to be effective, the following modules are to be updated: Hybrid Control Processor (HCP). Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM). This bulletin involves replacing the transmission."
- 11001645Warranty Bulletin D-23-07 Rev. A (XE1) eFlite Si-eVT Transmission Certain 2017 - 2023 Chrysler Pacifica (RU)
- 11001644FCA Caribbean Warranty Bulletin ID-23-07 Rev. A (XE1) eFlite Si-eVT Transmission Certain 2017 - 2023 Chrysler Pacifica (RU)
- 11001466Power Sliding Door Inoperative Or Intermittently Will Not Open Or Close
- 11001459Suspected Engine Coolant Leak
- 10251783Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
- 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10247948Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
- 10244356LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
- 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10243209FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
- 10243208Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
- 10242717Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
- 10239957Water Quality When Mixed With Engine Coolant
- 10236969Mirror
- 10236933wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
- 10234420Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
- 10230183No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration
- 10230180Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
- 10229572Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10229285Apple Carplay Inoperative Or Not Working, Phone Not Pairing, Carplay Lockup, Freeze or Audio Concerns
- 10229102CHRYSLER PACIFICA (RU) MY2017-21 ELECTRIC COOLANT HEATER Part Requirement Verification
- 10228989Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold
- 10227983If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
- 10227969Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold For concerns of V8 oil filter leaks on 22MY and up vehicles: 1. Clean the area and use oil dye to know the exact location of the leak with black/UV light. 2. Removal torque (force needed to loosen the filter) 3. If the source of the leak cannot be identified, please contact FCA Redacted Content to FasTrak parts back for analysis. If no response in 15 minutes, proceed with repair and email pictures of the following: A) Oil filter from the bottom to know if it has a "Factory Installed" filter. B) Leak. C) Damage in filter (if any) D) Gasket. E) Block or Oil Filter Adapter(OFA) or Engine Oil Cooler(EOC) sealing surface.
- 10227709No Start After a Flash or Powertrain Control Module (PCM), Body Control Module (BCM) Replacement
- 10225424Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10225287Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
Every Chrysler Pacifica Plug-In Hybrid model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.