2006 Ford F-650 SD

Owner complaints

What owners report most

1. Engine and engine cooling1
2. Fuel system, diesel1
3. Suspension1

Latest complaints

• Jun 17, 2022WA57,000 mi
  Engine and engine cooling
  The contact owns a 2006 Ford F-650 SD. The contact stated that he had noticed a leak coming from the vehicle. Upon inspection, the contact discovered that the fuel injector was leaking. Upon further investigation, the contact linked the failure to NHTSA Campaign Number: 08E042000 (Engine and Engine…

  The contact owns a 2006 Ford F-650 SD. The contact stated that he had noticed a leak coming from the vehicle. Upon inspection, the contact discovered that the fuel injector was leaking. Upon further investigation, the contact linked the failure to NHTSA Campaign Number: 08E042000 (Engine and Engine Cooling) however, the vehicle was not included. The manufacturer had been notified of the failure and the contact was informed that his vehicle was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 57,000.

• Aug 24, 2007GA80,000 mi
  Fuel system, diesel
  Tl*the contact owns a 2006 ford F-650 sd. the contact stated that when the vehicle was purchased, it began misstepping and lost power. in march of 2007, the fuel tanks failed and had to be replaced. he learned at that time that the fuel tanks were deteriorating and burned the fuel tanks from the…

  Tl*the contact owns a 2006 ford F-650 sd. the contact stated that when the vehicle was purchased, it began misstepping and lost power. in march of 2007, the fuel tanks failed and had to be replaced. he learned at that time that the fuel tanks were deteriorating and burned the fuel tanks from the inside out. the fuel tanks were replaced. on august 23, 2007, the fuel tanks failed again and the vehicle was towed to the dealer. the contact stated that the fuel tanks were replaced with the same defective fuel tanks. the vin, purchase date, and engine size were unknown. the current and failure mileages were 80,000.

• Dec 3, 2005OH9,700 mi
  Suspension › Front › Wheel bearing

  We bought 2- f 650 roll backs and they both have been in shop 3 times for wheel bearings to be replaced, tires wearing bad spots in them because of this, carrier bearing went out, and now one of them the axle broke and IS in shop and it only has 34000 miles on it. it has had a bad vibration in them since we bought them, that IS what we took them to shop for.*jb

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 10205026Exterior mirror - tubular stainless steel west coast style mirror - loose mounting bracket
• 10204983Exterior Mirror - Tubular stainless steel west cpast style mirror - Loose mounting bracket
• 10183762Some 2006-2015 F-Super Duty 650/750 vehicles equipped with exterior tubular stainless steel west coast style mirrors may have a loose mounting bracket due to poor rivet retention.
• 10095225Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4X4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit IS now available for customer purchase. The kit IS designed for severe duty and IS non warrantable. The knuckle seal shield kit gc3z-54024a38-a includes an instruction sheet.
• 10056196Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. Model 2003-2014 f-super duty, e series, excursion, F-53 motorhome chassis, low cab forward.
• 10055629Ford: on some trucks, there IS a no crank situation and if voltage on transmission range sensor at pin 21, IS less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. Model 2003-2007 f super duty, 2004-2010 e series, 2003-2005 excursion.
• 10026387Ford: 6.0L diesel hard start/long crank/no start du to low injector control pressure (icp). Ipe
• 100243256.0L turbocharger carbon deposit diagnostics and service tips. Updated 5/29/08.
• 100239892004-2006 f-650/f-750 and 2006 lcf - fuel tanks.
• 100238556.0L--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles.
• 10023852Some 2004-2008 f-super duty 650-750 vehicles equipped with air suspension may exhibit a condition where the air suspension springs are not re-inflating.
• 100234352005-2008 f-super duty manual transmission- clutch pedal concern.
• 10023233Some 2005-2007 F-650 and F-750 vehicles equipped w/ a 6.0L diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp).
• 10022675Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes.
• 10022673Stuck or jumping/bouncing/erratic speedometer and/or tachometer.
• 10022297White smoke, lacks power, exhaust odor, surges, runs rough, or no start.
• 100222936.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct.
• 10022283Rear of vehicle IS too high/low -5TH wheel and goose neck applications.
• 10022280Buck/jerk when pulling large heavy gooseneck trailers. Diesel engines. Reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue.
• 10022243Lack of power due to low fuel pressure - fuel tank liner seperation.
• 10022242Fuel tanks put into some vehicles were made out of steel. Which are going to be replaced by aluminum tanks.
• 10022236Misfire and dtc p0300.
• 10022234Turn signals flashing rapidly after modification.
• 10022233Misfire and dtc p0300.
• 10022232Headlight adjustment needed.
• 10022229Lack of power or lack of performance condition when operated above 5,000 feet of altitude.
• 10021978Power steering pump pulley alignment.
• 10021903ABS light on and possible c1175, c1236, p0500,p0503.
• 10021901Dual fuel tank. One empty fuel does not transfer. Updated 2/6/08.
• 10021621Lack of power due to low fuel pressure, fuel tank liner seperation.
• 10021619Air filter water ingestion / snow packing with codes p0103.
• 10021485White smoke, lacks power, exhaust odor, surges, runs rough, or no start.
• 10021484Adding additional bulbs to turn indicator or hazard flasher circuits.
• 10021483Right fuel tank empty - fuel does not transfer from left tank.
• 10021482No start, no ecm/tcm communications and/or flashing automatic transmission indicator.
• 100214646.0L oil seep or boost pressure leak at hot side charge air cooler duct.
• 10021462Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start.
• 100212786.0L - reduced engine performance - high altitude.
• 10021236Lack of cooling fan operation.
• 10021235Runs rough or misfire due to a stuck valve.

Every Ford F-650 SD model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.