2022 Hyundai Tucson

Recalls

3 recalls name the 2022 Hyundai Tucson. Newest first.

• Trailer hitches

  Dec 18, 2025NHTSA 25V89300051,587 vehicles

  Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.

  Risk and remedy

  Risk

  Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.

  Remedy

  Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.

  Full recall details →

• Structure › Body › Roof and pillars

  Jan 31, 2023NHTSA 23V03800016,104 vehicles

  Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.

  Risk and remedy

  Risk

  A detached roof molding could become a road hazard, increasing the risk of a crash.

  Remedy

  Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.

  Full recall details →

• Electrical system › Software

  Dec 2, 2021NHTSA 21V93800012 vehicles

  Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson vehicles. The software installed in the Integrated Central Control Unit (ICU) may be incompatible with the vehicle, which could result in inoperative headlights and/or taillights.

  Risk and remedy

  Risk

  Inoperative headlights or taillights can decrease visibility for both the driver and surrounding traffic, increasing the risk of a crash.

  Remedy

  Dealers updated the ICU software, free of charge. All affected vehicles have been repaired and therefore no owner notification letters will be mailed. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 214.

  Full recall details →

Owner complaints

What owners report most

1. Fuel/propulsion system132
2. Engine115
3. Power train64
4. Electrical system55
5. Unknown or other55
6. Forward collision avoidance49
7. Service brakes32
8. Vehicle speed control14
9. Air bags12
10. Back over prevention10

Latest complaints

• Oct 28, 2026FL70,800 mi
  Visibility › Sun/moon roof assembly

  The contact owns a 2022 Hyundai Tucson. The contact stated that while driving 60 MPH, the sunroof glass shattered without impact. The vehicle was taken to an independent mechanic, and the sunroof glass was replaced. The vehicle was repaired. The failure mileage was approximately 70,800.

• Oct 28, 2026OR
  Visibility/wiper
  The windshield wipers were set to auto during a torrential downpour. When they increased to a high speed of wiping, we heard a large crack and the windshield wiper had completely broke on us. We were going around 45 MPH on a highway and were 1 hour away from our destination. We had little to no…

  The windshield wipers were set to auto during a torrential downpour. When they increased to a high speed of wiping, we heard a large crack and the windshield wiper had completely broke on us. We were going around 45 MPH on a highway and were 1 hour away from our destination. We had little to no visibility for the remainder of the car ride as it continued to downpour and was the most terrifying drive. We went to Dick Hannah's in Portland, OR to get it fixed. My fiance, who is an automotive engineer, told them what he believed happened; something in the arm itself has malfunctioned or misaligned to cause this. The dealership claimed it was the windshield wipers that caused them to break. I had purchased the car from carmax a few months prior, so they told us it wasn't covered. We went back and forth as we were certain it wasn't the wipers, but took their word for it. They "fixed it". Then, it happened for the second time. I was driving 55 MPH on the freeway while it was down-pouring and again, while set to auto, the wipers broke. It's hard not to panic. I immediately turned off the wipers before more damage could happen and lost visibility completely, causing more panic. I tried to switch it to low to get some visibility and took the next exit I could. I never made it to my destination and drove home instead on inside roads just in case. I don't understand how this isn't a recall. It has put us in such dangerous situations. High-speed highways/freeways, downpours, and no visibility do not mix.

• Oct 27, 2026PA30,000 mi
  Visibility
  The contact owns a 2022 Hyundai Tucson. The contact stated that while attempting to operate the windshield wipers, the wiper blades froze. The contact attempted to restart the wiper blades cycle, but the failure reoccurred repeatedly. The contact stated that the failure created a safety hazard…

  The contact owns a 2022 Hyundai Tucson. The contact stated that while attempting to operate the windshield wipers, the wiper blades froze. The contact attempted to restart the wiper blades cycle, but the failure reoccurred repeatedly. The contact stated that the failure created a safety hazard while driving in inclement weather. The dealer was contacted and a diagnostic test was pending. The failure mileage was 30,000.

• Oct 12, 2026AZ
  Unknown or other

  The fuel door doesn't work. My safety is at risk because I cannot put gas in my car. If i can't put gas in my car then it will stop working. If it starts working, the car becomes useless. There were no warning lights or anything. This is a common problem and should have a lifetime warranty.

• Oct 8, 2026IN
  Back over prevention › Rearview system braking · Electrical system · Forward collision avoidance › Warnings
  Approximately one week after having my oil changed at a Hyundai dealership, I began experiencing intermittent collision safety alerts and multiple dashboard warning lights. On three separate occasions when I started the vehicle, warnings appeared for the forward and rear collision systems, along…

  Approximately one week after having my oil changed at a Hyundai dealership, I began experiencing intermittent collision safety alerts and multiple dashboard warning lights. On three separate occasions when I started the vehicle, warnings appeared for the forward and rear collision systems, along with multiple other sensor warnings and engine warning lights. During one incident while driving in traffic, the forward collision warning activated and the vehicle abruptly applied the brakes. I was nearly rear-ended as a result. I have taken the vehicle back to the dealership on two separate occasions. The dealership reported replacing a sensor, but the warning lights and collision system issues have continued to occur intermittently. I am concerned that the vehicle may unexpectedly apply the brakes again, creating a risk of a collision.

• Oct 6, 2026FL20,000 mi
  Service brakes, hydraulic
  The contact owns a 2022 Hyundai Tucson. The contact stated while driving at 5 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the vehicle independently accelerated. The contact stated that the brake pedal was depressed with force and the…

  The contact owns a 2022 Hyundai Tucson. The contact stated while driving at 5 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the vehicle independently accelerated. The contact stated that the brake pedal was depressed with force and the vehicle stopped. The failure was intermittent at first but became more persistent. The dealer was contacted by phone and made aware of the failure. The failure mileage was approximately 20,000.

• Sep 30, 2026RI
  Power train
  On three occasions my car suddenly stopped transferring power by not accelerating when the gas pedal was pressed. The first time the engine light came on and when I brought it for service they said it was a sensor covered by warranty and repaired it. The second time it happened while I was trying…

  On three occasions my car suddenly stopped transferring power by not accelerating when the gas pedal was pressed. The first time the engine light came on and when I brought it for service they said it was a sensor covered by warranty and repaired it. The second time it happened while I was trying to merge with traffic on the highway. I took an exit and managed to get to the dealer. They replaced the fuel injector and fuel line. The third time, first the car struggled to start after work. Then, I was pulling out of the parking lot, crossing a very busy road. The car could barely get up to and past 20 mph. Once I got it to 35 or so, I stayed on local roads with my hazards on, and managed to get it to the dealer. No engine light came on and they haven’t been able to replicate the issue. This is a very serious safety concern! I am afraid to drive it now since the car can stop without warning and without any brake lights coming on. I am fully covered by warranty but am worried they won’t want to cover the cost to make my vehicle safe. Google shows engine problems like this as one of the known issues on the 2022 Tucson Limited.

• Sep 28, 2026IN
  Fuel/propulsion system
  My car suddenly broke down on the side of a busy highway halfway through my workday. When attempting to restart it, all warning lights came on on the dashboard and I could see white smoke coming out of the exhaust pipe while the car shook. I had it towed to the nearest Hyundai dealership and they…

  My car suddenly broke down on the side of a busy highway halfway through my workday. When attempting to restart it, all warning lights came on on the dashboard and I could see white smoke coming out of the exhaust pipe while the car shook. I had it towed to the nearest Hyundai dealership and they confirmed it was broken fuel injector(s). I do not have the broken piece to show as it is with the dealership. It has not been examined by police or insurance. No warning lights came on until after the car had suddenly slowed to a stop and I attempted to restart it.

• Sep 10, 2026GA
  Engine · Fuel/propulsion system

  Vehicle Fuel Injector code P053F84 Reading on 9/9/26, this is the second time vehicle was taken to the dealership for the exact same problem, the idle button in orange, and displayed, first visit while vehicle within warranty limits technician stated couldn't find anything wrong, now vehicle is out of warranty and dealership wants $1300 to fix the same issue.also the Engine was hesitating at each occurrence.

• Sep 3, 2026FL
  Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings

  I had just started accelerating from a stop light at 715 am on a clear morning. I was not close to any other cars and there was no traffic entering. Without warning my collision warning came on and brought the car to a sudden stop. This is damgerous and I am lucky I was not rear ended

• Sep 2, 2026ID
  Engine · Forward collision avoidance › Automatic emergency braking · Lane departure › Blind spot detection

  The car was shaking, idling and accelerating and engine lights on.

• Aug 31, 2026MA69,000 mi
  Electrical system · Trailer hitches
  The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the right turn signal indicator light failed to illuminate on the instrument panel upon depressing the turn signal lever to make a right turn. No warning lights illuminated. Additionally, upon…

  The contact owns a 2022 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the right turn signal indicator light failed to illuminate on the instrument panel upon depressing the turn signal lever to make a right turn. No warning lights illuminated. Additionally, upon depressing the turn signal lever to make a left turn, the left turn signal indicator light failed to illuminate. The contact stated that the failure progressed. While driving at various speeds, the brake lights failed to illuminate when the brake pedal was depressed. The vehicle was taken to an independent mechanic, where it was diagnosed that the wiring harness needed to be replaced. The vehicle was repaired. The contact associated the failure with NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the VIN was not included in the recall. The dealer and the manufacturer were notified of the failure, and a case was filed. The failure mileage was approximately 69,000.

• Aug 29, 2026TX
  Engine · Fuel/propulsion system · Power train
  In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from…

  In April 2026 (29,805 miles) I was on an interstate underpass U-turn and when I went to accelerate from the U-turn, the vehicle “revved”, had difficulty accelerating, and appeared to not go into the next gear for a roughly 10 seconds, meaning I was unable to accelerate and get out of the way from oncoming traffic. Traffic slowed and the vehicle suddenly returned to normal (no warning lights appeared) and I drove home cautiously with hazards on. When attempting to leave less than 45 minutes later, the vehicle started, then as I placed it into drive, it began lunging and the check engine light appeared. Because it was running rough and kept lunging, I parked and had it towed to the dealership. The DTC code listed was PO30300 (DTC system powertrain and subsystem EMS). Per the dealership, fuel injector #3 was bad and needed to be replaced. When I picked up the vehicle, notes stated “ GDI FUEL INJCTR REPL (ALL4)”. I picked up the vehicle after the repair. In August 2026 (30,923 miles), with less than 1,000 miles driven since repair, I started the vehicle and it immediately “died”. I restarted it and the check engine light came on and it began lunging out of my driveway. I also had difficulty getting the vehicle to brake and almost hit our community entrance/exit gate. A notification appeared on my infotainment system stating: “A possible condition with your Engine Control System has been detected. A full system check is recommended to be done soon. Please contact your local dealership to schedule an appointment”. The DTC codes listed on the Hyundai app were: PO30020, PO30040, PO30010, PO30000, and PO19185, P217700. (DTC system powertrain and subsystem EMS). I had the vehicle towed to the dealership. They didn’t have a loaner vehicle and I canceled my trip. Later, I was notified that “a hose was disconnected and was allowing air to enter the engine”. He stated, “we flushed it out and everything is working now”. I was told I could come pick it up before they closed.

• Aug 28, 2026MA108,565 mi
  Electrical system · Engine
  The contact owns a 2022 Hyundai Tucson. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with ECU software error. The contact was advised to contact the dealer. The dealer…

  The contact owns a 2022 Hyundai Tucson. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with ECU software error. The contact was advised to contact the dealer. The dealer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,565.

• Aug 28, 2026WA
  Engine

  Vehicle turned itself off with no warning while being driven @ 40 moh. Dealer suspects fuel injectors, but could be ignition coil.

• Aug 26, 2026TN
  Fuel/propulsion system

  Fuel injector went bad causing vehicle engine to misfire and shake rapidly. Check engine light is on. The vehicle only has 40,000 miles on it. Seems to be a very common concern for this make and model and roughly the same years. Will not accelerate instantly and will surge a bit when it does. Will still shake when the vehicle is idle.

• Aug 26, 2026TX
  Unknown or other
  On August 26, 2026, while driving to work, my 2022 Hyundai Tucson unexpectedly lost power and shut down while the vehicle was being driven. This created a serious safety concern because the vehicle became inoperable while in traffic. This vehicle has had a history of repeated problems and has been…

  On August 26, 2026, while driving to work, my 2022 Hyundai Tucson unexpectedly lost power and shut down while the vehicle was being driven. This created a serious safety concern because the vehicle became inoperable while in traffic. This vehicle has had a history of repeated problems and has been taken to Hyundai dealerships for repairs on numerous occasions. Despite these previous dealership visits and repair attempts, the vehicle continues to experience problems. The latest incident, in which the vehicle shut down while being driven, has significantly increased my concern regarding the safety and reliability of the vehicle. The vehicle is being made available for inspection and diagnosis. At this time, the exact component or cause of the failure is unknown. I am requesting that this complaint be documented because of the sudden loss of power while driving and the vehicle's history of repeated dealership visits and repairs. I am concerned that this condition could cause a crash if the vehicle unexpectedly loses power again while traveling in traffic or at highway speeds.

• Aug 24, 2026MACrash
  Electrical system · Forward collision avoidance › Automatic emergency braking · Service brakes
  My wife was driving my SUV while I was a passenger. We were in the left lane, and put the left turn signal on while traveling south bound approaching an intersection to take a left turn (traveling approximately 3-5 Miles Per Hour and slowing) at the traffic light (traffic light was green). There…

  My wife was driving my SUV while I was a passenger. We were in the left lane, and put the left turn signal on while traveling south bound approaching an intersection to take a left turn (traveling approximately 3-5 Miles Per Hour and slowing) at the traffic light (traffic light was green). There was a car in front of us that had stopped waiting for oncoming traffic to clear and make the same left turn onto the same road as us. While traveling in this lane we hit a deep pot hole (not very visible while driving), just as we were approaching the vehicle stopped in front of us. When hitting the pot hole, our SUV seemed to leap forward a bit and when the brakes were applied to slow and stop, the braking system failed (appeared to freeze) and the brakes did not work, and because the braking didn’t work, our vehicle hit the car in front of us. Prior to and after hitting the pothole, no audible warning sounds or visible alerts appeared and no emergency braking was activated. The airbags in our vehicle never deployed. Our safety (my wife and I) as well as the safety of the 2 passengers in the other vehicle were at risk as we all could have been injured in the accident. As we needed the vehicle for transportation, we immediately began filing all the necessary police and insurance reports and brought our vehicle into an Auto Body Repair Shop to be repaired the next day. During the repair work, some of the responsible components may or may not have been replaced and the Auto Body Repair Shop also had all the car sensors recalibrated by a 3rd party, which is why we did not bring the car to a dealership to evaluate. To the best of our knowledge, the manufacturer, the police and the insurance company did not inspect the vehicle. We are not experts, but hitting a pothole might be considered an edge case, so I’m not sure that a dealership would have tried or been able to replicate the issue.

• Aug 14, 2026TX3,212 mi
  Electrical system · Engine
  The contact owns a 2022 Hyundai Tucson. The contact stated that the check engine warning light illuminated and was cleared; however, the warning light returned hours or days later. The dealer had cleared the check engine warning light approximately 15-16 times. The vehicle occasionally stalled…

  The contact owns a 2022 Hyundai Tucson. The contact stated that the check engine warning light illuminated and was cleared; however, the warning light returned hours or days later. The dealer had cleared the check engine warning light approximately 15-16 times. The vehicle occasionally stalled while driving at various speeds. The dealer diagnosed the vehicle with terminal engine failure. The contact was informed that the fuel system needed to be overhauled, and the fuel injectors and caps needed to be replaced. The vehicle was repaired twice. The failure persisted after the contact had confirmed the diagnosis with a certified mechanic. The vehicle was returned to the dealer, who replaced the engine. The vehicle was parked for several hours, and the contact attempted to turn on the headlights, but the headlights failed to illuminate. While driving the vehicle, the vehicle hesitated several times. The following day, the vehicle failed to start approximately four times. The vehicle was driven to the dealer but hesitated several times along the way and failed to start once at the dealer. The dealer diagnosed the vehicle and determined that the battery and other parts needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure, and a complaint was filed. The failure mileage was 3,212.

• Aug 6, 2026MD
  Exterior lighting · Unknown or other
  While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes…

  While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes using the turn signal will temporarily turn them back on. The headlight mode also changes by itself while driving (AUTO to OFF to ON to OFF). Additionally, when the vehicle is turned off, the headlights often stay on no matter what mode the switch is in. I have to restart the vehicle and manipulate the turn signal/headlight stalk multiple times to get the lights to turn off. This is a recurring and dangerous failure that affects nighttime visibility and safety for me and my family. No other electrical issues are present. This is available for inspection. Safety for my family and all others on the road put at risk as the headlights randomly shut off at night. The problem was reproduced by the dealer. The dealer quoted a $1,500 repair, but this a safety‑critical defect in the lighting control system.

• Aug 5, 2026CA
  Service brakes

  Front brake rotors warped causing violent brake pedal pulsating and steering wheel vibration. My vehicle has only 18000 miles. The dealership Hyundai reported problem as a service bulletin TSB 23-BR-004H. I believe this a safety issue and a recall should be annouced.

• Aug 3, 2026AZ
  Fuel/propulsion system
  While driving the car stalled and then the engine shutdown, caused by a misfired fuel injector. Myself and the passengers in the car were minorly safe, as this incident occurred while driving through the Yellowstone National park; having to pull over on the side of the road with no shoulder. The…

  While driving the car stalled and then the engine shutdown, caused by a misfired fuel injector. Myself and the passengers in the car were minorly safe, as this incident occurred while driving through the Yellowstone National park; having to pull over on the side of the road with no shoulder. The Woody Smith Hyundai Dealership in Idaho Falls confirmed that the feul injectors had misfired, and then replaced them. Prior to the failure, there was no warning until the car was actively stalling and failing (battery light and check engine light came on).

• Aug 3, 2026GA25,800 mi
  Electrical system · Exterior lighting
  The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the…

  The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the headlight became operable when his wife was near to her destination. The vehicle was not diagnosed or repaired. Upon investigation, the contact discovered NHTSA Campaign Number: 21V938000 (Electrical System, Exterior Lighting); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 25,800.

• Aug 2, 2026PA
  Forward collision avoidance › Adaptive cruise control · Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings
  Unintentional and unexpected activation of emergency collision or adaptive cruise control, causing the vehicle to stop and become immobile in the lane of traffic. I was driving down the interstate with the adaptive cruse control on and the lane keeping assistance on. These both were on for about…

  Unintentional and unexpected activation of emergency collision or adaptive cruise control, causing the vehicle to stop and become immobile in the lane of traffic. I was driving down the interstate with the adaptive cruse control on and the lane keeping assistance on. These both were on for about 20 minutes as I was driving down the highway. There were no vehicles in front of or behind me for a quarter mile or so. I as all alone with nothing around me. All of a sudden it seemed like the collision avoidance system activated. The car came to a complete stop in the right lane of the highway. I tried to proceed and could see the emergency brake was on, the engine was running the car was in drive but it would not move. Flipped on the hazard flashers and traffic caught up to me while sitting in the right lane of the highway waiting to get rear ended. Vehicles were barely getting by at 70 MPH. The car would I pressed the accelerator and the car move d forward enough to get off the highway, this took a minute or two. Once off he highway, I could see the emergency brake would not release. I turned the engine off went out to inspect all the forward sensors. There was no visible issue. I restarted the car after a minute or so and it proceeded normally. That was Saturday, this is Sunday, I am taking the vehicle to Hundai tomorrow for inspection.

• Jul 29, 2026TX
  Electrical system · Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings
  On July 24, 2026, while driving on a marked city street with no vehicle, pedestrian, or obstruction ahead, the Forward Collision-Avoidance system on our 2022 Hyundai Tucson Limited AWD applied emergency braking on its own, three to four separate times, each lasting one to two seconds. Traffic…

  On July 24, 2026, while driving on a marked city street with no vehicle, pedestrian, or obstruction ahead, the Forward Collision-Avoidance system on our 2022 Hyundai Tucson Limited AWD applied emergency braking on its own, three to four separate times, each lasting one to two seconds. Traffic behind us nearly struck our vehicle. My family was in the car. This is the latest event in a progressive electrical fault history. In June 2025, under warranty at 48,037 miles, a Hyundai dealer documented recurring multi-system warning cascades (forward safety, lane keeping, high beam assist, speed limit warning) and a failed auto start/stop system. The dealer's listed resolution was "battery voltage / replace battery"; their invoice records that no repair was performed. We replaced the battery at our own expense. The faults continued. In June 2026, the start/stop system shut the engine off at a red light and the vehicle would not restart, leaving us disabled in a live traffic lane. Power was only restored by cycling the hood release. Since then, TCM and ECU software updates and a battery harness replacement (our expense, approx. $1,200) have been performed. The faults persisted after these repairs and have now escalated to uncommanded emergency braking. Date- and time-stamped video and photographs exist for multiple events. Two Hyundai dealerships have not identified a root cause. Similar phantom braking reports exist from other owners of this model year. We no longer consider the vehicle safe to drive.

Defect investigations

NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.

• Pedestrian alert sounds

  DP22005Opened Jan 27, 2023Closed Aug 7, 2023Recall 22V063000
  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

• Loss of Motive Power

  DP22003Opened Sep 12, 2022Closed Dec 12, 2023
  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles…

  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11012043This bulletin provides the procedure for updating the automatic transmission TCU (Transmission Control Unit) software to improve shift quality, judder and hesitation when accelerating.
• 11008008A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
• 11007485A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
• 11006112Certain 20-22MY Sonata (DN8a), 21-23MY Santa Fe (TMa), and 22-23MY Tucson (NX4a) vehicles may experience a warning lamp illumination for a diagnostic trouble code P2181 that is related to the Integrated Thermal Management Module (ITM). Follow the service procedure outlined in this bulletin to replace the ITM.
• 11006111Some vehicles equipped with the AVN 5th Gen Wide system may exhibit a condition where the radio app crashes frequently when entering radio mode and/or displays a message that reads Uneven Road Ahead, Drive carefully on the cluster along with a warning sound. Follow the procedure outlined in this bulletin to update the AVN software to resolve this condition.
• 11002708A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
• 11000788A class settlement against Hyundai Motor America (HMA) that had alleged that certain 2011 2022 model year Hyundai vehicles that were not equipped with an engine immobilizer (called the Class Vehicles) contain design flaws, including the failure to manufacture the Class Vehicles with an anti-theft device called an engine immobilizer, that make them susceptible to theft and damage. Class Vehicles manufactured without an engine immobilizer have traditional turn-key-to-start ignition systems.
• 10253275This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.
• 10251293This bulletin provides the procedure for updating the automatic transmission TCU and ECU software (Santa Fe ONLY) to improve shift quality, judder with ISG enabled and hesitation when accelerating.
• 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
• 10251282Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. Campaign 9A8 has also been released to provide a revised software update to certain 2018 model year Elantra vehicles. For certain vehicles that cannot be upgraded with the software under Campaign 993, Hyundai is offering customers an anti-theft ignition cylinder protector to be installed on their vehicle. This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock anti-theft solutions available from HMA through Hyundai dealerships.
• 10251275Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be upgraded with the software (Campaign 993), Hyundai is offering customers an anti-theft ignition cylinder protector to be installed on their vehicle. This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock anti-theft solutions available from HMA through Hyundai dealers.
• 10249707Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be upgraded with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers.
• 10249699Some vehicles equipped with the AVN 5th Gen Wide system may exhibit a condition where the radio app crashes frequently when entering radio mode and/or displays a message that reads Uneven Road Ahead, Drive carefully on the cluster along with a warning sound. Follow the procedure outlined in this bulletin to update the AVN software to resolve this condition.
• 10247611Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be upgraded with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers.
• 10247606This bulletin provides the procedure to update the Transmission Control Module (TCM) for the 2022MY Tucson (NX4/NX4a) vehicles and the Engine Control Module (ECM) for the 2022-24MY Tucson vehicles to improve operation of the Idle Stop and Go (ISG) system. Under certain circumstances the vehicle may not restart after ISG system has engaged and require a manual restart due to the lack of intake manifold pressure recovery.
• 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
• 10245580This TSB provides information to diagnose the push button shifter operation.
• 10245579Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.
• 10245578Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers.
• 10245577Certain Tucson (NX4A), Santa Cruz (NXT), Santa Fe (TMA), and Santa Fe Hybrid (TMA HEV) vehicles may exhibit a brake judder condition. This bulletin describes the procedure to inspect the brakes, resurface or replace and perform a brake burnishing procedure.
• 10244992Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers.
• 10243340This bulletin is issued to provide the extended battery diagnosis procedure using GDS-M. This battery diagnosis function displays the various battery-related faults such as: Internal short circuit Battery deterioration Malfunction of electronic parts Insufficient battery charge Normal battery Charging defect Battery diagnosis uses the battery sensor history saved for the last 30 days and ICU diagnostic communication to track battery state of charge (SOC) and current parasitic draw history.
• 10243329If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. DIAGNOSTIC TROUBLE CODES: P070500 - Transmission range sensor circuit malfunction P070512 - Transmission range sensor circuit malfunction P070514 - Transmission range sensor circuit malfunction P07051C - Transmission range sensor circuit malfunction P070600 - Transmission range sensor circuit range/performance P070661 - Transmission range sensor circuit range/performance P070696 - Transmission range sensor circuit range/performance SYMPTOMS: Malfunction Indicator Light (MIL) illuminated 5th gear fail-safe Intermittently wont shift into D or R Intermittently wont shift out of Park Intermittent ly no engine cr ank/n o start in P or N with or without MIL or DTC.
• 10241887The Shift-By-Wire (SBW) buttons have been made available as separate service parts for the SBW lever. If replacement of the SBW button is required due to one or more button plating peeling, replace the button(s) with a new one. Do not replace the complete SBW lever.
• 10241885If you are servicing an 8-speed vehicle with a Check Engine light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.
• 10241874Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers.
• 10241849Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. This bulletin provides the procedure to update the remote start module to eliminate the horn honking during remote start operation.
• 10241796This TSB provides information to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms listed below or DTCs (listed on Page 2) , follow the Service Procedure on Page 3. SYMPTOMS: Shifter System Malfunction displayed in the cluster Wont shift into or out of gear or wont shift out of Park Incorrect gear display in cluster and/or wont start
• 10240084If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition.
• 10240081Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32).
• 10240080Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.
• 10238377This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain 21-23MY Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to internally leaking GDI injector(s)
• 10238353Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.
• 10237189Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.
• 10237180This bulletin provides repair information for a non-glossy front door pull handle that exhibits paint peeling on certain 2022 2023MY Tucson (NX4A) and Santa Cruz (NXT) vehicles. If a vehicle exhibits this paint peeling condition, replace the front door trim panel assembly.
• 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
• 10235556Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.
• 10235555Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2021, engine immobilizers became standard on all Hyundai vehicles produced.
• 10235341Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and installation of two anti-theft decals for the front windows.

Every Hyundai Tucson model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.