2023 Hyundai Tucson
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Hyundai › Tucson › 2023
These records cover every 2023 Hyundai Tucson. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
2 recalls name the 2023 Hyundai Tucson. Newest first.
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Risk and remedy
Risk
Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will remove the trailer wiring harness and install a dust cap over the wiring receptacle, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 290. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 20, 2025.
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.
Risk and remedy
Risk
An electric oil pump assembly that overheats increases the risk of a vehicle fire.
Remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect and replace the electric oil pump controller, as necessary, free of charge. Owner notification letters were mailed starting September 7, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 246.
Owner complaints
136 complaints12 involved a crash1 involved a fire5 injuries
What owners report most
Latest complaints
- Electrical system · Steering · Structure › Body
SAFETY DEFECT SUPPLEMENT TO NHTSA COMPLAINT #11685540 | VIN: [XXX] | MILEAGE: 27,370 This filing supplements Complaint #XXX regarding an uncorrected, compounded steering safety failure following the catastrophic detachment of the steering column while driving on XXX (Repair Order #XXX).…
SAFETY DEFECT SUPPLEMENT TO NHTSA COMPLAINT #11685540 | VIN: [XXX] | MILEAGE: 27,370 This filing supplements Complaint #XXX regarding an uncorrected, compounded steering safety failure following the catastrophic detachment of the steering column while driving on XXX (Repair Order #XXX). COMPONENTS FAILED: Steering column assembly, footwell closeout shield, dashboard lower crash pad structural frame, and push-start switch. All components and vehicle are available for immediate inspection. SAFETY RISK: Following an invasive warranty teardown for an ignition switch failure under R/O #XXX at [XXX] Hyundai, the vehicle was released in an incomplete, hazardous condition. The factory lower footwell closeout shield was completely omitted, leaving the rotating intermediate steering shaft, universal joint, electric power steering motor, brake clevis linkage, and wiring harness fully exposed directly above driver foot controls. This creates a severe entrapment and mechanical binding hazard. An unauthorized exterior screw was drilled directly through the finished lower crash pad trim to pinch broken internal plastic tabs together, and hardware was left rattling inside the column housing. DEALER CONFIRMATION & RECORD FALSIFICATION: Management dismissed the exposed shaft. On R/O #XXX Line 3, the dealership falsified the narrative as "customer needs screws put in behind steering wheel" under an engine line to conceal shop rework. Authorized remedy has completely failed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Unknown or other
Horn in vehicle stopped working it’s been 3 weeks and dealer can’t get parts. I feel it’s unsafe driving without ihaving access no horn especially around school.
- Fuel/propulsion system
2023 Hyundai Tucson Limited, 2.5L GDI, Alabama-built (VIN 5NMXXXXXXXXXXXXXX), built [XXX]. On [XXX], at about 37,550 miles, the check engine light came on flashing and the engine ran rough while I was traveling in Canada. My scan tool showed P0300, P0302 and P0304 (misfires on cylinders 2 and 4).…
2023 Hyundai Tucson Limited, 2.5L GDI, Alabama-built (VIN 5NMXXXXXXXXXXXXXX), built [XXX]. On [XXX], at about 37,550 miles, the check engine light came on flashing and the engine ran rough while I was traveling in Canada. My scan tool showed P0300, P0302 and P0304 (misfires on cylinders 2 and 4). On July 6, 2026, Experience Hyundai in Charlottetown, PE (service order 92XXX) replaced one ignition coil under warranty. No fuel injector leak test was performed. The misfires returned. On [XXX], at 39,409 miles, my scan showed P0302 active and P0304 pending. The car also had extended cranking after sitting and the check engine light was on. I was told I could keep driving the car unless it started to jerk or engine light started to flash, then immediately stop driving it and have it towed. On September 25, 2026, the car was towed to McGovern Hyundai Route 2, Leominster, MA (invoice 148XXX). The dealer found all 4 fuel injectors leaking and replaced them under warranty with injector service kit 35399-2S133QQH. My vehicle is outside the production range of Hyundai TSBs 23-FL-002H-1 and 26-FL-001H, which cover this injector failure only for Alabama-built Tucsons produced through July 11, 2022. Yet it failed in the same way. I am concerned the defect extends beyond the bulletin dates and that a sudden misfire could cause loss of power in traffic. There is no recall for this condition. The dealer found all 4 fuel injectors leaking, even though only cylinders 2 and 4 had set misfire codes and replaced them under warranty with injector service kit 35399-2S133QQH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Trailer hitches
See attached document for complaint.
- Fuel/propulsion system
The car was working perfectly fine I drive it for work all the time and one day it started shaking weirdly. A couple days later the check engine light turned on. It was throwing the code that was pointing to "misfiring in the 3rd cylinder" We changed all the spark plugs, 3rd cylinder coil pack, and…
The car was working perfectly fine I drive it for work all the time and one day it started shaking weirdly. A couple days later the check engine light turned on. It was throwing the code that was pointing to "misfiring in the 3rd cylinder" We changed all the spark plugs, 3rd cylinder coil pack, and switch the coil pack to see if it would say a misfiring in a different cylinder. We then took it to a mechanic saying that it is the high pressure fuel injectors and that he has seen this problem with other Hyundai Tucson around the same year as us and that there was a bulletin on it.
- Suspension
The right rear shock absorber failed and was replaced under warranty at approximately 22,000 miles. The car was making noise, the shock was leaking, and not working properly. The dealer admitted to problems with rear shock absorbers failing at low mileage on Hyundai Tucson Hybrid SUVs 2022 through…
The right rear shock absorber failed and was replaced under warranty at approximately 22,000 miles. The car was making noise, the shock was leaking, and not working properly. The dealer admitted to problems with rear shock absorbers failing at low mileage on Hyundai Tucson Hybrid SUVs 2022 through 2025 Tucson Hybrids. The left and right rear shock absorbers are the same part number so we now expect the left side to fail but the dealer will not replace the left until it fails.
- Electrical system
Under Hyundai Recall 290, the dealership permanently removed the functional trailer light wiring harness and replaced it with a nonfunctional rubber dust cap. A Hyundai case manager informed me that a replacement harness is "in development," but official NHTSA remedy filings show the cap is the…
Under Hyundai Recall 290, the dealership permanently removed the functional trailer light wiring harness and replaced it with a nonfunctional rubber dust cap. A Hyundai case manager informed me that a replacement harness is "in development," but official NHTSA remedy filings show the cap is the final remedy, resulting in the permanent loss of a factory feature I paid for. The removal of towing functionality without a clear timeline for a safe replacement parts remedy constitutes a failure to properly correct the vehicle defect.
- Forward collision avoidance › Automatic emergency braking
Emergency Brake applied while driving. Had been driving with vehicle in front, on each side and one at rear with issues and all of sudden the emergency brake was applied causing the vehicle in back to get very close to my car. This is has happened multiple times and reported to dealership multiple times. This was the second occurence on this day.
- Forward collision avoidance › Automatic emergency braking
While backing out of driveway, with parked vehicle along side and one moving vehicle in the road, I was applying the break and the Emergency Stop feature activated. My speed was 2-3 MPH and slowing.
- Air bags · Unknown or other
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal…
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.
- Fuel system, gasoline
The contact owns a 2023 Hyundai Tucson. The contact stated that the fuel filler door failed to open as needed. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 76,000.
- Electrical system · Engine · Unknown or other
The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000…
The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check engine light) also appeared during the incident. The warning light later turned off, but the engine surging continued. This unexpected increase in engine speed raises concerns about unintended vehicle movement or loss of driver control if the condition were to occur while shifting into gear or while driving. The unpredictable nature of the malfunction presents a potential safety risk to the occupants of the vehicle and to others on the road. The vehicle has been taken to an authorized Hyundai dealership for diagnosis and repair and remains under inspection. The problem is available for inspection. During my research, I found numerous reports from other Hyundai owners describing similar engine surging, idle fluctuation, and Auto Start/Stop malfunctions involving comparable vehicles. Because similar complaints appear to have been reported by multiple owners, I am submitting this report so the issue can be evaluated for a possible broader safety defect. I have videos of the incident
- Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings
2023 Hyundai Tuscon XRT has a dangerous and alarming issue. The Emergency Braking engages at highway speeds where no risk is present. The car groans and pulls dangerously. In addition, the Forward Collision Warning engages on surface streets every 10-15 seconds and there are no risks present. The…
2023 Hyundai Tuscon XRT has a dangerous and alarming issue. The Emergency Braking engages at highway speeds where no risk is present. The car groans and pulls dangerously. In addition, the Forward Collision Warning engages on surface streets every 10-15 seconds and there are no risks present. The emergency braking issue has occurred on several occasions. The Forward Collision Warning issue occurs every time the car is driven.
- Engine · Fuel/propulsion system · Vehicle speed control
I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.
- Electrical system · Power train
The contact's son owns a 2023 Hyundai Tucson. The contact stated that while driving at various speeds, various warning lights illuminated, and various messages were displayed on the instrument panel; however, the warning lights disappeared upon restarting the engine. The contact stated that her son…
The contact's son owns a 2023 Hyundai Tucson. The contact stated that while driving at various speeds, various warning lights illuminated, and various messages were displayed on the instrument panel; however, the warning lights disappeared upon restarting the engine. The contact stated that her son was forced to restart the vehicle after the vehicle failed to accelerate from a complete stop on one occasion. The vehicle was taken to the dealer for diagnosis; however, the dealer was unable to diagnose or duplicate the failure. The contact was informed that the vehicle could not be diagnosed unless the warning lights were illuminated. The manufacturer was notified of the failure, and a case was filed. The contact later received a letter from the manufacturer confirming the dealer's information. The vehicle had yet to be repaired. The failure mileage was 21,000.
- Visibility › Sun/moon roof assembly
The contact owns a 2023 Hyundai Tucson. The contact stated that the panoramic sunroof exploded while driving at approximately 40-50 MPH. The rear section of the sunroof glass had shattered into several pieces without impact. The contact closed the shade, and the glass fell inward. There was glass…
The contact owns a 2023 Hyundai Tucson. The contact stated that the panoramic sunroof exploded while driving at approximately 40-50 MPH. The rear section of the sunroof glass had shattered into several pieces without impact. The contact closed the shade, and the glass fell inward. There was glass inside the shade and the roof. There were no injuries. There was an abnormally loud sound like a handgun or several balloons popping. The vehicle was previously inspected, and there were no issues found with the sunroof. The vehicle was taken to the local dealer, and the dealer stated that a rock might have caused the failure. The vehicle was not repaired. The dealer referred the contact to the insurance company for assistance. The manufacturer was contacted, and an appointment was scheduled with the local dealer. Additionally, the manufacturer provided a loaner vehicle. The failure mileage was approximately 24,038.
- Electrical system
I received a letter in March that there is a problem with The Tow Hitch Harness Accessory which could lead to a fire etc. They said they will come out with a repair. I contacted the Victory Hyundai dealership in Jefferson Ohio where I got the car in April and they said they have a repair but the…
I received a letter in March that there is a problem with The Tow Hitch Harness Accessory which could lead to a fire etc. They said they will come out with a repair. I contacted the Victory Hyundai dealership in Jefferson Ohio where I got the car in April and they said they have a repair but the trailer electrical/ lights will not work. I got a second letter saying they have a solution for repair in May I contacted Classic Hyundai twice to make sure the repair now will allow the lights and brakes on the trailer work. Julie and Jesica there said all would be fixed and the lights and break lights will work. I brought the car there June 5th 2026 and asked again if all would work. Lyna there said no. I left. I called U-hall Streetsboro Ohio and talked to Bill who handles the hitch repairs and they said they could fix totally and have for some dealerships. I called Hyundai customer service Kyre and asked if Hyundai in Streetsboro Ohio can be set up to have it repaired. He said no. He would not document his response to me. I bought this car with their factory installed hitch because I needed one to pull my boat and move other stuff. My lawn tractor broke down and I have to pay $135 to have it towed for repair. I am unable to fish in my boat since I can not pull it. There is a repair that will work at U-haul and they are ignoring it.They want to make the hitch unusable. Uhaul will fix for $250-$350. If they disconnect the hitch electrical and the car is sold the new owner can get into an accident since they would have no lights and break lights, turn signal. This is a high risk for an accident. They intend to eliminate the fire risk and create an accident risk for the trailer now not working. What kind of engineers they have?? They should be contacted about this situation. It has been several months with no solution when one exists. I have had multiple Hyundais and will no longer purchase another vehicle from them. You should communicate with them on this issue.
- Service brakes
While driving on a highway shortly after taking delivery of this vehicle as a Certified Pre-Owned purchase from an authorized Hyundai dealership, I experienced sudden and total brake failure. The Electronic Parking Brake (EPB) warning light illuminated and an audible warning chime sounded. The…
While driving on a highway shortly after taking delivery of this vehicle as a Certified Pre-Owned purchase from an authorized Hyundai dealership, I experienced sudden and total brake failure. The Electronic Parking Brake (EPB) warning light illuminated and an audible warning chime sounded. The brake pedal did not respond normally. I was unable to slow the vehicle with the brakes and was forced to make an emergency maneuver to exit the highway and come to a safe stop. Upon inspecting the vehicle after stopping, I discovered that the rear left brake caliper had completely detached from its mounting bracket. The caliper was on the ground beneath the rear of the vehicle. Brake fluid had leaked onto the road surface. The vehicle had been in my possession for less than one full drive since purchase. As part of the CPO certification, the selling dealer performed a multi-point inspection and documented installation of new brake pads and certified the brake system as in good working order. The detachment of the caliper is consistent with mounting bolts that were either not reinstalled or not properly torqued following the dealer's brake service during CPO preparation. I have photographic evidence of the detached caliper and brake fluid loss. INJURIES: None, but significant risk to myself and other highway drivers. FIRES: No. MEDICAL ATTENTION: Not required. CONTACT WITH DEALER/MANUFACTURER: Yes — Hyundai corporate complaint filed. I am requesting this complaint be investigated as a potential safety defect related to brake service practices during Hyundai CPO vehicle preparation.
- Electrical system · Unknown or other
Horn on vehicle consistently goes out. Either goes out entirely or the volume of the horn is below a safe level. This is a known Hyundai issue and Hyundai refuses to acknowledge it on this specific model, but has acknowledged it on different models. I Have had multiple repairs by Hyundai directly…
Horn on vehicle consistently goes out. Either goes out entirely or the volume of the horn is below a safe level. This is a known Hyundai issue and Hyundai refuses to acknowledge it on this specific model, but has acknowledged it on different models. I Have had multiple repairs by Hyundai directly, and the horn consistently keeps going out. There are sometimes in dangerous situations where I need to utilize the horn to avoid an accident and warn other drivers of danger, and I am unable to do so, and it causes dangerous driving situations. This is a known defect on multiple Hyundai vehicles in this year, but the Tucson is one of the few vehicles they will not call a voluntary recall on and NHTSA needs to be notified about this and act accordingly as a regulatory body to protect consumers and people on the road.
- Electrical system
I received a Recall notice around January 2026 for the trailer hitch wiring harness on my 2023 Hyundai Tucson Hybrid. For 6 months the local dealer told me there was no fix available from Hyundai. I finally received a notice informing me that parts were now available and to bring it in to dealer…
I received a Recall notice around January 2026 for the trailer hitch wiring harness on my 2023 Hyundai Tucson Hybrid. For 6 months the local dealer told me there was no fix available from Hyundai. I finally received a notice informing me that parts were now available and to bring it in to dealer for repairs. I took the vehicle in for recall repairs on May 27, 2026. Instead of repairing/replacing the wiring harness, Hyundai removed the entire wiring harness making the trailer hitch which I use for my business inoperable legally. When I noticed the wiring harness missing several days later, the dealer said that was Hyundai's "fix" for the recall issue. I contacted Hyundai USA Customer Service who also told me that removing the wiring harness and replacing it with an inexpensive dust cover was the fix. They told me that sometime in the future there will be another recall to have the wiring harness replaced. In the meantime, they have taken my vehicle VIN off the open recall list, since it has been "fixed". Hyundai sold me a vehicle with a trailer hitch and now they have without my permission or prior knowledge disabled it.
- Structure › Body · Unknown or other · Visibility/wiper
I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.
- Forward collision avoidance › Automatic emergency braking · Forward collision avoidance › Warnings · Steering
I am writing regarding a serious vehicle safety issue involving my 2023 Hyundai Tucson Limited purchased from on [XXX] with approximately 61,000 miles. About one month after purchase, during a drive from Pennsylvania to Florida in October 2025, the vehicle experienced multiple dangerous steering…
I am writing regarding a serious vehicle safety issue involving my 2023 Hyundai Tucson Limited purchased from on [XXX] with approximately 61,000 miles. About one month after purchase, during a drive from Pennsylvania to Florida in October 2025, the vehicle experienced multiple dangerous steering and collision-assist malfunctions in clear highway conditions. The first incident occurred in Virginia while adaptive cruise control and steering assist were active at approximately 70 mph. Within seconds, the steering wheel aggressively turned left and right, causing the vehicle to tip and nearly roll until the driver manually regained control. Later during the same trip, while making a normal lane change with the right turn signal activated, the vehicle falsely detected a collision despite no vehicle being present. The vehicle then veered left toward traffic and unexpectedly slammed on the brakes. Following these incidents, all assist sensors and automated driving features were manually disabled for safety reasons. However, the vehicle has continued intermittently triggering false collision warnings and emergency braking events with no vehicles present, creating additional near-accident situations involving surrounding traffic. I recently had the vehicle inspected by Hyundai after initially believing this may only be a calibration issue. Due to financial and scheduling limitations, I delayed service until this month, but I now understand this issue is far more serious and systemic. Two separate mechanics have advised me the vehicle has major safety-system malfunctions making it unsafe to drive. There are no reported accidents or braking issues on Carfax. I am also concerned this appears to be a widespread issue affecting this vehicle model, yet I received no notification regarding related safety concerns or recalls until conducting my own research. One mechanic stated“I’m surprised this car hasn’t killed you yet. I wouldn’t put my own kids in this vehicle." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
- Unknown or other
The reverse beeping is just too loud for an Hybrid and many people online agree. I fully agree with having mandates for electric vehicles for safety concerns however they should not be so loud that they are louder or near as loud as a commercial truck and disturb residents. In fact Hyundai…
The reverse beeping is just too loud for an Hybrid and many people online agree. I fully agree with having mandates for electric vehicles for safety concerns however they should not be so loud that they are louder or near as loud as a commercial truck and disturb residents. In fact Hyundai responded to the complaints by re-designing it for 2025 and newer facelifts but won't give any services to upgrade it to newer versions. I fully believe that Hyundai should and must offer services to use the new updated VESS.
- Engine
The car has 57,000miles and needed a new transmission. Safety concern of the transmission failing while driving. There was a persistent and worsening rubbing noise once the car ran for 20 minutes or so. 4 visits to the dealer later, they confirmed the issue and Hyundai issued a warranty to replace…
The car has 57,000miles and needed a new transmission. Safety concern of the transmission failing while driving. There was a persistent and worsening rubbing noise once the car ran for 20 minutes or so. 4 visits to the dealer later, they confirmed the issue and Hyundai issued a warranty to replace the transmission with a remanufactured transmission. When I asked the dealer what happened, he said this was there 4th one in a few weeks. There were no indicator lights or anything besides the noise to indicate there was a problem.
- Forward collision avoidance › Automatic emergency braking
The automatic emergency braking system has activated on four separate occasions for unknown reasons or warning. Tapped the brakes and it disengaged. In three of the situations no vehicles or pedestrians nearby. One incident I was driving along a sidewalk when the braking system activated causing an abrupt stop
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11008008A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 11007485A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 11006112Certain 20-22MY Sonata (DN8a), 21-23MY Santa Fe (TMa), and 22-23MY Tucson (NX4a) vehicles may experience a warning lamp illumination for a diagnostic trouble code P2181 that is related to the Integrated Thermal Management Module (ITM). Follow the service procedure outlined in this bulletin to replace the ITM.
- 11006111Some vehicles equipped with the AVN 5th Gen Wide system may exhibit a condition where the radio app crashes frequently when entering radio mode and/or displays a message that reads Uneven Road Ahead, Drive carefully on the cluster along with a warning sound. Follow the procedure outlined in this bulletin to update the AVN software to resolve this condition.
- 11002708A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system.
- 10253275This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.
- 10253273Certain 2023-2024MY Tucson (NX4a) vehicles may exhibit delamination of the C-pillar garnish. Follow the procedure in this TSB to replace the C-pillar garnishes for vehicles exhibiting this condition.
- 10251285This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.
- 10251278Some vehicles equipped with the AVN 5th Gen Wide system may exhibit a condition where the radio app crashes frequently when entering radio mode and/or a message that reads Uneven Road Ahead, Drive carefully on the cluster along with a warning sound. Follow the procedure outlined in this bulletin to update the AVN software to resolve this condition.
- 10249699Some vehicles equipped with the AVN 5th Gen Wide system may exhibit a condition where the radio app crashes frequently when entering radio mode and/or displays a message that reads Uneven Road Ahead, Drive carefully on the cluster along with a warning sound. Follow the procedure outlined in this bulletin to update the AVN software to resolve this condition.
- 10247606This bulletin provides the procedure to update the Transmission Control Module (TCM) for the 2022MY Tucson (NX4/NX4a) vehicles and the Engine Control Module (ECM) for the 2022-24MY Tucson vehicles to improve operation of the Idle Stop and Go (ISG) system. Under certain circumstances the vehicle may not restart after ISG system has engaged and require a manual restart due to the lack of intake manifold pressure recovery.
- 10247189This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.
- 10245580This TSB provides information to diagnose the push button shifter operation.
- 10245577Certain Tucson (NX4A), Santa Cruz (NXT), Santa Fe (TMA), and Santa Fe Hybrid (TMA HEV) vehicles may exhibit a brake judder condition. This bulletin describes the procedure to inspect the brakes, resurface or replace and perform a brake burnishing procedure.
- 10243371This TSB applies to certain vehicles with 8-speed transmissions that may have had a machining operation out of specification that could lead to a higher mileage durability issue regarding the transmission oil pump. Follow the steps listed below to inspect the transmission. Replace the transmission if needed.
- 10243340This bulletin is issued to provide the extended battery diagnosis procedure using GDS-M. This battery diagnosis function displays the various battery-related faults such as: Internal short circuit Battery deterioration Malfunction of electronic parts Insufficient battery charge Normal battery Charging defect Battery diagnosis uses the battery sensor history saved for the last 30 days and ICU diagnostic communication to track battery state of charge (SOC) and current parasitic draw history.
- 10243329If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. DIAGNOSTIC TROUBLE CODES: P070500 - Transmission range sensor circuit malfunction P070512 - Transmission range sensor circuit malfunction P070514 - Transmission range sensor circuit malfunction P07051C - Transmission range sensor circuit malfunction P070600 - Transmission range sensor circuit range/performance P070661 - Transmission range sensor circuit range/performance P070696 - Transmission range sensor circuit range/performance SYMPTOMS: Malfunction Indicator Light (MIL) illuminated 5th gear fail-safe Intermittently wont shift into D or R Intermittently wont shift out of Park Intermittent ly no engine cr ank/n o start in P or N with or without MIL or DTC.
- 10241887The Shift-By-Wire (SBW) buttons have been made available as separate service parts for the SBW lever. If replacement of the SBW button is required due to one or more button plating peeling, replace the button(s) with a new one. Do not replace the complete SBW lever.
- 10241885If you are servicing an 8-speed vehicle with a Check Engine light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.
- 10241796This TSB provides information to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms listed below or DTCs (listed on Page 2) , follow the Service Procedure on Page 3. SYMPTOMS: Shifter System Malfunction displayed in the cluster Wont shift into or out of gear or wont shift out of Park Incorrect gear display in cluster and/or wont start
- 10240084If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition.
- 10238377This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain 21-23MY Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to internally leaking GDI injector(s)
- 10237180This bulletin provides repair information for a non-glossy front door pull handle that exhibits paint peeling on certain 2022 2023MY Tucson (NX4A) and Santa Cruz (NXT) vehicles. If a vehicle exhibits this paint peeling condition, replace the front door trim panel assembly.
- 10235566Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.
- 10235340If you are servicing an 8-speed vehicle with a Check Engine light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.
- 10233552This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain MY21-23 Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to internally leaking GDI injector(s).
- 10233551Some 23MY Tucson and Santa Cruz vehicles' sunroofs were not programmed at the factory. This causes the sunroof to become inoperable. This bulletin provides information to program sunroof operation.
- 10233539This bulletin provides information related to the Engine Control Module (ECM) / Hybrid Control Unit (HCU) software update for Tucson Hybrid (NX4 HEV) / Plug-in Hybrid (NX4 PHEV) vehicles to improve the following DTC and symptoms:
- 10233484This bulletin outlines the repair procedure for some 22MY and 23MY Tucson and Santa Cruz vehicles that exhibit symptoms of no audio or intermittent sound from the vehicle's speakers.
- 10232182This bulletin outlines the process for replacing the external amplifier on certain 22MY and 23MY Tucson and Santa Cruz vehicles equipped with an external amplifier.
- 10230904This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.
Every Hyundai Tucson model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.