2015 KIA Sportage

Recalls

2 recalls name the 2015 KIA Sportage. Newest first.

• Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module

  Feb 2, 2022NHTSA 22V051000126,747 vehicles

  Kia Motors America (Kia) is recalling certain 2016-2018 K900 and 2014-2016 Sportage vehicles. The Hydraulic Electronic Control Unit (HECU) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

  Risk and remedy

  Risk

  An engine compartment fire while parked or driving can increase the risk of injury.

  Remedy

  Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse for the HECU circuit board, free of charge. Owner notification letters were mailed September 22, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC227.

  Full recall details →

• Engine

  Dec 19, 2018NHTSA 18V90700071,653 vehicles

  Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been…

  Risk and remedy

  Risk

  A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy

  Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

  Full recall details →

Owner complaints

What owners report most

1. Engine84
2. Service brakes, hydraulic28
3. Unknown or other25
4. Electrical system18
5. Fuel/propulsion system7
6. Power train6
7. Air bags5
8. Vehicle speed control5
9. Steering3
10. Exterior lighting3

Latest complaints

• Jul 7, 2026IN
  Electrical system · Steering
  I own a 2015 Kia Sportage VIN in detail. On 7-2-2026, an authorized Kia dealer completed the anti-theft ignition campaign. Within days of that repair, my daughter was driving at highway speed when the ignition moved from the ON/RUN position to ACC. The engine shut off, resulting in loss of power…

  I own a 2015 Kia Sportage VIN in detail. On 7-2-2026, an authorized Kia dealer completed the anti-theft ignition campaign. Within days of that repair, my daughter was driving at highway speed when the ignition moved from the ON/RUN position to ACC. The engine shut off, resulting in loss of power steering and brake assist. Fortunately, she was able to safely pull over. The servicing dealer has stated that the ignition's ability to rotate from RUN to ACC with minimal pressure is normal and that the vehicle is safe. However, because this incident occurred immediately following the anti-theft campaign and involved a loss of engine power while driving it appears there could be a casual impact.

• Jun 13, 2026FLFire
  Engine

  Engine fire which led to explosion and total loss.

• Apr 23, 2026NC
  Engine · Power train
  Unjustified Denial of Engine Warranty Coverage - 2015 Kia Sportage "I am filing this complaint because Kia is denying warranty coverage for a known engine defect (rod bearing failure in the Theta II GDI engine) on my 2015 Kia Sportage. The manufacturer’s denial is based on the claim that I did not…

  Unjustified Denial of Engine Warranty Coverage - 2015 Kia Sportage "I am filing this complaint because Kia is denying warranty coverage for a known engine defect (rod bearing failure in the Theta II GDI engine) on my 2015 Kia Sportage. The manufacturer’s denial is based on the claim that I did not perform the KSDS (Knock Sensor Detection System) software update in previous years. However, I have officially performed this update at an authorized Kia dealership (Hendrick Kia of Cary) on April 17, 2026. Despite my vehicle now fully complying with the recall requirements, Kia continues to deny the warranty claim by retroactively applying a 'missed update' penalty. This is a clear attempt to evade their obligations under the class-action settlement regarding this engine defect. The manufacturer is holding the current owner responsible for maintenance history they cannot control, even though the vehicle is now technically compliant. I request that the NHTSA investigate this practice, as it prevents consumers from accessing the safety-related warranty protections they are entitled to." Tips for your submission:

• Jun 3, 2025TX
  Engine
  I own a 2015 Kia Sportage with an open safety recall (NHTSA Recall No. 22V051 / SC227B). The vehicle became undriveable years ago due to engine issues. I contacted both the dealership and Kia several times, but no one has responded or completed the recall. I received no notification letter. The…

  I own a 2015 Kia Sportage with an open safety recall (NHTSA Recall No. 22V051 / SC227B). The vehicle became undriveable years ago due to engine issues. I contacted both the dealership and Kia several times, but no one has responded or completed the recall. I received no notification letter. The vehicle has sat inoperable for years, and I had to stop payments because the engine failed and posed a safety risk. I am requesting NHTSA intervention as Kia has failed to complete the safety recall in a timely manner.

• May 16, 2025TN
  Electrical system · Engine

  The car just quit running as I was driving. It would not turn over using jumper cables. I had it towed to a local mechanic where they replaced the starter and the battery. Upon picking it up, it was making noises that it did not make previously.

• May 12, 2025OH
  Engine · Unknown or other

  Oil has been leaking for years. Always got regular oil changes and engine died while driving.

• Feb 14, 2025NC134,644 mi
  Electrical system · Engine · Service brakes, hydraulic
  The contact owns a 2015 Kia Sportage. The contact received notification of NHTSA Campaign Number 22V051000 (Service Brake, Hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.…

  The contact owns a 2015 Kia Sportage. The contact received notification of NHTSA Campaign Number 22V051000 (Service Brake, Hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer however, the part for the recall repair was not yet available. The dealer stated that an appointment would be scheduled; however, the contact had not yet heard back from the dealer. The contact stated that while driving 40 MPH, the low battery warning light illuminated, and the vehicle started to decelerate. The contact coasted over to the side of the road and had the vehicle towed to the residence. The dealer was contacted, and the contact was informed that the recall repair could not be completed because the mileage on the vehicle had been exceeded. The manufacturer was made aware of the issue and confirmed that an engine replacement recommended by the dealer was not covered under warranty. The failure mileage was 134,644. Parts distribution disconnect.

• Jan 11, 2025NY
  Engine
  We were driving down the highway and without any kind of warning the car lost all power I had to move to the shoulder of the road and wait over 5 hrs for a tow truck and then get a hotel room for the night before we could get a rental car the next morning once they opened. Then, a couple weeks…

  We were driving down the highway and without any kind of warning the car lost all power I had to move to the shoulder of the road and wait over 5 hrs for a tow truck and then get a hotel room for the night before we could get a rental car the next morning once they opened. Then, a couple weeks later we had to have the vehicle towed back home to NY since we broke down on [XXX] in PA. Then we had to have it towed to a repair shop and they told me it was rod iron knocking and was covered under the Theta II class action lawsuit according to the website when the vin# was inputted to the website. And Kia is saying it's not covered because of a recall that wasn't completed but being I never received the notification as I wasn't the 1st or 2nd owner of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• Oct 15, 2024NY
  Structure › Body
  Hood latch seccondary safety latch did not catch hood and hood flew up causing inability to see and luckily only damage the car itself. This is a dangerous problem with Kia and should be investigated for the safety catch becoming corroded and sticky. Its design is defective and it should be…

  Hood latch seccondary safety latch did not catch hood and hood flew up causing inability to see and luckily only damage the car itself. This is a dangerous problem with Kia and should be investigated for the safety catch becoming corroded and sticky. Its design is defective and it should be recalled and reworked so that it can not become corroded and sieze preventing safe operation in the event the primary latch comes unclipped while driving down the road at speed if a person were to accidentally pull the hood release in motion or it it were so fail to hold adequately.

• Aug 2, 2024WA91,000 mi
  Engine
  The contact owns a 2015 Kia Sportage. The contact stated while her son was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was…

  The contact owns a 2015 Kia Sportage. The contact stated while her son was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that the engine had seized, resulting in damages to the engine. The vehicle was not repaired. The vehicle was taken to the dealer, who confirmed the diagnosis. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 91,000.

• Jun 21, 2024TN
  Electrical system · Engine

  I was driving my car and it stalled out and stopped and never cranked back up so I had it pulled in and my mechanic said it was a burnt starter and motor locked up

• May 27, 2024CA
  Fuel/propulsion system · Unknown or other

  Emission system failure causing check engine light to turn on.

• May 10, 2024FL
  Engine
  I purchased the vehicle in February 9, 2024. A week after I purchased it the engine started making a knocking noise. I took the Sportage to Kia of Orange Park as I saw some there were some recalls on the vehicle. I paid to have a full diagnostic done. The gentleman that assisted me reached out to…

  I purchased the vehicle in February 9, 2024. A week after I purchased it the engine started making a knocking noise. I took the Sportage to Kia of Orange Park as I saw some there were some recalls on the vehicle. I paid to have a full diagnostic done. The gentleman that assisted me reached out to the Kia Corporation to see if they would repair the engine. Kia refused stating that the recall PI1802A - PI1802 (ECU Logic Upgrade KSDA 14- 15 MY) had not been done. This recall was out on the car prior to my ownership so there is no way for me to have it done when it came out.

• Apr 29, 2024MN90,000 mi
  Engine
  The contact owns a 2015 Kia Sportage. The contact stated that while driving at approximately 55 MPH, there was a loud clanking sound coming from the engine compartment. There was no warning light illuminated. An independent mechanic was contacted and diagnosed the vehicle with a cracked rod…

  The contact owns a 2015 Kia Sportage. The contact stated that while driving at approximately 55 MPH, there was a loud clanking sound coming from the engine compartment. There was no warning light illuminated. An independent mechanic was contacted and diagnosed the vehicle with a cracked rod bearing. The contact was informed that the engine needed to be replaced. The dealer was not contacted, and the vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a previously associated recall had expired related to the failure. The failure mileage was approximately 90,000.

• Apr 14, 2024CA
  Engine
  I took the vehicle in to Kia due to excessive oil consumption. I was told they could not do anything and that I should continue to drive the vehicle. Kia stated that since I am the second owner (purchased at 7,800 miles) that I am not eligible for the original warranty. They stated that if anything…

  I took the vehicle in to Kia due to excessive oil consumption. I was told they could not do anything and that I should continue to drive the vehicle. Kia stated that since I am the second owner (purchased at 7,800 miles) that I am not eligible for the original warranty. They stated that if anything were to happen to my engine I would need to provide documentation of oil changes from the first date the vehicle was purchased (which I don't have access to since I am not the original owner) and that Kia would assess to see if I were eligible for a new engine. They completed an oil change checked for leaks and sent me on my way. I continued to add oil every 500-1000 miles. On 4/11/24 I was driving me vehicle on the freeway at approximately 75-80 miles per hour when the vehicle lost power and would not drive over 40 miles per hour. Upon exiting the freeway the vehicle died at a red light. A tow truck driver took me to a mechanic who ran diagnostics and found codes P0300, P0302, and P0304. He stated that the 2 and 4 cylinders had no compression. Awaiting Kia inspection.

• Apr 5, 2024AR111,508 mi
  Engine · Power train
  The contact’s son owns a 2015 Kia Sportage. The contact stated that the vehicle experienced lunging and the engine seized. There was no warning light illuminated. The vehicle was towed to the contact’s residence. The contact used an ODB scanner to diagnose the vehicle and retrieved DTC codes…

  The contact’s son owns a 2015 Kia Sportage. The contact stated that the vehicle experienced lunging and the engine seized. There was no warning light illuminated. The vehicle was towed to the contact’s residence. The contact used an ODB scanner to diagnose the vehicle and retrieved DTC codes related for: camshaft timing in cylinder bank 1 advanced, low oil, phaser stuck, faulty sensor, failed valve control solenoid, and worn timing components. The contact had the vehicle towed to the dealer where a diagnostic test was performed, and the contact was informed that the internal engine failure was likely due to low oil pressure. The dealer also stated that the engine oil level was good and recommended that the engine be replaced. The vehicle was not repaired due to cost. The manufacturer was notified of the failure. The contact filed a case regarding the failure; however, the case was denied by the manufacturer. The failure mileage was approximately 111,508.

• Mar 4, 2024TX
  Engine

  Having to refill the oil every week ! This has been check over and over and they can’t find nothing my engine needs to be replaced ! Burning way too much oil and costing me too much money to keep refilling.

• Feb 7, 2024ME
  Fuel/propulsion system
  [XXX] Kia Dealer replaced the 2015 Kia Sportage engine under an extended warranty not a recall. (10 months ago) Kia failed to notify us there was a connection issue of the high pressure fuel line on replacement motors. [XXX] daughter drove from Boston to Maine when she arrived home gas vapors were…

  [XXX] Kia Dealer replaced the 2015 Kia Sportage engine under an extended warranty not a recall. (10 months ago) Kia failed to notify us there was a connection issue of the high pressure fuel line on replacement motors. [XXX] daughter drove from Boston to Maine when she arrived home gas vapors were coming out the front grill and between the hood and windshield. When I removed the plastic engine cover and had her start the car fuel sprayed out everywhere. 2-6-24: Kia dealer wont repair the leak because the engine was replaced under an extended warranty and not a recall. 2-7-24: Charles, a supervisor at Kia Customer Care said the same thing, sorry but nothing I can do. So let me understand what you are saying. If two 2015 Kia Sportage come in and both get the engines replaced , one under a recall the other under an extended warranty and then it is discovered that the pipe that connects to the high pressure fuel pump may have been damaged , misaligned or improperly fastened during replacement could result in a fuel leak and fire. Only the owner that had the engine replaced under the recall would be notified. The other owner will be driving around a potential Kia Fireball. He said that unfortunately is the case and our car is out of the warranty period. 18V-907 / SC172 Recall Summary Kia Motors America is recalling certain 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak. This recall affects only some Sportage vehicles. Specifically, it impacts any vehicles that had an engine replacement completed. This could have happened under a different recall or due to a warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• Feb 2, 2024GA
  Unknown or other

  I had the anti-theft security upgrade on my Kia done and it was still easily stolen in minutes from my driveway. The upgrade did absolutely nothing.

• Jan 8, 2024GA150,000 mi
  Engine

  The engine began knocking on a crowded roadway. The Kia dealership noted an engine recall, but that engine replacement claim was denied because a KSDS sensor update was not completed prior because the corporate office did not have my updated address, and I never got the recall letter.

• Dec 1, 2023OH80,000 mi
  Service brakes, hydraulic
  The contact owns a 2015 Kia Sportage. The contact stated while driving at an undisclosed speed, the ABS and traction control warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the ABS control module. The vehicle was not repaired. After investigating the…

  The contact owns a 2015 Kia Sportage. The contact stated while driving at an undisclosed speed, the ABS and traction control warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the ABS control module. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V051000 (Service Brakes, Hydraulic) however, the VIN was not included. The manufacturer was notified of the failure, and a case was filed. The failure mileage was 80,000.

• Oct 14, 2023CT
  Engine · Vehicle speed control
  Driving on the highway at 65mph, engine light started blinking then stayed solid and my speed declined to 40mph and would not go higher. Had to stay in slow lane to get off and get back on to make it home. I was unsure as to what was happening.It was the weekend so had to wait until Monday until i…

  Driving on the highway at 65mph, engine light started blinking then stayed solid and my speed declined to 40mph and would not go higher. Had to stay in slow lane to get off and get back on to make it home. I was unsure as to what was happening.It was the weekend so had to wait until Monday until i could find out and the dealership told me it was the valve cover gasket (which is brand new). I was also told they couldnt do anything else for me i need a long block assembly.

• Oct 10, 2023CT
  Engine

  Testing the vehicle is saying cylinder 3 misfire, tested it and misfire is not following. Cm is saying replacement of engine long block.

• Jul 31, 2023GA130,000 mi
  Engine

  The contact owns a 2015 Kia Shortage. The contact stated while driving 60 MPH, the vehicle lost motive power without warning. The contact was able to pull over on the side of the road. The vehicle was towed to an independent mechanic who stated that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 130,000.

• Jul 30, 2023CT
  Engine · Fuel/propulsion system

  My engine is making noise, I have to add oil everyday and there are no leaks under my car. The engine gets hot, i feel like it can catch fire.

Defect investigations

NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.

• Hyundai and Kia ABS Module Fires

  AQ23002Opened Nov 17, 2023Open
  The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by…

  The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

• Loss of Motive Power

  DP22003Opened Sep 12, 2022Closed Dec 12, 2023
  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles…

  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Service bulletins

Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.

• 11001593TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGREADE $ DECAL INSTALLATION (CS2302) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from December 10, 2015 through December 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
• 11000787This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
• 10252085TECHNICAL SERVICE BULLETIN: PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement"; equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
• 10250838TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR & DECAL INSTALLATION (CS2311) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 15, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) are not able to receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles that are not equipped with an immobilizer, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
• 10242913PITSTOP: AWD SYSTEM CONCERN DUE TO TIRE CIRCUMFERENCE - This Pitstop provides information regarding potential concerns with the All-Wheel-Drive (AWD) system due to tire sizes of differing circumference. Some customers may complain of a chatter sensation felt in the drivetrain of the vehicle and/or the failure of drivetrain component(s). A difference in tire size (width, aspect ratio, construction, rim diameter etc.) may be the cause.
• 10240557CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia is now making steering wheel lock devices available directly to certain Kia vehicle owners. These devices can help deter a theft attempt. We are making this device available to customers free of charge and will ship it directly to customers who place orders within eighteen (18) months from the date of this letter.
• 10239722CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
• 10239712TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2302) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from Dec 10, 2015 through Dec 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10236641TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2302) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from Dec 10, 2015 through Dec 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
• 10233650TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2302) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from Dec 10, 2015 through Dec 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
• 10232566CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is a follow-up notification advising that Kia developed a software upgrade that can be installed on your vehicle free of charge to restrict the operation of the vehicle's ignition system should your locked vehicle be the subject of a break-in and theft attempt without the key. However, the previous letter was sent in error. The customer's vehicles are equipped with an electronic engine immobilizer and are NOT equipped with a steel key and "turn-to-start" ignition system, and they are not targeted for theft by the social media challenge and does not require a software upgrade. As a result, customers may disregard that letter.
• 10231839CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
• 10230883CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
• 10230881TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2302) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from Dec 10, 2015 through Dec 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
• 10230879TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2302) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on some 2011-2016MY Sportage (SL) vehicles produced from May 6, 2010 through Nov 16, 2015, and 2017-2022MY Sportage (QL) vehicles produced from Dec 10, 2015 through Dec 7, 2021, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
• 10226555TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
• 10219692TECHNICAL SERVICE BULLETIN: BEARING CLEARANCE TESTER (BCT) PROCEDURES - This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supplier however, in some cases, due to variable shop compressor air pressure, the SST may need to be re-calibrated to ensure that the tool provides accurate readings when testing the engine rod bearing wear. The calibration and BCT measuring point maintenance is included in this bulletin.
• 10210431PITSTOP: INJECTOR HARNESS ROUTING FOR PI1802Y/Z AND PI1803Y/Z ENGINE REPLACEMENTS - This bulletin provides information to address a no-start or hard start with poor running condition after engine replacement under PI1802Y/Z or PI1803Y/Z. Some replacement long blocks may come with pre-installed fuel rail, injectors, and injector wiring harness. If the condition is present, it is possible that the injector harness was not installed correctly. The connections may be swapped from cylinder No. 1 and cylinder No. 4, and from cylinder No. 2 and cylinder No. 3.
• 10209438TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10206642TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10205865PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement" equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
• 10205426TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
• 10203695This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supplier however, in some cases, due to variable shop compressor air pressure, the SST may need to be re-calibrated to ensure that the tool provides accurate readings when testing the engine rod bearing wear. The calibration and BCT measuring point maintenance is included in this bulletin.
• 10203658PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement" equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
• 10202226TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
• 10201529TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
• 10201158TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
• 10189545TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
• 10189272TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
• 10186041TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
• 10183433TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring volume too loud" complaints when using certain smartphones (non-iPhone). Additionally, in 2014MY vehicles the upgrade will also improve Bluetooth connectivity and voice recognition.
• 10183431TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device
• 10183333TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
• 10183332TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
• 10183312PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled Knock Sensor Detection System - ECU Logic Improvement equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
• 10179255PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
• 10179250PRODUCT IMPROVEMENT - TSB_PI1802_R2 - Knock Sensor Detection System - ECU Logic Improvement - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
• 10177731PRODUCT IMPROVEMENT CAMPAIGN - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z_Rev3) - This bulletin has been revised to include additional information. - This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled "Knock Sensor Detection System - ECU Logic Improvement".
• 10177730PRODUCT IMPROVEMENT CAMPAIGN - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z_Rev2) - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled "Knock Sensor Detection System - ECU Logic Improvement".
• 10176911TSB: PRODUCT IMPROVEMENT CAMPAIGN : KNOCK SENSOR DETECTION SYSTEM (KSDS) LOGIC IMPROVEMENT (PI1802_R11) - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.

Every KIA Sportage model year

Bars are owner complaints, dots mark years with recalls. Select a year to open its report.