2021 Volkswagen Passat
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volkswagen › Passat › 2021
These records cover every 2021 Volkswagen Passat. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2021 Volkswagen Passat. Newest first.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Atlas, Atlas Cross Sport, and Passat vehicles. The front wheel bearing bolts may have been incorrectly tightened.
Risk and remedy
Risk
The bolts may loosen and cause a loss of control, increasing the risk of a crash.
Remedy
Dealers will inspect the tightness of the wheel bearing bolts and replace the bolts, as necessary, free of charge. Owner notification letters were mailed November 2, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40R7.
Owner complaints
20 complaints1 involved a crash1 involved a fire
What owners report most
Latest complaints
- Electrical system · Engine
Since purchase in XXX, the vehicle has intermittently illuminated the EPC warning light at startup, at which point the engine will not accelerate (reduced power/limp mode). Cycling the ignition usually clears it. Beginning in XXX, a second symptom appeared: while stopped at idle (traffic lights…
Since purchase in XXX, the vehicle has intermittently illuminated the EPC warning light at startup, at which point the engine will not accelerate (reduced power/limp mode). Cycling the ignition usually clears it. Beginning in XXX, a second symptom appeared: while stopped at idle (traffic lights, stop signs), the battery warning light illuminates and the engine stalls, requiring a restart in traffic. This has occurred approximately 8 times in XXX, most recently on Saturday, XXX when it happened twice. Wet or rainy conditions appear to make it worse. Stalling in traffic results in loss of power steering and brake assist and is a safety hazard. The vehicle has been to Volkswagen dealers six times for this complaint with no lasting repair: a wiring harness repair at Freehold VW (XXX); a boost pressure sensor diagnosis (XXX); an overlay harness, ECM-related repairs, and ECM software update under emissions recall 23EO (XXX); boost pressure sensor replacement (XXX); airflow meter replacement and harness repair (XXX); and re-pinning of loose connections at the ECM connector for the G31 boost pressure sensor (XXX), all at World VW in [XXX]. Fault code P0236 (turbocharger boost sensor circuit) has been recorded on every visit; P2261 was also recorded. The check engine light, EPC light, and stalling have all returned since the XXX repair. Current mileage is approximately 27,800. Repair orders are available on request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine
The contact owns a 2021 Volkswagen Passat. The contact stated that while driving, the check engine warning light remained illuminated. The vehicle was taken to a local dealer, where it was diagnosed with torque converter failure. The contact stated that the breather box was previously replaced by a…
The contact owns a 2021 Volkswagen Passat. The contact stated that while driving, the check engine warning light remained illuminated. The vehicle was taken to a local dealer, where it was diagnosed with torque converter failure. The contact stated that the breather box was previously replaced by a local independent service center. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.
- Electrical system · Engine
I am requesting that Volkswagen open a formal case regarding a fire involving my 2021 Volkswagen Passat. On May 6, 2026, at approximately 9:30 PM, after driving about seven miles, I came to a complete stop and the vehicle began smoking before catching fire. The vehicle has been declared a total…
I am requesting that Volkswagen open a formal case regarding a fire involving my 2021 Volkswagen Passat. On May 6, 2026, at approximately 9:30 PM, after driving about seven miles, I came to a complete stop and the vehicle began smoking before catching fire. The vehicle has been declared a total loss and is currently being stored at a salvage yard pending investigation. I am requesting that Volkswagen investigate the cause of the fire and advise whether an inspection of the vehicle will be conducted.
- Air bags
I was parking my car and then I heard a loud crack. Then I noticed my car's airbag malfunction warning notice came up on the dashboard along with other failures. I can see on the edges of the horn panel on the left that its slightly detached, so it seem the airbag has somewhat inflated. I haven't taken it to the dealer yet, but will later after work. I didn't notice any issues prior to this happening
- Forward collision avoidance › Automatic emergency braking · Service brakes
Driving home from work around 1:00 am at night with street lights and no other cars in the vicinity the auto brake engaged, causing an abrupt stop. Once the auto brake ceased I was able to complete my trip. There was a light coating of water in a spot on the road but nothing else and no reason for this to occur.
- Equipment · Equipment › Electrical › Infotainment
See attached document for complaint.
- Engine and engine cooling
The contact owns a 2021 Volkswagen Passat. The contact stated that while stopped at a red traffic light, the engine stalled. The low oil pressure and the battery warning lights were illuminated. The contact was able to restart the vehicle. The vehicle was taken to a local independent mechanic…
The contact owns a 2021 Volkswagen Passat. The contact stated that while stopped at a red traffic light, the engine stalled. The low oil pressure and the battery warning lights were illuminated. The contact was able to restart the vehicle. The vehicle was taken to a local independent mechanic, where it was diagnosed that the piston ring and engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 37,995.
- Air bags · Electrical system · Steering
Known issue in previous VW models. Broken clock spring in steering wheel from normal <100k miles no connection for all steering wheel electronics (airbags, radio controls, etc)
- Structure › Body
There is a headlight chrome accent piece right above the left headlight that one day just blew off the vehicle when driving down the highway. Oddly enough, I live in a small town of Mason City, IA and I saw another VW Passat (same year) missing the same exact piece so I know this is a vehicle…
There is a headlight chrome accent piece right above the left headlight that one day just blew off the vehicle when driving down the highway. Oddly enough, I live in a small town of Mason City, IA and I saw another VW Passat (same year) missing the same exact piece so I know this is a vehicle defect. You also can not just replace this one part, it costs over $1,000 to replace the full headlight assemble. I hope others report this defect as this is very dangerous when you have chrome pieces flying off your vehicle when it is not even windy and the vehicle has never had any other damage.
- Air bags · Exterior lighting · Unknown or other
The forward collision was not working on my car when someone pulled down in front of me and I hit the wall so I wouldn’t hit them.
- Tires › Sidewall
I own a 2021 Volkswagen Passat R-Line that has GITI 235/40R19 Comfort tires, I have had bubbles on two of the tires that blew out going down the interstate. I now have a third tire with the same issue.
- Electrical system · Service brakes
I have encountered severe and unresolved issues with the vehicle, and despite multiple visits to Serramonte VW dealership, the problems persist. I leased this car from VW Serramonte on 8/29/2021, and their contact information is as follows: Serramonte Volkswagen 711 Serramonte Blvd. Colma, CA…
I have encountered severe and unresolved issues with the vehicle, and despite multiple visits to Serramonte VW dealership, the problems persist. I leased this car from VW Serramonte on 8/29/2021, and their contact information is as follows: Serramonte Volkswagen 711 Serramonte Blvd. Colma, CA 94014 (650) 756- 9000 www.serramontevw.com To provide context, the vehicle began experiencing unresolved electrical problems at just 7,000 miles. Despite repeated attempts for repairs at the dealership, these issues persist. Additionally, at only 9,000 miles, abnormal wear on the rear brake pads and rotors was discovered, requiring replacement. The dealership acknowledged the unusual nature of this problem, stating that it typically occurs after 30,000 miles in a typical car. The combination of these issues in a new vehicle with such low mileage is concerning and raises questions about the vehicle's quality and safety standards.
- Service brakes
Rear brakes needed to be replaced at less than 20k miles The dealer comped it since we lease 2 different 2021 VW Passats and they both needed their rear wheels replaced at sub 20k miles
- Service brakes
Rear brakes needed to be replaced at 17,000 miles. Same thing happened to my wife’s 2021 Passat.
- Service brakes
The contact owns a 2021 Volkswagen Passat. The contact stated that the rear brake pads were generating an excessive amount of brake dust. The dealer was notified. The contact stated that he was informed a year later at a vehicle State Inspection, that the rear brakes were significantly worn. The…
The contact owns a 2021 Volkswagen Passat. The contact stated that the rear brake pads were generating an excessive amount of brake dust. The dealer was notified. The contact stated that he was informed a year later at a vehicle State Inspection, that the rear brakes were significantly worn. The vehicle was taken to the dealer, where it was diagnosed that there was an uneven brake wear as the rear brakes were prematurely worn while the front brakes were in very good condition. The dealer notified the manufacturer, who informed the dealer that there would be no assistance as the vehicle was not covered under warranty. The vehicle was not repaired. The failure mileage was approximately 5,000.
- Lane departure › Assist
The vehicle lane assistance feature for my 2021 Volkswagen Passat nearly caused me to collide with another vehicle on two separate occasions. While driving home on my regular route, there are many cross streets where intersecting traffic may cross in order to facilitate a left turn. On one such…
The vehicle lane assistance feature for my 2021 Volkswagen Passat nearly caused me to collide with another vehicle on two separate occasions. While driving home on my regular route, there are many cross streets where intersecting traffic may cross in order to facilitate a left turn. On one such occasion a vehicle pulling a utility trailer crossed in front of me but did not proceed through entirely, leaving the trailer sticking out into the lane ahead of me. As I approached I attempted to pilot the car into the right lane adjacent to me, in order to avoid a collision. The lane assist feature took control of the vehicle's steering, pulling me back on a collision-course toward the trailer and other vehicle. I was forced to wrest control of the wheel in order to avoid the other vehicle resulting in a near-miss. Several days later a similar occurrence happened, causing me to lose confidence in the vehicle entirely. This feature can not be permanently disabled, meaning that each and every time I start the car, I am forced to actively disable it. Should I forget to do so, I am in danger of another similar incident. A phone call to Volkswagen confirmed that there is no way to disable this feature permanently, and there is no intent to make an update to vehicle software. This feature, rather than assisting in the safety of individuals, is actively putting lives at risk! Volkswagen refused to offer a vehicle buy-back. I think that the dangers posed here are enough to investigate and also to mandate that manufacturers offer an option to permanently disable the active lane assist feature.
- Exterior lighting · Lane departure › Assist
The contact owns a 2021 Volkswagen Passat. The contact stated that while driving in the rain at an undisclosed speed, the Lane Departure Assist malfunctioned, causing the steering wheel to inadvertently move to the right or left. Additionally, the high-beam headlights were aimed too high upwards…
The contact owns a 2021 Volkswagen Passat. The contact stated that while driving in the rain at an undisclosed speed, the Lane Departure Assist malfunctioned, causing the steering wheel to inadvertently move to the right or left. Additionally, the high-beam headlights were aimed too high upwards, making it difficult for the contact to see the road ahead. The vehicle was taken to the dealer, but the dealer informed the contact that the Lane Departure Assist function could not be deactivated and that the high-beam headlights could not be adjusted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100.
- Lane departure › Lane keep › Automatic steering
The contact owns a 2021 Volkswagen Passat. The contact stated that while driving through a pedestrian intersection with thick white lines, the vehicle automatically veered to the left or right. The contact stated that the failure occurred while driving 30 to 45 MPH. The contact had not contacted the manufacturer or the dealer. The failure mileage was 27,232.
- Lane departure › Assist · Steering
The assisted lane control is working terribly on my car and cannot be turned off permanently. The take over steering must be turned off before I drive the car every single time. It does not work properly. Last week I went to steer around a pothole and almost went in the ditch because the…
The assisted lane control is working terribly on my car and cannot be turned off permanently. The take over steering must be turned off before I drive the car every single time. It does not work properly. Last week I went to steer around a pothole and almost went in the ditch because the steering control was "fighting" with me to not let me steer where I needed to go. The previous incident I was trying to go around a cyclist and had to literally fight with my steering to keep it from hitting the biker. It is terrible. The dealer told me it could not be permanently disabled. It is a hazard and someone is going to get hurt. The service rep told me that NHTSA has made it mandatory for the car manufacturers to have these safety features disabled by default with no way to permanently turn them off. I want to stress how unsafe this is. I truly believe there are many things government can help us with but to get in the middle of me steering my car is not one of them. This is government overreach. The VW customer care person I spoke to also told me they have been plagued with complaints from owners who want the steering control disabled. There is a setting to disable it, but I have to remember to turn it off every single time I start my car. I want the NHTSA to (1) put pressure on VW to fix the steering assist problem and allow for steering changes to safely pass bikers and other vehicles on the shoulder without needing the directional signal and (2) make the assist something that can be turned off by default. I do like to use it when I am on a long highway drive, but never around town. It is terrible and beeps and takes control of the steering and I am tired of fighting with my car. Someone will get killed if you leave it like this. People need to decide for themselves if they want the steering assist or not. Default ON needs to end when a person turns it off - it stays off until they turn explicitly it back on.
- Lane departure › Assist
VW Lane Assist is on when the vehicle is turned on. It must be turned off by the driver which I forget to do. Driving on country two lanes I've encountered joggers, bikers in the designated bike lane, service vehicles on the right shoulder. When I give them some extra room to avoid them the Active…
VW Lane Assist is on when the vehicle is turned on. It must be turned off by the driver which I forget to do. Driving on country two lanes I've encountered joggers, bikers in the designated bike lane, service vehicles on the right shoulder. When I give them some extra room to avoid them the Active Lane Assist steers the car towards the people I'm trying to avoid. If the road is pitched enough the Lane Assist steering is rather abrupt. There is no feature that allows Lane Assist to be disabled and manually re-enabled when needed. The best solution would be to allow lane assist only when the Active Cruise control is active.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011377This is a notice for software changes with the ODIS diagnostic program to correct the communication for the airbag control module. For trouble code DTC B10001B. Driver airbag igniter resistance too high -N95
- 11011375moisture witin rear tail lamp assembly
- 11011374HVAC duct cleaning and deodorizing
- 11010025Green Light Does Not Illuminate
- 11010024Lack of paint under roof
- 11010022Engine Oil Standards
- 11010021Additional reporting
- 11010011Vehicle Concerns Before Recall Repair Available
- 11008866Inspecting sensors for damage
- 11008861Fluid requirements
- 11008860Manual transmission noise diagnosing
- 11008858A list of engine oil that meet Volkswagen Engine Oil Standards
- 11008857How to perform the engine oil consumption measurement
- 11008856Checking Engine Oil and correctly reading dip stick
- 11008853How to manage software versions using VW diagnostic Tool
- 11008852Recommended Gasoline Quality
- 11008851Engine Misfire Diagnostic Aid
- 11008850Fuel additive to help with misfire faults
- 11008846Wind & Water Leak Checking
- 11007398Battery testing
- 11007396Car-net 2.0 may not fully complete the initial Register and Pairing process (R&P) after removal of
- 11007393Engine Oil Standards
- 11005830Phyical condensation within Taillamp cluster is an optical phenomenon and does not affect the function of the taillights.
- 11005826Car-net 2.0 may not fully complete the initial Register and Pairing process (R&P) after removal of
- 11005825Engine oil quality standards
- 11005821Engine Oil Pressure-Priming
- 11005820Engine Assembly Tip
- 11005819Engine Replacement Tip
- 11005817Mandatory Fastener Replacement
- 11002875Engine oil quality standards
- 11001522These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the Class Action Settlement
- 11001508Engine oil quality standards
- 11001503Forigen objects inside seat belt buckle
- 11001494These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the Class Action Settlement
- 10253481Carefree Maintenance and VW Care Maintenance Plans Interim AdBlue Refills -? Diesel Engines Model Year 2015 and Newer
- 10253477Volkswagen Carefree Maintenance Program ? Diesel Engines Model Year 2015 and Newer
- 10253474This communication contains important information and SAGA claim entry requirements for the Volkswagen Carefree Maintenance Program for all Model Year 2015 and newer VW models with Gasoline Engines.
- 10253262VW Engine oil quality standards
- 10253192Infotainment Worksheet (U.S. Only)
- 10251674Air Conditioning, Cleaning of the R1234yf Refrigerant Circuit (U.S. Only) updated to adjust Flush machine filter pricing.
Every Volkswagen Passat model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.