2004 Dodge Stratus
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Dodge › Stratus › 2004
These records cover every 2004 Dodge Stratus. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
7 recalls name the 2004 Dodge Stratus. Newest first.
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2000-2005 Eclipse vehicles manufactured April 5, 1999, to December 17, 2004, 2001-2005 Eclipse Spyder vehicles manufactured January 19, 2000, to March 18, 2005, 2001-2005 Chrysler Sebring vehicles manufactured April 17, 2000, to February 21, 2005, and 2001-2005 Dodge Stratus…
Risk and remedy
Risk
If the passenger side sun visor detaches and is propelled rearward, there is an increased risk of occupant injury.
Remedy
MMNA will notify their owners, and Chrysler will notify the Chrysler and Dodge owners. Dealers will install a tether strap to retain the passenger sun visor, free of charge. The recall began on July 20, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-005. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R30.
Federal-mogul IS recalling certain replacement control arm assemblies, part numbers k7425, 10945, fa4510x, k7427, 10946, and fa4611x, sold for use on various passenger vehicles listed above. the ball joint on the control arm assembly can fail causing the ball stud to wear through the control arm housing resulting in noise and/or separation of the ball stud…
Risk and remedy
Risk
If there IS a separation of the ball stud from the housing, the driver can loose steering control, possibly resulting in a vehicle crash.
Remedy
Federal-mogul will notify owners of record and replace the affected control arms free of charge. the safety recall began on january 28, 2011. owners may contact federal-mogul at 1-877-489-6659.
Qualis automotive IS recalling certain aftermarket ball joints sold for use on certain passenger vehicles. the socket may have been excessively hardened which could cause it to crack near the retaining ring groove allowing the ball stud to separate under impact load. the subject ball joints were sold as four part numbers, d10945, d10946, g10945, and…
Risk and remedy
Risk
Separation of the ball stud from the socket of the ball joint housing would allow the control arm to collapse and the wheel to fold in causing loss of steering control, possibly resulting in a crash.
Remedy
Qualis automotive will replace the ball joints free of charge. the safety recall began on november 9, 2009. owners may contact qualis automotive at 1-800-493-4128.
Dope, inc. IS recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. At 1-626-272-1798.
Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
Risk and remedy
Risk
Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Remedy
Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
On certain 2-door passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be improperly molded.
Risk and remedy
Risk
Breakage could result in a leakage of fuel and in the presence of an ignition source, it could result a fire.
Remedy
Dealers will replace the fuel pump. the recall will begin on august 9, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
On certain passenger vehicles, the fuel return line hose fitting on the electric fuel pump may be restricted, causing excessive fuel pressure to build up in the fuel injection system. excessive fuel pressure may result in a leak in the fuel return hose.
Risk and remedy
Risk
Fuel leakage in the presence of an ignition source could result in a fire.
Remedy
Dealers will inspect the fuel pump pressure. those vehicles exhibiting higher than normal fuel pump pressure will receive fuel pump modifications. Owner notification began on december 15, 2003. owners should contact daimlerchrysler at 1-800-992-1997.
Owner complaints
144 complaints24 involved a crash1 involved a fire17 injuries
What owners report most
Latest complaints
- Wheels › Lugs/nuts/bolts/studs
The contact owns a 2004 Dodge Stratus. The contact stated while reversing, the passenger's side front wheel detached. The contact stated that the vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact referenced an unknown…
The contact owns a 2004 Dodge Stratus. The contact stated while reversing, the passenger's side front wheel detached. The contact stated that the vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact referenced an unknown recall repair with similar failure; however, the VIN was not associated with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 136,334.
- Fuel/propulsion system
Fuel pump went out and in order for me to replace the fuel pump you have drop the tank. I could not get the intake hose off or the smaller fuel line along side it off. And there very little room to work with to get it off. And I have purchased the vehicle a little over a year ago and was not told about any recalls on this vehicle
- Suspension
The contact owns a 2004 Dodge Stratus. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds and then lost motive power. Additionally, the front passenger's side ball stud separated from the ball joint housing, and the front passenger's side tire was stuck…
The contact owns a 2004 Dodge Stratus. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds and then lost motive power. Additionally, the front passenger's side ball stud separated from the ball joint housing, and the front passenger's side tire was stuck on the fender, preventing the engine from falling onto the ground. The failure almost caused a collision. The vehicle was towed to the contact's residence. While the vehicle was being placed on the flatbed tow truck, the oil filter fractured and detached. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 51,000.
- Engine · Structure › Body · Suspension
2.7 liter engine should be recalled and replaced because? 1. The internal water pump which have been known to wear out prematurely and destroy the engine regardless how well the owner maintains vehicle. 2. Subframe and rear suspension crossmember should be replace due to rotting out prematurely. 3 Gloss on paint prone to pealing.
- Suspension
TL* the contact owns a 2004 dodge stratus. The contact stated while driving at various speeds, there were unknown rattling sounds coming from the vehicle. Additionally, the wheels were wobbling as if they were going to detach from the vehicle. The vehicle was taken to an independent mechanic to be…
TL* the contact owns a 2004 dodge stratus. The contact stated while driving at various speeds, there were unknown rattling sounds coming from the vehicle. Additionally, the wheels were wobbling as if they were going to detach from the vehicle. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the ball joints on the control arm assembly were faulty. The vehicle was not yet repaired. The dealer and manufacturer were not made aware of the failure. The contact related the failure to nhtsa campaign number: 10e059000 (suspension). The failure mileage was 116,508.
- Steering · Suspension · Wheels
I have noticed when I am turning my steering wheel to the left or right there appears to be somewhat of a lack of control and loosening of the front end of my vehicle as I am driving. Also, the suspension on my vehicle has become much more pronounced negatively.
- Suspension
While making a turn at 5MPH, my front right wheel collapsed causing complete separation of the wheel and control arm in turn causing my axle to come out from the transmission at the cv joint. There IS a recall for this ball joint issue but not for my vin specifically.
- Steering · Unknown or other
As I am turning the steering wheel when driving or idle the steering IS making a squeaking/creaking noise I believe it has to do with recall: 10e059000 front control arm - lower arm
- Air bags
Driving on a 35 mph road going across the cross road got hit by a truck doing about 70 mph. Hit on the passenger side front bumper to the back edge truck f the front passenger tire. Put into a spin then was hit in the rear passenger tire and bumper. No air bags came out with massive trauma to both…
Driving on a 35 mph road going across the cross road got hit by a truck doing about 70 mph. Hit on the passenger side front bumper to the back edge truck f the front passenger tire. Put into a spin then was hit in the rear passenger tire and bumper. No air bags came out with massive trauma to both myself as driver and my passenger. Police, ambulance and doctors asked why the air bags did not expand. If the air bags would of worked less injuries would of happened. We had just stopped at a stop sign and proceeded to cross the road at like about 15 mph when hit.
- Fuel/propulsion system
TL* the contact owns a 2004 dodge stratus. While driving various speeds over a bump, the contact heard an abnormal noise coming from the rear passenger side of the vehicle. In addition, the fuel pressure warning indicator illuminated. The vehicle was taken to an independent mechanic, but was not…
TL* the contact owns a 2004 dodge stratus. While driving various speeds over a bump, the contact heard an abnormal noise coming from the rear passenger side of the vehicle. In addition, the fuel pressure warning indicator illuminated. The vehicle was taken to an independent mechanic, but was not diagnosed or repaired. The vehicle was not taken to a dealer for diagnostic testing. The manufacturer was notified of the failure and opened case number: 34782223. The approximate failure mileage was 151,000.
- Steering
The ball joint on the lower control arm assembly separated causing the front passenger side wheel to turn to the right and preventing the driver from being able to steer the car. the vehicle was in motion driving in a straight line when it happened. This IS similar to nhtsa recall #10e059000 and #09e056000. I think the control arm was the original factory part. I'll attach pictures with the part number.
- Power train · Steering · Vehicle speed control
Car has shut down while driving on highway and on city street. Sometimes the steering wheel will lock up and be hard to turn. Sometimes speedometer will stop working correctly. Car will shut down.
- Electronic stability control (esc) · Steering · Vehicle speed control
Lately when I drive my car the check engine light will come on and then a couple minutes after it comes on the steering will lock up. It has done this multiple times within the last couple of months. The first time I was able to get it started again but then the speedometer wouldn't work. After the…
Lately when I drive my car the check engine light will come on and then a couple minutes after it comes on the steering will lock up. It has done this multiple times within the last couple of months. The first time I was able to get it started again but then the speedometer wouldn't work. After the first time I thought it was fixed but now whenever it malfunctions the car shuts off on its own and will not start again until its been sitting untouched for at least 10 minutes. This has happened in town (25 mph) and on roads up to 55 mphs.
- Air bags
I was driving down the street and I parked at a friend's house. me and him were talking and without warning the driver side airbag went off. no one was touching the car and I was not touching the steering wheel. I don't know what triggered the airbag to go off. and I'm glad I wasn't on the road when it happened.
- Power train · Steering · Suspension
Lower left front suspension arm ball joint broken. the outer bearing carrier, fell away from the suspension arm, pulling the half shaft out of the transmission, and the wheel/tire assembly jammed up in the wheel well with a complete loss of steering control. the vehicle was in motion just following a turn, in a parking area.
- Engine
Car lost power. no accelerator or power in traffic.09/01/16 was last time.. does this quite often.
- Air bags
TL* the contact owns a 2004 dodge stratus. The contact received notification of nhtsa campaign number: 15v338000 (air bags); however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Service brakes · Suspension
TL* the contact owns a 2004 dodge stratus. The contact stated that the vehicle made an abnormal noise and the brakes functioned intermittently. The failures happened without warning. The vehicle was taken to an independent mechanic where the control arm assemblies were defective and needed to be…
TL* the contact owns a 2004 dodge stratus. The contact stated that the vehicle made an abnormal noise and the brakes functioned intermittently. The failures happened without warning. The vehicle was taken to an independent mechanic where the control arm assemblies were defective and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. Nhtsa campaign numbers: 07e023000 (service brakes, hydraulic) and 10e059000 (suspension) were issued for these failures. The failure mileage was approximately 100,000. *tr
- Fuel/propulsion system
Car IS leaking fuel
- Fuel/propulsion system
I went to visit son and yes I took it to auto zone to have it checked to make sure that everything was ok to drive on the highway. So I made it to my sons home then I have to make a run to the store as I got back on the highway to drive a guy starts to flag me down and said there was sparks under…
I went to visit son and yes I took it to auto zone to have it checked to make sure that everything was ok to drive on the highway. So I made it to my sons home then I have to make a run to the store as I got back on the highway to drive a guy starts to flag me down and said there was sparks under my car an soon as I pull over to the side of the road the whole front part of my car caught a fire fire department was called car was towed. They say its nothing they can do even through it IS a recall on the car for that reason,no one will return my calls from the company.
- Air bags
Hit a car doing 85 mph ripping off my front bumper an side panal on passsenger side along wit headlite assembly an grill air bag did not deploy. *tr
- Air bags
I was following a semi when he missed his turn and slammed on the brakes. I didn't have enough time to stop and I hit the back end of the trailer. Half of the front end of my car went right under the trailer and my car was totaled. On impact, my airbags didn't deploy and my face hit the steering wheel which caused bruising and severe pain. *tr
- Visibility › Windshield · Visibility/wiper
My windshield cracked on the passenger side of my dodge stratus I was told by the company that replaced my windshield that all the dodge car hes seen with this problem where water will get in the top of the windshield and I well rust from the inside out this would be a safety issue on the road to…
My windshield cracked on the passenger side of my dodge stratus I was told by the company that replaced my windshield that all the dodge car hes seen with this problem where water will get in the top of the windshield and I well rust from the inside out this would be a safety issue on the road to the driver/passenger safety up to pedestrians on the road also if the air bags where to deploy it could cause the windshield to detach from the car I have photo of the car rust under the windshield I don't have pitches of the windshield. *tr
- Engine and engine cooling · Fuel system, gasoline · Suspension
Car IS driven on regular city streets and freeways. roads I drive are paved - no country, dusty roads and area isn't heavy in pollution. I purchase my gas from shell or chevron and refill at 1/4 to 1/3 tank to reduce chance of picking up sediment from fuel tank. noticed while driving on…
Car IS driven on regular city streets and freeways. roads I drive are paved - no country, dusty roads and area isn't heavy in pollution. I purchase my gas from shell or chevron and refill at 1/4 to 1/3 tank to reduce chance of picking up sediment from fuel tank. noticed while driving on freeway.that car would drop in speed from 60 mph to 20 rather quickly and then forget about going up a hill. I was also getting 8-10 mpg. a couple weeks later I noticed even on level city streets the loss of power. car was diagnosed as catalytic converter and with california emission regulations the cost of parts and labor was $ 1,600.00. a year later, I noticed some loss of power and increased fuel consumption. car was diagnosed to need cat converter replaced again and paid another $ 1,600.00. also was diagnosed that rear mounts needed replacement and was wondering if this was normal. very bouncy ride. *tr
- Service brakes
Driving down the road, I had lost my brakes, took it to a mechanic and the brakes line on the left front wheel broke, this happened in september 2013, and the left front brake line broke again in december 2013. I called the dealer and they said there were no recalls for brakes, maybe next time I'll be traveling the interstate and realize I have no brakes when I need to apply them. *tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10229256KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10229181Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10223854Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
- 10223602Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
- 10221686KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10220995Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
- 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10220099Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10220097Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 10217728Generic Powertrain Control Module (PCM) Procedure This bulletin involves programming a generic PCM with software.
- 10191460Valve Body. These may cause over drive cycling.
- 10175743Disinfectant Solution Recommended for COVID-19
- 10175735Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
- 10169249Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10169247Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10169245Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 1012900882212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
- 10021684Generic powertrain control module (pcm) procedure.
- 10021239Powertrain control module initialization.
- 10019906The front heated seat control modules may cause the seat elements to overheat under certain operating conditions. Customer satisfaction notification E12 - heated seat control modules.
- 10017651Revised power steering system bleeding procedures.
- 10016603Air conditioning (a/c) cooling coil odor.
- 10013985Down stream fuel system.
- 10013774Cylinder head bolt re-torque procedure. Gpop - issue review system.
- 10013731Powertrain control module initialization.
- 10013716Flash: mil illumination diagnostic trouble codes (dtc/diagnostic trouble code) p0300, p0301, p0302, p0302, p0303, p0304, p0305, p0306-cold start misfire.
- 10012809Mopar accessory remote starter inoperative due to hood switch.
- 10012801Blower motor does not run on every speed.
- 10012341Transfer gear whine sound between 68 mph and 84 mph either accelerating or decelerating.
- 10011958Power steering fluid contamination.
- 10010535Driveability improvements. Engine stumbles, runs rough, idle fluctionation, or surge when at idle or coming to a stop.
- 10010491Power seat will not adjust.
- 10009791Intermittent loss of accessories (IG1 circuit) on initial vehicle start.
- 10009785Steering column click sound.
- 10009729Air conditioner and heater performance.
- 10008426Idle fluctuation and or malfunction indicator lamp (mil) illumination diagnostic trouble codes p0300, p0301, p0302, p0303 or p0304.
- 10006892Incorrect oil filter usage. Also includes 2005 sebring and stratus.
- 10006455Irregular engine snapping sound.
- 10005981Generic powertrain control module (pcm) procedure. This bulletin supersedes bulletin 18-006-04a dated 04/06/2004.
- 10005978Transmission solenoid replacement.
Every Dodge Stratus model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.