2009 Ford F-250
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Ford › F-250 › 2009
These records cover every 2009 Ford F-250. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
1 recall names the 2009 Ford F-250. Newest first.
Continental tire IS recalling certain contitrac tr tires, size lt275/70r18 125/122s outline white letters and black sidewall, and contitrac, size lt275/70r18 125/122s, black sidewall, produced from may 6, 2007, through september 20, 2008, sold as aftermarket and installed as original equipment on some model year 2008 and 2009 ford F-250 and F-350 trucks.…
Risk and remedy
Risk
Separation of the belt edges could lead to tread belt separation, increasing the risk of a crash.
Remedy
Continental tire will notify owners and replace the affected tires free of charge. the safety recall began on april 14, 2011. owners may contact continental customer service toll-free at 1-888-799-2168.
Owner complaints
54 complaints1 involved a fire
What owners report most
Latest complaints
- Engine · Fuel system, gasoline › Delivery › Fuel pump
The contact owns a 2009 Ford F-250. The contact stated while driving 55 MPH, the vehicle lost motive power. The contact stated that the cruise control was inoperable. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined…
The contact owns a 2009 Ford F-250. The contact stated while driving 55 MPH, the vehicle lost motive power. The contact stated that the cruise control was inoperable. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The dealer changed the filters and sensors. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact stated that the fuel tank was contaminated. The vehicle was repaired. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 128,484.
- Steering · Suspension
While driving at freeway speeds (typically above 50mph) the vehicle will have extended steering oscillation (violent shaking of the steering wheel) after going over normal expansion joints in the roadway and other roadway bumps. It is impossible to control the vehicle steering when oscillations…
While driving at freeway speeds (typically above 50mph) the vehicle will have extended steering oscillation (violent shaking of the steering wheel) after going over normal expansion joints in the roadway and other roadway bumps. It is impossible to control the vehicle steering when oscillations start. Sometimes the only thing that stops the oscillations is slowing, and leaving the freeway. No warning messages or lamps appear. When brought to dealership for repair, was told to contact manufacturer customer service.
- Steering · Suspension · Vehicle speed control
Driving and suddenly the entire vehicle will start to shake until slow or near complete stop. I think it’s called a death wobble
- Engine · Unknown or other
Motor gaskets leak oils and cracked and the other one is that when driving the truck it begins to shake aggressively and dangerously to where you can lose control
- Suspension
Was driving on the highway when my truck started shaking violently, had to pull over and check what was wrong, but no did not see anything wrong. Took it to the Ford dealership near me. Was told the tires were my problem had them replaced but the shaking continues. Ford does not have an explanation for me. What are my options?
- Steering · Suspension
Death Wobble. Hit a dip in the road steering wheel and whole truck Shakes out of control until you slow WAY down or stop.
- Suspension · Unknown or other
Vehicle shakes violently at highway speeds. Suspected "death wobble."
- Unknown or other
When putting fuel into the car, it was cut off as if it IS full, and nowhere near being a full tank.
- Steering · Suspension
I was driving down a city street and my 2009 F250 started to violently shake and I could barely control the steering wheel, it was like I had blown all 4 tires or the suspension had fallen apart. I was talking to my sister on the car speaker when it happened and she could even hear the shaking and…
I was driving down a city street and my 2009 F250 started to violently shake and I could barely control the steering wheel, it was like I had blown all 4 tires or the suspension had fallen apart. I was talking to my sister on the car speaker when it happened and she could even hear the shaking and started yelling to make sure I had not wrecked my vehicle. I pulled over in a parking lot and everything looked fine, all tires in tact, suspension still on the vehicle. This has happened 3 more times while driving on a city street and also once on a packed interstate. I called a ford dealer and they acknowledged this was known as the "death wobble" but would need to charge me $120 to diagnose the issue. This IS not only scary but also very dangerous and could cause injury or even death. I checked google and see lawsuits and ford acknowledge the issue but no recalls and I would have to pay the repairs and save my receipts! Ford needs to fix this! That IS too big of a vehicle to have this kind of known issue and no recall to repair!
- Steering
When driving speed between 35 and 40 mph, the steering starts wobbling back and forth. have to slow down and pull over. Road IS a 4 lane straight street. has happened twice. truck as 43,000 miles. taking to a mechanic today for assistance in diagnoses. looked up on the internet and this seems to be a common issue with this model. having the stabilizers checked. *tr
- Steering · Suspension
I have had multiple episode of death wobble. I have had the front end suspension rebuilt twice and have had the problem return, mechanics say its the worse they have ever seen. I've had to replace body mounts because they were destroyed by the violent wobble. this happens at speeds over 45 miles an hour and only stops when slowed down to about 35 miles an hour, which IS very dangerous on the interstate
- Steering · Suspension · Unknown or other
While driving on a highway at 65-70 miles per hour, if your front tires hit a small bump, especially on curves, the pickup front end wil go into an uncontollable wobble and you must immediately hit your brakes to get it to come to an almost dead stop before it will quit. You can end up in the other…
While driving on a highway at 65-70 miles per hour, if your front tires hit a small bump, especially on curves, the pickup front end wil go into an uncontollable wobble and you must immediately hit your brakes to get it to come to an almost dead stop before it will quit. You can end up in the other lane or cause the person following you to rearend you or end up in the ditch. So far, we have been lucky when this has happened as we live in a farming area and not heavily populated but are afraid to haul cattle to sale with this pickup which IS what we need it for. This started around at around 88,000 miles on speedometer. We have reseached this and talled to others and found it IS called the "death wobble".
- Engine
While driving down the highway, the truck shut off and wouldn't come back on. Had to drift into a parking lot to have it towed home. After months and several mechanics later, changing out different fuel parts, engine components, batteries, etc. We found out it was the high pressure fuel injection…
While driving down the highway, the truck shut off and wouldn't come back on. Had to drift into a parking lot to have it towed home. After months and several mechanics later, changing out different fuel parts, engine components, batteries, etc. We found out it was the high pressure fuel injection pump. The pump "exploded" for lack of better word, inside and sent metal shavings throughout the fuel rail and engine itself. We spent 12,000 to put a used motor and all new fuel components. It took us a year to save up because we had to make a payment on a vehicle that couldn't be used.
- Steering
Track bar failing. Causing 'death wobble' while driving at highway speeds during braking and when hitting small bumps
- Power train · Suspension
My husband and I purchased a ford F250 lariet truck from a ford dealership in california on 3-11-2012. ever since we have owned the vehicle we have had problems with a wobble when on traveling on the freeway. we have had the truck in the shop on many occasions and were told we needed new tires…
My husband and I purchased a ford F250 lariet truck from a ford dealership in california on 3-11-2012. ever since we have owned the vehicle we have had problems with a wobble when on traveling on the freeway. we have had the truck in the shop on many occasions and were told we needed new tires, etc. several times we both have experienced severe shaking on the freeway which causes us to slow way down and move to the slow lane. this IS very dangerous and scary. I have documentation from visits to the ford garage where we have mentioned the issue and have had paid for items that I do not believe we necessary since the problem was still ongoing. the issue continued to get worse so we recently took the truck to a different ford garage on 7-25-19 where we were told ball joints were worn, we need a new track bar and hub seals. the bill for this along with a smog check came to $2296.16. the total amount spent on this issue over the last few years IS quick significant. I still do not have confidence that the issue IS fixed and I recently became aware that this IS a problem that ford IS aware of and has done nothing about. We have a 5TH wheel that we intended to pull with this truck but the stress involved with this issue IS enough to not feel confident that we can do that. IS there anything we can do to get reimbursement and have ford fix this issue and guarantee this will not be an ongoing problem?
- Suspension
Right after performing the front and back brake pads replacement took my truck for a family trip in which we experience a sever shaking in the front end of the truck to the point that we had to come to a full stop the speed we were traveling was 70mph, at first I thought it was a flat tire but it…
Right after performing the front and back brake pads replacement took my truck for a family trip in which we experience a sever shaking in the front end of the truck to the point that we had to come to a full stop the speed we were traveling was 70mph, at first I thought it was a flat tire but it wasn't the case. We continue traveling at slower speed (60 mph) and slowly increasing it and again at 70 mph and stepping on a little bump the shake started again. I set up an appointment for the dealer to find out if the issue was related with the break job they did. They mentioned to me about a similar issue that this kind of trucks are been reporting. Definitely, this IS a safety issue ⚠️ if this issue IS been happening more and more, definitely there IS a fault in the truck suspension.
- Steering · Suspension
While in motion, this vehicle has had violent shaking at highway speeds 60-70mph and at low speeds of 30-40mph. the steering wheel violently shakes from side to side along with the entire truck shaking violently. it nearly caused an accident twice while traveling on the highway with very light…
While in motion, this vehicle has had violent shaking at highway speeds 60-70mph and at low speeds of 30-40mph. the steering wheel violently shakes from side to side along with the entire truck shaking violently. it nearly caused an accident twice while traveling on the highway with very light load in the bed (approximately 110lbs). this has been coined the "death wobble" from other F-250 owners that have experienced this issues as well. it seems that hitting a bump causes issues within the suspension and steering.
- Steering · Suspension
My truck going highway speeds has had numerous issues with death wobble. If you don't know what that IS it's where the truck starts shaking violently and the only way to control it IS to cone to a complete stop which in the middle of the highway IS very dangerous. This has happened many times with me and my family in the truck.
- Tires
TL* the contact owns a 2009 ford F-250 equipped with bf goodrich tires, tire line: rugged terrain, tire size: lp 275/70/r18 and the dot number was not available. The contact stated that the front driver side and passenger side tire tread prematurely separated causing both tires to fail at different…
TL* the contact owns a 2009 ford F-250 equipped with bf goodrich tires, tire line: rugged terrain, tire size: lp 275/70/r18 and the dot number was not available. The contact stated that the front driver side and passenger side tire tread prematurely separated causing both tires to fail at different points in time. A tire repair shop due to the contact indicating that the extensive nature of the tread separation caused damages to the fender, headlights, and the front frame inspected the tires. The manufacturer was notified of the failure and the contact was waiting on a response to determine their recommendation or solution. The vin was not available. The approximate vehicle failure mileage was not available and the tire failure mileage was not available.
- Steering · Suspension · Wheels
When driving at highway speeds (50 mph or higher) the truck experiences "death wobble" when it hits a small rough patch. During "death wobble" the vehicle shakes uncontrollably and won't stop until the vehicle speed IS brought down to 30 mph or lower.
- Steering
I am the original owner of a 2009 F250 super duty pu. The vehicle has been well maintained over the 61630 miles I have accumulated. Recently the truck has started experiencing what can only be described as a loss of power steering. This seems to most often occur after starting from a stop, and…
I am the original owner of a 2009 F250 super duty pu. The vehicle has been well maintained over the 61630 miles I have accumulated. Recently the truck has started experiencing what can only be described as a loss of power steering. This seems to most often occur after starting from a stop, and turning left. The wheels seem to be "stuck" in the turned direction, and needs to be muscled back into a straight path. This IS usually followed by an unusual slight tugging of the wheel in the opposite direction. The other day it was sticking from one direction to the other direction. Fortunately we had just started to merge onto a road that typically IS 45 mph (we were only doing about 20 mph). My partner thought I was horsing around by "yanking the steering from side to side, but it was the trucks steering that was doing it, and I was trying to straighten it out. We pulled off the road, and as I was pulling forward I could feel a difference in the steering (back to normal). My commute IS a mere 15 mins, but based on locations of my home and work, I do typically jump on the highway. I have stopped doing this because I fear with increased traffic and speed, I worry about causing an accident, although I have not experienced this at normal speed. I have brought this to my mechanic and he could not duplicate the condition. He checked the vehicle over, and found nothing worn or broken. He has been the only person servicing this vehicle since nov 2009, so he IS very familiar with the upkeep. In fact he had replaced the brakes and rotated the tires at 59000 miles. I do haul single and double axle trailers from time to time, and worry about the next time I need to.
- Steering
When I hit a small bump at highway speeds my truck will start to shake violently and will not stop without hard braking or aggressively jerking the steering wheel. I feel this IS a real hazard and am afraid to let my family drive the truck. I will not let my grand children ride with me in fear of an accident when the truck decides to shake.
- Wheels
I had a low tire pressure warning come on so I took my truck to the tire shop. The shop found I had a cracked wheel on the right rear of my truck. I keep my truck and wheels clean and have never pulled heavy loads so I do not understand why I have a cracked wheel. This truck IS a daily driver on us highways and has never been off road.
- Electrical system · Engine
TL* the contact owns a 2009 ford F-250. The contact stated that the vehicle would not accelerate over 40 mph and the check engine warning indicator illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the computer needed to be updated. The manufacturer was made…
TL* the contact owns a 2009 ford F-250. The contact stated that the vehicle would not accelerate over 40 mph and the check engine warning indicator illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the computer needed to be updated. The manufacturer was made aware of the failure and stated that they would not assist until a recall was issued. The contact referenced tsb number: 11-04-22. The failure mileage was approximately 219,500.
- Steering · Suspension
My truck has began a violent shaking, bouncing, and vibrating from the front end when I hit an uneven service on the interstate. feels as if someone else grabs my steering wheel and shakes it as hard and as fast as they can back and forth leaving me with little or no control. terrifying!! the…
My truck has began a violent shaking, bouncing, and vibrating from the front end when I hit an uneven service on the interstate. feels as if someone else grabs my steering wheel and shakes it as hard and as fast as they can back and forth leaving me with little or no control. terrifying!! the only way to stop the violence IS to slow to a stop on the shoulder. this began about a month ago and has happened at least a dozen times. my family IS afraid to ride in the truck.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10179912In monitoring our technical service inquiries and technical service bulletins from Ford, there is the potential for moderate to severe steering wheel oscillation (wobble) to occur. After extensive testing and outside feedback, the following details have been established to correct or prevent steering wheel oscillation occurrences in lifted 05-16 Ford Super Duty 4wd pickups.
- 10054755Ford: the malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0713 and/or p0710 regarding torqshift transmission. Model 2008-2009 F-53 motorhome chassis, low cab forward, 2008-2010 F-250, F-350, 2008-2011 E-350, E-450, F-450, F-550, 2011 F-53 motorhome chassis, F-50 commercial stripped chassis.
- 10040784Roush industries service campaign: see document search button for owner letter. The emission control labels do not meet standards.
- 10039053Ford: if there IS an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration.
- 10038965Comm-trans lund: some 2009-2011 models may have the air bag inicator flashing with a stored trouble code. This IS a software problem.
- 10038950Ford: some continental tires might have uneven wear, vibration, or the possible tread detachment. 2008-2009 f250/f350. Updated 8/3/11.
- 10038949Ford: 2005-2011 f250/f350. The fuel fill nozzle may automatically shut off too early.
- 10037561Ford: vehicles may run rough, hard start after refueling, clicking noise under hood, and have trouble codes stored.
- 10034712Ford service campaign: see document search button for owner letter. Catalyst y pipe warranty extension.. In some of the affected vehicles, certain vehicle operating conditions can cause the catalyst substrate to crack or melt. This can cause symptoms including but not limited to audible noise from the catalyst y pipe and/or malfunction indicator lamp illumination. Csc letter was received.
- 10034631Ford: supply/return lines installation at high pressure pump-revised washer for trucks equipped with 6.4L engines. When installing supply or return lines at high pressure pump on diesel engines, do not use the bonded style washer (w302870), use only the hybrid style washer (w303659).
- 10034628Ford: some trucks with 6.4L engine will run rough, smokes, or no start due to gasoline or alcohol in the fuel. Gasoline/alcohol lack the lubricity of diesel fuel and will cause fuel system failure.
- 10033139Ford trucks: on some trucks equipped with a 6.4L diesel engine, with less than 5000 miles, may exhibit diagnostic trouble codes p0404 and/or p1335. This may be due to weld slag/debris, from turbo up-pipe manufacturing process, being stuck in the egr valve and preventing it from seating properly. Models f super duty-f250-f550.
- 10029024Ford service campaign: see document search button for owner letter. Vehicles fuel injector o rings can prematurely wear. As a result, fuel may leak into crankcase causing oil level to rise. High oil levels can cause drivability concerns and ultimately lead to engine damage. Csc letter was received. Updated 12/08/09. Csc letter was rec'd.
Every Ford F-250 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.