2012 Jeep Compass
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Jeep › Compass › 2012
These records cover every 2012 Jeep Compass. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2012 Jeep Compass. Newest first.
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of…
Risk and remedy
Risk
If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy
Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.
Risk and remedy
Risk
In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.
Remedy
Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.
Chrysler Group LLC (Chrysler) is recalling certain model year 2012 Jeep Patriot and Compass vehicles manufactured October 18, 2011, through May 7, 2012. Due to an incorrectly manufactured transfer tube, the transfer of fuel from the secondary side to the primary side of the fuel tank may be interrupted, causing the engine to stall.
Risk and remedy
Risk
If the engine stalls while driving it may increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will replace the fuel tank transfer tube free of charge. An interim letter was mailed to owners on May 30, 2013. Owners were notified by Chrysler on July 19, 2013, that parts are now available. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is N17.
Chrysler IS recalling certain model year 2012 jeep patriot and compass vehicles manufactured from december 17, 2011, through january 2, 2012. some vehicles may have been built with a fuel tank assembly containing a damaged roll-over valve.
Risk and remedy
Risk
In the event of an impact or roll-over, fuel leakage could occur, increasing the risk of a fire.
Remedy
Chrysler will notify owners, and dealers will replace the fuel tank, free of charge. the safety recall IS expected to begin on or about may 25, 2012. owners may contact chrysler at 1-800-853-1403.
Owner complaints
184 complaints3 involved a crash5 involved a fire2 injuries1 deaths
What owners report most
Latest complaints
- Structure › Body · Suspension
2012 Jeep Compass has excessive rust and corrosion from the frame to the chassis. Vehicle has 69,000 miles on it and after each snow storm undercarriage was washed. I was told this vehicle is now unsafe and I need to purchase a new car. I really do like my Jeep Compass, is there any remedy to…
2012 Jeep Compass has excessive rust and corrosion from the frame to the chassis. Vehicle has 69,000 miles on it and after each snow storm undercarriage was washed. I was told this vehicle is now unsafe and I need to purchase a new car. I really do like my Jeep Compass, is there any remedy to this situation. I have the report in a email sent to me and can send the report to you if I have an email address to send it to.
- Fuel system, gasoline
The contact owns a 2012 Jeep Compass. While the contact's daughter was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the engine seized. No warning lights were illuminated. The contact stated that the failure…
The contact owns a 2012 Jeep Compass. While the contact's daughter was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the engine seized. No warning lights were illuminated. The contact stated that the failure occurred in the middle of the road. The vehicle was pushed to the shoulder of the roadway. The contact stated that while attempting to restart the vehicle, the vehicle failed to restart. The vehicle was jumpstarted and driven to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. In addition, the contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 109,000.
- Fuel system, gasoline
The contact owns a 2012 Jeep Compass. The contact stated that while attempting to refuel the vehicle, the contact was unable to pump more than one gallon at a time. The contact had taken the vehicle to a local dealer, who diagnosed the vehicle and determined that the roll-over valve was defective…
The contact owns a 2012 Jeep Compass. The contact stated that while attempting to refuel the vehicle, the contact was unable to pump more than one gallon at a time. The contact had taken the vehicle to a local dealer, who diagnosed the vehicle and determined that the roll-over valve was defective and needed to be replaced. The contact was made aware of NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 63,000.
- Fuel/propulsion system
When I attempt to fuel the car, the gas pump immediately shuts off regardless of the gas station or the pump that I am at. The gas also seemed to not want to go into the tank, as I could see some of the gas leaking out around the rim of the tank even though it was empty when I began to fuel.
- Engine · Fuel/propulsion system · Unknown or other
I have had problems with a hitch or pause in the acceleration of my 2012 Jeep Compass since at least April of last year. I purchased the vehicle used in January 2021. In and of itself, the hitch would be a minor thing, but I think it's related to other problems I'm having with the vehicle losing…
I have had problems with a hitch or pause in the acceleration of my 2012 Jeep Compass since at least April of last year. I purchased the vehicle used in January 2021. In and of itself, the hitch would be a minor thing, but I think it's related to other problems I'm having with the vehicle losing acceleration, which has become a real point of concern. This has occurred multiple times when I start accelerating from a stop, such as when I'm at an intersection. The car loses acceleration, the traction control light sometimes will come on, the steering will tighten up like I've lost power steering, and the car will come to a halt and stop idling. Nothing happens when I give it gas after it's stopped in these circumstances. I learned that if I turn the car off and back on, that will serve as a sort of reset, and I regain power and can get back on the road. The car has had active codes for a catalytic converter and a crankshaft position sensor. I replaced the crankshaft position sensor in April of last year (with an OEM sensor) after losing power while merging onto an interstate. That seemed to resolve the loss of acceleration problem, but it recurred starting in December of last year. I replaced the crankshaft position sensor again recently, this time with an aftermarket sensor, as I thought the sensor I put in previously may have been defective, but the problem has started occurring more frequently. Losing power while turning into or crossing intersections is a scary thing, and I've begun to feel I cannot drive the car safely. I've read accounts online of many Jeep Compass owners having problems with losing acceleration, and I've begun to suspect that the problem is not simply related to the parts associated with the active codes. The sad thing is that I just finished paying off the loan I took out for this car, and I have little extra money. I don't know what I'm going to do. Please investigate these vehicles (problem affects various Compass model years).
- Fuel system, gasoline
The contact owns a 2012 Jeep Compass. The contact stated that while refueling the vehicle, the nozzle kicked off and shut down. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline). The vehicle was…
The contact owns a 2012 Jeep Compass. The contact stated that while refueling the vehicle, the nozzle kicked off and shut down. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline). The vehicle was taken to an independent mechanic who determined the failure was due to the fuel tank rollover valve being defective. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 63,176.
- Steering · Structure
The contact owns a 2012 Jeep Compass. The contact stated while driving 65 MPH, the steering wheel became difficult to turn to the right or the left. The contact stated there was no warning light illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined…
The contact owns a 2012 Jeep Compass. The contact stated while driving 65 MPH, the steering wheel became difficult to turn to the right or the left. The contact stated there was no warning light illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the front cross members were severely corroded and needed to be replaced. The dealer advised the contact that the vehicle was not safe to be driven. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 97,000.
- Engine · Fuel/propulsion system
Everytime I drive it acts as if it’s not getting sufficient fuel to the engine . Have had multiple things replaced to try and fix the problem but still not helped . Whole Engine sputters when I stop and acts as if it’s not getting any fuel to accelerate. Has almost caused a few crashes . To my surprise recalls have been made for my vehicle but says they have been repaired. I personally don’t think they have
- Fuel/propulsion system
The vehicle just went through an inspection with the dealership before being sold to me. The vehicle is stalling when making turns and driving. There are no warning lights, there is a full tank of gas, no warning of it going to happen and it just stalls. The Jeep stalled at an intersection, stalled…
The vehicle just went through an inspection with the dealership before being sold to me. The vehicle is stalling when making turns and driving. There are no warning lights, there is a full tank of gas, no warning of it going to happen and it just stalls. The Jeep stalled at an intersection, stalled driving through a parking lot and again today stalled turning from an intersection. It almost caused me to get rear ended in an accident. Luckily they did not but that was scary enough for me to check for recalls and to my surprise there is for my year and type but not my VIN, my vehicle was manufactured April 2012, does not have high miles and should not be having these issues.
- Fuel/propulsion system · Unknown or other
My Coils had to be replaced several times. Last week I started to drive my car on a major road, shaking and no power. My car had to be towed once again. My mechanic told me the Jeeps have issues with the Coils. Not sure why this keeps happening but now It's scary to drive my vehicle and not…
My Coils had to be replaced several times. Last week I started to drive my car on a major road, shaking and no power. My car had to be towed once again. My mechanic told me the Jeeps have issues with the Coils. Not sure why this keeps happening but now It's scary to drive my vehicle and not knowing how quick this happens again. Recently my check engine light came on and off, changed the fuel gas cap, and had a code read. My mechanic mentioned that there was a safety recall regarding the manifold ? if so was this ever done and where I would like documents provided. Please respond Via email [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Fuel/propulsion system · Suspension
The catalytic converter is failing on this vehicle. The vehicle had been maintained pre manufacturer specifications. Check engine light came on without warning. Crank shaft and cam shaft sensor both Failed on vehicle and had to be replaced. All bearing had to be replaced. Two of which were fixed before 60,000 miles. Hood rusted completely through. Cross members are rusting through.
- Fuel system, gasoline
The contact's daughter-in-law owns a 2012 Jeep Compass. The contact stated that an additional 20-30 minutes was needed to fill the fuel tank while refueling. The vehicle was initially taken to an independent mechanic and was diagnosed, and it was determined that the roll-over valve was damaged. The…
The contact's daughter-in-law owns a 2012 Jeep Compass. The contact stated that an additional 20-30 minutes was needed to fill the fuel tank while refueling. The vehicle was initially taken to an independent mechanic and was diagnosed, and it was determined that the roll-over valve was damaged. The failure was linked to NHTSA Campaign Number: 12V142000 (Fuel System, Gasoline). The vehicle was then taken to a dealer where the contact was informed that the vehicle was not included in the recall. The dealer later referred the contact to the NHTSA Hotline for additional assistance. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 44,000.
- Electrical system · Unknown or other
I’m in Bradley, Illinois, and after the first snowfall, these indicators lit up. The ABS, the ESC, and the 4WD. I thought because of inclement weather, they would go off, but have remained lit for a couple of weeks now. One day, while driving to work, the throttle lagged, and I couldn’t accelerate…
I’m in Bradley, Illinois, and after the first snowfall, these indicators lit up. The ABS, the ESC, and the 4WD. I thought because of inclement weather, they would go off, but have remained lit for a couple of weeks now. One day, while driving to work, the throttle lagged, and I couldn’t accelerate past 20 mph for over 10 minutes amidst heavy traffic. When this occurred, the ABS light turned off, then suddenly lit up again, and the truck sped up. This has happened several times. I was told all recalls were repaired, so I am wondering if this is a new concern? Please advise. Thank you for your help and time.
- Air bags
- The passenger headrest of my 2012 Jeep Compass Limited deployed while the car was in motion on the highway with no reason to deploy. Yes, the component is available for inspection. - This created a distraction to the driver that could have resulted in an accident and also could have injured the…
- The passenger headrest of my 2012 Jeep Compass Limited deployed while the car was in motion on the highway with no reason to deploy. Yes, the component is available for inspection. - This created a distraction to the driver that could have resulted in an accident and also could have injured the passenger. - The dealer mentioned that the issue has happened to other cars, but in my case they could not help me because my car is not under warranty. They told me they could not assist and requested I call Jeep Customer Care. - Jeep Customer Care replied ""We have review the information on your case and sadly found that we are unable to offer any assistance with the head restraint repair." - The vehicle component has not been inspected. - No warning lights, messages or symptoms of the problem
- Suspension
The rear suspension crossmember and suspension control arm rotted out on my 2012 Jeep Compass. Also, cross member cracked. Two repair shops inspected the damage and told me that I should be very careful driving the vehicle to get it repaired because there wasn't much hold the rear wheel on. They…
The rear suspension crossmember and suspension control arm rotted out on my 2012 Jeep Compass. Also, cross member cracked. Two repair shops inspected the damage and told me that I should be very careful driving the vehicle to get it repaired because there wasn't much hold the rear wheel on. They both said that the problem cause cause a catastrophic failure, which would lead to the rear wheel falling off. At highway speeds this might cause a serious accident. Both repair shops also said they have seen a lot of Jeeps with this type of rust damage. The steel used for the components must have been inferior or the factory rust protection on these components was inadequate. There are probably thousands of older jeep models (Compass, Patriot, etc.) driving around in a dangerous condition. The only warning that I got was a slight squeaking noise when I went over bumps. The sound would be fairly normal for an eleven year old vehicle. But, I decided to get under the car and spray some liquid lubricant to try to eliminate the squeak. The crack in the crossmember was up high on the underside of the car and it was difficult to see. Luckily, I noticed that the component was entirely cracked in two pieces. The second repair shop told me that Jeep extended the warranty on the components to 10 years. This was due to the large number of similar issues reported. Although the 10 year period ran out in my case in September 2022, I still plan to contact Jeep to see if they will reimburse me for a portion of the repair. But, I believe that a recall should be issued before some Jeep owner is seriously injured due to this problem. The repair cost is in the thousands of dollars. I have attached a photo showing the crack in the crossmember.
- Seats
The passenger active restraint headrest exploded spontaneously. The vehicle was not in any accident. I happen to notice one morning that the headrest was deployed due to no known issue. Appears this has happened to numerous other people and not sure why this make/model issue has not come under a manufacturers safety recall.
- Seat belts · Unknown or other
Brake light in dash would come on and off then go out for a day or so and then will stay on all the time. Also seatbelt light IS on and wont go off.
- Forward collision avoidance › Automatic emergency braking · Unknown or other
My car caught a fire while in the parking while sitting in an parking lot.
- Structure › Frame and members
The contact owns a 2012 Jeep Compass. The contact stated while having a routine check on the vehicle by an independent mechanic, the mechanic stated that the front and rear subframe of the vehicle was extremely rusted. The vehicle was taken to the dealer and the dealer replaced the crossmember of…
The contact owns a 2012 Jeep Compass. The contact stated while having a routine check on the vehicle by an independent mechanic, the mechanic stated that the front and rear subframe of the vehicle was extremely rusted. The vehicle was taken to the dealer and the dealer replaced the crossmember of the front and rear subframe. The manufacturer was contacted, and the manufacturer stated that the extended warranty had expired. The failure mileage was 63,513. The contact stated that the vehicle has been repaired.
- Engine
This vehicle has shut down while on the street & on the dangerous highway with vehicles behind me. It wouldn’t start back up either I had to keep playing with the key or try starting it & it wouldn’t turn over
- Suspension
The contact owns a 2012 Jeep Compass. The contact stated upon taking the vehicle to an independent mechanic for inspection prior to a road trip, he was informed that the rear cross members were severely corroded and had holes. The vehicle was then taken to the dealer where it was diagnosed that the…
The contact owns a 2012 Jeep Compass. The contact stated upon taking the vehicle to an independent mechanic for inspection prior to a road trip, he was informed that the rear cross members were severely corroded and had holes. The vehicle was then taken to the dealer where it was diagnosed that the rear cross members needed to be replaced. The dealer also informed the contact that he had to pay for a diagnostic test and the repair because the VIN was not included in TSB Number: 23-007-17. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact that the dealer could repair the vehicle under the TSB; however, the dealer declined. The failure mileage was approximately 78,000.
- Fuel/propulsion system
When driving the vehicle will hesitate then stall after refueling. Happen after almost every refueling case. Believe it is a stuck rollover valve that is allowing gas to enter vent lines and causing the stall. When accelerating the vehicle suddenly dies and there is a complete loss of all systems.…
When driving the vehicle will hesitate then stall after refueling. Happen after almost every refueling case. Believe it is a stuck rollover valve that is allowing gas to enter vent lines and causing the stall. When accelerating the vehicle suddenly dies and there is a complete loss of all systems. No power steering to help get off the side of the road. Often there are no Check Engine Lights or other warnings. Obviously if your engine suddenly dies when accelerating this can cause major safety concerns. I had this happen 3 times while trying to merge onto an interstate. Thankfully I was in the right lane and able to get off to the shoulder and avoid an accident. Have not had a mechanic verify but it is a very common problem with these vehicles and the manufacturer needs to address this.
- Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
The contact owns a 2012 Jeep Compass. The contact stated that previously there was a recall for the catalytic converter and the vehicle was repaired; however, the failure recurred. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local mechanic…
The contact owns a 2012 Jeep Compass. The contact stated that previously there was a recall for the catalytic converter and the vehicle was repaired; however, the failure recurred. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local mechanic who diagnosed a failure with the oxygen sensor and threading with the stream sensor of the catalytic converter. The sensors were replaced; however, the vehicle was taken to another dealer for the catalytic converter replacement. The manufacturer was notified of the failure. The approximate failure mileage was 146,000.
- Electrical system · Engine · Fuel/propulsion system
I've recently out of the blue developed problems with my car. For some reason it want crank ( 2), air-conditioner making popping noise as well stopped working, and it also jerks shortly after cranking ( like a hiccup. Please let me know something as quickly as possible if my vehicle has any recalls. I would highly appreciate it.
- Engine and engine cooling › Exhaust system › Emission control › Catalytic convertor
The contact owns a 2012 Jeep Compass. The contact stated while driving 35 MPH, the vehicle seized and the check engine warning light was illuminated. The contact was able to restart the vehicle and continue driving to her destination. The contact took the vehicle to an independent mechanic, where…
The contact owns a 2012 Jeep Compass. The contact stated while driving 35 MPH, the vehicle seized and the check engine warning light was illuminated. The contact was able to restart the vehicle and continue driving to her destination. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the catalytic convertor to be replaced. The vehicle was not repaired. The contact stated that the check engine warning light turned off independently but would intermittently illuminate. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 130,000.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
- Active Head Rest Inadvertent Deployment
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When…
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10248517LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
- 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10244356LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
- 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10242717Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
- 10236933wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
- 10231753Emissions recal U67 Catalytic Converter Efficiency
- 10230438Some of the above-involved vehicles may exceed NOx (Oxides of Nitrogen) emission level standards due to loss of catalytic converter efficiency
- 10230180Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
- 10229998KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
- 10229936RBZ Or RHB Radio Software Enhancements
- 10229935RBZ Or RHB Radio Software Enhancements
- 10229919Low Frequency Moan Noise Heard During First Brake Apply This bulletin involves installing an anti-vibration bracket to the rear brake caliper. A low frequency moan noise is heard during the first brake apply when in reverse, while the vehicle is cold or has been parked for several hours.An audio sound file of the moan noise can be found in DealerCONNECT> TechCONNECT under: Service Info> 05 - Brakes> 05 - Brakes, Base> Diagnosis and Testing.If the low frequency moan noise can be verified, the addition of the anti-vibration bracket may correct the condition.
- 10229871Dielectric Grease This product is no longer approved for use on ignition coil and spark plug boots. Current plug boot material(silicone) is not compatible with this grease and can cause deterioration over time.
- 10229825RHW RHP Radio Software Enhancements
- 10229572Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10228020Customer Satisfaction Notification V51 Reprogram Powertrain Control Module
- 10227983If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
- 10226273Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Codes (DTCs) have been set: **U0140 - Lost Communication With Body Control Module (TIPM).** P219A - Air-Fuel Ratio Cylinder Imbalance Bank 1. **The following software enhancements are also available: Cruise control enhancements. Engine is hard to start at temperatures -29C (-20F) for vehicles utilizing E15 fuel only.** In addition, customers may report that the vehicle has failed the emissions certification test. Upon further investigation, it may be found that the Individual Cylinder Fuel Control (ICFC) monitors are reporting as failing to the scan tool even though the monitors have actually passed.
- 10225424Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10225287Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10224861Low Frequency Moan Heard During First Brake Apply This bulletin involves installing an anti-vibration bracket to the rear brake caliper. A low frequency moan is heard during the first brake apply when in reverse while the vehicle is cold or has been parked for several hours. An audio sound file of the moan can be found in DealerCONNECT> TechCONNECT under: Service Info> 05 - Brakes> 05 - Brakes, Base> Diagnosis and Testing. If the low frequency moan can be verified, the addition of the anti-vibration bracket may correct the condition.
- 10224076Active Head Restraint (AHR) Inadvertent Deployment - X86 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on the following:The AHR is deployed on one or both front seats and will not reset.
- 10224065Warranty Bulletin D-20-18 (X86) Active Head Restraint - Select 2012-2017 Jeep Compass/Jeep Patriot (MK) and 2012 Dodge Caliber (PM) (Rev. A)
- 10224059Warranty Bulletin D-20-18 (X86) Active Head Restraint - Select 2010-2017 Jeep Compass (MK) and 2010-2012 Dodge Caliber (PM)
- 10223855Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has been resolved. Continue with repair if necessary. Also, please inform the customer not to use Rain-X in the system to avoid this issue. Please contact Chuck Hood at cell (248) 613-7591 if you have questions or need additional information. Thank you.
- 10223825Flash: Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following DTCs have been set: P0335 - Crankshaft Position Sensor Circuit. U0140 - Lost Communication With Body Control Module (TIPM). P219A - Air-Fuel Ratio Cylinder Imbalance Bank 1.The following software enhancements are also available: Engine is hard to start at temperatures -29C (-20F) for vehicles utilizing E15 fuel only. Cruise control enhancements.In addition, customers may report that the vehicle has failed the emissions certification test. Upon further investigation, it may be found that the Individual Cylinder Fuel Control (ICFC) monitors are reporting as failing to the scan tool even though the monitors have actually passed.
- 10223677This bulletin involves inspecting the front and rear crossmembers for perforation/rust through and if necessary, replacing the crossmember(s). Customers may describe a vibration at the steering wheel or may have been informed by a technician or state vehicle inspection that the front and/or rear crossmember is severely corroded.
- 10223599Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
- 10223512THROTTLE BODY For clarification, only use 68414676A$ on 2010 & earlier vehicles as supply is limited.
- 10223509TRANSMISSION, 5 Speed On replacing OE transmission 05106567A$/68042567A$ with reman transmission R8142074A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
- 10223508TRANSMISSION, 5 Speed Replacing OE transmission 05106789A$/68042789A$ with reman transmission R8142073A$ replace with new Hydraulic Clutch Tube 05273429A$ to avoid interference with shift lever
- 10223386KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
- 10223226KEY, BLANK WITH TRANSMITTER Please note that after programming the new key integrated transmitter that Lock, Unlock and Remote Start will all function as expected but the Remote Start Cancel button requires a double (2x) button press versus the original single (1x) button press to cancel the remote start function and turn the vehicle off.
- 10221594Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
- 10221150Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
- 10221097Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
- 10221088Low Frequency Moan Noise Heard During First Brake Apply This bulletin involves installing an anti-vibration bracket to the rear brake caliper. A low frequency moan noise is heard during the first brake apply when in reverse, while the vehicle is cold or has been parked for several hours.An audio sound file of the moan noise can be found in DealerCONNECT> TechCONNECT under: Service Info> 05 - Brakes> 05 - Brakes, Base> Diagnosis and Testing.If the low frequency moan noise can be verified, the addition of the anti-vibration bracket may correct the condition.
- 10220993RHR Radio Issue Description: Issue 1: While performing RHR radio reflash (software update), on rare occasions, the flash can fail to properly update the radio resulting in the radio running in Emergency IFS mode. This error condition can occur due to interrupting the software update, background radio operations interfering with the reflash process, etc. The radio will reboot, but with limited functionality ( may include but are not limited to: NAV, Voice Recognition, Bluetooth, or AUX jack are inop, no available space shown on HDD, etc.). The radio can still be properly updated by simply reinserting the software update disc and performing the reflash procedure again. To assist in the verification that the radio is running Emergency IFS perform the 1. Power on radio~ 2. Press MENU H/K~ 3. Press System Setup S/K~ 4. Press Manage HDD S/K~ 5. Press Display Available Space on HDD S/K~ 6. When running Emergency IFS, all items under Used, Available, and Capacity report as dashes Issue 2: If you are having troubles connecting a phone or a MP3 player, try removing the battery on the device and then going through the pairing/connection procedure again. If you cannot remove the battery on the device, perform a reboot. Each manufacturer has a different series of buttons to hold down to perform a reboot. If the problem still persists, try the device on another like vehicle with the same radio. If you are having the same connection issues on another like vehicle, the device may be faulty or it may not be compatible with the RHR radio. Go to www.chrysler.com/hostb/crossbrand/owners/en and click on ?Bluetooth Phone Compatibility Test Results? link for a list of phones that are compatible. For MP3 players and media storage devices, only .wma, .aac, .mp3, .sacd, .jpeg & .jpg files are supported. Remove all other file types and reevaluate the concern. Issue 3: If upgrading a vehicle from a low line radio that has factory installed UConnect
- 10220403New Safety Recall Advanced Communication ? N01060613 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2010 through 2012 model year (MK) Jeep Compass and Patriot vehicles. Some of the above vehicles were built with a software error in the Occupant Restraint Control (ORC) module. The ORC software error may result in delayed or non-deployment of seatbelt pre-tensioner or side airbag curtains involved in certain low-speed rollover events. Chrysler will conduct a voluntary safety recall on all involved vehicles to reprogram the ORC module with the corrected software. Dealers will be notified of the launch of this safety recall by way of established methods used in the past. We ask that you please take the time to ensure that your personnel are aware of this communication and are prepared to execute a customer friendly process for inquiries on involved vehicles.
Every Jeep Compass model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.