2006 Volvo XC90
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volvo › XC90 › 2006
These records cover every 2006 Volvo XC90. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
3 recalls name the 2006 Volvo XC90. Newest first.
Volvo IS recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
Risk and remedy
Risk
An overheated battery could lead to a fire.
Remedy
Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit IS affected. the unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. this service will be performed free of charge. the safety recall began on november 18, 2010. owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
On certain passenger vehicles,the outer tie rod ball joint can deform at high loads causing a loss of the clamping force and the nut may loosen, which may eventually lead to a fatigue fracture of the outer tie rod ball joint.
Risk and remedy
Risk
The driver may notice that the vehicle IS difficult to maneuver increasing the risk of a crash.
Remedy
Dealers will replace the outer ball joint tie rods with improved outer ball joint tie rods free of charge. the recall began on june 23, 2006. owners may contact volvo at 1-800-458-1552.
On certain vehicles, if the wiper arm IS activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm might slip on its driveshaft, resulting in an inability to move the wipers from the park position.
Risk and remedy
Risk
Inoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.
Remedy
Dealers will replace the wiper arms and retaining nuts. the recall began on september 5, 2006. owners may contact volvo cars at 1-800-458-1552.
Owner complaints
53 complaints4 involved a crash4 involved a fire3 injuries
What owners report most
Latest complaints
- Electrical system
Had to replace emission coil plugs.My mechanics said it has wiring issues
- Electrical system · Exterior lighting · Suspension
Vehicle is slightly off-balance no matter if I do an alignment ball joints seem to always get affected. I’m not sure if the hydraulics are working correctly. Yesterday I just started leaking antifreeze fluid.
- Electrical system
Awakened to lights flashing, horn going off, wipers running on a vehicle that was parked with keys removed. The cem underneath driver's side dash had gotten wet from rain water leaking into it and subsequently shorted out requiring $2350 replacement via dealer. This IS A Huge problem....…
Awakened to lights flashing, horn going off, wipers running on a vehicle that was parked with keys removed. The cem underneath driver's side dash had gotten wet from rain water leaking into it and subsequently shorted out requiring $2350 replacement via dealer. This IS A Huge problem.... however, and wait for it. IT IS NOT DUE TO THE SUNROOF.... I know this with absolute certainty because I have 3 2006-2010 xc90's and NONE HAVE SUNROOFS but all 3 had to have CEM reprogrammed. I can't understand why NOTHING has been done about this... it's absurd.
- Unknown or other
The tensioner pulley for the serpentine belt seized up while traveling at 70 mph, melting the serpentine belt and causing an engine fire.
- Vehicle speed control
The contact owned a 2006 Volvo XC90. The contact stated that while depressing the brake pedal to park the vehicle when the vehicle's RPMs revved up causing the vehicle to unintentionally accelerate and crash into the wall in front. The air bags did not deploy. After the crash occurred, the low…
The contact owned a 2006 Volvo XC90. The contact stated that while depressing the brake pedal to park the vehicle when the vehicle's RPMs revved up causing the vehicle to unintentionally accelerate and crash into the wall in front. The air bags did not deploy. After the crash occurred, the low coolant warning light failed. A police report was filed. The contact sustained injuries to their scrotum and rib area. The contact was a physician and therefore provided their own medical care. The vehicle was towed and deemed totaled. The contact stated their insurance diagnosed that the vehicle experienced sudden acceleration. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000
- Engine
This has happened multiple times on the highway going 60 mph. And at slow speeds, last time on an entrance ramp onto the highway. The vehicle will shut off, as if the key has been turned off. But it hasn't been touched. Steering becomes difficult and I have to try and get off the road. Once I…
This has happened multiple times on the highway going 60 mph. And at slow speeds, last time on an entrance ramp onto the highway. The vehicle will shut off, as if the key has been turned off. But it hasn't been touched. Steering becomes difficult and I have to try and get off the road. Once I get pulled over and put it in park, it will start and run normally for a time. It most often happens when i turn to the right fairly tight. But not exclusively. Today after driving it approximately 120 miles with one shut off, my check engine light came on and it was difficult to get started again. This is absolutely a Hazzard to others and myself
- Firerelated
The contact owns a 2006 Volvo XC90. The contact stated while attempting to turn around, he saw a warning message transmission overheating message and the vehicle shut off. After an unknown amount of time, the vehicle was started up again and proceeded to fill the cabin with smoke and within 5…
The contact owns a 2006 Volvo XC90. The contact stated while attempting to turn around, he saw a warning message transmission overheating message and the vehicle shut off. After an unknown amount of time, the vehicle was started up again and proceeded to fill the cabin with smoke and within 5 minutes the entire vehicle was on fire. The vehicle was extinguished on its own and a report was not taken. The contact sustained injuries to the lungs and burns to the face. The vehicle was not towed away. The manufacturer was not informed of the failure. The failure mileage was approximately 190,000. The VIN was not available.
- Electrical system · Seats
the drivers side electric seat controls are causing unsafe driving conditions. i drive with the seat all the way back and down. I have the memory sets all for that position. Problem is when I get back in the car it will be back up and forward al the way. So i will set it back down. Well while ia…
the drivers side electric seat controls are causing unsafe driving conditions. i drive with the seat all the way back and down. I have the memory sets all for that position. Problem is when I get back in the car it will be back up and forward al the way. So i will set it back down. Well while ia m driving it will automatically start raising back up and forward. As you can imagine this gets very uncomfortable and feels like i am getting choked to death. I will set it back and it will keep doing that . I will hear clicking and then it will start moving. sometimes. i will have to hold my finger on the down button to keep it from moving on me while im driving, sometimes it will still move all the way up while i am holding the button down. and then it will get all the way forward and the buttons will not work for me for a while. Im stuck in the forward up position choking and cant do anything about it. Eventually they will start working again nut its a very impossible position to be left in. I don't know why it is doing this. I feel like I have a Christine car(from the movie) . I haven't taken it anywhere and not sure where to go. I feel like the dealer would try to hide the problem.
- Engine
The contact owns a 2006 Volvo XC90. The contact stated there was an abnormal odor of fuel detected in the vehicle. The local dealer was contacted however, the vehicle was not diagnosed or repaired. The manufacturer was notified however, no further assistance was provided. The failure mileage was…
The contact owns a 2006 Volvo XC90. The contact stated there was an abnormal odor of fuel detected in the vehicle. The local dealer was contacted however, the vehicle was not diagnosed or repaired. The manufacturer was notified however, no further assistance was provided. The failure mileage was approximately 160,000. The contact stated the failure was similar to NHTSA Campaign number 09V483000 (Fuel System, Gasoline).
- Fuel system, gasoline · Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
TL* the contact owns a 2006 volvo XC90. The contact stated that the vehicle was leaking fuel from the fuel pump assembly. The contact stated no warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the fuel filter and fuel…
TL* the contact owns a 2006 volvo XC90. The contact stated that the vehicle was leaking fuel from the fuel pump assembly. The contact stated no warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the fuel filter and fuel line needed to be replaced. The vehicle was not yet repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 244,777.
- Engine
TL* the contact owns a 2006 volvo XC90. The contact stated that while driving at various speeds, an abnormal popping sound emitted from the vehicle. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact…
TL* the contact owns a 2006 volvo XC90. The contact stated that while driving at various speeds, an abnormal popping sound emitted from the vehicle. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to a worn suspension mount. Additionally, the mechanic also diagnosed the vehicle with a defective boost pressure sensor, a defective mass air flow sensor, and a defective vanos sensor which needed to be replaced. Neither the dealer nor the manufacturer were notified of the failure. The vehicle was not repaired. The failure mileage was 175,000.
- Electrical system · Fuel/propulsion system · Structure › Body
Water leaking from an unknown place gathering in passenger side floor ! causing many electrical problems! Vehicle was in idol and cut off will not restart leaving my young daughter and I stranded! While investigating and removing carpet came to realize they were 30 gallons of water under carpet!!…
Water leaking from an unknown place gathering in passenger side floor ! causing many electrical problems! Vehicle was in idol and cut off will not restart leaving my young daughter and I stranded! While investigating and removing carpet came to realize they were 30 gallons of water under carpet!! Looking into it more online noticed many many many others have expressed this same problem! Why IS not an important issue to volvo to want to fix this problem?? Why wasn't this problem issued for recall???? Does son have to die of physically harmed for their to be a recall for this ongoing problem
- Electrical system · Steering · Suspension
TL* the contact owns a 2006 volvo XC90. While driving various speeds, the vehicle would pull to the right. The vehicle was taken to crippen volvo (8300 w. Saginaw hwy, lansing, mi), but the failure could not be duplicated. Approximately one month later, while driving 70 mph, the vehicle suddenly…
TL* the contact owns a 2006 volvo XC90. While driving various speeds, the vehicle would pull to the right. The vehicle was taken to crippen volvo (8300 w. Saginaw hwy, lansing, mi), but the failure could not be duplicated. Approximately one month later, while driving 70 mph, the vehicle suddenly pulled hard to the right and the driver nearly lost control of the steering. After stopping the vehicle, it was discovered that the front passenger side tie rod ball joint failed and the wheels were not properly positioned. The vehicle was towed to an unknown dealer and the tie rod was damaged. The contact indicated that the vin was not included in nhtsa campaign number: 06v155000 (steering) although the vehicle experienced the same failure listed in the recall. Also, on several occasions, the vehicle could not be immediately started. While driving various speeds, the vehicle would suddenly shut off and caused the power steering and power brakes to become inoperable. The cause of the failures was not determined. The manufacturer was not notified of the failures. The failure mileage was 130,000. *Tt*jb
- Steering · Wheels
TL* the contact owns a 2006 volvo XC90. While driving approximately 50 mph, the front end of the vehicle shook uncontrollably. The failure recurred numerous times. The vehicle was taken to a mechanic and the steering column was replaced. The failure recurred. The vehicle was not repaired. The…
TL* the contact owns a 2006 volvo XC90. While driving approximately 50 mph, the front end of the vehicle shook uncontrollably. The failure recurred numerous times. The vehicle was taken to a mechanic and the steering column was replaced. The failure recurred. The vehicle was not repaired. The manufacturer was not notified. The vin was not included in nhtsa campaign number: 06v155000 (steering). The approximate failure mileage was 70,000.
- Engine
TL* the contact owns a 2006 volvo XC90. While driving 55 mph, the vehicle stalled without warning. The vehicle was able to restart. The failure recurred intermittently. The vehicle was taken to a dealer where it was diagnosed, but the cause of the failure was not found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The vin was unknown. The failure mileage was 115,000.
- Electrical system · Structure › Body · Unknown or other
Fire started in rear near battery compartment. Within seconds, it exploded.
- Fuel/propulsion system
TL* the contact owns a 2006 volvo XC90. The contact stated that fuel was leaking from the fuel pump and there was an abnormal fuel odor inside the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was 132,330.
- Unknown or other
I smell gas in my car now its leaking gasoline. When I pull in driveway I see gas leaking from bottom.
- Power train
Have researched this car after I bought it used from a small dealership and seems like a large problem with all types of volvo's. I had my car for a couple days, shop noticed there was an oil leak. Turned out to be the rear main seal. Dealership would not fix it even though it was within warranty.…
Have researched this car after I bought it used from a small dealership and seems like a large problem with all types of volvo's. I had my car for a couple days, shop noticed there was an oil leak. Turned out to be the rear main seal. Dealership would not fix it even though it was within warranty. Saved up for 2 months straight to pay $1100 cash out of pocket to get it fixed by my personal mechanic. Right before I took it in to get the work done, the transmission was shifting hard while driving in city. Highway it was fine. Had the seal replaced, transmission flushed before putting back together thinking it would solve problem. Nope! So I saved up once again to go to the actual volvo dealership and pay $200 out of pocket for a reflash ed and software update on the transmission. Didn't work! Looked up other possible problems that could be causing transmission to shift weird...numerous complaints online about other petes volvo's doing the same thing! So why hasn't volvo done a recall on this transmission? It's a matter of time before I myself or someone else IS driving and the thing slams into park or any other gear and cause an accident. I'm scared to drive my own car and I'm to the point where I can't dump anymore money into it and have to trade it in for a different car. please help and make volvo recall the transmissions before myself or my husband and 2 kids die because of their negligence!!
- Unknown or other
For the second time in 6 months, the vehicle lost all power without warning while in transit. yesterday, it occurred on a major highway at 60 mph. the car died without warning with resultant loss of power stearing, breaking, dash, etc. we were able to coast into a breakdown lane, but it could…
For the second time in 6 months, the vehicle lost all power without warning while in transit. yesterday, it occurred on a major highway at 60 mph. the car died without warning with resultant loss of power stearing, breaking, dash, etc. we were able to coast into a breakdown lane, but it could have been disasterous. state police arrived within minutes of dialing 911. this happened 6 months ago as well and the dealership replaced a fuel injector module. the internet IS repleat with very similar issues involving this model and vintage. the common response from volvo dealers seems to be that it IS an "act of god". this IS a defect, not an act of god, and these vehicles should be recalled. it IS only a matter of time before there will be major injuries or deaths as a result of the defect.
- Suspension
I have had multiple issues with the suspension of this car in the past two years.- up until recently, these were the only problems I had with the car. first the strut engine mount brace and torque rods needed replacing, then at 155,000 I needed to have the front ball joint,control arms and…
I have had multiple issues with the suspension of this car in the past two years.- up until recently, these were the only problems I had with the car. first the strut engine mount brace and torque rods needed replacing, then at 155,000 I needed to have the front ball joint,control arms and bushings replaced. at 158,000 I had to replace the right rear knuckle and wheel bearings. now at 189,000 I have a problem with my outer tie rods. I had just thought these were expected wear and tear for a high mileage vehicle, but I saw that there had been recalls for failures of these parts in some versions of my car. I checked with volvo and they claimed that my vin was not included in these recalls. but I do find it suspicious that I now am having the same issues that so many "other versions" of my model and year vehicle had. should my car have been included in the recalls? how do they determine which ones have a problem and which ones do not? thanks *tr
- Engine
Without any warning, the motor suddenly dropped from 60-65 mph to 35-40 and would not accelerate beyond this- I got a warning message after this happened "reduced engine performance". research on this later told me that this was "limp mode." I was on an expressway and other vehicles around…
Without any warning, the motor suddenly dropped from 60-65 mph to 35-40 and would not accelerate beyond this- I got a warning message after this happened "reduced engine performance". research on this later told me that this was "limp mode." I was on an expressway and other vehicles around me, including many large semi trucks, were driving at high speeds. fortunately, I had just come out of a toll plaza and was in the right lane so I was able to get out of the way quickly enough to avoid a collision. I had to have the car towed since it was not safe to continue to drive at such a slow speed and I was far from a suitable exit. my repair shop identified a problem with the throttle body and the pcv (valve) I see on research of earlier models of this car that there had been an "warranty extension" for this very problem. my car apparently was not included on this extension, but I find it suspect that I had the same problem. there may not be that many reports of problems like this with my particular model year because a large number of the 2006 xc90s had early transmission failures and are no longer being used. *tr
- Electrical system › Ignition › Switch
This IS then second time the ignition switch on my 2006 volvo XC 90 has failed. the original was replaced with a new switch and now that replacement switch has also failed. this should not be a part that fails twice in 7 years. *tr
- Seat belts
I entered the car and attempted to put on the driver's seat belt. it would not release from its housing (inside the panel above my left shoulder). it made a strong clicking noise, as if it had locked up. I made numerous other attempts to put on my seat belt, with the engine turned on, turned…
I entered the car and attempted to put on the driver's seat belt. it would not release from its housing (inside the panel above my left shoulder). it made a strong clicking noise, as if it had locked up. I made numerous other attempts to put on my seat belt, with the engine turned on, turned off, car in park, car in drive, car moving. no change. I feel this IS a serious safety issue. when I called volvo, they told me that seatbelts were only covered under a 5 year warranty. I would expect seatbelts to have mandatory lifetime warranties, required by law. I am surprised to find that this IS not the case. *tr
- Service brakes
While going approximately 35 mph and in a slight turn (very mild curve), traffic in front of me slowed. I moved my foot to the brake and the brake pedal was "hard" and the brakes did not work. I let off the brake and put my foot back on the pedal again, very firmly. the ABS immediately kicked…
While going approximately 35 mph and in a slight turn (very mild curve), traffic in front of me slowed. I moved my foot to the brake and the brake pedal was "hard" and the brakes did not work. I let off the brake and put my foot back on the pedal again, very firmly. the ABS immediately kicked in. had traffic not started to speed up, I would have rear-ended the car in front of me. Not fun, volvo. when you press the brakes, you expect them to actually work. no error messages were on for the brake system or any other error messages at all. the brakes just didn't work. *tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11007925Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
- 10249191This is a Technical Journal: 12V Battery Testing Method
- 10241661Complimentary upgrade c00009 description.
- 10241651Rubber cushion
- 10219421Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
- 10213885The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
- 10213883ICUP/Google Built-In Diagnostic Operations
- 10213882Battery Charger/maintainer requirement
- 10212892Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- 10212891VIDA QR Scanner Mobile App
- 10205670XC90 Noise/Squeal from rear brakes
- 10202436New Software Products (SP) have been developed to convert a Care Key to a standard key.
- 10197371This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form
- 10188881Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. By setting clear performance expectations and parameters and assisting retailers in focusing on individual processes and procedures, all retailers are provided with adequate tools to help achieve the ultimate goal of qualifying for self-authorization status.
- 10182494This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form
- 10182493This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form
- 10181041Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10179681This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
- 10173760This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
- 10171688This is a Technical Journal: 4 Cylinder VEP engine: Castrol Edge Professional V 0W-20 Synthetic oil.
- 10171676Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10170147Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
- 10169394This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
- 10169393This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
- 10169391Software Installation Policy changes.
- 10169389This is a Service Manager Bulletin: Technician Skillset Requirments
- 10169388This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other vehicles.The attached checklists can be used for restoring customer settings, where applicable.
- 10169036Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
- 10169030This is a Technical Journal: Oil in cooling system. New cleaning method developed.
- 10169021Service Manager Bulletin TITLE : Service Action Notification Re - Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 - 323 and SMB00 - 323A YEAR MONTH DAY SERVICE SERVICE WARRANTY 2013 02 15 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 1 Volvo monitors completion rates for all service actions and will complete notification re - mails to vehicle owners when necessary . Listed below are the latest notification re - mails . Please refer to SMB 00 - 323 and SMB 00 - 323A for information on how and where to find the related Service Action documents in VRC2 and TIE . FEBRUARY RE - MAILS Action Description # of Re - Mails Service Campaign 236 Washer Reservoir Sensor Canada ? 295 Recall 129 Brake Vacuum Pump U.S . ? 3,430 Recall 245 Replace Fuel Lines U.S . ? 48 MARCH RE - MAILS Action Description # of Re - Mails Recall 246 Inspect P / S Return Hose U.S . ? 1,367 Recall 246 Inspect P / S Return Hose Canada ? 95 Recall 251 Inspect Underbody Coating Canada ? 54 Recall 255 TCM Software Upgrade U.S . ? 499 Recall 256 TPMS Warning Message U.S . ? 123 Please be prepared to accommodate vehicle owners that may contact you regarding these actions . ? Fixed Right ? First Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2013 VOLVO CARS OF NORTH AMERICA , LLC
- 10168247VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer - to - Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 337 REFERENCE BULLETINS : DATE : YEAR MONTH DAY SERVICE SERVICE WARRANTY 2015 01 19 MANAGER WRITER ADMINISTRATOR Service Personnel : Read and initial Page 1 of 17 ? Right first time in Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . 2015 VOLVO CARS OF NORTH AMERICA , LLC Service Manager Bulletin 00 - 337 Page 2 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 3 of 17 Service Manager Bulletin 00 - 337 Page 4 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 5 of 17 Service Manager Bulletin 00 - 337 Page 6 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 7 of 17 Service Manager Bulletin 00 - 337 Page 8 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 9 of 17 Service Manager Bulletin 00 - 337 Page 10 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 11 of 17 Service Manager Bulletin 00 - 337 Page 12 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 13 of 17 Service Manager Bulletin 00 - 337 Page 14 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 15 of 17 Service Manager Bulletin 00 - 337 Page 16 of 17 2015 - 01 - 19 Service Manager Bulletin 00 - 337 2015 - 01 - 19 Page 17 of 17
- 10167953Software Installation Policy changes.
- 10167952Descripition of Goodwill Policy and Guidelines.
- 10167915Dice Tool bulletin explaining the offer.
- 10167909Please return stock of 31430070 service kit to your servicing distribution center.
- 10167907This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017
- 10167901This is a Technical Journal: Replacing CEM or Recommunicating with a 'sleeping' vehicle
- 10167895This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other vehicles.The attached checklists can be used for restoring customer settings, where applicable.
- 10167887Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes active. The advantage of using the EFF function is that error frames are usually transmitted on the network before a vehicle symptom can occur. Hence, if the fault is very intermittent in nature, it may be possible, for example, to induce the wiring fault for a short duration by manipulating the vehicle harnesses and connectors. The electrical fault will occur and be detected by the EFF without ever having a vehicle symptom appear. The instructions for setting up the tool have been simplified.
- 10167872This is a Service Manager Bulletin: Service Scheduling system enhancements. Improving Service Action/Recall scheduling.
Every Volvo XC90 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.