2022 Volvo XC90
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Volvo › XC90 › 2022
These records cover every 2022 Volvo XC90. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2022 Volvo XC90. Newest first.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Risk and remedy
Risk
A short circuit in a high-voltage battery increases the risk of a fire.
Remedy
Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Risk and remedy
Risk
An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy
Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Risk and remedy
Risk
A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy
Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Risk and remedy
Risk
The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Remedy
Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
Owner complaints
31 complaints1 involved a fire
What owners report most
Latest complaints
- Fuel/propulsion system
I own a 2022 Volvo XC90 Recharge T8 plug-in hybrid. An authorized Volvo dealer diagnosed an internal fault in high-voltage battery Cell Module E. According to the technician's written report, diagnostic code BECM-P0BBE62 was present. The technician ran the Cell Module component test through…
I own a 2022 Volvo XC90 Recharge T8 plug-in hybrid. An authorized Volvo dealer diagnosed an internal fault in high-voltage battery Cell Module E. According to the technician's written report, diagnostic code BECM-P0BBE62 was present. The technician ran the Cell Module component test through Volvo's VIDA diagnostic system, which returned a “fault found” status for Cell Module E. The technician recommended replacing the faulty module. The replacement part is on back order, and I have been advised that obtaining battery modules into the United States is a known supply bottleneck that could delay repairs for several months. Volvo has confirmed that the repair is covered under warranty, but the vehicle remains unrepaired while I wait for the part. Of particular concern, the technician documented that the vehicle would not start when they attempted to move it into a parking space. The technician noted that this failure may or may not occur again. This creates uncertainty about the vehicle's ability to start and operate reliably. The vehicle previously displayed a “Propulsion System Service Required” warning. Although the vehicle had reportedly behaved normally during earlier driving, the subsequent diagnostic findings and failure to start raise concerns about the reliability and safe operation of the high-voltage propulsion system. I am concerned about: The high-voltage battery cell module failure and the possibility of a recurrence or additional battery faults. The vehicle's documented failure to start. The potentially prolonged period during which the vehicle cannot be repaired because the replacement module is unavailable. Whether similar failures and parts delays are affecting other Volvo plug-in hybrid vehicles. I request that NHTSA review this report alongside similar complaints to determine whether there is a broader safety-related defect or pattern involving high-voltage battery cell modules in affected Volvo plug-in hybrid vehicles, and whether further
- Back over prevention › Warnings · Electrical system · Visibility/wiper
My 2022 Volvo XC90 (VIN: [XXX]) has a recurring failure of the center touchscreen display, which controls the climate system. Almost daily, the display shuts off while I’m driving and does not reboot. When it fails, I cannot use the heat, the windshield defroster, or the defogger. As cold weather…
My 2022 Volvo XC90 (VIN: [XXX]) has a recurring failure of the center touchscreen display, which controls the climate system. Almost daily, the display shuts off while I’m driving and does not reboot. When it fails, I cannot use the heat, the windshield defroster, or the defogger. As cold weather sets in, this is a serious visibility and safety hazard. On XXX, at approximately 35,400 miles, I took the vehicle to the authorized Volvo dealership in [XXX] (repair order #XXX). I paid approximately $366 for a software reset. The repair did not fix the problem. Since then, the system crashes right after startup. It also intermittently plays loud white noise through the speakers, at random times and without warning while I’m driving. The sudden loud noise startles and distracts the driver. The dealer’s technician said he would submit a report to Volvo engineering. I have also opened a case with Volvo Car USA Customer Care. As of XXX, the vehicle has not been repaired, and the failures continue regularly. I have heard nothing back from Customer Care or the dealership despite repeated attempts to contact them respectively. Summary of hazards: Loss of windshield defrost and defog, which reduces visibility. Loss of cabin heat in winter conditions. Sudden loud audio noise that distracts the driver. A control screen that cannot be relied on while driving. I am asking NHTSA to review this as a potential safety defect affecting the center display and climate control on this model. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Engine · Fuel/propulsion system · Unknown or other
This is my 2nd Volvo xc90. Both models have turbo issues that is costly repairs. Volvo dealership also stated that turbo repairs usually are an issue in Volvo. My first Volvo was 2016 which had a turbo issue. Now my 2022 is now in shop due to turbo and oil spills on inside. There should be a recall.
- Back over prevention › Rearview system braking · Back over prevention › Sensing system › Camera · Lane departure › Blind spot detection
The electrical/infotainment display failure causes the factory rearview camera image not to display when the vehicle is shifted into reverse. The center infotainment display on my 2022 Volvo XC90 intermittently goes completely black and remains inoperable for days at a time. When the screen is…
The electrical/infotainment display failure causes the factory rearview camera image not to display when the vehicle is shifted into reverse. The center infotainment display on my 2022 Volvo XC90 intermittently goes completely black and remains inoperable for days at a time. When the screen is black, the factory rearview camera image does not display when the vehicle is shifted into reverse. All sound, including warning signals, is inoperable. Climate controls are also inaccessible through the screen, and inoperable. This has happened repeatedly: the screen goes dark for several days, returns temporarily, then goes dark again. The failure affects rear visibility during backing events and creates a safety risk because the driver cannot see the rear camera image. I brought the vehicle to a Volvo dealer. The dealer stated that the infotainment head unit must be replaced and quoted approximately $4,000 to replace it with the same non-Google system. Volvo corporate denied assistance. I believe this is a safety-related defect because the failed infotainment display disables the rearview camera function.
- Electrical system
In the middle of a cold snowstorm the screen froze and started glitching. As I was trying to change the drive mode to all wheel drive the ESC off button triggered and ESC stayed off without AWD mode and screen was unresponsive. Had to pull over and turn car off and back on for screen to reset.
- Unknown or other
There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months after the fix, the SAME issue is happening.
- Electrical system · Fuel/propulsion system · Unknown or other
My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only…
My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as required, and taken care of it as responsible vehicle owners. Beginning around June or July of 2025, I began seeing the "check engine" light, so I called the dealership where I purchased the vehicle and took it in for servicing. After a day, they said it was fixed and that it was a blown fuse or two, and it was good to go. Not even 3 weeks to a month later, the "check engine" light came on again. I called and took it back to the dealership. Same story, after less than a day they called me back after fixing something else (don't remember off the top of my head what they said it was, but it was allegedly minor). Now, about 3 days ago, Sept. of 2025, I began seeing the "check engine" light again, so for the 3rd time in less than 3 months I arranged for it to be serviced by the dealership again on 9/30. A day later, another "Propulsion System/maintenance required!!!" light came on as well, so I called to get servicing sooner because obviously the message is scary. I was told to bring it in, they would "work me in" but had no loaners I could use to get to and from work. So, at that point, I got my husband involved and now no one from the dealership is returning either of our calls, AND I'm being told there is no recall on my car, even though a simple google search reveals there is a recall on my same make/model/year SUV. I'm getting the same messages people got about the recall, so no clue why my vehicle isn't considered as part of the recall when I am having the SAME issues as the recalled vehicles are having. I am beyond frustrated and ready to dump this SUV if they are unable to properly repair it!!!!!
- Unknown or other
I park my Volvo in my driveway which has a blind exit to a pedestrian sidewalk. When I start the car and put it in D or B mode, it does not make any sound. This happens in any of the vehicle modes including "Pure" electric where the ICE is not engaged unless the battery runs out. There is no way…
I park my Volvo in my driveway which has a blind exit to a pedestrian sidewalk. When I start the car and put it in D or B mode, it does not make any sound. This happens in any of the vehicle modes including "Pure" electric where the ICE is not engaged unless the battery runs out. There is no way for oncoming pedestrians to hear the vehicle or to understand that it might pull out of the blind corner. According to the NHTSA Federal Motor Vehicle Safety Standard Number 141 "The final rule requires hybrid and electric vehicles to emit sound at minimum levels while the vehicle is stationary (although not when the vehicle is parked, i.e., when the transmission is in “park”), while in reverse, and while the vehicle is in forward motion up to 30 km/h. (sic) full compliance should be by September 1, 2020" Our 2022 XC90 T8 Recharge does not make any sound while stationary in N, D, or B tranmission modes or while in Hybrid or Pure drive modes. I see this as a serious safety issue and wanted to report it before I have an actual safety incident. Volvo claims that my vehicle is in compliance with all NHTSA safety standards. Their response is attached.
- Electrical system
The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount…
The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
- Air bags
I received an SRS airbag, service urgent, drive to workshop warning. I took the car in six times the first two times they said it was a software update and they failed to update the software the third time they updated the software. It didn’t work the fourth time they said it was the passenger seat…
I received an SRS airbag, service urgent, drive to workshop warning. I took the car in six times the first two times they said it was a software update and they failed to update the software the third time they updated the software. It didn’t work the fourth time they said it was the passenger seat and the scale wasn’t working or connecting so it was throwing off the airbag. They fixed that, it didn’t change that warning. I still got the warning. And the last time they said it was a battery issue the battery wires weren’t connecting. They fix that, but after five minutes of driving out of the dealership and a repair shop, the warning came up again.I’ve sent an email to Corporate asking for either a refund or or a new car in accordance with the lemon law of California. They want me to take it in the seventh time which I refuse to do because the car is on safe safe to drive and I have two kids that I cannot keep driving in this car.
- Electrical system
There have been three incidents where the following happens: While driving in regular suburban driving, the entire infotainment system and cluster panel (all digital--odometer, tachometer, everything) shut off entirely (go black) and the climate system also shuts off. It goes through some reset…
There have been three incidents where the following happens: While driving in regular suburban driving, the entire infotainment system and cluster panel (all digital--odometer, tachometer, everything) shut off entirely (go black) and the climate system also shuts off. It goes through some reset cycle and then eventually restarts after several seconds. Both times it has been right after pressing some button on the steering wheel that controls the infotainment or doing some operation with the infotainment system such as skipping a track or making a call. Apple Car Play has not been in use. The first time it was 4-5 months ago (2024). The second time was about 2 months ago. The third time was on June 6, 2024. This third time, while at a red light, everything went black and even the car shut off. Luckily, the car was not moving and within a couple of seconds, without touching anything or changing anything, it restarted itself and the infotainment system and cluster rebooted. I am concerned that this may eventually happen while the car is moving. Will be taken to the dealer for review/repair immediately.
- Engine and engine cooling
The contact owned a 2022 Volvo XC90. The contact stated that while driving in stop-and-go traffic, the odor of smoke was suddenly present inside the vehicle and moments later smoke was viewed coming from under the hood. The vehicle was stopped and moments after exiting the vehicle the vehicle was…
The contact owned a 2022 Volvo XC90. The contact stated that while driving in stop-and-go traffic, the odor of smoke was suddenly present inside the vehicle and moments later smoke was viewed coming from under the hood. The vehicle was stopped and moments after exiting the vehicle the vehicle was engulfed in flames. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle and property inside the vehicle were destroyed. A fire report was taken at the scene and the vehicle was towed to the local towing yard. The cause of the fire was not yet determined. The manufacturer was not yet notified of the failure. The local dealer was contacted. The failure mileage was 11,000
- Electrical system · Engine · Power train
I was going 60 mph when the check engine light came on , the car started to jerk and reduce speed. I pulled onto the shoulder until the car stopped. I than proceeded to drive slowly and the turtle appeared on the dash. I drove about another mile until I reached my home doing 30 miles per hour or less.
- Electrical system
The vehicle is equipped with wireless phone charger. I was charging my phone and could not lift it off the charger with my bare hand. According to the dealership test, their test started at 80 degrees Fahrenheit and tested after 10 minutes at 102 degrees Fahrenheit. The dealership stated that the charger is operating as designed. The phone was too hut to handle and could have caused an accident.
- Back over prevention › Warnings · Electrical system · Forward collision avoidance › Warnings
Front sensor not detecting objects when parking. First time the dealership checked it, they said it was operating as designed. The second time, while driving on the freeway, I got a blind spot sensor service required warring error on dashboard. The dealership said that there was a bug residue on the outside sensor.
- Service brakes
During cold weather, and when backing up, the vehicle makes a loud knocking noise as if an accident has occurred. This is an intermittent problem. The vehicle is equipped with Auto-hold brakes. The dealership stated that this might be the issue where the auto-hold is engaging without warring. The…
During cold weather, and when backing up, the vehicle makes a loud knocking noise as if an accident has occurred. This is an intermittent problem. The vehicle is equipped with Auto-hold brakes. The dealership stated that this might be the issue where the auto-hold is engaging without warring. The dealership tested the brakes and stated that it was operating per manufacturing specs. This issue happened several times so far since 2022. It is a scary moment when feeling as if I had hit some one or some thing.
- Electrical system
The vehicle is equipped with Park Assist Camera. It automatically activated when reverse gear is engaged. The camera is angled is a way where display screen on front dash shows about half inch of the license plate. According to the dealership, the camera could not be adjusted and it is operation according to factory specs. This is safety issue as it distract the driver.
- Engine · Fuel/propulsion system
Driving on the highway, check engine light came on followed by turtle mode and subsequent engine failure. Stranding driver with three small children on the highway. This has occurred several times, again stranding driver and three small children in the middle of nowhere at night having to await a…
Driving on the highway, check engine light came on followed by turtle mode and subsequent engine failure. Stranding driver with three small children on the highway. This has occurred several times, again stranding driver and three small children in the middle of nowhere at night having to await a tow truck and find a ride to hotel. Currently in service center for the fourth time with no apparent solution found. Volvo is not helping remedy the solution.
- Seat belts · Seats
We took our Volvo to the dealer today to address another problem with the Volvo care system. We were told it was the back up battery. The car was left at Volvo for no more than 90 minutes. Prior to leaving it with Volvo, we had a convertible car seat installed in the second row, passenger side…
We took our Volvo to the dealer today to address another problem with the Volvo care system. We were told it was the back up battery. The car was left at Volvo for no more than 90 minutes. Prior to leaving it with Volvo, we had a convertible car seat installed in the second row, passenger side seat. We have a 26-month-old who rides in it every day. Later today, we picked up our son and ran several errands and returned home tonight around 9 PM. That’s when we discovered that the car seat had been completely disconnected from the vehicle. Apparently this is done to access some component of the car for the repair that was performed. Volvo technicians apparently uninstalled the car seat, performed the repair, and then returned the car seat, uninstalled, right back in the exact spot they had taken it from. The main connection is down behind the seat, at the base, so it was not obvious that the car seat had been uninstalled. Apparently Volvo is not providing instructions to their technicians to ask permission to uninstall a car seat, or to refrain from replacing the car seat without informing drivers that it is not installed. Hopefully Volvo improves this process before a child is hurt or killed because they are not secured to the vehicle.
- Wheels
After we purchased the vehicle, we discovered that it did not come with a spare tire. It came with inflator kit. This is a huge safety concern to us. The inflator kit is a quick repair, a temporary tire sealer. The disadvantages with this, as we read online, is that this kit can only be used if the…
After we purchased the vehicle, we discovered that it did not come with a spare tire. It came with inflator kit. This is a huge safety concern to us. The inflator kit is a quick repair, a temporary tire sealer. The disadvantages with this, as we read online, is that this kit can only be used if the puncture is on the tire’s tread and is not larger than 4 millimeters. It will not work if the puncture is on the tire sidewall. We spend most of our driving in remote areas where there is no cell phone coverage and repair shops are miles away. If we were to be stuck in a remote area without a spare tire, in a 110 degree weather or 20 degree weather it will be catastrophic. We cannot call for help and on a good day, usually we don’t see another person or vehicle for hours. Also, the vehicle does not have space for a spare tire. Dealership or the manufactory needs to provide a warning label that this vehicle does not come with a spare tire. If we had known this formation, we would not have purchased the vehicle.
- Electrical system · Latches/locks/linkages › Doors › Latch
The vehicle locking system malfunctioned, locking itself with the keys inside the vehicle. The vehicle was in park, the engine was off, I was only out of the vehicle for 30 seconds to 1 minute in time while filling my gas tank. My dog was inside the vehicle, in the back with no access to door locks…
The vehicle locking system malfunctioned, locking itself with the keys inside the vehicle. The vehicle was in park, the engine was off, I was only out of the vehicle for 30 seconds to 1 minute in time while filling my gas tank. My dog was inside the vehicle, in the back with no access to door locks or keys, it was 90* outside, he was locked in the car for 30minutes until the fire department arrived and broke the rear passenger a window. The vehicle will go in for diagnostic testing 9/12/23 at a Volvo dealership. Volvo USA refused to note the safety concern, they believe the vehicle operated as designed to self-lock if you forget. My vehicle has never self locked in the 1.5 years of owning it, rather it sends you an alert to your phone to inform you that it is unlocked- it does not lock itself. There have been no lights to alert of any possible concerns.
- Electrical system
The contact's father owns a 2022 Volvo XC90. The contact stated that upon entering the garage where the vehicle was parked, he became aware that the vehicle was idling and had turned on remotely. The contact stated that a message displayed on the instrument panel stated that the vehicle was…
The contact's father owns a 2022 Volvo XC90. The contact stated that upon entering the garage where the vehicle was parked, he became aware that the vehicle was idling and had turned on remotely. The contact stated that a message displayed on the instrument panel stated that the vehicle was remotely started by an unknown app. An undisclosed dealer was notified of the failure and an appointment was scheduled. The contact was concerned for his family’s safety. The manufacturer was notified of the failure and informed the contact that the app had been deactivated and advised to take the vehicle to the dealer for assistance. The failure mileage was approximately 11,400.
- Fuel/propulsion system
On 6/12/23, I was driving on a highway in New York State when I heard a bump under my car and I thought it was a rock. Nothing flashed on my dash to warn me that something serious had happened. Another driver pulled next to me and shouted out of the window, "YOUR CAR IS SPILLING GAS OUT OF THE…
On 6/12/23, I was driving on a highway in New York State when I heard a bump under my car and I thought it was a rock. Nothing flashed on my dash to warn me that something serious had happened. Another driver pulled next to me and shouted out of the window, "YOUR CAR IS SPILLING GAS OUT OF THE BOTTOM OF YOUR CAR, PULL OVER OR YOUR CAR MAY CATCH FIRE." As I was near an exit, I got off the highway, and there was a service station right there. When I got out of the car, with the ignition off, I saw gas coming from the bottom of my car like a faucet (Tank was 1/2 full). The service people told me to get away from the car and they tried to catch the gas as it was going all over the road and parking lot. My car was towed by Volvo to a dealer and they found that there was a 4 inch gash in my gas tank, likely caused by a piece of metal that fell from a truck. It took a week to fix my car, replace the gas tank, fuel pump and everything associated with the fuel system. It cost me $3,800 to fix. My car had less than 9,000 miles on it. When I approached VOLVO USA headquarters and asked that they try to reimburse me they replied it was an ACT OF GOD, and they would not cover any of it. My insurance would not cover it as it was not an accident. My complaint is that this car had no warning system within the high tech dashboard to alert me that my car was in trouble. Had it not been for the stranger on the road, I would not have known, as my A/C was on and my windows were closed. I did not smell the gas until I left the car. It is a flaw of this car that there was no warning system in place to let me know that my gas tank was breached. My dash flashes signals when my windshield wiper fluid is low. I am appealing to the National Highway Safety Commission to report this to Volvo, and not only try to get me paid back some of the money I spent, but to upgrade their safety alert system so someone does not get killed in a freak incident like this
- Electrical system · Engine · Fuel/propulsion system
The vehicle went into "turtle mode" on the freeway, abruptly started vibrating, reduced speed to a crawl, and then shut down. My family and I were trapped in the vehicle on the center divider of the freeway.
- Electrical system
Electric charging connector frozen. Electronic release inoperable, and no alternate way provided to disconnect charger from vehicle. As a result, vehicle is completely stuck in very cold weather.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011735This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
- 11009819This is a Technical Journal: Engine, "Low Oil" message during break-in period. This is normal during engine break in period.
- 11009818This is a Technical Journal: White patch defect in paint when removed rapgard. Expose vehicle to outside daylight for 48hrs.
- 11009817This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
- 11009815This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS. The 56 kO resistor ensures safe and appropriate power delivery.
- 11009811This is a Technical Journal: Software Upgrade / Download Guide. If one control unit is upgraded and not all, it may result in various problems.
- 11009803This is a Technical Journal: Outer rear view mirror intermittently not folding. May required replacing terminals.
- 11009511This is a Technical Journal: Alleged issues with Intellisafe functionality. Inform the customer of the functions and limitations
- 11007932This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
- 11007926This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
- 11007925Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
- 11007924This is a Technical Journal: Park Assistance System enhanced troubleshooting. Clean the sensor
- 11006576This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 11006564This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control). software is available in VIDA beginning 2024 week 21.
- 11006562This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 11006560This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
- 11006557This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 11006554This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
- 10254406This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700). Download software.
- 10254399This is a Technical Journal: Vibration/shudder while braking. Replace front brake pads
- 10254398This is a Technical Journal: Call button in the OHC might not be lit. Perform a total upgrade according to TJ 31543.
- 10253788This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
- 10253775This is a Technical Journal: DIM Message and DTC IEM P0A4000. Erase DTC. -Let the vehicle go to "Abandoned mode" - this can take up to 20 minutes. -Perform a new VIDA readout
- 10253774This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit. Install a repair kit.
- 10253773This is a Technical Journal: Long Range PHEV ERAD Sound Information. A slight whining sound noticed during electric drive is to be considered normal.
- 10253771This is a Technical Journal. If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
- 10253003This is a Technical Journal: Squeak noise from second row outer seats over bumps. Apply PFPE Anti squeak spray, p/n 30749880 spray.
- 10253000This is a Technical Journal: Oxygen Sensor DTCs. Perform a Total Upgrade of the vehicle software.
- 10252999Volvo Car USA LLC and Volvo Car Canada LTD, on behalf of Volvo Car Corporation, has decided to launch Complimentary Upgrade C00013 on certain Android-based Infotainment system (iCup) vehicles that have missed three (3) or more consecutive Over-The-Air (OTA) downloads. Complimentary Upgrade C00013 addresses vehicles that are no longer able to receive OTA updates. This Upgrade is necessary to have the correct baseline for future OTA deployments. In order to explain the features and benefits we recommend noting the software level before the download is completed. This will aid in explaining to the customer what improvements have been added since their last software download. To remedy concerned cars, please follow the instructions outlined in TJ 36139.
- 10252722This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 10252682This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 10251606This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
- 10251328CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer.
- 10251147This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester.
- 10251143This is a Technical Journal: SR PHEV Cell Module Replacement. Updated BECM software was released
- 10251124This is a Technical Journal: PHEV IEM P060700 Control Module Performance DTC. Clear DTCs, road test and then perform a new readout.
- 10249465This is a Technical Journal: WPC, none or unstable charging. recalibrate the WPC by performing a WPC reload.
- 10249392IHU General Issues
- 10249391ICUP, Upper & Lower bar in CSD not visible
- 10249388Call button in the OHC might not be lit
Every Volvo XC90 model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.