1996 Chevrolet Blazer
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Blazer › 1996
These records cover every 1996 Chevrolet Blazer. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
11 recalls name the 1996 Chevrolet Blazer. Newest first.
Sabersport IS recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain…
Risk and remedy
Risk
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes…
Risk and remedy
Risk
This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
Remedy
Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Risk and remedy
Risk
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Remedy
Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo USA at 909-468-3688.
On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor may fail due to cracked solder joints on the controller circuit board. the windshield wipers could work intermittently or not at all.
Risk and remedy
Risk
If this were to occur during bad weather, driver visibility would be reduced, which could result in a crash.
Remedy
Dealers will replace the wiper motor circuit board and cover. owner notification began on june 19, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
This IS not a safety recall in accordance with the safety act. however, it IS deemed a safety improvement campaign by the agency. vehicle description: 1996-1997 4-wheel drive chevrolet blazer, GMC jimmy, and oldsmobile bravada sport utility vehicles. some owners have had to pay for replacement of the upper ball joints that have separated. gm IS…
Risk and remedy
Risk
This could cause a loss of steering control of the vehicle.
Remedy
Gm has decided to conduct a customer satisfaction campaign to replace the upper ball joints on affected vehicles. this special policy IS for a period of 8 years or 100,000 miles, whichever occurs first, from the date the vheicle was originally placed in service, regardless of ownership. the upper ball joint replacement, due to separation, will be made at no charge to the customer during this period. owners can contact chevrolet at 1-800-222-1020, GMC at 1-800-862-4389, or oldsmobile at 1-800-442-6537, concerning this program.
On certain sport utility vehicles originally sold in or currently registered in the states of connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, and wisconsin, and in the district of columbia. failure…
Risk and remedy
Risk
This can result in impaired steering or steering loss, or a partial or complete collapse of the front suspension, increasing the risk of a crash.
Remedy
Dealers will replace both upper ball joints. owner notification began september 4, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
This IS not a safety recall in accordance with the safety act. however, it IS deemed a safety improvement campaign by the agency. vehicle description: certain light duty pickup trucks, sport utility vehicles, or minivans equipped with 3-sensor ABS (antilock braking system) EBC4 units.
Risk and remedy
Risk
These vehicles can experience extended stopping distances during ABS stops on certain multiple surfaces, increasing the risk of a crash.
Remedy
Dealers will modify the computer program which operates the ABS unit on some vehicles, or replace the computer on others to improve the performance of the ABS on these surfaces.
Vehicle description: certain 4-wheel drive pickup trucks and sport utility vehicles equipped with ABS (antilock braking system) manufactured from september 1989 through august 1996. under certain driving conditions the switch which signals the ABS system whether the vehicle IS in 2-wheel or 4-wheel drive can malfunction causing increased stopping…
Risk and remedy
Risk
If this occurred at a time when minimum stopping distance was required, a vehicle crash could occur without prior warning.
Remedy
Dealers will replace or repair the 4-wheel/2-wheel drive switch.
Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
Risk and remedy
Risk
This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
Remedy
Dealers will replace the wiper motor circuit board and cover.
Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. the outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
Risk and remedy
Risk
If a separation occurred and there were secondary crash events or vehicle rollover, there would be no belt restraint of the occupant and increased injuries could occur.
Remedy
Dealers will install a protective cover over the recliner mechanism.
Vehicle description: 4-door, 4-wheel drive and all-wheel drive multi-purpose passenger vehicles. during development testing, the prop shaft contacted the inboard side of the fuel tank allowing fuel leakage. this leakage was in excess of the amount permitted by fmvss 301, "fuel system integrity."
Risk and remedy
Risk
If an ignition source IS present, and there IS a fuel leak, a fire could occur.
Remedy
Dealers will install additional shielding of the fuel tank. this will be added without removing or disassembling the fuel system.
Owner complaints
1,153 complaints158 involved a crash32 involved a fire103 injuries2 deaths
What owners report most
Latest complaints
- Service brakes
On March 23, 2023 ABS Extended Stopping Distance on snow / slush surface proceeding downhill on a 4 lane highway (7200 South Wasatch Blvd. Midvale Utah). Other vehicles around me were stopping without issue. I noticed my ABS brakes were making the (typical operating sound a type of grinding) and I…
On March 23, 2023 ABS Extended Stopping Distance on snow / slush surface proceeding downhill on a 4 lane highway (7200 South Wasatch Blvd. Midvale Utah). Other vehicles around me were stopping without issue. I noticed my ABS brakes were making the (typical operating sound a type of grinding) and I wasn't stopping. I changed lanes twice to provide for more stopping distance and eventually stopped in the left turn lane within 2 feet from rear-ending other cars had I remained in the inside lane. Located Investigation EA94-038 noting 10,000 complaints, 2000 accidents, 600 injuries. Chevrolet Safety campaign 99I006000 addressing a PCM coding change and replacing the Kelsey Hayes ABS actuator unit. Chevrolet at 800-222-1020 declined to say whether this recall was in force, was a valid recall or had ever existed.
- Electrical system · Service brakes
TL* the contact owns a 1996 chevrolet blazer. While driving at various speeds, an abnormal noise was heard from the brakes when the brake pedal was depressed. There were no warning lights illuminated. The steering wheel began to seize and the turn signals began to malfunction. The vehicle was taken…
TL* the contact owns a 1996 chevrolet blazer. While driving at various speeds, an abnormal noise was heard from the brakes when the brake pedal was depressed. There were no warning lights illuminated. The steering wheel began to seize and the turn signals began to malfunction. The vehicle was taken to a dealer where it was diagnosed that the struts, and both driver and passenger side brake pads and rotors failed and needed to be replaced. The vehicle was repaired, but the failure recurred numerous times. The manufacturer was not aware of the failures. The failure mileage was approximately 142,185.
- Air bags
Driving approx. 35 mph north on 5700 blk of tacony st philadelphia pa 19137, 2005 silver honda pulls out of drive way hits the rear passenger side and rear passenger tire of truck, truck then spins and flips over. no air bag deployed at all sustained injuries. Was taken by rescue to hospital.
- Electrical system · Exterior lighting · Service brakes
Car accident was may 2008 was reported to usaa insurance and nc commissioner. I am former us army spouse and contractor 15 years. I am back at home of record. I have lost over $5000 to this incident and I deal with added medical disabilities from this dealing with chronic back, tbi ptsd and…
Car accident was may 2008 was reported to usaa insurance and nc commissioner. I am former us army spouse and contractor 15 years. I am back at home of record. I have lost over $5000 to this incident and I deal with added medical disabilities from this dealing with chronic back, tbi ptsd and brain injury to left side. confirmed with cat scan and army womack hospital. did not have health care at the time. I have had ignition switch. the light bulb dealing with nc testing issues costing me with testing. ohio thanks goodness not. but brights don't come on. radio clock stays on drained battery in the past. Also, there was a problem with the brakes. I tried to get a service but didn't know where in dayton , ohio.....updated10/20/15 *bf
- Service brakes · Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module
TL* the contact owns a 1998 chevrolet blazer. The contact stated that the brakes failed and the brake pedal traveled to the floor. The ABS light illuminated on the instrument panel. The vehicle was taken to the dealer and it was determined that the pressure modulator valve needed to be replaced.…
TL* the contact owns a 1998 chevrolet blazer. The contact stated that the brakes failed and the brake pedal traveled to the floor. The ABS light illuminated on the instrument panel. The vehicle was taken to the dealer and it was determined that the pressure modulator valve needed to be replaced. The manufacturer stated that the part was not under warranty. The vehicle was not repaired. The failure mileage was 81,000. updated 5/4/15*cn the consumer stated the ABS midule shorted out. Updated 05/07/15*jb
- Service brakes
Brake performance had started to degrade on last trip to lake place (200 miles round trip). Pedal seemed softer than normal brake warning light came on and stayed lit.. Once at home check fluid which was low. Added some fluid. Brake light went out tried several hard stops in drive way and pedal…
Brake performance had started to degrade on last trip to lake place (200 miles round trip). Pedal seemed softer than normal brake warning light came on and stayed lit.. Once at home check fluid which was low. Added some fluid. Brake light went out tried several hard stops in drive way and pedal travel went almost to floor. Observed brake fluid on the ground adjacent to fuel tank on drivers side. Drivers side frame rail was wet with brake fluid. Further investigation revealed dirt packed around rear brake line on top of ramp rail. Brake line was found to be severely degraded on top of the frame rail extending all the way to the junction with the rubber rear splitter line. Had to replace line from junction at rear splitter up to the junction at the frame rail near the front drivers side tire. Very disturbing to have a two foot section of brake line so severely compromised. This seems to be a common problem and related to the build up of compacted dirt on the frame rail carrying the rear brake line. Should be a recall or at least a notification to have the area inspected for compromised bake lines. *tr
- Tires
TL* the contact owns a 1996 chevrolet blazer equipped with definity tires ex600, size 235-70-r15 (n/a). The contact stated that the vehicle was taken to a mechanic for a routine tire rotation when he was informed that the front driver's side tire belt became separated. In addition, the passenger's…
TL* the contact owns a 1996 chevrolet blazer equipped with definity tires ex600, size 235-70-r15 (n/a). The contact stated that the vehicle was taken to a mechanic for a routine tire rotation when he was informed that the front driver's side tire belt became separated. In addition, the passenger's side rear and front tires were prematurely worn. The tires were not replaced. The manufacturer was made aware of the failure. The tire failure mileage was 50,000. The vehicle approximate current mileage was 153,000. updated 12/18/13*cn
- Electrical system · Engine
I have a 1996 chevy blazer 4WD 4.3L central port fuel injection. The #4 fuse which IS my gauge fuse keeps blowing and when it blows my instrument cluster zeros out and I have no clue what my speed IS what my rpms are what my fuel level its, etc. My alternator stops charging and my vehical eventually stalls out due to the battery draining. *tr
- Electrical system
Put the cigarette lighter in. Got out of my car and walked to the front of the car. By the time got back to the door of the car to get my things out for work the dashboard of my car was on fire. *tr
- Visibility › Defroster/defogger/hvac system
TL* the contact owns a 1996 chevrolet blazer. The contact stated that the vehicle was parked when the interior caught on fire. The fire department came and extinguished the fire. The fire department informed the contact that the origin of the fire was from the heater. Three weeks prior to the fire…
TL* the contact owns a 1996 chevrolet blazer. The contact stated that the vehicle was parked when the interior caught on fire. The fire department came and extinguished the fire. The fire department informed the contact that the origin of the fire was from the heater. Three weeks prior to the fire, the vehicle had regular maintenance performed. There were no injuries and the vehicle was destroyed. A fire report was filed. The manufacturer was not notified of the incident. The failure mileage was unknown.
- Fuel system, gasoline
I have a 1996 chevy blazer and the gas hand floats. it does not give an accurate reading on the gas gauge. I can drive and it will float from 1/2 tank to 1/4 tank while driving. it floats no matter how full or empty the tank IS. it has caused me to run out of gas due to the inaccuracies. I…
I have a 1996 chevy blazer and the gas hand floats. it does not give an accurate reading on the gas gauge. I can drive and it will float from 1/2 tank to 1/4 tank while driving. it floats no matter how full or empty the tank IS. it has caused me to run out of gas due to the inaccuracies. I have another gm vehicle--1993 suburban that has the same exact issue. I have ran out of gas on the freeway on the way to the airport--only thing that saved me and my children at 2:00 am in the morning was that I have roadside. *tr
- Air bags
TL* the contact owns a 1996 chevrolet blazer. The contact was traveling 40 mph when the vehicle was involved in a front end crash with another vehicle. The contact stated that none of the air bags deployed. The vehicle was taken to the dealer where the contact was informed that the vehicle had performed as designed based on the specifications of the crash. The current and failure mileage was 145,000.
- Electrical system · Exterior lighting › Brake lights › Switch
On my 1996 chevy blazer it was recently brought to my attention that I had no rear brake lights. I brought the vehicle to my regular mechanic and I was told that the multifunction switch was defective, as I had no rear hazards either. The only operational brake light was the overhead center light.…
On my 1996 chevy blazer it was recently brought to my attention that I had no rear brake lights. I brought the vehicle to my regular mechanic and I was told that the multifunction switch was defective, as I had no rear hazards either. The only operational brake light was the overhead center light. I had the item replaced and received the car back yesterday, but decided to google the item and came up with the recall #01v364000. this recall only covers GMC related vehicles during calendar years 2000-2002. I have the receipt for work and have the defective part in my possession. *Tr
- Suspension › Front · Suspension › Front › Control arm › Upper ball joint
Right side upper ball joint separation. *Tr
- Suspension › Front › Wheel bearing · Tires
1996 chevrolet blazer right rear tire came off vehicle while driving on the ohio turnpike. *kb the right rear tire fell off, due to bad bearings. Ohio traffic report# 10-0020-89 updated letter 04/29/10 *bf
- Vehicle speed control
TL* the contact owns a 1996 chevrolet blazer. the contact was driving approximately between 40-45 mph on a country roadway. there was pressure applied to the accelerator pedal, followed by an unintended increase of acceleration. the driver was able to resume to normal operation. in addition…
TL* the contact owns a 1996 chevrolet blazer. the contact was driving approximately between 40-45 mph on a country roadway. there was pressure applied to the accelerator pedal, followed by an unintended increase of acceleration. the driver was able to resume to normal operation. in addition, the "engine" warning light illuminated on the instrument panel intermittently. The identical failures occurred on three separation occasions. the vehicle was taken to an independent mechanic for inspection. the head gasket was blown as a result of the failures. the vehicle was repaired for the malfunctions. the failure mileage was 100,000. updated 08/24/10. *Lj the consumer stated there were 2 incidents of the accelerator sticking; putting in the clutch and kicking the accelerator corrected the problem at the time. on january 19, 2010 a piece from the cruise control came loose on the engine and the accelerator became stuck in the open position. Updated 08/25/10 *jb
- Steering · Suspension › Front · Wheels
The front tires are worn, and I have been told that I need upper and lower ball joints. I have had these replaced in the past. this IS a continual repair and getting costly. I called gm and they told me there was a recall but because of the time that has past that it IS no longer covered. I am…
The front tires are worn, and I have been told that I need upper and lower ball joints. I have had these replaced in the past. this IS a continual repair and getting costly. I called gm and they told me there was a recall but because of the time that has past that it IS no longer covered. I am in fear of getting in an accident driving the way it IS. it IS very unsafe. I was told also that I need idler arm replacements. *Tr
- Engine and engine cooling
I purchase my vehicle used on 12/4/01 , I have had to replace the temperature gauge every year because it indicates it IS overheating. 3 weeks ago it started saying it was overheating and smoke filled the interior of my vehicle with fumes. it was repaired. at 3:15 p.m. Today, my car…
I purchase my vehicle used on 12/4/01 , I have had to replace the temperature gauge every year because it indicates it IS overheating. 3 weeks ago it started saying it was overheating and smoke filled the interior of my vehicle with fumes. it was repaired. at 3:15 p.m. Today, my car indicates it IS overheating and now the service car light IS on. this has been an ongoing issue with the coolant system. as soon as I turn the car on it indicates it IS overheathing. happening too many times. *Tr
- Latches/locks/linkages · Structure › Body › Door
Tl*the contact owns a 1996 chevrolet blazer. while proceeding to turn a corner at 25 mph, the driver's side door unexpectedly opened. the driver immediately closed the door manually while the vehicle was in motion. the driver then went to a repair shop and had the door temporarily secured. the…
Tl*the contact owns a 1996 chevrolet blazer. while proceeding to turn a corner at 25 mph, the driver's side door unexpectedly opened. the driver immediately closed the door manually while the vehicle was in motion. the driver then went to a repair shop and had the door temporarily secured. the failure recurred on a separate occasion. the authorized dealer was notified of the failure and the vehicle has not been repaired. updated 04/21/09. *Lj updated 04/21/09.*jb
- Electrical system · Exterior lighting › Brake lights › Switch
I have a 96 chevy blazer. My brake lights are doa, the top strip IS working but the brake lights itself are not. I changed everything that has to do with the brake lights and still nothing. I went online and also saw other people with the same problem and frustration. I called the dealership and…
I have a 96 chevy blazer. My brake lights are doa, the top strip IS working but the brake lights itself are not. I changed everything that has to do with the brake lights and still nothing. I went online and also saw other people with the same problem and frustration. I called the dealership and there was a recall on that part but for a 2001. They also estimated that the switch and the labor would cost $700!!!! I went online and found the part itself for $369. I have not yet fixed the problem. This a problem to many chevy lovers and chevy should be liable to fix it cause it was an engineering problem. *Tr
- Engine and engine cooling · Equipment › Appliance › Air conditioner
Tl*the contact owns a 1996 chevrolet blazer. the contact stated that the air conditioner would not function. in addition, the radiator hose was leaking and the vehicle was taken to a repair shop for inspection. the contact was informed that there was a crack on the block (heater core) of the…
Tl*the contact owns a 1996 chevrolet blazer. the contact stated that the air conditioner would not function. in addition, the radiator hose was leaking and the vehicle was taken to a repair shop for inspection. the contact was informed that there was a crack on the block (heater core) of the radiator. the radiator hose was leaking at the connection of the hose. the vehicle also overheated at times, in which the mechanic stated that this failure was included in nhtsa campaign ID number 06e043000 (fuel system, gasoline). the dealer refused to perform the recall repair because other work needed to be done at the contact's expense. the current mileage was 169,123 and failure mileage was approximately 165,000. updated 09/15/08 *bf the consumer stated brown sludge was found in the radiator. Updated 09/18/08. *Jb
- Exterior lighting › Back up lights › Switch · Service brakes, hydraulic › Antilock/traction control/electronic limited slip · Visibility › Rear window wiper/washer › Motor
There are several different issues with this truck: 1. The wheels are making a squeaking noise while driving; replaced brakes, rotors, had tires rotated, balanced and new alignment done with no help 2. Brakes go to floor while braking..this just started 3. Back windshield wiper makes a loud…
There are several different issues with this truck: 1. The wheels are making a squeaking noise while driving; replaced brakes, rotors, had tires rotated, balanced and new alignment done with no help 2. Brakes go to floor while braking..this just started 3. Back windshield wiper makes a loud noise and doesn't work...ever! 4. Seat control gets stuck and won't move 5. No reverse light(s) and cannot figure out issue 6. Final and biggest issue IS that all the lights (including headlights) flicker both while driving and idling) I have had the alternator tested and replaced as well as the battery..still happening I bought this truck december 8, 2007 used from a local dealer. I purchased a small warranty but one that won't cover anything mentioned above. if there are any recalls will someone please contact me! *tr
- Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
I recently was on the way home from denver, co on the highway. I stopped for fuel noticing my vehicle was consuming more gas than usual. I fueled up and left. when I arrived home I noticed gasoline dripping on the ground. I immediately called a mechanic. my wife's father IS a certified…
I recently was on the way home from denver, co on the highway. I stopped for fuel noticing my vehicle was consuming more gas than usual. I fueled up and left. when I arrived home I noticed gasoline dripping on the ground. I immediately called a mechanic. my wife's father IS a certified mechanic and owns his own shop in denver. he fixed the leak, but told me the leak started because the fuel lines were rubbing the transmission and showed me. to my surprise the fuel lines were not secured in their proper location. I have never had any work done to the fuel lines or even any work done in the area of the problem. so I took the blazer back home to colorado springs. about a month later I noticed the fuel smell was back. I popped the hood because I did not see any fuel leaking. the fuel was pouring out of the lines at the top of the engine where they connect to the couplings for removal of the engine. I then decided to take the blazer to a closer location for repair. this location was daniels chevrolet located in colorado springs. they told me that the o-rings were pinched and that the gasket where the fuel lines go into the intake manifold was bad. I paid them 480.60 to repair the o-rings and gasket. four days later, the smell of fuel IS back and the leak IS there again at the couplings on the back of the engine were the dealership repaired them the first time. now the blazer IS back at the dealership again for the second time for the same issue. the vehicle IS my wife's, but due to the problem with the fuel, I have been driving it. the fuel leaks right on top of the exhaust pipe. this IS could be a very dangerous situation if the fuel were to ignite. my wife had taken the blazer to work three nights after the dealership repaired the o-rings and gasket, she had almost passed out while driving due to the fuel vapors entering the passenger compartment. now the dealership wants to charge me again for the same repair they did. I am at wits end. *tr
- Latches/locks/linkages › Doors › Latch
Tl*the contact owns a 1996 chevrolet blazer. while driving 35 mph, the front driver side door flew open. the contact examined the door and noticed that the latch failed. he placed a piece of wood at the lock position to keep the door closed. a few days later, the front passenger side door lock…
Tl*the contact owns a 1996 chevrolet blazer. while driving 35 mph, the front driver side door flew open. the contact examined the door and noticed that the latch failed. he placed a piece of wood at the lock position to keep the door closed. a few days later, the front passenger side door lock also failed. the vehicle IS currently parked at her home and will be taken to the dealer for a diagnostic. the vin, engine size, number of cylinders, dealer information, and failure mileage were unavailable. the current mileage was 49,000.
- Fuel system, gasoline › Delivery › Fuel pump
We have replaced the fuel pump 3 times. It has caused us to miss work several days, and put our jobs at risk. We have been out money for towing, parts and labor twice. The third time it failed, it was just past the parts warranty for a grand total of $1950.00. We have to continue to take it back to firestone to be replaced and make our lives miserable. *tr
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Windshield wiper failure
As a result of this, and the precedinginvestigation, rq99-003, gm has expanded the population of safety recall 98v-150 (replacement of the windshield wiper control module) to include an additional 1.77 million vehicles.included are various 1994-1997 my M/L vans, s/t trucks and suvs, & c/k trucks and suvs.see attached technical report for details.
- Upper and lower control arm ball joint
There is no summary currently available
- Front seat recliner bolt failure
- Upper control arm ball joint breakage
An upper control arm ball joint fails, resulting in the front suspension collapsing on the failed side.
- Steering shaft separations
Coupling bolts, joining the steering shaft, may separate.in some cases, total unforeseen, loss of steering control may result.
- Seat belt webbing separation
Nhtsa's new car assessment program (ncap) tested a 1997 chevrolet S-10 extended cab pickup equipped with a driver-side air bag.the front passenger seat belt was completely cut during the test.
- ABS braking system
This investigation resulted in a safety recall, 99v-193, and a service campaign, 99i-006.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10246631Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- 10232287This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
- 10208027This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 10171318This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 10168979This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable. E version update is to add administrative details.
- 10166638This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
- 10165876This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code. The PI update to version D is to advise the unlock procedure is temporarily unavailable.
- 10157018This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 10154641This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
- 10141381This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
- 10139019This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern.
- 10138060This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
- 10114947This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
- 10114924This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.
- 10113443This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 100135724WD models with noise, vibration on dry pavement.
- 10010270Heat coming from vents with hvac off.
- 10007838Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan.
- 10006961Pop snap noise in the front suspension when braking.
- 10004371Rattle noise in engine.
- 10004301Rattle noise in engine.
- 10000749Antilock brake (ABS) activation at low speeds on various models including the 1995 and 1996 envoy.
- 10000062Antilock brake (ABS) activation at low speeds.
- 634999Diagnosis of cracked or broken transmission case. 2006 and prior cars and light duty trucks.
- 634823Technical information - some customers may comment that the rear portion of the roof has some rust forming.
- 634506Subject regarding general waterleak guide.
- 634218Subject regarding rust in cooling system, heater inoperative, blows cold air, engine overheats (flush cooling system). Nlm
- 629470Some customers may comment that the rear portion of the roof has some rust forming.
- 628913Special policy adjustment 01049 for upper ball joint replacement.
- 628854Subject regarding rear roof perforation.
- 628852Concerns that the rear portion of the roof has some rust forming.
- 628527Special policy adjustment for four-wheel and all-wheel utility vehicles that may have front suspension upper ball joints that separate at a lower mileage than expected by customers.
- 628512Subject regarding rear roof perforation (install new rear roof section) including 1995-1997 GMC blazer.*jg
- 628070Some vehicles may exhibit an exhaust noise, rattle noise at 550 rpm.
- 627489Information regarding rear roof perforation.
- 625141Customers may comment that the seat recliner handle IS stripped.
- 623086Some customers may comment that the heater IS inoperative, blows cold air, engine may exhibit an overheat condition or the coolant reservoir has rust in it.
- 615106Product recall campaign involving windshield wiper motor replacement.
- 611277Some customers may comment that the heater IS inoperative, blows cold air, engine may exhibit an overheat condition or the coolant reservoir has rust in it.
- 609717Some customers may comment that the heater IS inoperative, blows cold air, engine may exhibit an overheat condition or the coolant reservoir has rust in it.
Every Chevrolet Blazer model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.