2008 Chevrolet Express
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chevrolet › Express › 2008
These records cover every 2008 Chevrolet Express. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
10 recalls name the 2008 Chevrolet Express. Newest first.
Main mobility IS recalling certain conversion vans built on model year 2008-2010 chevrolet express, 2009 GMC savana, and 2010 ford transit connect chassis, and fitted with certain braun wheelchair lifts. over time and with frequent use, the roll stop latches on the wheelchair lifts outer barrier may become bent or misaligned.
Risk and remedy
Risk
A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. if this occurs when the lift platform IS in an elevated position, the wheelchairs occupant could fall and sustain injury.
Remedy
Main mobility IS working with braun to notify owners, and braun dealers will repair the vehicles, free of charge. main mobility has not provided a notification schedule. Owners may contact main mobility at 1-716-759-6811.
Main mobility IS recalling certain model year 2008 and 2009 conversion vans built on chevrolet express and GMC savana chassis from october 2007 through may 2010 and fitted with certain ricon s series and k series l-model wheelchair lifts. due to a problem in the software that controls the lift's "up" function, should the "up" button be released before the…
Risk and remedy
Risk
When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it IS possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries.
Remedy
Main mobility will notify owners and the repairs will be performed by authorized ricon dealers free of charge. a software solution for this safety defect IS under investigation. until the software solution IS available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. the safety recall began on may 27, 2010. owners may contact ricon at 1-818-267-3000 or main mobility at 1-716-759-6811.
Cues, inc. IS recalling certain model year 2007-2009 service vehicles built on various chassis equipped with carrier airv ceiling units, model nos. 68Rv0010ba, 68rv0012ca, and 68rv0010ea. the heater element in these assemblies may be defective which could cause the unit to create smoke or sparks.
Risk and remedy
Risk
This defect could result in a fire.
Remedy
Cues IS working with carrier to remedy the affected vehicles. repairs will be made by carrier free of charge. please see carrier's defect report 09e-053. the safety recall began on january 5, 2010. owners may contact carrier at 1-877-584-7059 or cues at 1-407-849-0190.
Main mobility IS recalling 185 model year 2005 through 2009 chevrolet express and GMC savana vans manufactured between april 1, 2005 and june 25, 2009, equipped with ricon platform style wheelchair lifts. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations in motor vehicles."…
Risk and remedy
Risk
The user of the lift could be injured should the lift move unintentionally.
Remedy
Main mobility IS working with ricon to correct the wheelchair lifts free of charge (please see 07e095). owners may contact ricon at 1-818-267-3000 or main mobility at 1-716-759-6811.
Main mobility IS recalling 185 model year 2005 through 2009 chevrolet express and GMC savana vans manufactured between april 1, 2005 and june 25, 2009, equipped with ricon platform style wheelchair lifts. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift installations in motor vehicles."…
Risk and remedy
Risk
The user of the lift could be injured should the lift move unintentionally.
Remedy
Main mobility IS working with ricon to correct the wheelchair lifts free of charge (please see 07e097). owners may contact ricon at 1-818-267-3000 or main mobility at 1-716-759-6811.
Cummings IS recalling 42 my 2006-2008 ford E150, E350, chevrolet express, my 2006 ford E250, GMC savanna, dodge sprinter conversion vans, and my 2007 newmar dutchstar motor homes equipped with ricon platform style wheelchair lifts. these buses fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installation…
Risk and remedy
Risk
The user of the lift could be injured should the lift move unintentionally.
Remedy
Cummings IS working with ricon to correct the wheelchair lifts free of charge (please see 07e095). owners may contact ricon at 1-818-267-3000 or cummings at 1-763-498-7887.
Cummings IS recalling 42 my 2006-2008 ford E150, E350, chevrolet express, my 2006 ford E250, GMC savanna, dodge sprinter conversion vans, and my 2007 newmar dutchstar motor homes equipped with ricon platform style wheelchair lifts. these lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for…
Risk and remedy
Risk
A lift occupant can be injured should the lift begin to stow unintentionally.
Remedy
Cummings IS working with ricon to correct the wheelchair lifts free of charge (please see 07e097). owners may contact ricon at 1-818-267-3000 or cummings at 1-763-498-7887.
Gm IS recalling 151 my 2008 chevrolet express and GMC savana vehicles equipped with all wheel drive (AWD). some of these vehicles have transfer cases that were manufactured with an incorrect part that can cause early failure of a drive chain. if the chain breaks, shifting the transmission to park may not keep the vehicle stationary.
Risk and remedy
Risk
If the vehicle IS parked on an incline or bumped, it may roll and strike a person, object, or another vehicle without warning, and cause personal injury.
Remedy
Dealers will inspect the transfer case date code and, if necessary, replace the transfer case. the recall began on august 15, 2008. owners may contact chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
Gm IS recalling 567 my 2008 chevrolet express and GMC savana cutaway vehicles with a 139" wheel base. the frame rail on the driver's side may be wider than specification.
Risk and remedy
Risk
If the frame rail IS wider than specification, over time it may contact the fuel tank housing, resulting in a possible fuel leak. Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Dealers will inspect the clearance between the frame rail and fuel tank housing and will rework the frame rail if necessary free of charge. the recall began on july 30, 2008. owners may contact chevrolet at 1-800-630-2438, GMC at 1-866-966-9463, or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
Gm IS recalling 2,481 my 2008 chevrolet express and GMC savana g-cutaway fleet van equipped with a 6.0L (rpo LY6) V8 engine, 4l80e (rpo MT1) transmission, 4.10 (rpo GT5) axle and 75 mph governor (rpo 9D7). these vehicles have a condition in which the transmission may be damaged due to first gear engagement at highway speeds and then does not transmit power…
Risk and remedy
Risk
The vehicle may be stranded on or near a highway, increasing the risk of a crash.
Remedy
Dealers will reprogram the transmission and engine control modules free of charge. the recall began on or about july 30, 2008. owners may contact chevrolet at 1-800-630-2438 and GMC at 1-866-996-9463, or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
Owner complaints
14 complaints
What owners report most
Latest complaints
- Engine · Fuel/propulsion system
2008 Chevrolet Express van stalled while driving. I was able to coast over to the highway's shoulder. Van restarted after a few attempts and I resumed driving towards a small town ahead. Van re-stalled in the town. Attendant at small garage said the van had diagnostic codes for the fuel system.…
2008 Chevrolet Express van stalled while driving. I was able to coast over to the highway's shoulder. Van restarted after a few attempts and I resumed driving towards a small town ahead. Van re-stalled in the town. Attendant at small garage said the van had diagnostic codes for the fuel system. I was able to idle the van to a Chevrolet dealership for servicing. The dealership diagnosed and replaced the Fuel Pump Driver Module (part 20759945) (aka: Chassis Electronic Control Module) 17-days later, for about $650. Why wasn't I given notice and serviced under GM Recall Bulletin 14515 or 14515B, which specifies my van and that exact part? The dealership said my van is not part of that recall. The NHTSA site says my van has no pending recalls. The problem is serious enough that the Recall Bulletin applies regardless of years or miles. Even if an affected vehicle came in for an oil change, it can't be released until 20759945 is replaced. Van now suffering from code for upset oxygen sensor. VAN IS SPECIFIED IN THE RECALL BULLETIN BUT WAS NOT ADDED TO THE DATABASE OF VEHICLES TO BE SERVICED! The contact stated that the dealership told them that the module failure "probably" did not ruin the catalytic converters. The contact said they would look into the issue within their home garage.
- Service brakes
Total brake failure. Brake line completely rusted through went through a intersection at 50 mph no brakes
- Air bags
Passenger seat air bag sensor has failed.
- Engine · Power train
TL* the contact owns a 2008 chevrolet express. While driving, the transmission disengaged. The vehicle was taken to an independent mechanic where it was diagnosed that the engine control module and transmission control module needed to be reprogrammed. The vin was not included in nhtsa campaign…
TL* the contact owns a 2008 chevrolet express. While driving, the transmission disengaged. The vehicle was taken to an independent mechanic where it was diagnosed that the engine control module and transmission control module needed to be reprogrammed. The vin was not included in nhtsa campaign number: 08v313000 (power train). The manufacturer was notified of the failure. The failure mileage was 55,000. updated 10/28/16*lj the consumer stated the local dealer reprogrammed the ecm and tcm. Updated 11/02/16.*jb
- Service brakes
When I was driving in my local area,my brakes started to give out.in order to stop I needed to press very hard on the brakes to stop. Not easy to do.the warning brake indicator light came on.i took it to a local auto repair shop.they said they could not fix it.the brake line was the issue.they…
When I was driving in my local area,my brakes started to give out.in order to stop I needed to press very hard on the brakes to stop. Not easy to do.the warning brake indicator light came on.i took it to a local auto repair shop.they said they could not fix it.the brake line was the issue.they filled it with brake fluid then I was able too drive it to the dealer who then repaired the line ,for 600 dollars. My question IS were there other complaints about this issue.?if my kids were driving this it might have been a different story.thank goodness no one was hurt. There was no other indicators of this issue. *tr
- Fuel/propulsion system
Mechanic tested from canister to fuel tank has small leak, which may result to engine light on. I went to local auto mechanic shop san jose ca and there are two chevy express of the same failure before me. *tr
- Structure › Body
The side doors on both sides very hard to open because you cannot grease them, the sunroof leaks ,back rear doors handles stop working, took these problems several times to be address and paid for some of the work to be done to no avail still have the problems, I have a son that's disable and its…
The side doors on both sides very hard to open because you cannot grease them, the sunroof leaks ,back rear doors handles stop working, took these problems several times to be address and paid for some of the work to be done to no avail still have the problems, I have a son that's disable and its very dangerous if something happens and we cannot get him out the doors, plus the sunroof leaks so bad that anyone in the rear will get soak again paid to have it done but to no avail. Call gm but again no help just was told they knew about the problem and that's why they change the hinges this year, granted I had this problem with the hinges on a 2001 chevy 1500 express both van I purchased new to say I had these problems within a few weeks or months after purchase and no recall and to say they knew about the problem. *tr
- Air bags · Electrical system · Electronic stability control (esc)
While driving down the road at approximately 50 mph all warning lights on the dash lit up, the speedometer ceased to function, the radio cut out, the airbags were reporting as nonfunctional, the ABS system was reporting nonfunctional. Took vehicle to local mechanic who said the problem appeared to…
While driving down the road at approximately 50 mph all warning lights on the dash lit up, the speedometer ceased to function, the radio cut out, the airbags were reporting as nonfunctional, the ABS system was reporting nonfunctional. Took vehicle to local mechanic who said the problem appeared to be caused by corrosion on the ABS sensor as well as corrosion on the power distribution cables into the fuse box. According to the mechanic gm was aware of the problem, as technical bulletins dating back to around 2005 were issued. He also stated should it happen at the time of an accident the air bags would likely fail to deploy, and the problem in general could lead to the possibility of a vehicle fire. According to him the entire problem could have been avoided by the manufacturer if they had made sure the cables were wrapped in shrink tube-thus eliminating the introduction of moisture to the electrical wires. *tr
- Electrical system
TL* the contact owns a 2008 chevrolet express. The contact was driving 45 mph when the exterior and interior lights failed to illuminate. The vehicle was taken to the dealer seven times. The dealer stated that the wiring harness needed to be replaced. The manufacturer was not contacted. The vehicle was not repaired. The failure mileage was 12,000 and the current mileage was 47,115.
- Power train
While merging on the expressway the transmission failed to shift out of first or second gear causing high engine rpm's . I had to shift into neutral and back into drive several times but it still failed to shift into any gear. I had to put on flashers ( heavy traffic ) and make my way to the…
While merging on the expressway the transmission failed to shift out of first or second gear causing high engine rpm's . I had to shift into neutral and back into drive several times but it still failed to shift into any gear. I had to put on flashers ( heavy traffic ) and make my way to the emergency lane. When I came to a complete stop and shifted back into drive it shifted correctly. I have had this problem for several months to present date. I took the van to the dealership who said they could not replicate the problem and their were no code reports so they could not fix the issue. this IS still a very real danger for my family ( seven children ) because this malfunction occurs while at high speeds usually while entering the expressway. *tr
- Service brakes, hydraulic
My rotors keep warping and endangering my life!!!!!!!!!!!!!!!! I am on my fourth set of rotors in 84,000 miles!!!! And on top of that I have the original brake pads. As a matter of fact from 14,000 mi to 94,000 my brake pads have not worn at all. I had to cut the rotors at 30,000, and then at…
My rotors keep warping and endangering my life!!!!!!!!!!!!!!!! I am on my fourth set of rotors in 84,000 miles!!!! And on top of that I have the original brake pads. As a matter of fact from 14,000 mi to 94,000 my brake pads have not worn at all. I had to cut the rotors at 30,000, and then at 50,000 they were warped and too thin to resurface. I replaced them again. At 80,000 I had to have them cut because they were warped. Then at 85,000 I had to have them replaced again because they were warped. my rotors get to hot that when I brake, my whole steering column shakes and the vehicle swerves to hard that I can barely stay within the lines on the interstate. I feared for my life. I have tried to have chevy look into this and every time they just slap new rotors on and send me on my way. They give a 12,000 mile warranty on rotors and they are warping in half that time. Chevy has had to replace them for free under warranty 3 times and I have had to pay once. I feel like all they want to do IS slap new parts on instead of finding the problem or having a recall! I have spoke to corporate, who agrees something else IS wrong but they won't do anything about it. They say they've checked everything. I finally got the service supervisor to admit to me that these vehicles have crappy metal rotors from china and that they have been failing in the safety lane tests for their ability to brake and stop in the required distance. I feel that my vehicle was overrated to it's weight limit and it cannot stop itself if it has any kind of load in the cargo area. I have already filed a complaint with the us department of transportation highway safety administration. I have also worked with a gentleman from the corporate office, he seemed to be on my side but was unable to do anything. my case #'s are 71-869-1333444.
- Exterior lighting
Tl*the contact owns a 2008 chevrolet express van. The contact was driving and came across a dark road. The contact was forced to use the high beams and when they were turned on, they caused all of the exterior lights to fail. The contact turned the headlights on and off, but the high beams no…
Tl*the contact owns a 2008 chevrolet express van. The contact was driving and came across a dark road. The contact was forced to use the high beams and when they were turned on, they caused all of the exterior lights to fail. The contact turned the headlights on and off, but the high beams no longer worked. The dealer inspected the vehicle and stated that both light bulbs failed. The contact was concerned about the failure since they were able to use the low beams. The low beam head lights and high beam head lights were identical and the failure occurred in both. The failure mileage and current mileages were 37405.
- Vehicle speed control
While driving van at start of rush hour traffic. And need to stop at traffic light. The road a head of me merges from 3 lane to 2. When light changed I stepped on pedal to merge left. And gas pedal stayed to floor. I am not sure if I stepped on pedal a few times to get it unstuck, as I had my foot…
While driving van at start of rush hour traffic. And need to stop at traffic light. The road a head of me merges from 3 lane to 2. When light changed I stepped on pedal to merge left. And gas pedal stayed to floor. I am not sure if I stepped on pedal a few times to get it unstuck, as I had my foot on brake to slow van down. I am not sure of the sequence. But van then starting to slow down. All this happen in under a minute. If it had not slowed down I would of ran in to the back of car in front of me. It was very scary. Since then pedal has worked fine. I reported this to our main office. And told them I would take it to a chevy dealer to have it looked at. On 10-11-10 I took it to dealer and they didn't believe me. But took a quick look at pedal. And said same thing as toyota "it must of been floor mat. we haven't seen or heard of this problem in this van. Van IS out of warranty. Spring return pressure IS good". I told them I have been driving for 40 years and this van for 2. And never had a problem like this happen to me. So I ordered a replacement pedal. And they said it should be in 10-13-10. That IS today. I will keep old pedal for future study. I don't think people believe me as I am not looking for any fame. It was just a scary time. *Tr
- Power train · Traction control system
2008 chevy 3500 express van with about 40,000 miles. have a problem with the stabilatrack system and the dealer said it IS a wiring problem. it IS a fleet van. have had the problem on 2 of 15. transmission down shifts when this happens, speed IS limited to about 15 mph, speedometer quits. stabilatrack light turns on. *Tr
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11011782This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.
- 11010544This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
- 11009531This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11009156This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.
- 11009088This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is more often seen visually, rather than felt, when viewed from the outside and using the auto-start feature, if equipped.
- 11008956This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).
- 11007936This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007935This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak.
- 11007744This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007743This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.
- 11007208This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. Technician should not use the information that is provided by the antilock braking system tire size selection.
- 11007196This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, and/or B3935. Technician should not replace any parts for this concern. If unable to duplicate the concern ask if the customer uses any Radio Frequency Identification Devices when the concern is present. Dealer should also direct their customers to the appropriate section in the Owner manuals that references that the device complies.
- 11007116This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.
- 11007095This bulletin provides information on the TOP TIER Detergent Gasoline Licensed Brands and the TOP TIER Diesel Fuel Licensed Brands that are recommended for use in all GM vehicles and the TOP TIER FUELS website URL.
- 11007091This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.
- 11006682This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.
- 11006621Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
- 11006421GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.
- 11004761This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 11004727This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
- 11004557This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
- 11002312This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
- 11001325This warranty administration bulletin provides policy information to cover GMs policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada.
- 11001321This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.
- 11000576This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
- 11000162The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.
- 11000160This service bulletin provides information on proper use of floor mats.
- 11000158This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.
- 11000119This service bulletin provides technicians with information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.
- 10253770This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
- 10253632Rear and Side Tempered Glass Spots.
- 10252735This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
- 10252163XM Audio Traffic And Travel Link Availability And Operation.
- 10251890This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
- 10251888This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
- 10250775This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
- 10250505This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
- 10250347This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle service record retention and proper handling of assembly returns for Canadian Dealers only.
- 10250100Special Coverage Adjustment ? Throttle Position Sensor Replacement
- 10250030Exterior Lighting Inoperative - Incorrect Upfitter BCM Connections
Every Chevrolet Express model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.