2013 Chrysler Town And Country
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Chrysler › Town And Country › 2013
These records cover every 2013 Chrysler Town And Country. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
4 recalls name the 2013 Chrysler Town And Country. Newest first.
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model…
Risk and remedy
Risk
An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy
Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Risk and remedy
Risk
An overheated switch may result in a vehicle fire.
Remedy
Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Chrysler is recalling certain model year 2013 Town & Country, Dodge Grand Caravan, and RAM C/V Tradesman vehicles manufactured May 10, 2012, through June 7, 2013. A software error may result in the opposite side airbags deploying from the collision point (a left side impact would deploy the right side airbags and vice versa).
Risk and remedy
Risk
In the event of a crash, the wrong side airbags could deploy leaving the occupant with no airbag protection at the point of impact, increasing the risk of injury.
Remedy
Chrysler will notify owners, and dealers will flash the occupant restraint control module, free of charge. The recall began during September 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N44.
Chrysler is recalling certain model year 2013 Town & Country and Dodge Grand Caravan vehicles manufactured June 11, 2013, through June 12, 2013. The occupant restraint control module (ORC) has incorrect software installed which may adversely affect air bag deployments in collisions. Thus, these vehicles fail to conform to the requirements of Federal Motor…
Risk and remedy
Risk
An air bag that does not deploy, or deploys improperly, may increase the risk of injury.
Remedy
Chrysler will notify owners, and dealers will replace the ORC module, free of charge. The recall began on October 3, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N48.
Owner complaints
681 complaints15 involved a crash9 involved a fire30 injuries
What owners report most
Latest complaints
- Visibility › Windshield
The contact owns a 2013 Chrysler Town and Country. The contact stated that while driving 65 MPH, a carrier truck with a trailer was traveling nearby and debris came from the vehicle. The contact stated that due to the debris, the windshield was damaged and became inoperable, with a chip on the…
The contact owns a 2013 Chrysler Town and Country. The contact stated that while driving 65 MPH, a carrier truck with a trailer was traveling nearby and debris came from the vehicle. The contact stated that due to the debris, the windshield was damaged and became inoperable, with a chip on the windshield. The contact expressed concern that the damaged windshield was a safety hazard, especially since the windshield had previously been replaced. The failure mileage was approximately 171,226.
- Air bags · Electrical system · Fuel/propulsion system
When I started my car I heard a “ding” and saw that my airbag light was on. I called the local dealership to ask about it and they said that in the case of a crash that light usually indicates that there is something wrong with the sensors to the airbags and if I was to get into an accident, they…
When I started my car I heard a “ding” and saw that my airbag light was on. I called the local dealership to ask about it and they said that in the case of a crash that light usually indicates that there is something wrong with the sensors to the airbags and if I was to get into an accident, they wouldn’t deploy; which could cause loss of life if there is failure to deploy. My vehicle also revs and has more get up and go (when I’m not intentionally accelerating) sometimes when I’m driving which is abnormal and can cause an accident.
- Seats
I found the headrest exploded on the driver side when I got in the car in the morning. Apparently, this is common as I found it on the Internet while looking for a solution. Looks like a plastic part inside the headrest broke. AHR system inadvertently activated it seems. I’m glad I wasn’t in the car and it didn’t hit my head.
- Electrical system
The vehicle will be started and running and shut off. Driving down the road and all of the electrical shuts off, stops running and no gages work. You have to put the vehicle in N and restart. This is extremely dangerous as you never know when it will happen. driving down the interstate at 80mph or…
The vehicle will be started and running and shut off. Driving down the road and all of the electrical shuts off, stops running and no gages work. You have to put the vehicle in N and restart. This is extremely dangerous as you never know when it will happen. driving down the interstate at 80mph or driving when you can't just pull over to get started again. Failure in the ignition is what we think. There is an active recall but not for our VIN 2013 Chrysler Town & Country vehicles may stall or shut off while driving due to a known recall regarding a faulty Wireless Ignition Node (WIN) module, which can allow the key to move from the "run" to "accessory" or "off" position.
- Electrical system · Engine · Power train
While driving at highway speed, 65mph, the 2013 Town and Country shut down. The dash instruments and all internal lighting shut off, the radio shut off and the blower fan for heat shut off. I lost the ability to steer and brake (power steering went out) but managed to maneuver the vehicle to the…
While driving at highway speed, 65mph, the 2013 Town and Country shut down. The dash instruments and all internal lighting shut off, the radio shut off and the blower fan for heat shut off. I lost the ability to steer and brake (power steering went out) but managed to maneuver the vehicle to the right lane. The car would not respond to any acceleration attempt. I tried turning the key while coasting down the highway, the vehicle did not restart. I then put the vehicle into neutral and tried turning the key and it did not restart. I then turned the key to the off position and then tried to restart and it successfully started. My dash instruments illuminated, the radio and heat blower came back on and I was able to regain control of the vehicle.
- Electrical system · Seats · Unknown or other
The Battery died and would not recharge. I checked the van. No lights were left on; no warning notifications. I replaced the battery. I had the seat behind the driver seat stowed because I had surgery on my left foot and needed to haul my knee cart with me. I no longer needed it so I raised the…
The Battery died and would not recharge. I checked the van. No lights were left on; no warning notifications. I replaced the battery. I had the seat behind the driver seat stowed because I had surgery on my left foot and needed to haul my knee cart with me. I no longer needed it so I raised the seat and found it had melted/burnt in several spots on the seat back. I was mortified! My van is a 2013 but is in great shape and only has 46,937 miles on it. It was parked in my garage and could have caused a house fire killing all occupants. I contacted Chrysler. They won't assist in the repair or replacement stating it hadn't been recalled and was no longer in warranty. Insurance denied the claim due to it being a part malfunction. Please let others know that the seat heater & wiring harness are defective!! I feel Chrysler should accept the responsibility pay for the repairs due to defective parts. Had this fire continued, they would be facing a much larger lawsuit such as wrongful death, etc.
- Engine
The van has stopped running on the highway without warning 3 times creating a very serious problem,had to be towed to get home,dealer could find nothing wrong.
- Air bags · Electrical system
The contact owns a 2013 Chrysler Town And Country. The contact stated that while his wife was driving 55 MPH, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the…
The contact owns a 2013 Chrysler Town And Country. The contact stated that while his wife was driving 55 MPH, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle was able to restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the ignition switch. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V373000 (Electrical System, Air Bags); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 98,000.
- Air bags · Seats
The driver side headrest airbag deployed. No one was hurt, this was a replacement recall part from December 2023. This was supposed to be safe, what if I was driving my family and friends around and this happened? We don’t feel safe. I left a message with the dealer and am waiting to hear back. No one has inspected it this time yet. No warning signs.
- Seats › Front assembly › Head restraint
The contact owns a 2013 Chrysler Town and Country. The contact stated that while stopped, the child sitting in the second row hugged his sibling, who was sitting in the front seat, and the front passenger’s seat headrest deployed. The contact was unable to push the headrest back down. The headrest…
The contact owns a 2013 Chrysler Town and Country. The contact stated that while stopped, the child sitting in the second row hugged his sibling, who was sitting in the front seat, and the front passenger’s seat headrest deployed. The contact was unable to push the headrest back down. The headrest struck the child on the face; however, no injuries were sustained. The vehicle was taken to the dealer and diagnosed that an unknown plastic item had detached from the head restraint. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 132,168.
- Power train
Transmission codes but not having transmission issues even verified by shop and couldn't find issue. Then out of no where transmission revved hard on its own causing it to almost red line.
- Electrical system · Fuel/propulsion system
I experienced a no start situation. The vehicle would crank but not start. I did some research on the internet and found other Dodge/Chrysler vehicles with the same problem. I noticed they all had a similar, if not the same TIPM fusebox. The remedy was the same. You can put a bypass jumper wire on…
I experienced a no start situation. The vehicle would crank but not start. I did some research on the internet and found other Dodge/Chrysler vehicles with the same problem. I noticed they all had a similar, if not the same TIPM fusebox. The remedy was the same. You can put a bypass jumper wire on the fuse and the car will start. The problem is a fuel relay failure that is soldered to a circuit board inside the TIPM. There are after- market remedies. I don’t know if these remedies protect in the event of a crash, severed fuel line, and fire. Some Dodge/Chrysler models have a recall on this issue. This recall should be extended to my vehicle and many more. This is not my vehicle. I do some of the service of this vehicle.
- Electrical system
The contact owns a 2013 Chrysler Town & Country. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The contact stated that after several attempts, the vehicle started; however, the vehicle lost motive power. The vehicle was started, and the…
The contact owns a 2013 Chrysler Town & Country. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The contact stated that after several attempts, the vehicle started; however, the vehicle lost motive power. The vehicle was started, and the contact turned the vehicle off. The contact became aware that the fuel pump had continued running. The contact, who was a licensed independent mechanic, diagnosed the vehicle with TIPM failure. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 19V813000 (Electrical system); however, the VIN was not included in the recall. The dealer was made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 136,000.
- Electrical system
Intergrated power control module is throwing error even after being fixed by Firestone automotive. Car is randomly Turing off while driving down the road. Issues startin.
- Structure › Body
The rear drivers side sliding door no longer functions. The issue began when the door would intermittently make a buzzing sound but would not open or close. Shortly after, the door continued the first issue but also began pulsating when it actually would open. Around the same time these issues…
The rear drivers side sliding door no longer functions. The issue began when the door would intermittently make a buzzing sound but would not open or close. Shortly after, the door continued the first issue but also began pulsating when it actually would open. Around the same time these issues began, the door started opening by itself while driving. Though i have not had any accidents yet, several near misses have occurred due to the confusion and stress that this generates. The opening while driving issue occurs most often when on the highway. The primary passengers in the rear are children so there is heightened risk based on their very appropriate age based reaction of panic. The door is also no longer opening electronically from the key fob nor from the front seat buttons.
- Electrical system · Unknown or other
TIPM recall
- Electrical system
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving 40 MPH, the vehicle lost automotive power. There was no warning light illuminated. The contact was able to safely park on the side of the road, where the vehicle failed to restart. The vehicle was towed to a local…
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving 40 MPH, the vehicle lost automotive power. There was no warning light illuminated. The contact was able to safely park on the side of the road, where the vehicle failed to restart. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the failure was linked to the TIPM. The contact was informed that the TIPM needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
- Engine
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving 40 MPH, the check engine warning light illuminated. The contact also stated that the vehicle hesitated with an engine misfire. The vehicle was taken to independent mechanic and was diagnosed with cylinder #4…
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving 40 MPH, the check engine warning light illuminated. The contact also stated that the vehicle hesitated with an engine misfire. The vehicle was taken to independent mechanic and was diagnosed with cylinder #4 misfire. The spark plug and ignition coil was replaced; however, the failure persisted. The vehicle was taken to the dealer and the dealer declined to repair the vehicle under TSB: 09-002-14 (Cylinder leakage). The dealer referred the contact to Chrysler Customer Care for assistance. The manufacturer was notified of the failure. The failure mileage was 171,955.
- Engine · Service brakes · Steering
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The brake pedal was depressed; however, the vehicle failed to stop as intended. Additionally, the vehicle lost power steering functionality and the vehicle…
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The brake pedal was depressed; however, the vehicle failed to stop as intended. Additionally, the vehicle lost power steering functionality and the vehicle became difficult to steer. The contact stated that the failure occurred while driving uphill on a very narrow street. The contact was able to shift the vehicle into park, while using both feet to depress the brake pedal. The vehicle was stopped, and the contact turned off the vehicle. The contact stated that her four-year-old granddaughter was a passenger in the vehicle and the situation was very scary. The contact waited for several minutes, before restarting the vehicle. The vehicle was driven to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the failure had occurred several times and the vehicle had been taken to an independent mechanic several times; however, the failure was not duplicated. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,000.
- Electrical system · Electrical system › Starter assembly
The contact owns a 2013 Chrysler Town & Country. The contact stated that while starting the vehicle, the "Accessory On" light illuminated, and the starter made an abnormal grinding sound. The contact stated that several attempts were needed to start the vehicle. The contact stated that the failure…
The contact owns a 2013 Chrysler Town & Country. The contact stated that while starting the vehicle, the "Accessory On" light illuminated, and the starter made an abnormal grinding sound. The contact stated that several attempts were needed to start the vehicle. The contact stated that the failure occurred several times per week and several times during the same day. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 144,000.
- Unknown or other
* My Van loses unexpected power while driving. With this happening, I am afraid to drive on the highway due to the risk of causing an accident if it loses power. Local street driving, I am afraid that someone will rear end me if it loses power. Once it lose power making a right turn onto…
* My Van loses unexpected power while driving. With this happening, I am afraid to drive on the highway due to the risk of causing an accident if it loses power. Local street driving, I am afraid that someone will rear end me if it loses power. Once it lose power making a right turn onto another street. Fortunately, there were no other cars coming toward me. I was able to re-start the Van and drove on. The Van is a hazard for myself and others. * Do not know exactly what component or system failed or malfunctioned. * Have had 2 diagnostics done. One at the Dealer and one at an independent car repair shop. Neither one found anything. *Occasionally, the Lighting Bolt symbol will show. *Alternator has been replaced. TPMS sensor changed out. TIPM sensor changed out.
- Electrical system
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at various speeds, the vehicle lost motive power and stalled. After restarting the vehicle, the vehicle operated normally. The vehicle was examined by an independent mechanic, and it was determined that the WIN…
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at various speeds, the vehicle lost motive power and stalled. After restarting the vehicle, the vehicle operated normally. The vehicle was examined by an independent mechanic, and it was determined that the WIN Module was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 120,000.
- Air bags
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed that the wiring harness underneath the seat had fractured, which could cause the air…
The contact owns a 2013 Chrysler Town and Country. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed that the wiring harness underneath the seat had fractured, which could cause the air bags not to deploy during a crash. The vehicle was not repaired. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 120,000.
- Air bags · Seats
I was enjoying holiday driving with family in my 2013 Chrysler Town & Country Limited when suddenly a very loud pop was heard, with a forceful strike to the back of my head being felt. Alarmed & dazed for a moment, it was observed that my driver’s side active headrest had just exploded forward…
I was enjoying holiday driving with family in my 2013 Chrysler Town & Country Limited when suddenly a very loud pop was heard, with a forceful strike to the back of my head being felt. Alarmed & dazed for a moment, it was observed that my driver’s side active headrest had just exploded forward striking me on the back of my head. Once off the highway and stopped, I discovered that the active headrest had actually come apart. From the damage inside the exposed headrest, this catastrophic failure seemed to be mechanical in nature with root cause thought to be STRESS FATIGUE for the plastic casement. In other words, this active headrest did not just randomly “go off” from an errant SRS command or an electronically manipulated trigger short. I observed the headrest’s metal latch pin to still be in the locked or reset position. Instead, the plastic assembly holding two (2) heavy coil springs ruptured unprovoked. When this happened, the front part of the headrest assembly rapidly propelled forward. Though the 2010-2016 Chrysler Town & Country active headrests are an integral part of the air bag or Supplemental Restraint System, THIS particular failure was NOT due to a SRS Control nor electrical malfunction. Rather, the plastic retainer struts surrounding the metal latch pin failed. Being that my head and neck were static in position with a small amount of clearance from the front face of the headrest, the propulsion of the headrest forward caused quite a sharp smack to the back of my head. This led to some residual neck strain for the balance of the day. I have not experienced any repercussions since that day of the incident, but I do believe this to be a SAFETY ISSUE for others who may be more age OR physically compromised. I’ve found through MOPAR tech forum and dealership research that the 2010 - 2016 active headrest FAILURE is NOT rare, but more and more COMMON to the Chrysler make. Please advise. Thank you so much.
- Electrical system · Engine · Fuel/propulsion system
Today, we experienced, for the FOURTH time, a complete stall while driving. Accelerator would not work at all. Van died while driving approx 25 mph. We just had the entire fuel pump & fuel pump relay completely replaced. We have replaced both of these twice now, in less than 3 years. Same problem…
Today, we experienced, for the FOURTH time, a complete stall while driving. Accelerator would not work at all. Van died while driving approx 25 mph. We just had the entire fuel pump & fuel pump relay completely replaced. We have replaced both of these twice now, in less than 3 years. Same problem keeps happening. Mechanic agrees, that the core problem lies within a failure of the TIPM system. It's an electrical problem causing the fuel pump to fail while driving. This is extremely dangerous. It happened to us previously, while we were on the interstate driving approx 65 mph, and it almost caused us to crash the vehicle. Another problem to also note, is this same problem has caused the A/C unit to stop working. Blows out hot air, but will not produce cold air. A/C was completely replaced. Still not working. Mechanic says yet again, it's a failure of electrical sources due to the TIPM module. This should be an immediate recall from Chrysler, for 2013 Town N Country Minivan. Over 200 logged complaints of the exact same problem. They manufactured a broken TIPM module in these make & model vehicles. Now, my husband is stranded 200 miles from home, on the side of the road, and it's 98 degrees out. This is 4th time, weve experienced a total power failure. So it doesn't matter if you replace the fuel pump, it will still DIE. We are having this POS towed to our local mechanic, AGAIN. Its available for inspection. Problems have been confirmed by an independent servicer. Check engine remains on. Someone is going to die, if Chrysler doesn't issue an recall for this ongoing problem. The interior power is still on,and engine will turn over, will not start.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Active Head Rest Inadvertent Deployment
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When…
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
- Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007…
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 11010954Incoming Vehicles with Deployed Active Head Rest (AHR) should have a through enquiry. If there is no Broken Pieces or Electrical failure, Direction to RESET the AHR following the Procedure.
- 10248517LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
- 10248509Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10247995Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
- 10247906ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10247905ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10244356LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
- 10244348Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
- 10243209FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
- 10243208Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
- 10243207FCA Caribbean Warranty Bulletin ID-22-23 - 2017 - 2023 (Current) Chrysler Pacifica (RU) and 2013 - 2016 Chrysler Town & Country/ 2013 - 2020 Dodge Caravan (RT) - Corrosion - Complete Hood Panel Warranty Claim Simplification (Rev. B)
- 10243206Warranty Bulletin D-22-17 - 2017 - 2023 (Current) Chrysler Pacifica (RU) and 2013 - 2016 Chrysler Town & Country/ 2013 - 2020 Dodge Caravan (RT) - Corrosion - Complete Hood Panel Warranty Claim Simplification (Rev. B)
- 10242771FCA Caribbean Warranty Bulletin ID-22-23 - 2017-2023 (Current) Chrysler Pacifica (RU) and 2013-2016 Chrysler Town & Country/ 2013-2020 Dodge Caravan (RT) - Corrosion Complete Hood Panel Warranty Claim Simplification (Rev. A)
- 10242768Warranty Bulletin D-22-17 - 2017-2023 (Current) Chrysler Pacifica (RU) and 2013-2016 Chrysler Town & Country/ 2013-2020 Dodge Caravan (RT) - Corrosion Complete Hood Panel Warranty Claim Simplification (Rev. A)
- 10242717Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
- 10239957Water Quality When Mixed With Engine Coolant
- 10236933wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
- 10234468Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
- 10234379ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10234378ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
- 10230180Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
- 10229987Hands Free Feature Inoperative
- 10229898Service Bulletin 08-046-14 REV. A Superseded By Customer Satisfaction Notification (CSN) P25 Refer to service procedures outlined in CSN P25.
- 10229871Dielectric Grease This product is no longer approved for use on ignition coil and spark plug boots. Current plug boot material(silicone) is not compatible with this grease and can cause deterioration over time.
- 10229866Setting Mode Is Selected And Headlamps Always Stay On
- 10229845HVAC System Intermittently Blows Cold Regardless of Setting
- 10229830This Bulletin involves disconnecting the switch for the rear power vent window, if requested by the customer
- 10229829Power Window-Vent Switch - Interim CSN Repair
- 10229825RHW RHP Radio Software Enhancements
- 10229810Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Digital imaging pre authorization is required for Smart Warranty Base dealers or Pre Approval is required from Regional Office depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
- 10229775Warranty Bulletin D-22-17 2017?2023 (Current) Chrysler Pacifica (RU) and 2013?2016 Chrysler Town & Country/2013?2020 Dodge Caravan (RT) - Corrosion ? Complete Hood Panel Warranty Claim
- 10229572Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10229178Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
- 10228989Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold
- 10228975Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. b) Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA. c) Vehicles built on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. Only use the reman 62TE specified in StarParts for each model year - Only use R8210327A$ for 2014 - 2018 VF. - Only use R8453637A$ for 2019 VF. - Only use R8599680AA for 2020/1VF. Installing a R8453637A$ or R8599680A$ in a 2014-18 VF will result in a 2014-18 MY core being returned. Mopar can no longer convert 2014-18 VF 62TE core to the 2019-21 version. Continued mis-usage will result in a core shortage. Mopar may deny warranty claims where the incorrect version is used in 2014-18 VF. 3. The engine to transmission dowel pins are critical to the longevity of several components. Verify the dowel pins are in the rear face of engine block before installing a replacement transmission. Mopar will add loose dowel pins with remanufactured 62TE. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter. 5. There may be incorrect fluid measurement on the dipstick tool when checking 62TE fluid level after filling the ATF as per service library specification. Please change with new valve body pan P/N:68145886A$ as there may be incorrect valve body pan is used in Transmission.
- 10228020Customer Satisfaction Notification V51 Reprogram Powertrain Control Module
- 10227983If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
- 10225424Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10225287Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
- 10224894Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam phasers. Please use this new information for trouble shooting of cam phasers and oil control valves for MIL on issues.
Every Chrysler Town And Country model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.