2001 Dodge Grand Caravan
Safety record from NHTSA: recalls, owner complaints, investigations and service bulletins.
Have the VIN?
Vehicles › Dodge › Grand Caravan › 2001
These records cover every 2001 Dodge Grand Caravan. To see whether one car still needs a recall repair, decode its VIN or check it with NHTSA.
Recalls
5 recalls name the 2001 Dodge Grand Caravan. Newest first.
On certain MINI vans, condensation from the instrument panel air conditioning ducts may drop through vent holes in the top of the radio and result in a short circuit that subsequently sends direct current to the rear speakers.
Risk and remedy
Risk
This could result in a speaker fire.
Remedy
Dealers will add a special tape to the top of the radio to prevent the potential of water intrusion. the recall began on january 31, 2005. owners should contact daimlerchrysler at 1-800-853-1403.
Certain aftermarket replacement fuel filters, models wix filter part numbers 33576, 33577, 33734; napa filter part numbers 3576, 3577, 3734; and carquest filter part numbers 86576, 86577, 86734 used on 1996-2000 daimlerchrysler town & country, dodge caravan, and plymouth voyager vehicles, can cause the fuel lines to leak.
Risk and remedy
Risk
A possible fire can occur in the presence of an ignition source.
Remedy
Wix will notify its customers and replace the fuel filters free of charge. note: this does not involve any products manufactured by the daimlerchrysler corp. Nor any dailmerchrysler dealers. owner notification IS expected to begin during november 2003. owners who do not receive the free remedy within a reasonable time should contact wix at 704-864-6711.
Certain pickup truck, van, and MINI van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. these units contain a courtesy light or lights that might overheat when the wire harness IS exposed to excessive moisture and road salt.
Risk and remedy
Risk
This overheating condition can cause the running board to melt or cause a fire.
Remedy
Dealers will replace the wiring harness on these running boards. owner notification began march 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
This IS not a safety recall in accordance with the safety act. however, it IS deemed a safety improvement campaign by the agency. vehicle description: 2001 plymouth voyager, chrysler town & country, and dodge caravan/grand caravan MINI vans that are not equipped with the remote keyless entry option. the sliding door latches on these vehicles could…
Risk and remedy
Risk
This could allow the sliding door to partially open.
Remedy
Dealer will replace both sliding door key cylinder-to-bell crank links on the sliding doors free of charge (parts and labor). daimlerchrysler has decided to conduct a service campaign to replace the sliding door key cylinder-to-bell crank links. owners can contact daimlerchrysler at 1-800-853-1403, concerning this program.
Vehicle description: minivans. the lower control arm pivot bolt could fracture.
Risk and remedy
Risk
If the bolt fractures, the lower control arm could separate from the crossmember, causing a loss of vehicle control.
Remedy
Dealers will replace the left and right lower control arm bolts and nuts. owner notification began april 30, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
Owner complaints
298 complaints9 involved a crash1 involved a fire10 injuries
What owners report most
Latest complaints
- Fuel/propulsion system
Fuel lines leak,fuel filter clogged, won't start,paid 100.00,dlls, to get fixed, my van started stalling, got home from work, next day didn't start at all
- Seat belts
My dodge grand caravan 2001 was involved in a front end collision in october of 2015. I t-boned another car that pulled out in front of me. I was going 35-40 miles per hour. The seat belt failed to tighten around my hips. Because of this failure I sustained extensive damages to my right leg.…
My dodge grand caravan 2001 was involved in a front end collision in october of 2015. I t-boned another car that pulled out in front of me. I was going 35-40 miles per hour. The seat belt failed to tighten around my hips. Because of this failure I sustained extensive damages to my right leg. This included a displaced fracture, numerous other fractures, a crushed injury to the tibia plateau. I had 5 months in rehab, 3 surgeries, extensive physical therapy. I am still receiving medical treatment a year later. If the seatbelt had done what it . Was designed to do, my leg would not of hit the dash board. These injuries were caused by a seatbelt failure of my dodge grand caravan.. Extensive records are available.
- Air bags · Unknown or other · Vehicle speed control
Clock spring. Horn, cruise control stop working. Airbag light on. Chrysler will not acknowledge, as well as local dealer as a problem and/or a safety nor a recall issue.
- Electrical system
TL* the contact owns a 2001 dodge grand caravan. While making a right or left turn using the turn signal, the lights on the instrument panel failed to illuminate. The vehicle was taken to an independent mechanic where it was diagnosed, but the technician could not locate the failure. The manufacturer was not notified of the failure. The failure mileage was 157,936.
- Electrical system
The car instrument gauges became erratic along with the instrument lights. The care jerked as though it lost its electrical power to the ignition but returned to normal and then quit in front of traffic. We could have been killed by a semi-truck. I got the car over and re-started it and it ran fine…
The car instrument gauges became erratic along with the instrument lights. The care jerked as though it lost its electrical power to the ignition but returned to normal and then quit in front of traffic. We could have been killed by a semi-truck. I got the car over and re-started it and it ran fine until later it started to die out again after starting to run. I had to accelerate the engine to get the car moving but the car jerked and went dead again. The car will start and run fine at times and shift well at times and then starts to repeat the same problems over and over. I only know that this situation could have gotten someone killed and I do not want it to be my children or wife or me. I only have one way to go now and have no way to have it looked at because I have been told a thousand things it could be and cannot afford non-sense like this. this 2001 van runs at times like a brand new one and shifts out like brand new and then all of sudden the gauges go crazy, it lurches at stopping, go dead when I slow down at times and sometimes it seems like it IS in overdrive and jerks like mad, then runs fine again. It IS a repeat and it IS dangerous.
- Air bags · Vehicle speed control
The airbag warning light stays on all the time. At the same time the speed control stopped working and the horn does not work
- Fuel/propulsion system
Tl*the contact owns a 2001 dodge grand caravan. The contact discovered that there was a fuel leak. The vehicle was taken to an independent mechanic, who diagnosed that the fuel rail needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 120,000.
- Air bags · Electrical system
TL* the contact owns a 2001 dodge grand caravan. the contact stated that the air bag warning light continuously illuminated. Also, the contact mentioned that the buttons on the steering wheel would not work. The dealer stated that the failure might be due to a defective clock spring. If a crash…
TL* the contact owns a 2001 dodge grand caravan. the contact stated that the air bag warning light continuously illuminated. Also, the contact mentioned that the buttons on the steering wheel would not work. The dealer stated that the failure might be due to a defective clock spring. If a crash occurred, the air bag could potentially not deploy. The vehicle had not been repaired and the manufacturer had not been notified of the failure. The approximate failure mileage was 138,000.
- Exterior lighting
Sometimes when the vehicle IS started only the driver side daytime running light comes on. Turn the lights on and the driver side light goes out and the other side comes on. Turn on the high beams, the driver side light comes on and the other side goes out. Took the vehicle to a dealer,cause was…
Sometimes when the vehicle IS started only the driver side daytime running light comes on. Turn the lights on and the driver side light goes out and the other side comes on. Turn on the high beams, the driver side light comes on and the other side goes out. Took the vehicle to a dealer,cause was said to be the multi function switch shorted. The multi function switch was replaced, lights worked properly for about 2 weeks,then the problem returned. Took vehicle back to the same dealer and was told they could not duplicate the problem.when both lights are on at the same time they flicker,the problem has gotten to the point to where only one light IS working more times than when both lights are working. I researched the problem on the internet and found several other owners having the same problem as early as 2005. I contacted dodge and was told they were unaware of the problem and that there were no recalls on my vehicle. All 2001 dodge grand caravan should be recalled at once, because of this safety issue with the lights. It should not take someone having an accident whether minor or fatal in order to get this defect corrected.we are at risk of receiving a traffic ticket for driving a vehicle with defective equipment and or being in an accident because of the lighting problem. We have lost use of this for up to 3 weeks because of the problem with the head lights,and we can not afford to replace it at this time. Even if we replace this vehicle the problem would only be passed on to someone else. All 2001 dodge grand caravans need to be recalled at once. *tr
- Electrical system
Purchased used minivan took it to get registered and found out the mileage has been tampered with and its not accurate. Seller said it had 90000 miles odometer read a little over 90000 but mvd said it was not accurate. *tr
- Electrical system · Exterior lighting
Using either turn signal cuts off power to the dash. dash comes back on a few seconds after using. I check the lights (exterior), but no blinking the interior turn signals blink sometimes, but no sound anybody familiar with problem? I've seen many similar conditions. *tr
- Fuel/propulsion system
Fuel jumper hose popped off from steel line that comes from fuel tank supply the side that keeps coming off, IS connect to the fuel jumper hose fitting to the fuel rail V-6 3.3L engine. *tr
- Electrical system · Engine · Fuel/propulsion system
Sitting idle at a stop light and my van stalled. While I tried to start it again, it began to accelerate on its own. It will stall while driving and lose all power and the steering/ brakes get hard. It will begin to accelerate on its own while the brake IS pushed. I had it diagnosed yesterday and…
Sitting idle at a stop light and my van stalled. While I tried to start it again, it began to accelerate on its own. It will stall while driving and lose all power and the steering/ brakes get hard. It will begin to accelerate on its own while the brake IS pushed. I had it diagnosed yesterday and it IS a melted wiring fuel rail harness that was placed right above the exhaust manifold. It can melt and catch fire. This IS a known problem with this year and model. Please help! *tr
- Fuel system, gasoline · Structure › Body › Door
The first year I purchased the vehicle, I had to take it in for fuel issues ,paid out $50 the first time for deductible, then the second year $150 same problem, fuel, had to have a new fuel pump,now I have having more fuel problems which means I will have to pay out $250 being this IS my third…
The first year I purchased the vehicle, I had to take it in for fuel issues ,paid out $50 the first time for deductible, then the second year $150 same problem, fuel, had to have a new fuel pump,now I have having more fuel problems which means I will have to pay out $250 being this IS my third year. Now I was reading online that there have been some recalls for this same problem on dodge caravans. I would like to know if there IS anything I can do, to have y problem looked at and fixed without coming out of my pocket a 3RD time for the same issue. When I purchased the veh from drive time, they stated they did an all around inspection. Also, my passenger side sliding door will open on its own even while I am driving sometimes. And it wont latch on until the 3RD or 4TH try. *tr
- Fuel system, gasoline
While driving it cut out and stalled. I was on the highway going about 65 mph. there was minimal fuel pressure. *Tr
- Engine and engine cooling · Service brakes, hydraulic
I have a 2001 dodge grand caravan sport and I had nothing but problems with it from the brake lines rotted away to the anti freeze line rotted away also the steering getting hard to were it wont budge also lights flickering and overheating so there's nothing on my van that isn't a problem I spent…
I have a 2001 dodge grand caravan sport and I had nothing but problems with it from the brake lines rotted away to the anti freeze line rotted away also the steering getting hard to were it wont budge also lights flickering and overheating so there's nothing on my van that isn't a problem I spent thousands of dollars on these problems and they just continue to happen anything on my van that holds fluids just rots away from the inside out and now the water pump housing that's bolted onto the motor were the hose attaches to goto the firewall so that you have heat and ac inside the van rotted off so there's a hole were the nipple would be to connect a hose to and the dealership wont help me in anyway shape or form so im basically on my own so I guess there waiting for someone to die before they fix anything on these vans they have so much concern for the civilians that buy there car vans ext. They keep up like this everyone who buys a vehicle from them IS certain to die and they wont have any customers to sell to period because they will all be dead.... Its time to take our story to the press and you will see how fast the will fix these issues so if your a owner of a dodge chrysler and having problems such as me we should get the press involved and have them write a story about there lack or care for there customers safety so lets team up and write me at [xxx] and lets put a flame under there butts. information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(B)(6). *Tr
- Air bags
TL* the contact owns a 2001 dodge grand caravan. The contact stated that while driving various speeds, the air bag warning light illuminated intermittently and whenever the contact would attempt a turn. The light remained illuminated as the failure progressed. The controls on the steering wheel…
TL* the contact owns a 2001 dodge grand caravan. The contact stated that while driving various speeds, the air bag warning light illuminated intermittently and whenever the contact would attempt a turn. The light remained illuminated as the failure progressed. The controls on the steering wheel failed and later, the horn also failed. After performing extensive research, the contact concluded that the clock spring failed. the dealer and manufacturer were both notified and neither offered any assistance to the contact. The vehicle was not repaired. The failure mileage was 151,000 and the current mileage was 166,000.
- Engine and engine cooling
My van IS overheating. It broke down on the massachusetts pike, it then started smoking from under the hood and from the undercarriage. The fans aren't turning on when the air conditioner IS on, and the air conditioner IS not staying cool. *tr
- Steering
In april of 2009 I noticed that the steering was tight at times. I checked the power steering fluid and when added, the steering was better. in cold months it was worst. In dec. 2009 I had the power steering pump replaced. it worked for about a year. Then in dec. 2010, I had the power steering…
In april of 2009 I noticed that the steering was tight at times. I checked the power steering fluid and when added, the steering was better. in cold months it was worst. In dec. 2009 I had the power steering pump replaced. it worked for about a year. Then in dec. 2010, I had the power steering pump flush. The mechanic said to warm up the car before driving. it worked in the summer months but not in the winter. in january 2012 the steering was really hard. I had a hard time backing up, turning either way or just driving at all. I got two different mechanics opinion and they said that the rack and pinion, steering rack, needed to be replaced. so, after changing the reservoir the rack and pinion still needed to be changed. the mechanic said they have changed a lot of rack and pinion in dodge/chrysler MINI vans. they are not lasting the life of the vehicle.
- Suspension
TL* the contact owns a 2001 dodge grand caravan. the contact heard a clunking noise when he applied pressure to the brakes. the vehicle was taken to a private mechanic who informed the contact that the lower control arm pivot bolt was fractured. The dealer informed the contact that his vin was…
TL* the contact owns a 2001 dodge grand caravan. the contact heard a clunking noise when he applied pressure to the brakes. the vehicle was taken to a private mechanic who informed the contact that the lower control arm pivot bolt was fractured. The dealer informed the contact that his vin was not included in the recall associated with nhtsa campaign ID number: 01v152000 (suspension:front:control arm:lower arm) and offered no further assistance. the manufacturer was made aware of the failure and offered no assistance. no repairs were performed. the current and the failure mileages were 171,000.
- Fuel system, gasoline
Ruptured fuel line spraying gasoline onto muffler. the fuel lines are plastic and are attached to the fuel filter and are replaced together as a unit. the plastic line had a quarter inch rupture. this filter had less than 30K miles and was about a year old. why does chrysler use plastic fuel…
Ruptured fuel line spraying gasoline onto muffler. the fuel lines are plastic and are attached to the fuel filter and are replaced together as a unit. the plastic line had a quarter inch rupture. this filter had less than 30K miles and was about a year old. why does chrysler use plastic fuel line? I do not know the cause - a weak inferior plastic or a sharp stone perhaps. either way, it does not matter. I have never seen a hard plastic used for fuel delivery. the old style rubber fuel hoses would be much better and safer. I am thinking this plastic IS used because of the flex fuel option but I am not a mechanic. I am glad my vehicle did not catch fire. I was lucky. after replacing the filter with a new one from napa one of the fuel lines would not stop leaking. I had to return it for another non leaking filter. because of this I am also concerned about the quality of replacement parts as well. *tr
- Electrical system
TL* the contact owns a 2001 dodge grand caravan. The contact stated that upon starting the vehicle, only one of the headlights illuminated. The vehicle was taken to various authorized dealers and independent mechanics where the body control module was replaced several times. The failure continued.…
TL* the contact owns a 2001 dodge grand caravan. The contact stated that upon starting the vehicle, only one of the headlights illuminated. The vehicle was taken to various authorized dealers and independent mechanics where the body control module was replaced several times. The failure continued. The manufacturer was made aware of the failure, but offered no assistance. The failure mileage was 60,000. updated 10/12/11 *bf updated 10/21/11
- Exterior lighting
Own 2001 dodge grand caravan sport, 3.3L. Left (driver side) headlight does not work and it IS not the bulb. Also have flickering of dashboard lights. prob started in 08' repair shop advised me this IS ongoing prob with these vans. Repair shop said it was moisture in relay box, he dried it out for…
Own 2001 dodge grand caravan sport, 3.3L. Left (driver side) headlight does not work and it IS not the bulb. Also have flickering of dashboard lights. prob started in 08' repair shop advised me this IS ongoing prob with these vans. Repair shop said it was moisture in relay box, he dried it out for me and headlight worked fine for almost 2 years, but he said it was only matter of time until moisture builds up again and headlight wont work. He was right, because now not working again. *Tr
- Exterior lighting
2001 dodge grand caravan. Left headlight works on low. Right only on high. Researched on line after spending a fortune by mechanics who couldn't repair it. Found to be fcm. Multiple complaints but chrysler not fessing up to issue. *Tr
- Air bags
Own a 2001 dodge grand caravan. passenger side airbag deployed immediatley after van placed in park and ignition turned off. one month later, driver's side airbag also deployed immediately after being placed in park and ignition turned off. no previous warning lights or indicators.
Defect investigations
NHTSA’s Office of Defects Investigation opened these reviews into vehicles including this one.
- Headlight malfunction
Owner reports indicate allegations of improper headlight operation of one or both headlights.some report intermittent outage or dimming.many report that the condition IS random; it sometimes does not repeat and lasts for a very short duration. A safety-related defect has not been identified at this time and further…
Owner reports indicate allegations of improper headlight operation of one or both headlights.some report intermittent outage or dimming.many report that the condition IS random; it sometimes does not repeat and lasts for a very short duration. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation IS closed.the closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.the agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.see summary report for additional information.
- Headlight malfunction
The office of defects investigation (odi) opened this investigation after receiving reports from consumers that their headlights would malfunction in various ways from flickering to complete non-illumination.headlight operation IS monitored by the vehicle's body control module (bcm) and front control module (fcm).odi…
The office of defects investigation (odi) opened this investigation after receiving reports from consumers that their headlights would malfunction in various ways from flickering to complete non-illumination.headlight operation IS monitored by the vehicle's body control module (bcm) and front control module (fcm).odi IS upgrading this preliminary evaluation to an engineering analysis (ea05-009) to further examine the issue.
- Power liftgate latch
This investigation was opened as pe04-054 regarding reports of alleged power liftgate (plg) opening while driving.the investigation was upgraded on november 22, 2004 based on information provided by daimlerchrysler corporation (dcc) in its september 17, 2004 response to pe04-054. By letter of april 5, 2005, dcc has…
This investigation was opened as pe04-054 regarding reports of alleged power liftgate (plg) opening while driving.the investigation was upgraded on november 22, 2004 based on information provided by daimlerchrysler corporation (dcc) in its september 17, 2004 response to pe04-054. By letter of april 5, 2005, dcc has notified the agency that it will conduct a safety recall of 70,235 model year (my) 2003 chrysler town & country and dodge grand caravan vehicles equipped with the plg option.dcc has identified a problem in early production my 2003 plg control modules that can prevent the plg door from latching closed in a power open/close cycle.in this condition the plg can rise (not power open) during vehicle operation.dealers will install a revised plg control module to remedy the affected vehicles.see safety recall 05v134 for details.
Service bulletins
Technical service bulletins and other communications the manufacturer sent dealers about this vehicle. Ask a dealer for the full document by its number.
- 10229256KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10223854Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 Nm [21 ft. lbs.].
- 10221686KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
- 10220101Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10220099Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10220097Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 10191460Valve Body. These may cause over drive cycling.
- 10175743Disinfectant Solution Recommended for COVID-19
- 10175735Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
- 10169249Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
- 10169247Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
- 10169245Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
- 1012900882212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
- 10019015The front seat electric heater elements may fatigue and cause localized overheating and/or discoloration of the seat cover surface. Customer satisfaction notification D58 - heated seat elements.
- 634264Subject regarding the powertrain control module (pcm) may cause air conditioning compressor failure for RS models. *Slc
- 614668Removable floor console electrical connector.
Every Dodge Grand Caravan model year
Bars are owner complaints, dots mark years with recalls. Select a year to open its report.